2022 RAM 2500 Brakes Problems

ABS system HCU leaking internally Vehicles stopping ability may be impaired Vehicle brake pedal slowly sinks to floor. Ram dealership diagnosed a failed master cylinder internal seal and replaced the master cylinder with 25,272 miles on the vehicle on 3/17/26. Returned to dealership with same issue on 8/3/26 with 28,488 miles on vehicle. Ram dealership diagnoses the hydraulic control unit (HCU) is leaking internally on the ABS system. No warning lamps or other messages. First reported soft brake issue on 2/11/26.

NHTSA ID

11756058

Incident

Aug 3, 2026

The contact owns a 2022 Ram 2500. The contact stated that while operating the vehicle, the messages “Auto Park Disabled”, “Service Electronic Stability Control”, and “Trailer Brake System” were displayed. Additionally, while hauling a camper, the message “Trailer Brakes Disabled” was displayed, and the trailer brakes became inoperable. After restarting the vehicle, the failure was self-corrected, and the trailer brakes operated normally. The vehicle was taken to the local dealer, but the cause of the failures was not yet determined. The manufacturer was not yet contacted. The failure mileage was 65,000.

NHTSA ID

11747220

Incident

Oct 10, 2024

Mileage

65,000 mi

Vehicle would not start. I put a new battery in, the vehicle still would not start, and the break pedal was stiff. Had someone jump the vehicle, i started it and drove to the dealership service department where I originally bought the vehicle. They said it may be the starter. but they hadn't looked at the vehicle. I told them I would drive to a different shop because it's cheaper. When I tried to put it in drive the vehicle would not move it was giving an error message on the dash. I had to leave the truck there. 2 days later they called me and told me the issue was caused by a recalled part and they fixed the issue. When I arrived they told me I would have to pay $215 diagnostic fee. I told them it's federally prohibited to charge for a recalled part. I had to argue with them to get my vehicle back. They told me next time I should tow the vehicle if I dont want to pay a diagnostic fee. I attached proof of the recall service and the $215 fee listed that they tried to charge me.

NHTSA ID

11745288

Incident

Jun 19, 2026

The contact owns a 2022 Ram 2500. The contact stated that the trailer wiring pigtail produced only 9 to 10 volts to the trailer lights and brake system. Even when the brake pedal was depressed, the voltage output was insufficient. While towing a trailer, the trailer brakes failed to operate adequately. The vehicle was taken to a local dealer, who stated that the vehicle was operating as designed. The vehicle was not diagnosed nor repaired. The manufacturer was notified, and a claim was opened. The approximate failure mileage was 110,000.

NHTSA ID

11739071

Incident

May 20, 2026

Mileage

110,000 mi

I had to hard brake on a damp roadway at about 50 mph. The truck began to rotate and skid. I had no control over the vehicle until it stopped. The dash lights came on for a failure of the brakes, abs, traction control, and stability control. All of the lights went off then the truck seemed to drive normally. A short time later the lights came on and would not go off. Took the truck to the dealer. The hydraulic control unit was bad and was replaced. This did not fix the truck. Now it needs an abs control module. The truck remains at the dealer awaiting this repair. This appears to be a problem in the previous model year Ram 2500’s and it looks like my 2022 is affected also. There are recalls for these trucks but not for my model year.

NHTSA ID

11730817

Incident

Feb 1, 2026

What component or system failed or malfunctioned, and is it available for inspection upon request? FACTORY TRAILER BRAKE CONTROL UNIT. How was your safety or the safety of others put at risk? BRAKE CONTROL INTERMITTENTLY FAIL TO WORK. NOT ABLE TO STOP 15,000 LB TRAILER. WEIGHT PUSHS VEICHLE OUT OF CONTROL. Has the problem been reproduced or confirmed by a dealer or independent service center? NEVER DOES IT FOR THE DEALER OR INDEPENDENT SERVICE CENTER AND THEY TOW MY TRAILER AROUND SEVERAL TIMES. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? DEALER & SERVICE CENTER Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? NO NO HOW DO I GET HELP IT IS A 2022 RAM 2500 BROUGHT NEW BY ME AND STARTED HAVING TROUBLE OFF AND ON SINCE THE FIRST 1,000 MILES AND NOW HAVE 26,000 MILES. I READ ABOUT THE RECALLS ON THE 2024 2025 RAM 2500 3500 MODELS WITH AN ENGINEERING PROBLEM ON TWO DIFFERENT VENDORS MAKING CONTROLERS FOR FCA.

NHTSA ID

11722127

Incident

Mar 4, 2026

The ABS, traction control, and 4x4 lights all came on at the same time. None are operable. During my research I was able to find recall 75b that aligns with the exactly with my current set of issues. 24v-653 is the NHTSA recall number associated. I need that recall added to my vehicle so I can get the very unsafe issue fixed

NHTSA ID

11719982

Incident

Feb 22, 2026

The contact owns a 2022 Ram 2500. The contact stated while driving at an undisclosed speed, the brake pedal was depressed and traveled to the floorboard. There was no warning illuminated. The contact engaged the parking brakes to stop the vehicle. The vehicle was towed to the dealer; however, the failure was not duplicated. The vehicle was not diagnosed or repaired. The contact stated that the failure persisted, and several unknown warning lights were illuminated. The manufacturer was made aware of the failure and a case was opened. The approximate failure mileage was 44,000.

NHTSA ID

11638115

Incident

Jan 23, 2025

Mileage

44,000 mi

Recall said completed it's not and code is still coming up on reader. So many problems with it. How to find out to get the services I'm paying for.

NHTSA ID

11632113

Incident

Dec 12, 2022

1. Complete Brake Failure. No warning lights came on. There is no emergency warning system for Brake Failure. This could have been catastrophic. This could have turned deadly if we were driving on the highway with no warnings Dec 15, 2024 I drove the truck during the day on the highway and made various stops for Christmas Shopping. I went for dinner with my Family. After dinner climbed into the truck and depressed the break and started the truck. Once the truck started the break pedal could be pushed to the back floorboards. I know this was not right. Turned the truck off and started it again and up it in drive thinking it would correct. It did not turned onto a sidewalk put he truck in park and called a towtruck. 2. The 12" display goes black constantly. Even after several software upgrades. You cannot see heat/radio/ mapping/ phone system nothing it completely shuts down 3. Transmission, when you stop and then drive slowly, press the brakes lift off the brakes slightly the truck lunges forward so you really have to be careful or you will crash into the car in front of you.

NHTSA ID

11630887

Incident

Dec 15, 2024

Vehicle purchased June 2022. I can't keep front brakes on the vehicle. July 4, 2023 Mileage 52154, the front brakes were worn out and replaced with Brake Best brake pads. January 12, 2024 Mileage 76200. Front brake pads worn out and ruined the rotors. Pads replaced with Raybestos pads and Brake Best Rotors. December 2024 Mileage 114261. Front brake pads worn out and are cutting into the front rotos so, I'm about to replace them with the fourth set of brakes since the truck was manufactured.

NHTSA ID

11629389

Incident

Dec 7, 2024

The contact owns a 2022 Ram 2500. The contact received notifications of NHTSA Campaign Numbers: 23V060000 (Electrical System), 24V415000 (Electronic Stability Control (ESC), Service Brakes, Air) and 24V436000 (Back Over Prevention); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11617406

Incident

Feb 9, 2023

Driving on the freeway and I was cut off. And failed to work went sliding and had to steer into the emergency lane to avoid a collision

NHTSA ID

11593905

Incident

May 29, 2024

the integrated trailer brake controller does not perform enought to actually engage the trailer brakes on multiple trailers. this should be a recall issue for ram. we have two ram trucks with the same issue.

NHTSA ID

11587271

Incident

May 3, 2024

My 2022 RAM 2500 only has about 10k miles and today when I started the vehicle in my driveway, the ABS and Traction control lights came ON. Did some google searching and found that this is a known issues plaguing RAM trucks since 2018! I'm going to call dealer tomorrow and hopefully this can be diagnosed and fixed promptly. However I'm not confident as I'm still waiting on a different RAM recall which dealer says the parts are only being released to each dealer in quantities of 1 per month. Paying $80k+ for a truck that can't be driven due to known manufacturers issues from 6 yrs ago is unacceptable. I hope NHTSA can help force RAM to address these issues.

NHTSA ID

11572227

Incident

Feb 15, 2024

the vehicle has been inspected by an independent engineer from Bosch, supplied by FCA (Fiat Chrysler Automobiles), it indicates that an expert assessment has been conducted. In this case, the following answers can be provided based on that information: 1. Components or systems that failed or malfunctioned: - Half shaft axle front left - Wheel assembly - Brake rotor disc - Suspension - Drive shaft - Transfer case - Right front axle shaft - Right front caliper - Right front caliper bolts 2. Availability for inspection upon request: The availability of the failed components for inspection may depend on the specific arrangements made between the vehicle owner and the independent engineer from Bosch. It is recommended to contact the engineer or FCA for further information regarding inspection availability. 3. Safety risks: Considering the multiple component failures mentioned, there is a significant safety risk not only to yourself but also to others. These failures can lead to loss of vehicle control, compromised braking, and potential accidents or collisions. 4. Confirmation by the independent engineer: Since the vehicle has been inspected by an independent engineer from Bosch, it suggests that the problems have been reproduced and confirmed. The engineer's evaluation should provide valuable insights into the nature and causes of the failures. 5. Inspection by manufacturer, police, insurance representative, or others: The information provided indicates that an independent engineer from Bosch, supplied by FCA, has inspected the vehicle. However, it is not specified whether the vehicle or its components have been inspected by other parties such as the manufacturer, police, or insurance representative. 6. Warning lamps, messages, or symptoms: Over the past months and throughout the last year, you have experienced multiple issues with the four-wheel drive system and e

NHTSA ID

11550722

Incident

Aug 28, 2023

The contact owns a 2022 Ram 2500. The contact stated that while driving and attempting to park, when the brake pedal was depressed, it became spongy and was inoperable. As a result, the contact crashed into a building and damaged the aluminum siding of the building. The vehicle was taken to the dealer, where it was diagnosed with front left caliber failure and needed to be replaced. The manufacturer was not made aware of the failure. The failure mileage was approximately 2300.

NHTSA ID

11534756

Incident

Jul 7, 2023

Mileage

2,300 mi

The contact owns 2022 Ram 2500. The contact received notification of NHTSA Campaign Number: 22V140000 (Service Brakes, Hydraulic, Electronic Stability Control), 22V835000 (Power Train), 22V904000 (Structure), and 23V060000 (Electrical System) however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect. The contacted both recalls were completed on June 13th, 2023, but feels the length of time to repair the recall was excessive.

NHTSA ID

11525062

Incident

Jun 2, 2023

Second 2022 ram 2500 tradesman and front end shimming at all speeds. Brakes go to floor. Radio, heater doesn't work all the time. Has a ticking sound until it warms up. Been in shop many times for problems

NHTSA ID

11524173

Incident

Dec 10, 2022

2nd ram tradesman 2500 2022. Front end shakes and goes all over. Shimmer is normal at 65 but it's actually doing it at 35. Brakes are to the floor

NHTSA ID

11520759

Incident

Dec 10, 2022

Went in on July 2022 to trade in my 2017 dodge was looking at the 2500 2022 was told 2 times it was a big horn. Wasn't was a tradesman. After so many times in shop I went over to sales in December to find out what to do so many safety issues. They called it a lemon and trade for exact same one make model year. Had 6 people helping us and they did it as a trade in. Lost my 30,000 trade in and made to pay off lemon. They sold it when no it is legally ours since we had to pay it off. New one is in shop with so many problems and lied to

NHTSA ID

11511119

Incident

Dec 9, 2022

The brakes fail to work when applied. When depressing the brake pedal it sticks half way and requires continued pressing and release of the pedal before locking the disc. During the process the vehicle propels forward, creating a safety hazard that could result a serious accident and death. The malfunction occurs at low and high speeds.

NHTSA ID

11508926

Incident

Feb 23, 2023

The abs and traction control Lights keep coming on making the safety systems unavailable. This has happened 5 times, they clear when stopped but come on again. I am driving in snowy conditions and am in danger. This was scanned By one dealer and they said sometimes the sensor malfunctions and it reset and it was fixed - it kept happening on a cross country trip.

NHTSA ID

11499120

Incident

Dec 21, 2022