RoadVitals

2006 Orion Vii

Recalls, owner-reported complaints, investigations and safety data

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
0
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
9
Latest Sep 27, 2013
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains no NHTSA owner-reported complaints for the 2006 Orion Vii. 9 safety recalls have been issued covering this model year; 1 NHTSA investigation names it; and 14 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Safety recalls

9 campaigns cover this model year

View all 9

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
13V476000

ELECTRICAL SYSTEM

Sep 27, 2013
3,009 units potentially affected
The defect: Daimler Buses North America Ltd. (DBNA) is recalling certain model year 2003-2008 Orion V and model year 2002-2010 VII buses equipped with Sure Power equalizers and DC-DC Converters. The specific potting compound used in the equalizers and convertors for insulation was found to be capable of conducting electricity after being exposed to heat.
The risk: Once electrically conductive, the material is capable of melting and burning, increasing the risk of a fire.
The remedy: DBNA will notify owners and Sure Power representatives will change out the equalizer and/or convertor, free of charge. The recall is expected to begin during November 2014. Owners may contact DBNA at 1-905-403-1111.
Daimler Buses North AmericaView on NHTSA.gov
12V447000

ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER

Sep 13, 2012
187 units potentially affected
The defect: Daimler Buses North America (DBNA) is recalling certain model year 2004-2008 Orion V and model year 2005-2006 Orion VII transit buses equipped with John Deere Compressed Natural Gas (CNG) turbocharged engines. The turbine or compressor wheel may fail, resulting in subsequent damage to the engine and/or an oil leak.
The risk: Failure of the turbine or compressor wheel may result in smoke, fire, and stalling, increasing the risk of a crash.
The remedy: DBNA will notify owners. The remedy for this issue is still under development. The safety recall began on September 28, 2012. Owners may contact Daimler Buses North America at 1-800-882-8054.
DAIMLER BUSES NORTH AMERICA, INC.View on NHTSA.gov
10V015000

POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)

Jan 21, 2010
426 units potentially affected
The defect: DAIMLER BUSES IS RECALLING CERTAIN ORION TRANSIT BUSES EQUIPPED WITH THE MORSE REMOTE THROTTLE CONTROL. THE MORSE REMOTE THROTTLE CONTROL PANEL IS LOCATED IN THE ENGINE COMPARTMENT AND A SWITCH ON IT IS LABELED, "THROTTLE"; "OFF" OR "FRONT" AND "ON" OR "REAR" SELECTING THE ACTIVE ENGINE CONTROL STATION. IF A PERSON OPERATING THE ENGINE FROM THE "REAR" POSITION (AT THE ENGINE) FAILS TO PLACE THE SWITCH IN THE "OFF" OR "FRONT" POSITION AND THE ENGINE RPM WAS SET TO ABOVE IDLE DURING MAINTENANCE FOR EXAMPLE, WHEN THE BUS IS STARTED FROM THE DRIVER'S STATION THE ENGINE COULD CHANGE TO THE HIGHER RPM RESULTING IN UNWANTED ENGINE POWER.
The risk: THE BUS COULD ACCELERATE AT A HIGHER RATE THAN ANTICIPATED INCREASING THE RISK OF A CRASH.
The remedy: DAIMLER WILL PROVIDE INSTRUCTIONS TO MODIFY THE WIRING TO THE MORSE THROTTLE CONTROL SWITCH. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 1, 2010. OWNERS MAY CONTACT DAIMLER BUSES AT 1-800-716-7466.
DAIMLER BUSES NORTH AMERICA, INC.View on NHTSA.gov

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect.

EQ09007ClosedInvestigation

FALLING BUS WINDOWS

Opened Aug 18, 2009
Closed Nov 24, 2009

THE PURPOSE OF THIS INVESTIGATION WAS TO DETERMINE WHETHER THE TIP-IN STYLE TRANSOM WINDOWS SUPPLIED TO DAIMLER BUSES FOR USE ON BUSES IT MANUFACTURED, AND CONCERNING WHICH THAT COMPANY MADE A DEFECT DETERMINATION, WERE SUPPLIED TO ANY OTHER VEHICLE MANUFACTURERS OR AS REPLACEMENT EQUIPMENT AND, IF SO, TO PROMPT ADDITIONAL SAFETY RECALLS IF AND WHERE NEEDED.RMD ISSUED A REQUEST FOR INFORMATION TO THE WINDOWS' MANUFACTURER, HEHR INTERNATIONAL, INC. (HEHR) ON SEPTEMBER 2, 2009, INQUIRING ABOUT ITS DISTRIBUTION OF THE WINDOWS AND SOLICITING ITS OPINION AS TO WHETHER A SAFETY DEFECT EXISTED IN THOSE WINDOWS.HEHR RESPONDED ON OCTOBER 28, 2009, THAT IT HAD NOT SUPPLIED THE WINDOWS TO ANYONE OTHER THAN DAIMLER BUSES.IT ALSO OPINED THAT THE WINDOWS DID NOT CONTAIN A SAFETY DEFECT AND THAT ANY SCREW LOOSENING, AND CONSEQUENTIAL WINDOW COLLAPSE, WOULD BE DUE TO A FAILURE TO PROPERLY RETIGHTEN A SCREW AFTER MAINTENANCE, AS OPPOSED TO A DEFECT INHERENT TO THE DESIGN OR MANUFACTURE OF THE SCREWS OR WINDOWS.IN SUPPORT OF ITS OPINION, IT PROVIDED A SUMMARY OF HISTORICAL FIELD DATA AND ITS FIELD INSPECTION INVESTIGATION, NEITHER OF WHICH DEMONSTRATED ABERRANT PERFORMANCE.IT ALSO PROVIDED A SUMMARY OF TESTING CONDUCTED BY AN INDEPENDENT TESTING FACILITY DEMONSTRATING THAT THE SCREWS WOULD NOT LOOSEN AS MANUFACTURED. IN VIEW OF HEHR'S RESPONSE AND THE INFORMATION PROVIDED THEREIN, THIS INVESTIGATION IS CLOSED.

VISIBILITY:GLASS, SIDE/REAR

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

No owner complaints recorded for this model year

Either none have been filed with NHTSA, or this vehicle is too new for reports to have accumulated.

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

NYCT LETTER

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL; STRUCTURE:FRAME AND MEMBERS

Letter to four (4) New York State transit bus customers regarding performing

14CSA23

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

14CSA23 CSC Announces ?Tech Tips? ? DDCSN

16TS7

FUEL SYSTEM, DIESEL

16TS7 Reman Diesel Particulate Filter Serial Number

14TL8

EQUIPMENT

14TL8 TorcUP? Non-Impacting Torque Tool.

14CSA22

ELECTRICAL SYSTEM:WIRING

14CSA22 DTNA Chassis Wiring Diagrams

14TL9

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

14TL9 Special Tool Warranty Program.

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

Orion Vii by model year
YearComplaintsRecallsInvestigationsIssue Index
2012041—
2011041—
2010050—
2009181—
20080111—
2007191—
2006Viewing091—
20050120—
20040141—
2003081—
2002081—
2001020—
2000000—
1999000—
1998000—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.