2018 Lincoln Mkz

On August 8, 2022, the Office of Defects Investigation (ODI) opened this investigation based on 50 Vehicle Owner Questionnaires (VOQs) alleging front brake jounce hose ruptures on model year (MY) 2013-2018 Ford Fusion and Lincoln MKZ vehicles. A ruptured front brake hose results in a brake fluid leak. As a result, the driver may experience an increase in pedal travel and a reduction in the rate of deceleration, increasing the risk of a crash. It should be noted that the subject vehicles identified fell outside the scope of NHTSA Safety Recall 20V-469, which addressed front brake hoses rupturing on certain MY 2015-2018 Ford Edge and 2016-2018 Lincoln MKX vehicles. The result causes a brake fluid leak, lengthening the distance needing to stop the vehicle, increasing the risk of a crash.On March 10, 2023, Ford Motor Company (Ford) submitted to NHTSA Safety Recall 23V-162 (Ford Recall 23S12) to address front brake jounce hoses that may rupture. Ford found the rupture occurs from a localized failure of the internal reinforcement braid due to cyclic fatigue through tensile/bending and torsional inputs during suspension and steering articulations. The supplier for the front brake jounce hoses is Hitachi. This recall affects the subject vehicles equipped with non-hybrid engines and the suspect front brake jounce hoses (a total of 1,280,726 vehicles). The recall covers subject vehicles built from February 3, 2012 to July 19, 2017 when the suspect hoses were used in vehicle production. The remedy is for dealerships to replace both front brake jounce hoses with new hoses that have a revised braid material at no cost. The vehicles equipped with hybrid engines are excluded from the recall because the internal hose pressure is much lower due to the regenerative braking provided by the hybrid brake system. No failures of brake hoses on hybrid vehicles have been reported to ODI or Ford.Ford's actions address ODIs concerns at this time. Hybrid vehicles will be monitored for related failures. The agency reserves the right to take further action if warranted by new circumstances.The 103 ODI numbers cited above can be viewed at NHTSA.gov under the following ID numbers:11511014, 11510867, 11510318, 11509030, 11505993, 11504989, 11504400, 11502147, 11502082, 11501820, 11501283, 11498439, 11498296, 11496842, 11496335, 11494931, 11494851, 11494252, 11493001, 11492084, 11492070, 11491444, 11491274, 11488858, 11488027, 11487627, 11487416, 11487233, 11486150, 11484924, 11484526, 11484080, 11483948, 11483926, 11483739, 11483723, 11482773, 11482690, 11481077, 11480788, 11480294, 11480052, 11479338, 11479334, 11479252, 11479247, 11479187, 11479094, 11479048, 11478985, 11478953, 11478729, 11478216, 11476892, 11476282, 11470558, 11468994, 11467109, 11466294, 11462746, 11461217, 11456065, 11455367, 11444848, 11436419, 11436376, 11430685, 11428329, 11425083, 11421026, 11420738, 11420735, 11420298, 11418197, 11403926, 11397549, 11366991, 11366757, 11361016, 11359968, 11354569, 11352165, 11350344, 11348799, 11343929, 11343205, 11331947, 11329020, 11319596, 11310529, 11292271, 11288455, 11254787, 11253479, 11253244, 11234622, 11230669, 11230050, 11228240, 11221111, 11143630, 11129392 and 11120228.

I recently have been losing antifreeze, The car stared to overheat, the P303 engine code came on. The car hasn't been inspected yet but my mechanic said it's a sign of a long or short block issue. I've been looking the problem up. It seems to be a problem with many of these cars, a known issue with the card from 2017-2020.

NHTSA ID

11766289

Incident

Sep 15, 2026

While driving, the car stalled. I could not restart it. It was towed to Lincoln Dealer and determined that coolant had leaked into the cylinders and seized the engine. This is a known defect on the Ford EcoBoost Engine. Fully aware of the defect, Ford redesigned the engine in 2019 for later models. I am now faced with the huge expense of having Lincoln replace the engine. Ford needs to take responsibility and pay for this. Please help me.

NHTSA ID

11764046

Incident

Jul 22, 2026

The contact owns a 2018 Lincoln MKZ. The contact stated that while driving approximately 30-35 MPH, the engine overheated. The contact pulled over and became aware that the coolant reservoir was empty. The contact added coolant to the coolant reservoir. The vehicle was taken to an independent mechanic, where it was determined that there was coolant leaking into the cylinder, which caused engine failure. The vehicle was taken to the local dealer, where it was diagnosed, and the engine was replaced. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 80,000.

NHTSA ID

11756956

Incident

Jul 15, 2026

Mileage

80,000 mi

The engine light came on. The car suddenly wouldn’t go past 35 mph . Thankfully I was on a local road. I had it towed to the dealer and was told that the engine needed to be replaced because coolant leaked into the engine. There were no warning lights except the day of . The car did not give any indication of a leak. Nor was it running hot. Everything was functioning fine.

NHTSA ID

11748460

Incident

Jun 26, 2026

Scanned codes P0741, P1450, P1744, & P2196. Hard starts after fuel refills.

NHTSA ID

11747721

Incident

Apr 21, 2026

Scanned codes P0741, P1450, P1744, & P2196. Check the transmission fluid level and condition. No fluid drained from hole, added a little fluid, and retrieved a sample of the fluid. The fluid is very dark. Identifix states, if the fluid smells or has the appearance of being black due to internal clutch slippage, the transmission should be replaced or overhauled. If the transmission fluid is in good condition and found to be at the proper level, monitor the Torque Converter Clutch actual slip (TC_SLIPACT) and TCC desired slip (TC_SLIPDSD) PIDs through the scan tool as the vehicle is driven noting these reading should stay relatively closed together expecting the reading to show to be within 10 RPM of each other. Seeing the values spread apart supports the setting of the P0741 and P1744 codes. Note that excessive TCC slip can be caused by multiple internal factors including mechanical failure of the TCC solenoid, an issue of a valve body component that does not hydraulically react to the activation of the solenoid, a leaking valve body gasket, a leaking input shaft seal, or failure of the torque converter seal. There are no external testing measures that can be taken to verify any of these as the specific cause of the concern. Per the test drive, the difference between actual and desired TCC slip was 100-125 rpm.

NHTSA ID

11747716

Incident

Apr 21, 2026

My 2018 Lincoln MKZ began misfiring on startups. Eventually the check engine light came on with a code of P0302. About a week later while driving, the engine temp gauge reached the hottest temp reading on the gauge. I had to immediately pull over. Upon pulling over I immediately checked the coolant level in the overflow reservoir and it was empty. After refilling with coolant I was able to drive the car home. Over the next few days I monitored the coolant level but at the same time the car was experiencing rough startups and smoke coming out of the exhaust upon startup. Sometimes turning the engine off and restarting it would stop the smoke, but sometimes it wouldn't. I began doing some research and discovered, Technical Service Bulletin (TSB) 19-2346, which explains my exact experience with my 2018 Lincoln MKZ. I have yet to take my car to the dealership for repairs due to the costs that are expected to have this issue resolved. Documents in the legal case, Miller, et al. v. Ford Motor Company (Case No. 2:20-cv-01796) claim that Ford was aware of this defect in their vehicles dating back to 2010. I purchased my 2018 Lincoln MKZ back in 2019.

NHTSA ID

11746143

Incident

Jun 19, 2026

My Check Engine Light came on, I took my car to the dealership that I have using for eight years with less than 38k miles on it and I was told by the service technician who gave the diagnose as, there was coolant in the cylinder where the spark plug #3 is housed. He stated that the car is misfiring and I was told I needed to get an new engine replace to correct the problem. I was given a Service Bulletin stating the manufacturer knew of the problem with this model. I talk to the dealership service manager and questioned why no indication, clue, or suggestion was told to me of the problem with that type of engine. I have not contact my insurance company and I don't if they have information on the problem of the engine problem. I did tell the service technician on routine maintenance for the car that is running "rich" in using gas. In May of this year is when the engine problem started, 3 weeks before actually being eight years officially, no other indication lights came. I drive to work on the streets and freeway everyday.

NHTSA ID

11743958

Incident

May 8, 2026

This article supersedes TSB 24-2165 to update the TSB Service Procedure. Some vehicles listed in the Model statement above may exhibit various SYNC performance related concerns including but not limited to:  Display operation concerns  Navigation inoperative  Voice recognition concerns  Phone connection issues  Dropped phone connections  Applink related performance  Travel Link not present or showing incorrect traffic  Slow system response NOTE: Ford has found some of the APIMs replaced and returned for inspection contained an outdated software level and the APIM did not require replacement. The customer concern may have been resolved by updating the APIM with latest level of software. The SYNC 3 universal thumb drive will be able to update the APIM software without the use of a scan tool and does not require the process to be monitored. Ford will be monitoring APIM replacements to confirm TSB directed software updates have been performed.

Some 2015-2021 Ford and Lincoln vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0011, P0012, P0014, P0015, P0016, P0017, P0018, P0019, P0021, P0022, P0024 and/or P0025. Pinpoint test HK in the Powertrain Control and Emissions Diagnosis (PC/ED) or in Section 303-14 of the Workshop Manual (WSM) has been updated to address this concern.

Various vehicles equipped with a 2.7L or a 3.0L gas engine may require a crankshaft bolt replacement during repairs. Various vehicles equipped with a 2.7L or a 3.0L gas engine may require a crankshaft bolt replacement during repairs.

While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions. While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions.

This article supersedes TSB 21-2175 to update the TSB Service Procedure. Some 2016 MKS, 2016-2017 Navigator, 2016-2018 F-150/Focus/C-MAX/Edge/Fiesta/MKX/Transit Connect/Mustang, 2017-2018 Continental/Fusion/MKZ, 2017-2019 Explorer, 2016-2019 Escape/MKC/Flex/MKT/Taurus/Transit/Expedition/F-Super Duty, and 2018-2019 EcoSport vehicles equipped with SYNC 3 may experience various SYNC performance related concerns. related concerns including but not limited to: Display operation concerns Navigation inoperative Voice recognition concerns Phone connection issues Dropped phone connections Applink related performance Travel Link not present or showing incorrect traffic Slow system response This may be due to the SYNC software. To correct the condition, follow the Service Procedure to update the accessory protocol interface module (APIM) software. NOTE: Ford has found some of the APIMs replaced and returned for inspection contained an outdated software level and the APIM did not require replacement. The customer concern may have been resolved by updating the APIM with latest level of software.

For 2015-2024 Ford and Lincoln vehicles equipped with turbocharged engines and customer concern of an engine oil leak, refer to Workshop Manual (WSM), Section 303-00 for oil leak inspection and testing methods. Ford has evaluated turbochargers replaced for oil leak symptoms and although oil may collect on the external surface of a turbocharger, it is extremely rare for a turbocharger assembly to be the root cause of the oil leak. Careful inspection of the turbocharger oil feed and drain tubes should be performed along with the recommended WSM procedures as needed. Warranty claims for turbocharger replacement going forward will be assessed.