Owner-reported complaints naming the brake system, filed with NHTSA
Data refreshed
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake. Every record below is an owner-reported complaint about the 2003 Lincoln Town Car submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 19 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
The rear-end failed does not have tempered axle There was a recall on 2003 lincolns with same problem but when I enter vin It does not pull anything up Lost control of car and had to be towed home have not had it to the dealer yet
ASSISTING A FRIEND WITH THIS. THE LEFT REAR AXLE HAS BROKEN AND DAMAGED THE BRAKES AND ABS SENSOR. HE HAD DRIVEN THE VEHICLE TO WORK AND PARKED IT. AFTER HIS SHIFT ENDED, HE STARTED THE VEHICLE, SHIFTED INTO GEAR AND FOUND THE VEHICLE WOULD NOT MOVE & WAS MAKING NOISE. HE HAD IT TOWED TO HIS HOUSE AND ASKED ME TO DIAGNOSE THE CAUSE. AFTER RAISING THE REAR AXLE, I WAS ABLE TO DETERMINE THAT THE LEFT REAR AXLE BEARING HAD WORN THROUGH THE AXLE AND IT BROKE. WHEN I CHECKED THE NHTSA WEBSITE, IT SHOWED IT WAS NOT COVERED UNDER THE REAR AXLE SAFETY RECALL, ALTHOUGH THE CONDITIONS ARE SIMILAR TO WHAT WAS LISTED.
TL* THE CONTACT OWNS A 2003 LINCOLN TOWN CAR. WHILE REVERSING AT A LOW SPEED, THE BRAKE WARNING LIGHTS ILLUMINATED. UPON FURTHER INSPECTION, THE CONTACT NOTICED THAT THERE WAS GREASE ON THE INNER SIDE OF BOTH RIMS. IN ADDITION, THE CONTACT NOTICED THAT GREASE WAS LEAKING FROM BOTH REAR BEARINGS. THE CONTACT REPAIRED THE BRAKES. HOWEVER, THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 04V328000 (SUSPENSION), BUT THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 150,000.
I TOOK MY 2003 LINCOLN TOWN CAR TO THE LOCAL FORD DEALERSHIP BECAUSE I HEARD A NOISE IN THE REAR OF THE CAR. I WAS TOLD THAT THE REAR AXEL SEAL WAS BLOWN OUT AND THE AXEL ASSEMBLY WAS DAMAGED ON BOTH SIDES OF THE CAR. IN ADDITION, THE BRAKES WERE RUINED BY THE AXEL FLUID THAT LEAKED OUT. I FOUND OUT THAT THERE WAS A RECALL FOR THE REAR AXEL PROBLEM IN 2003 LINCOLN TOWN CARS FOR FLEET CARS ONLY. I CALLED THE FORD SERVICE CENTER AND ASKED THEM FOR HELP WITH MY EXPENSIVE REPAIR BILL. THEY SAID NO. IN ADDITION TO A VERY LARGE REPAIR BILL, MY CAR WAS UNSAFE DUE TO THE CONDITION OF THE AXEL YET I WAS NOT INFORMED OF THE SITUATION BECAUSE I DON'T OWN A FLEET CAR. *TR
TL*THE CONTACT OWNS A 2003 LINCOLN TOWN CAR. THE CONTACT HAS HAD TWO ALTERNATORS INSTALLED IN HER VEHICLE WITHIN THE LAST SIX MONTHS. THIS DOES NOT INCLUDE THE ONE THAT CAME WITH THE VEHICLE AT THE TIME OF PURCHASE. WHILE DRIVING 30 AND 60 MPH, THE VEHICLE WILL LOSE POWER AND THE ENGINE SHUTS OFF. IN ADDITION, THE POWER STEERING AND BRAKES FAIL. ALL OF THE INSTRUMENT PANEL INDICATORS FLASH ON AND OFF AT THE TIME OF THE FAILURE. OCCASIONALLY, THE VEHICLE WILL TAKE A MINUTE BEFORE RESTARTING. THE VEHICLE IS CURRENTLY AT THE DEALER, BUT THEY COULD FIND NO FAILURES. THE CONTACT WOULD HAVE TO PAY $90 PER HOUR FOR A DIAGNOSTIC. THE FAILURE MILEAGE WAS 29,000. UPDATED 03/09/09. *LJ THE ALTERNATOR WAS REPLACED DUE TO IT OVERCHARGING. THE BATTERY WAS REPLACED AS WELL. THE TRUNK WOULD NOT CLOSE PROPERLY. UPDATED 03/10/09. *JB
TL*THE CONTACT OWNS A 2003 LINCOLN TOWN CAR. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED A LEAK BEHIND THE REAR DRIVER'S SIDE TIRE. THE VEHICLE WAS DRIVEN TO FIRESTONE AND THE MECHANIC STATED THAT THE SEAL FAILED ON THE REAR DRIVER'S SIDE TIRE. WHILE THE MECHANIC WAS REPAIRING THE VEHICLE, HE NOTICED THAT THE REAR WHEEL BEARING AND STUB AXLE WERE DEFECTIVE, WHICH WAS THE ACTUAL CAUSE OF THE SEAL FAILURE. AS A RESULT, THE REAR DIFFERENTIAL FLUID HAD TO BE REFILLED. THE VEHICLE WAS REPAIRED AND THE DEALER AND MECHANIC WERE NOT NOTIFIED. IN JANUARY OF 2009, WHILE DRIVING APPROXIMATELY 60 MPH, THE CONTACT NOTICED A CHIRPING NOISE WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS DRIVEN TO FIRESTONE FOR A BRAKE INSPECTION AND THE MECHANIC STATED THAT THE BRAKE PADS AND ROTORS NEEDED TO BE CHANGED. WHEN THE MECHANIC REMOVED THE ROTORS, HE NOTICED THAT THE REAR BALL JOINTS WERE RUBBING AGAINST THE AXLES AND NEEDED TO BE REPLACED. BOTH OF THE REAR END AXLES AND BALL JOINTS WERE REPLACED. THE DEALER AND THE MANUFACTURER WERE NOTIFIED AND THE CONTACT WAS INFORMED THAT THE VIN WAS NOT RELATED TO ANY RECALLS. HE WOULD BE RESPONSIBLE FOR THE REPAIR COSTS. THE CONTACT HAS THE PARTS AND SUPPORTING DOCUMENTATION IN HIS POSSESSION. THE CURRENT MILEAGE WAS 81,131 AND FAILURE MILEAGE WAS 51,863. UPDATED 2/5/09 *CN UPDATED 02/10/09. *JB
TL*THE CONTACT OWNS A 2003 LINCOLN TOWN CAR. THE CONTACT NOTICED GREASE ON THE WHEELS AND TIRES. THE VEHICLE WAS TAKEN TO A MECHANIC, WHO STATED THAT BEARINGS, AXLES, AND REAR BRAKES WERE NEEDED. THIS WAS THE THIRD TIME IN FOUR YEARS THAT THE FAILURE HAS OCCURRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 04V328000 (SUSPENSION:REAR). THE FAILURE MILEAGE WAS 66,745. UPDATED 06/09/08 *BF THE CONSUMER STATED THE REAR BRAKES WERE SOAKED WITH OIL. UPDATED 06/09/08
2003 LINCOLN TOWN CAR CUSTOMER STATES THAT THE BACK WHEELS LOCKED WHILE DRIVING**CC THE CONSUMERS WIFE WAS MAKING A SLOW LEFT TURN WHEN THE VEHICLE SUDDENLY JERKED TO A STOP RIGHT IN THE MIDDLE OF THE TURN. WHEN SHE PLACED THE VEHICLE INTO REVERSE AND THEN INTO DRIVE, THE VEHICLE DIDN'T MOVE FORWARD. SHE HAD TO PLAY WITH THE GEARS UNTIL THE VEHICLE FINALLY WENT FORWARD. THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM ON 2 SEPARATE OCCASIONS. AFTER THE FOURTH OCCURRENCE, THE CONSUMER WAS INFORMED THAT THEY FOUND A BROKEN PARKING BRAKE LINKAGE. *JB
TL*THE CONTACT OWNS A 2003 LINCOLN TOWN CAR. WHILE DRIVING 55 MPH, THE CONTACT HEARD A GRINDING NOISE COMING FROM THE REAR OF THE VEHICLE. THE MECHANIC STATED THAT THE REAR AXLES, THE WHEEL BEARINGS, AXLE SEALS, AND BRAKE PADS ALL NEED REPLACING. THE MECHANIC MADE THE REPAIR AND NO OTHER FAILURES HAVE OCCURRED. THE CURRENT MILEAGE IS 135,300 AND FAILURE MILEAGE WAS 135,223. UPDATED 07/06/07. *JB
I RECENTLY PURCHASED THE VEHICLE AND NOTICED ON THE FIRST NIGHT DRIVE THAT WHEN APPLYING THE BRAKES, THE 3RD BRAKE LIGHT(THE ONE AT THE TOP OF THE BACK WINDOW GLOWED BRIGHTLY OVER THE INSIDE OF THE WINDOW MAKING IT IMPOSSIBLE TO SEE TO THE REAR. WHEN IT RAINED AND THE BACK WINDOW WAS WET. THE PROBLEM WAS EVEN WORSE. UPON FEELING AROUND THE LIGHT I DISCOVERED 3/4 INCH SPACE BETWEEN THE LIGHT AND THE GLASS THUS LETTING THE LIGHT SPILL OUT. I CALLED THE LOCAL LINCOLN DEALER WHO AFTER EXAMINING IT SAID THEY WERE ALL LIKE THAT AND COULDN'T HELP ME. I CALLED FORD MOTOR CUSTOMER SERVICE AND GOT THE SAME RESPONSE. I HAVE HAD TO PUT DUCT TAPE AROUND IT TO STOP THE LIGHT BUT I KNOW THIS SUMMER WHEN SUN GETS ON IT THE TAPE WILL NOT STICK AND LEAVE GLUE RESIDUE. I CAN RAISE THE CEILING (AND LIGHT ) UP AND DOWN 3/4 OF AN INCH BUT THEY SAY THATS THE WAY THEY WERE BUILT. IT'S DANGEROUS. I HAD A MERCURY BEFORE AND YOU COULDN'T EVEN TELL WHEN THE 3RD LITE WAS ONL.
DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, A GRINDING NOISE WAS HEARD. THE VEHICLE WAS DRIVEN TO AN INDEPENDENT REPAIR SHOP, WHO DETERMINED THE LEFT AND RIGHT REAR AXEL BEARINGS, SEALS, AND PARKING BRAKE SHOES NEEDED TO BE REPLACED. THE DEALER WAS NOTIFIED.
MY 2003 LINCOLN TOWN CAR WAS SLOWING (FOOT OFF GAS, COASTING) DOWN OFF-RAMP FROM FREEWAY BECAUSE THE STOP LIGHT AT THE BOTTOM OF THE OFF-RAMP WAS RED. WHEN I BEGAN TO APPLY THE BRAKES TO COME TO A COMPLETE STOP, THE CAR LURCHED FORWARD VIOLENTLY AS THE FRONT BRAKES LOCKED COMPLETELY, CAUSING THE CAR TO SLIDE TO A STOP. I COULD NOT MOVE THE CAR FORWARD OR BACKWARD IN GEAR, AND COULD NOT GET IT TO COAST IN NEUTRAL. THE CAR COULD NOT BE MANUALLY PUSHED FROM ITS RESTING SPOT AND I HAD TO HAVE IT WINCHED ONTO A FLATBED TOW TRUCK AND TAKEN TO THE LINCOLN DEALERSHIP. THE REPAIR MANAGER TOLD ME AFTER INVESTIGATION THAT THE LINING INSIDE THE BRAKE LINES LEADING TO THE CALIPERS HAD BEEN SLOWLY FLAKING OFF INTO THE BRAKE FLUID. WHEN SUFFICIENT AMOUNTS HAD COLLECTED IN THE FLUID THEY ACTED LIKE A CHECK-VALVE, ALLOWING FLUID INTO THE CALIPERS TO ACTUATE THE BRAKES BUT WOULD NOT ALLOW THE FLUID TO RETURN AND THE BRAKES COULD NOT RELEASE. THE REPAIR CONSISTED OF REPLACING BOTH FRONT BRAKE LINES AND BOTH CALIPER UNITS, COSTING OVER $600. ONLY MOMENTS BEFORE THE BRAKES LOCKED MY CAR HAD BEEN AT SPEEDS OF 55 - 65 MPH ON THE FREEWAY. HAD I NEEDED TO APPLY THE BREAKS WHILE AT THOSE SPEEDS, THE RESULTS WOULD HAVE BEEN DEVASTATING; MY CAR WOULD HAVE BEEN SLIDING OUT OF CONTROL IN HEAVY FREEWAY TRAFFIC AND LIKELY WOULD HAVE LED TO SEVERE INJURY OR DEATH OF MY FAMILY MEMBERS OR OTHER DRIVERS/PASSENGERS. THE LINCOLN DEALERSHIP SEARCHED FOR RECALL AND/OR SAFETY BULLETINS FROM THE MANUFACTURER AND COULD FIND NONE. I'M INFURIATED BY THIS ~ IT IS AN APPARENT DESIGN AND/OR MANUFACTURING DEFECT, ADMITTEDLY SEEN SEVERAL TIMES BEFORE OVER RECENT YEARS BY THE MECHANICS AT MY LOCAL DEALERSHIP, YET NOTHING HAS BEEN DONE TO ADDRESS IT. I SUSPECT THAT IT'S NOT A "SEVERE" ENOUGH SITUATION YET BECAUSE THERE HAVE BEEN NO DEATHS REPORTEDLY LINKED TO THE CATASTROPHIC FAILURE I SURVIVED. *NM
DT: THE CONTACT COMPLAINED ABOUT SUDDEN ACCELERATION PROBLEMS. WHEN APPLYING THE BRAKES VEHICLE DID NOT STOP BUT ACCELERATED 6-10 SECONDS. THIS WAS THE FOURTH INCIDENT. *AK THE THINKS IT IS A POSSIBILITY THE PEDALS ARE TOO CLOSE TOGETHER. *JB
WHEN VEHICLE ENGINE IS RUNNING AND TURN SIGNALS ARE ACTUATED, THE DIGITAL DASH, TURN SIGNALS, AND AIR CONDITIONER CUTS OFF. ADDITIONALLY, STEERING EFFORT INCREASES SUBSTANTIALLY, ABS CYCLES OFF AND BACK ON WHEN THE POWER IS RESTORED. THE DURATION MAY BE MOMENTARY (LESS THAN 5 SECONDS) OR LAST FOR A MINUTE OR LONGER. FREQUENCY IS 80+ PERCENT OF THE TIME WHEN THE TURN SIGNALS ARE ENGAGED (LEFT OR RIGHT). I HAVE HAD ANOTHER FORD VEHICLE WHICH GAVE PROBLEMS WITH THIS MULTI-FUNCTION SWITCH ALSO. FORD HAS A POORLY DESIGNED TURN SIGNAL-WINDSHIELD WIPER-WASHER SWITCH COMPOUNDED BY THE FACT POWER IS SHUNTED THROUGH THIS SWITCH ALL THE TIME, CAUSING OVERHEATING AND PREMATURE FAILURES. THIS LINCOLN IS NOT AN INCOMPLETE VEHICLE. THE LAST LINE OF THE VEHICLE DETAILL FORM NEEDS A 2ND ALTERNATIVE OR WEBMASTER NEEDS TO PROVIDE FOR THE DEFAULT CHOICE (--).
THIS IS A DESIGN FEATURE; UNDER THE DASHBOARD WHERE THE STEERING COLUMN IS LOCATED ISN'T ENOUGH CLEARANCE WHEN DRIVER ATTEMPTS TO BRAKE, HE MUST SLIDE HIS FOOT SIDE WAYS TO NOT MAKE CONTACT WITH CONSOLE. ALSO, THIRD BRAKE LIGHT AT NIGHT ILLUMINATES BRIGHTLY. THE DRIVER DESCRIBES THE PROBLEM AS "BLINDING". *AK
THE BRAKES FAILED WITHOUT WARNING. *JB
WHEN THE DRIVER'S LEFT FOOT WAS QUICKLY MOVED TO THE BRAKE PEDAL FROM ITS RESTING POSITION, IT ENCOUNTERED AN OBJECT ABOVE IT THAT GAVE THE IMPRESSION THE FOOT DID NOT REACH THE BRAKE PEDAL, WHICH RESULTED IN USING THE RIGHT FOOT WHICH CAUSED AN ACCIDENT. THE CONDITION WORSENED WITH THE BRAKE AND GAS PEDAL IN THE FULL DOWN POSITION THEN THE LEFT KNEE ENCOUNTERED THE STEERING WHEEL, WHICH GAVE THE IMPRESSION THE PEDAL WAS NOT REACHED. DEALERSHIP WAS NOT WILLING TO DO ANYTHING BUT ADVISED TO HAVE VEHICLE MODIFIED. CONSUMER IS 5-9 IN HEIGHT AND WEIGHTS 180 LBS. INSTEAD, CONSUMER REPOSITIONED THE PLASTIC PANEL 14"X14" ABOVE THE DRIVER'S LEFT FOOT AND TIED UP THE SMALL LIGHT NORMALLY INSTALLED IN THE PANEL. AND MOVED THE MOVABLE BRAKE/GAS PEDAL FORWARD AND KEPT THE STEERING WHEEL FULLY UPWARD. THIS MADE THE VEHICLE SAFE TO DRIVE. *TT *JB
LED HIGH-MOUNT BRAKE LIGHT CAUSES A DISTRACTING REFLECTION ON THE REAR WINDOW.
CONSUMER STATES THE INTERIOR MOUNTED REAR BRAKE LAMP'S SHIELD IS 3/4 INCHES FROM THE BACK WINDSHIELD. WHEN MOVING IN REVERSE LAMP CAUSING ENTIRE WINDSHIELD TO ILLUMINATE RED. CONSUMER IS UNABLE TO SEE OUT OF BACK WINDSHIELD AS A RESULT. TS
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .