1998 Oldsmobile Silhouette

SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.

ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

ODI IDENTIFIED 59 REPORTS WITH THE ALLEGED DEFECT.ODI WAS ABLE TO CONTACT 44 OF THE 59 CONSUMERS IN ORDER TO DETERMINE THE SPECIFIC CAUSE OF THE LATCH PROBLEMS.OF THE 44 OWNERS CONTACTED, ODI DETERMINED THAT FOUR FAILURES WERE DUE TO AN OUT-OF-TOLERANCE LATCH PLATE, AND THAT 23 FAILURES WERE DUE TO A DISPLACED BUCKLE HOUSING COVER.THE REMAINING 17 FAILURES HAD INDETERMINABLE CAUSES.OF THE 59 REPORTS, THERE WERE THREE ALLEGED MINOR INJURIES.NO LEGAL CLAIMS OR LAWSUITS HAVE BEEN FILED WITH REGARD TO THIS ALLEGED DEFECT.BASED ON THE LIMITED NUMBER OF REPORTS, AND A DECLINING REPORT TREND, THIS INVESTIGATION IS CLOSED.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEARED TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ADDITIONAL SUMMARY REPORT.

ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.

TL* THE CONTACT OWNS A 1998 OLDSMOBILE SILHOUETTE. THE CONTACT STATED THAT WHILE EXITING A PARKING SPACE, THE STEERING WHEEL FAILED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT OFFERED NO ASSISTANCE. THE CONTACT WAS INFORMED OF NHTSA CAMPAIGN ID NUMBER: 02V286000 (STEERING:RACK AND PINION) BUT WAS ADVISED THAT HIS VEHICLE WAS NOT PART INCLUDED IN THE RECALL. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 107,519.

NHTSA ID

10466669

Incident

Jul 12, 2012

Mileage

107,519 mi

WHILE DRIVING VAN THE TEMPERATURE GAUGE SHOWED HOT AND HEATER STOPPED BLOWING HOT AIR FEW MINUTES LATER IT COOLED BACK DOWN AND STARTED BLOWING WARM AIR AND IT CONTINUED TO DO THAT OVER AND OVER PUT A THERMOSTAT IN IT AND IT DID NOT HELP IT CONTINUED TO DO THE SAME THING IT IS FULL OF WATER STILL NOT BLOWING ANY WARM AIR OUT AND STEAMING OUT THE EXHAUST. *TR

NHTSA ID

10442808

Incident

Dec 24, 2010

TL* THE CONTACT OWNS A 1998 OLDSMOBILE SILHOUETTE. THE CONTACT STATED THAT ONCE THE VEHICLE WAS STOPPED AND SHIFTED INTO PARK, THE VEHICLE WOULD NOT SHIFT INTO DRIVE. IN ADDITION, THE VEHICLE WOULD ONLY REMAIN IN PARK IF THE EMERGENCY BRAKE WAS ENGAGED. THE VEHICLE WAS TOWED TO A LOCAL REPAIR FACILITY WHERE IT WAS INSPECTED BY AN INDEPENDENT MECHANIC. THE MECHANIC ADVISED THAT THE SHIFT LINKAGE CABLE WAS FRACTURED AND WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 120,000. UPDATED 03/24/11*LJ THE DOOR LATCH AND SEAT BELTS WERE INOPERATIVE. UPDATED 05/05/11

NHTSA ID

10386019

Incident

Feb 27, 2011

Mileage

120,000 mi

AIRBAG LIGHT IS INTERMITTENT. AS THE VEHICLE STARTS, THE COMPUTER RUNS THROUGH IT'S CHECKS, EVERY NOW AND THEN THE AIRBAG LIGHT ILLUMINATES AND STAYS ON UNTIL THE VEHICLE IS SHUT OFF AND RE-STARTED. THERE IS NO WARNING WHEN THE LIGHT WILL STAY ON OR TURN OFF DURING START-UP. THIS HAS BEEN AN ON-GOING ISSUE WITH THIS VEHICLE. *TR

NHTSA ID

10376717

Incident

Jan 14, 2011

TL*THE CONTACT OWNS A 1998 OLDSMOBILE MINIVAN. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH UNEXPECTEDLY THE TIRE FLATTENED. THE VEHICLE WAS DRIVEN TO THE SIDE OF THE ROAD. THE CONTACT OBSERVED THAT THE SPARE TIRE DETACHED FROM THE RUSTED SPARE TIRE CABLE BRACKET. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS 124,000. THE CURRENT MILEAGE WAS 124,430.

NHTSA ID

10326388

Incident

Apr 6, 2009

Mileage

124,000 mi

TL*THE CONTACT OWNS A 1998 OLDSMOBILE SILHOUETTE. THE RIGHT PASSENGER DOOR WAS REPAIRED ON JANUARY 7, 2002 PER RECALL 01V067000 LATCHES/LOCKS/LINKAGES: DOORS: LATCH. THE RECALL REPAIR DID NOT CORRECT THE FAILURE AND THE RIGHT SLIDING DOOR WILL NOT LOCK OR LATCH. THE MANUAFACTURER WAS NOTIFIED AND WAS ADVISED THAT THE TIME ALLOTED FOR A SECOND REPAIR HAD EXPIRED DUE TO THE VEHICLES MILEAGE. THE FAILURE MILEAGE WAS 34,694 AND THE CURRENT MILEAGE WAS 128,382.

NHTSA ID

10280652

Incident

Jan 7, 2002

Mileage

128,382 mi

TL*THE CONTACT OWNS A 1998 OLDSMOBILE SILHOUETTE. DURING A ROUTINE INSPECTION, A TECHNICIAN STATED THAT THERE WAS AN ABNORMAL OIL LEAK. THE OIL LEAKAGE INCREASES THE RISK OF AN ENGINE COMPARTMENT FIRE. NO REPAIRS WERE MADE AT THE TIME OF INSPECTION. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 86,000.

NHTSA ID

10266634

Incident

Mar 8, 2009

Mileage

80,000 mi

TL*THE CONTACT OWNS A 1998 OLDSMOBILE SILHOUETTE. THE CONTACT STATED THAT THE VEHICLE MADE A LOUD BANGING NOISE. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT THE NOISE WAS COMING FROM THE BRAKES. REPAIRS WERE MADE TO THE ENTIRE BRAKING SYSTEM, BUT THE NOISE CONTINUED. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND THEY DETERMINED THAT THE FUEL SYSTEM WAS THE CAUSE OF THE FAILURE. THE DEALER STATED THAT IT WAS NOT A SAFETY CONCERN BECAUSE THE ISSUE WAS COMMON IN SOME FUEL TANKS. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 70,000. UPDATED 01/07/09. *LJ UPDATED 01/08/09.*JB

NHTSA ID

10250868

Incident

Jul 31, 2008

Mileage

70,000 mi

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.  E version update is to add administrative details.

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.