2007 Nissan Xterra

On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.

I took my 2007 Nissan Xterra to the dealer on 08/04/2025 to complete the air bag safety recall. The dealer performed the recall service, but the recall status has not been updated in the system or on the NHTSA website. It still shows as “incomplete.” Because the recall remains listed as open, I am unable to pass my brake and light inspection or complete my vehicle registration with the DMV. I have contacted the dealer and Nissan customer service multiple times, but they have not corrected the recall record or provided a timeline for when it will be updated. The recall has technically been completed, but Nissan’s failure to update the record is preventing my vehicle from being legally inspected and registered. I am requesting NHTSA’s help to ensure the manufacturer updates the recall status properly.

NHTSA ID

11691704

Incident

Aug 4, 2025

Oil is getting into the radiator and causing a gray gunk build up in radiator and possibly the engine. I have had the car less than a 1 1/2 years And I've already had to have the same issue fixed 3 × first time. The heater hose blew out caused an air bubble in the radiator which caused us to have to burp the radiator Which is when we found it the first time had sent it to the mechanic. Had it flushed, had it fixed. it was fine or so we thought until about a month ago. Car overheats radiator fluid spews out everywhere. Fix the hose, add radiator fluid and start. The burping process again and out comes the gray gunk. Sent it back to mechanic had it flush had gaskets to the transmission cooler and Oil cooler fixed. Mechanic cannot find how it's getting into radiator. Break pads wear prematurely due to calipers constantly sticking. Rust is everywhere on frame, suspension, shocks undercarriage and body. Vdc/slip light will come on while driving causing the car to stall at any speed. Fixed those sensors 2 times since I bought the car in December 2023 from a used car lot. State I I've in has no laws to protect people buying from used car lots but they do for new cars even though new cars come with warranties. Should be the other way around protect the people who can't afford the 30000 dollar cars. There's a reason we go to used car lots. Paid 4500 after taxes and registration and have put almost 5000 into it. Nissan is aware of the problem just not enough to deem a recall.

NHTSA ID

11656933

Incident

Aug 8, 2024

The contact owns a 2007 Nissan Xterra. The contact stated that the vehicle was taken to a dealer to be repaired under NHTSA Campaign Number: 08V690000 (Air Bags). The contact stated that after retrieving the vehicle, the air bag warning light was blinking. The vehicle was returned to the dealer and the contact was informed that a diagnostic test was needed to determine the cause of the failure. The contact refused to pay for the diagnostic test and stated that the warning light was not illuminated prior to the recall repair being performed. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 167,000.

NHTSA ID

11625920

Incident

Mar 18, 2024

Mileage

167,000 mi

The vehicle was driving just fine, then about a month later the heat gauge started to fluctuate, i replaced the radiator caps, thermostat...it ran good for another month, started to overheat....i made sure water was in radiator and overflow...about a month went by the gauge started to fluctuate again, i had it towed to sayre auto parts in sayre, al to have a water pump installed and the mechanic told me their is now there is water in my oil, meaning a cracked head gasket...the vehicle never got over the 3/4 mark on gauge and this is the 2nd vehicle ive purchased that the same thing has happened to.

NHTSA ID

11594708

Incident

Apr 12, 2023

My 07 Xterra has extreme rust in the door jams and rear panels. The rack-n-pinion, power steering system leaks fluid.

NHTSA ID

11577919

Incident

Apr 1, 2017

There is usual rust on body of truck. There is some kind of electrical problem rather it’s the security system or wiring. There’s a clicking sound coming from dash area. There is a suspension problem, has to change leaf springs, struts and shocks often.

NHTSA ID

11562845

Incident

Dec 3, 2013

The recall has been in place with no solution presented by the manufacturer since February of 2023 with no remedy for the steering wheel emblem issue, making airbag deployment potentially unsafe.

NHTSA ID

11548155

Incident

Oct 4, 2023

The contact owns a 2007 Nissan Xterra. The contact stated that the air bag warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed and produced codes: B1049 and B1054. Additionally, the contact indicated Part Number: 4790453X10A needed to be replaced. The vehicle was not repaired. The contact then received notification of the NHTSA Campaign Number: 23E012000 (Air Bags) however, the part to do the recall repair was not yet available. The dealer was contacted and confirmed that parts were not yet available for the recall repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure and the contact was informed that they were not responsible for the individual dealers and no further assistance was provided. The failure mileage was approximately 110,000. VIN tool confirms parts not available. The contact stated that there were 3 parts that needed to be replaced but the parts were unavailable. The contact paid a bill from the dealership, yet the vehicle was returned back without any repairs being made.

NHTSA ID

11524425

Incident

May 3, 2022

Mileage

110,000 mi

CERTIFICATION LABEL AND VIN PLATE REPLACEMENT SERVICE INFORMATION Because of collision damage or other vehicle repair, a replacement “Certification Label” or “VIN Plate/Label” may be needed. HINT: Certification Label = FMVSS (Federal Motor Vehicle Safety Standards) label. These items may be available from Nissan by request if certain criteria are met. This bulletin lists the criteria and provides an application form for such replacements. · The “VIN Plate/Label” (metal plate or vinyl label) is attached to the instrument panel or body on the driver side at the base of the windshield (see Figure 1). · The “Certification Label” (vinyl adhesive label) is located on the lower area of the driver side B-Pillar (see Figure 1).

CERTIFICATION LABEL AND VIN PLATE REPLACEMENT SERVICE INFORMATION Because of collision damage or other vehicle repair, a replacement “Certification Label” or “VIN Plate/Label” may be needed. HINT: Certification Label = FMVSS (Federal Motor Vehicle Safety Standards) label. These items may be available from Nissan by request if certain criteria are met. This bulletin lists the criteria and provides an application form for such replacements. · The “VIN Plate/Label” (metal plate or vinyl label) is attached to the instrument panel or body on the driver side at the base of the windshield (see Figure 1). · The “Certification Label” (vinyl adhesive label) is located on the lower area of the driver side B-Pillar (see Figure 1).

VOLUNTARY SAFETY RECALL CAMPAIGN 2005-2013 FRONTIER, PATHFINDER, AND XTERRA; DRIVER AIR BAG COVER CAMPAIGN ID #: PC945 and PC948 APPLIED VEHICLES: 2005-2013 Frontier (D40) 2005-2012 Pathfinder (R51) 2005-2013 Xterra (N50) Check Service COMM or Dealer Business Systems (DBS) National Service History to confirm campaign eligibility. INTRODUCTION Nissan is conducting this voluntary safety recall campaign on certain specific model year 2005-2012 Pathfinder, and 2005-2013 Frontier and Xterra vehicles to inspect and, if necessary, replace the Driver Air Bag Cover. This service will be performed at no charge to the customer for parts or labor. IDENTIFICATION NUMBER Nissan has assigned identification number PC945 and PC948 to this campaign. This number must appear on all communication and documentation of any nature dealing with this campaign. DEALER RESPONSIBILITY It is the dealer’s responsibility to check Service COMM or Dealer Business Systems (DBS) National Service History for the campaign status on each vehicle falling within the range of this voluntary safety recall which for any reason enters the service department. This includes vehicles purchased from private parties or presented by transient (tourist) owners and vehicles in a dealer’s inventory. Federal law requires that new vehicles in dealer inventory which are the subject of a safety recall must be corrected prior to sale. Failure to do so can result in civil penalties by the National Highway Traffic Safety Administration. While federal law applies only to new vehicles, Nissan strongly encourages dealers to correct any used vehicles in their inventory before they are retailed.

CAN COMMUNICATION – NETWORK DIAGNOSTIC FLOW CHART This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

VEHICLE KEY NOT DETECTED / AUTHENTICATED, ENGINE WILL NOT START This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

CAN COMMUNICATION CODES – DIAGNOSTIC TIPS AND GUIDELINES This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.