1997 Mercury Mountaineer

ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.

There is no summary currently available

There is no summary currently available

There is no summary currently available

TL* THE CONTACT OWNS A 1997 MERCURY MOUNTAINEER. THE CONTACT STATED WHILE THE VEHICLE WAS STATIONARY, THE VEHICLE STALLED. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN UNKNOWN DEALER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 385,000.

NHTSA ID

11402578

Incident

Mar 6, 2021

Mileage

385,000 mi

DRIVERS SIDE SEAT BELT BUCKLE WILL NOT LATCH. 185,000 MILES.

NHTSA ID

11311224

Incident

Feb 23, 2020

Mileage

185,000 mi

TL* THE CONTACT'S HUSBAND OWNS A 1997 MERCURY MOUNTAINEER. THE CONTACT STATED THAT WHEN THE BRAKE PEDAL WAS RELEASED, THE VEHICLE UNINTENTIONALLY ACCELERATED. AS A RESULT, THE CONTACT'S HUSBAND REAR ENDED ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000.

NHTSA ID

11286936

Incident

Nov 29, 2019

Mileage

110,000 mi

DRIVER SIDE SEAT BELT REFUSES TO LATCH AND, IF IT DOES LATCH, COMES UNLATCHED ON ITS OWN. ON INSPECTION, THE 'GUTS' OF THE MECHANISM ARE GONE.

NHTSA ID

11100258

Incident

Apr 15, 2018

Mileage

198,000 mi

I WAS AT A GAS STATION MAKING A PURCHASE WITH MY DISABLED MOTHER. WE LEFT THE STORE, AND GOT INTO MY TRUCK. I STARTED MY TRUCK AND PROCEED TO DIVE TOWARDS THE EXIT OF THE GAS STATION WHEN I SMELLED SOMETHING LIKE BURNING RUBBER. I SAID TO MY MOTHER THAT SOMETHING SMELLED FUNNY AND THEN LOOKED AND SAW A THIN STEAM OF SMOKE COMING UP FROM IN BETWEEN MY LEGS. I PARKED THE TRUCK AND JUMPERS OUT LEAVING MY OM IN THE CAR. I THEN SAW A FIRE INSIDE OF THE METAL TRACK IN WHICH MY SEAT MOVES MECHANICALLY UNDERNEATH MY SEAT, WHERE THE WIRES ARE. I RAN INTO THE GAS STATION PANICKED AND ASKED THE ATTENDANT FOR A FIRE EXTINGUISHER, TO WHICH HE REPLIED " NO, I DON'T KNOW I DON'T HAVE ONE" AND DID NOTHING. SO I RAN BACK OUTSIDE TO MY TRUCK WHERE MY MOTHER WAS HAVING TROUBLE EXITING MY TRUCK AS SHE HAS ANXIETY AND HEALTH ISSUES. SHE FINALLY GOT OUT AND A TOW TRUCK THAT WAS DRIVING BY, SAW THE SMOKE GETTING HEAVIER AND FLOWING OUT OF MY TRUCK, HE STOPPED AND OUT THE FIRE OUT WITH AN EXTINGUISHER. THE FLAMES WERE COMING THROUGH MY SEAT AND I WAS AT A GAS STATION. I WAS TERRIFIED. I HAVE PTSD AND THIS HASN'T HELPED MY SLEEP AT ALL. ALSO, WE WERE AT A GAS STATION AND AS YOU KNOW, FIRE IS VERY DANGEROUS AT A GAS STATION. WE COULD'VE BEEN SERIOUSLY HURT OR WORSE.

NHTSA ID

10993068

Incident

May 27, 2017

Mileage

3 mi

WHEN I USE THE CRUISE CONTROL AND THEN TURN IT OFF I CAN'T SEEM TO PUSH MY GAS PEDAL WHEN YOU ARE DRIVING THE VEHICLE. I HAVE TO KEEP PUTTING EXTREME PRESSURE ON THE ACCELERATOR PEDAL UNTIL SOMETHING BREAKS OR POPS AND THEN IT ALLOWS ME TO PUSH THE PEDAL. I KEEP HAVING PROBLEMS WITH SMOKE COMING FROM ON TOP OF THE STEERING COLUMN LIKE SOMETHING IS BURNING WHEN YOU ARE DRIVING, NOW I HAVE ELECTRICAL PROBLEMS TO WHERE MY HORN WILL NOT WORK ANYMORE. I KEEP HAVING PROBLEMS WITH THE FRONT FRAME OF THE SUV. THE FRAME SOUNDS AND FEELS LIKE IT IS GOING TO FALL APART AND IT DOESN'T MATTER IF YOU ARE DRIVING OR STATIONARY. THE MECHANIC SAYS IT IS THE SWAY BAR THAT IS CAUSING THAT PROBLEM. I HAVE BEEN CALLING FORD ABOUT IT AND THEY KEEP SAYING THERE IS NO RECALL ON MY VEHICLE.

NHTSA ID

10904769

Incident

Jan 1, 2014

THE DRIVER'S SEAT BELT WILL NOT LATCH.

NHTSA ID

10794584

Incident

Oct 30, 2015

Mileage

137,400 mi

TL* THE CONTACT OWNS A 1997 MERCURY MOUNTAINEER. THE CONTACT STATED THAT THE FRONT DRIVER SIDE SEAT BELT BUCKLE FAILED TO LATCH. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000. THE VIN WAS UNAVAILABLE.

NHTSA ID

10693941

Incident

Nov 7, 2014

Mileage

170,000 mi

FRONT AXLE LEAKS FLUID FROM VENT TUBE - VEHICLES EQUIPPED WITH 4X4 OR AWD. *TT

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT

GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT

LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT), SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS WITH POSSIBLE DIAGNOSTIC TROUBLE CODES P0732, P0733, P1762 SET ON VEHICLES BUILT BEFORE 12/1/2001. *TT

MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. *TT

REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT