2009 Mazda Mazda6 Fuel system Problems

Vehicle jerks at low speed when accelerate and idle when accelerate, P0766 Code shows, engine noise and gears jump, when reverse the vehicle jerks.

NHTSA ID

11615881

Incident

Sep 16, 2024

Unknown Upon research I saw there was a prior recall Mazda Recall Number 6211B NHTSA Campaign Number 11V134000 About January of 2022 My service engine light has been turning on and off Around and about July 2022 I noticed a dark black colored puddle gathered wherever I would have my vehicle parked and there is a gas smell upon entering the vehicle. I took my vehicle to a mechanic and after their initial inspection I was informed that they would have to further inspect my vehicle but it would be costly because they would have to remove exhaust system to have a better visual. Mechanic also advised not to fill up my gas tank when refueling I believe my vehicle has the problem that the said recall describes

NHTSA ID

11477273

Incident

Jul 1, 2022

THERE HAVE BEEN PROBLEMS WITH OTHER MAZDA CARS THAT GOT RECALLED DUE TO A POSSIBLE FAULTY FUEL SHUT-OFF VALVE THAT COULD ALLOW GASOLINE TO ENTER THE FUEL TANK EMISSION SYSTEM. IF ENOUGH FUEL GETS INTO THE SYSTEM, IT CAN CAUSE THE ENGINE TO STALL. HOWEVER, THIS RECALL DID NOT COVER MY 2009 MAZDA 6 AND I HAD THE SAME PROBLEM. DOOR LOCK ACTUATOR HAS FAILED! THE ALARM ON MY MAZDA GOES OFF AT RANDOM PERIODS OF TIME. SOMETIMES ITS ONCE A WEEK AND SOMETIMES IS 5 TIMES A DAY OR NIGHT. I HAVE REVIEWED SEVERAL INTERNET FORUMS AND IT APPEARS THAT THERE ARE A LOT OF PEOPLE WITH THE SAME PROBLEM BUT THEY HAVE NOT CREATED A COMPLAINT ON THIS WEBSITE. THE REMEDIES THAT THEY HAVE FOUND TO HAVE THE DEALER REPLACE A DOOR ACTUATOR THAT IS FAULTY. THIS DOOR ACTUATOR LOCKS THE DOORS AND IF WHEN IT FAILS TO PROPERLY LOCK THE DOOR IT WILL INTERMITTENTLY SOUND THE ALARM. THE ALARM IS NOT SO MUCH THE CONCERN AS MUCH AS THE DOOR LOCK ACTUATOR. IT IF FAILS TO LOCK IT CREATES A SAFETY HAZARD FOR PEOPLE AS THEY ARE DRIVING DOWN THE ROAD THE DOOR COULD ACCIDENTALLY BE OPENED. CHILDREN COULD OPEN THE DOOR AND FALL OUT OF THE CAR AS IT IS FAILING. PLEASE LOOK INTO THIS ISSUE AS IT IS A SAFETY CONCERN. THIS HAS BEEN HAPPENING FOR AT LEAST THE PAST 4-5 YEARS.

NHTSA ID

11277189

Incident

Oct 1, 2014

Mileage

70,000 mi

ENGINE LIGHT CAME ON PUT ON MACHINE FOR DIAGNOSTIC IT WAS CANISTER PURGE VALUE SITTING OR DRIVING.

NHTSA ID

10967199

Incident

Mar 17, 2017

Mileage

97,000 mi

TL* THE CONTACT OWNS A 2009 MAZDA 6. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 11V134000 (FUEL SYSTEM), 13V425000 (LATCHES/LOCKS/LINKAGES), 16V356000 (AIR BAGS), AND 16V594000 (AIR BAGS). THE PARTS TO DO THE REPAIRS WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIRS. THE MANUFACTURER WAS NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ID

10945039

Incident

May 25, 2016

THE PRESSURE OR HEAT COMING FROM MUFFLER BURNT BACK PART OF VEHICULAR I AM PAYING 1400.00 IN WIRE REPAIRS. AIR BAGS RECALL, SCARS ME DON'T HAVE ANOTHER CAR.THE PASSENGER DOOR AIR NOISE ESCAPING,MELTING DASH BOARD, ALARM SYSTEM GOES OF EVERYDAY UP TO 3TO 4 TIMES. TIRE PRESSURE, AND ENGINE LIGHT ON.

NHTSA ID

10894127

Incident

Mar 20, 2015

Mileage

134,000 mi

CAR GETS SELF ACCELERATED FROM FULL STOP RIGHT AFTER SHIFTING FROM DRIVE INTO REVERSE GEAR-AUTOMATIC TRANSAXLE. I HAVE HAD THREE OCCURRENCES WITCH TRIGGER TO FILL THIS COMPLAINT.

NHTSA ID

10871117

Incident

May 26, 2016

Mileage

70,000 mi

TL* THE CONTACT OWNS A 2009 MAZDA 6. WHILE DRIVING 70 MPH, THE LOOSE FUEL CAP WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 105,000.

NHTSA ID

10863572

Incident

May 5, 2016

Mileage

105,000 mi

TL* THE CONTACT OWNS A 2009 MAZDA MAZDA6. THE CONTACT STATED THAT THE CHECK ENGINE AND CHECK FUEL CAP WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT SPIDER WEBS WERE DEVELOPING IN THE FUEL AND CANISTER VENT LINES. THE TECHNICIAN ADVISED THAT THE WEBS NEEDED TO BE REMOVED, THE CANISTER VALVE AND THE CANISTER VENT LINES NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN RECALL NHTSA CAMPAIGN NUMBER: 11V134000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 97,000.

NHTSA ID

10607356

Incident

Jun 24, 2014

Mileage

97,000 mi

TL* THE CONTACT OWNS A 2009 MAZDA, MAZDA 6. THE CONTACT NOTICED A LARGE AMOUNT OF GASOLINE LEAKING FROM THE FUEL TANK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT THE FAILURE WAS CONTRIBUTED TO A CRACK IN THE UPPER PORTION OF THE FUEL TANK. A TEMPORARY REPAIR WAS PERFORMED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 11V134000 (FUEL SYSTEM, GASOLINE). THE CONTACT STATED THAT THE FUEL TANK REPLACEMENT SHOULD HAVE BEEN INCLUDED IN THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 41,000.

NHTSA ID

10515031

Incident

May 28, 2013

Mileage

41,000 mi

TL*THE CONTACT OWNS A 2009 MAZDA MAZDA6. THE CONTACT STATED THAT THEY TURNED THE DEFROST ON AND A YELLOW SAC SPIDER CAME OUT OF THE VENT AND BIT HIM. THE CONTACT SPOKE WITH A PHARMACIST REGARDING THE SPIDER BITE AND WAS TOLD THAT THEY HEARD OF THE FAILURE WITH THE YELLOW SAC SPIDER. THE CONTACT SPOKE WITH MANUFACTURER AND WAS TOLD THAT THEY HAD CONSIDERED ISSUING A RECALL NOTICE AT THE END OF MARCH OR THE BEGINNING OF APRIL, BECAUSE THIS HAPPENED IN OTHER COUNTRIES. THE CONTACT STATED THAT THE MANUFACTURER CAME TO HIS HOME, RETRIEVED THE VEHICLE, INSPECTED IT BY PLACING A STICK AND A BRUSH INSIDE THE FUEL LINE. IF THERE WERE NO SPIDERS IN THE FUEL LINE, THEY WOULD RETURN THE VEHICLE. THE CONTACT WAS CONCERNED SINCE THEY WERE NOT CHECKING THE AIR VENTS WHERE THE SPIDER WAS. THE CONTACT WAS CONCERNED ABOUT THE SAFETY RISK SINCE THE SPIDERS COULD COME OUT OF THE VENTS WHILE DRIVING. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE AND CURRENT MILEAGE WAS 17,800.

NHTSA ID

10392590

Incident

Mar 21, 2011

Mileage

17,800 mi