2022 RAM 2500 Problems

The contact owns a 2022 Ram 2500. The contact stated that while driving at an undisclosed speed, the vehicle intermittently went into LIMP Mode and failed to accelerate as needed. The contact pulled over and turned off the vehicle. The failure failed to be self-corrected after the vehicle was restarted. The vehicle was taken to a transmission specialist, who was unable to duplicate the failure. The contact was informed that the failure was electrical, and an unknown sensor was replaced; however, the failure persisted. The vehicle was taken to the dealer, who discovered a leak in the transmission pump. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and directed the contact to the dealer to have the transmission replaced. The failure mileage was approximately 120,000.

My truck was started in the morning and as it sat idle in the driveway I started attaching my trailer. By the time I got the trailer attached(20 seconds) there was smoke pouring out from under the hood. I immediately turned off the truck popped the hood and it was engulfed in flames. I was able to put out the fire with the garden hose. No check engine lights, no warning lights on dash, and I had just got it back from the dealership 2 days earlier and it passed a safety inspection before I picked it up. Im not sure what component failed but whatever did caused a fire

The contact owns a 2022 Ram 2500. The contact stated that while driving at an undisclosed speed, the vehicle intermittently went into LIMP Mode and failed to accelerate as needed. The contact pulled over and turned off the vehicle. The failure failed to be self-corrected after the vehicle was restarted. The vehicle was taken to a transmission specialist, who was unable to duplicate the failure. The contact was informed that the failure was electrical, and an unknown sensor was replaced; however, the failure persisted. The vehicle was taken to the dealer, who discovered a leak in the transmission pump. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and directed the contact to the dealer to have the transmission replaced. The failure mileage was approximately 120,000.

Per mopar recall ZA3 transmission tube and dipstick recall. When completed at Orange Coast Ram [XXX] , dealership completed recall, removed original dipstick, and provided a 15" locking dipstick the does NOT provide needed transmission fluid level. Inquired in Orange Coast Ram service department, stated they will not provide needed 44"dipstick to monitor trans fluid. I cannot order, purchase the needed dipstick, creating a dangerous situation if fluid is low, and will result in transmission damage and possible dangerous condition if transmission fails while driving/.towing. I was told I will have to go to dealership and have the level checked, which is a routine needed owner maintenance job CORRECTIVE MEASURE: PROVIDE NEEDED 44" DIPSTICK TO MONITOR TRANSMISSION FLUID LEVEL INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The DPF system failed prematurely at 68k. My truck as working fine with zero problems until I took it in for the Y43 safety recall July 2025. the dealership performed the software update without verifying if parts were in stock first. They took the part (dpf module) off a used truck from the lot and installed it on mine without asking me first. They told me they would call me when the parts became available. They never called so I took it in for a battery issue were the batteries were overheating and dying. I asked that they replace the used part and look into the fried battery issue. Knowing how this dealership operates I went ahead and marked the old part with nail polish. when I was called to pick up my truck I met with the GM and he assured me everything was taken care of and the new DPF Module was replaced. I got under my truck and the used part as still there. The GMs face went pale and couldn't believe that they had lied. He asked that I leave it so he could make things right. They replaced the DPF module and the batteries. I met with the service manager and he took full responsibility for the lies and theft. ( I have the conversation recorded). I went back a few days later to ask why my truck kept doing Regens like every 3 days and they informed me it was normal. fast forward to July 2006 same issues batteries fried and died then the DPF notification came up saying "DEF Filter Full Power Reduced See Dealer". I take it back to the same dealership and they informed me my DPF filter is full and I must pay $3800 out of pocket because the recall didn't cover it and neither does the extended warranty. I asked them how is it possible for my DPF filter to be full if all the REGENS are performed and the message will NOT clear until the region is complete. my filter never showed it was getting full and it never surpassed the 40 percent full and its impossible for it to be full from one day to the other. I took it to another dodge and stellantis refused to fix it.

Lifter failure occurred on dangerous interstate interchange complete loss of power while towing a 14k pound mobile restroom bumper pull trailer in 6 lanes merging traffic from center lane 45 mph exit onto 60 mph interstate speeds XXX going onto XXX/[XXX] my scanner said dpf plugged stellantis mechanic claims lifter failure problem is complete loss of power happened in a dangerous area and waiting for a tow while hooked to a trailer was also dangerous due to high traffic area INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ABS system HCU leaking internally Vehicles stopping ability may be impaired Vehicle brake pedal slowly sinks to floor. Ram dealership diagnosed a failed master cylinder internal seal and replaced the master cylinder with 25,272 miles on the vehicle on 3/17/26. Returned to dealership with same issue on 8/3/26 with 28,488 miles on vehicle. Ram dealership diagnoses the hydraulic control unit (HCU) is leaking internally on the ABS system. No warning lamps or other messages. First reported soft brake issue on 2/11/26.

The contact owns a 2022 Ram 2500. The contact stated that while operating the vehicle, the messages “Auto Park Disabled”, “Service Electronic Stability Control”, and “Trailer Brake System” were displayed. Additionally, while hauling a camper, the message “Trailer Brakes Disabled” was displayed, and the trailer brakes became inoperable. After restarting the vehicle, the failure was self-corrected, and the trailer brakes operated normally. The vehicle was taken to the local dealer, but the cause of the failures was not yet determined. The manufacturer was not yet contacted. The failure mileage was 65,000.

The DPF system failed prematurely at 68k. My truck as working fine with zero problems until I took it in for the Y43 safety recall July 2025. the dealership performed the software update without verifying if parts were in stock first. They took the part (dpf module) off a used truck from the lot and installed it on mine without asking me first. They told me they would call me when the parts became available. They never called so I took it in for a battery issue were the batteries were overheating and dying. I asked that they replace the used part and look into the fried battery issue. Knowing how this dealership operates I went ahead and marked the old part with nail polish. when I was called to pick up my truck I met with the GM and he assured me everything was taken care of and the new DPF Module was replaced. I got under my truck and the used part as still there. The GMs face went pale and couldn't believe that they had lied. He asked that I leave it so he could make things right. They replaced the DPF module and the batteries. I met with the service manager and he took full responsibility for the lies and theft. ( I have the conversation recorded). I went back a few days later to ask why my truck kept doing Regens like every 3 days and they informed me it was normal. fast forward to July 2006 same issues batteries fried and died then the DPF notification came up saying "DEF Filter Full Power Reduced See Dealer". I take it back to the same dealership and they informed me my DPF filter is full and I must pay $3800 out of pocket because the recall didn't cover it and neither does the extended warranty. I asked them how is it possible for my DPF filter to be full if all the REGENS are performed and the message will NOT clear until the region is complete. my filter never showed it was getting full and it never surpassed the 40 percent full and its impossible for it to be full from one day to the other. I took it to another dodge and stellantis refused to fix it.

I have dead pedal going on with my truck and when pulling out into traffic and truck does not go almost get hit by oncoming traffic and cause an accident and could end up deadly when the truck just losses the possibility to be limited to truck not being able to accelerate because it is having issues with the computer communicating with the sensor on the truck.

The DPF system failed prematurely at 68k. My truck as working fine with zero problems until I took it in for the Y43 safety recall July 2025. the dealership performed the software update without verifying if parts were in stock first. They took the part (dpf module) off a used truck from the lot and installed it on mine without asking me first. They told me they would call me when the parts became available. They never called so I took it in for a battery issue were the batteries were overheating and dying. I asked that they replace the used part and look into the fried battery issue. Knowing how this dealership operates I went ahead and marked the old part with nail polish. when I was called to pick up my truck I met with the GM and he assured me everything was taken care of and the new DPF Module was replaced. I got under my truck and the used part as still there. The GMs face went pale and couldn't believe that they had lied. He asked that I leave it so he could make things right. They replaced the DPF module and the batteries. I met with the service manager and he took full responsibility for the lies and theft. ( I have the conversation recorded). I went back a few days later to ask why my truck kept doing Regens like every 3 days and they informed me it was normal. fast forward to July 2006 same issues batteries fried and died then the DPF notification came up saying "DEF Filter Full Power Reduced See Dealer". I take it back to the same dealership and they informed me my DPF filter is full and I must pay $3800 out of pocket because the recall didn't cover it and neither does the extended warranty. I asked them how is it possible for my DPF filter to be full if all the REGENS are performed and the message will NOT clear until the region is complete. my filter never showed it was getting full and it never surpassed the 40 percent full and its impossible for it to be full from one day to the other. I took it to another dodge and stellantis refused to fix it.

I have dead pedal going on with my truck and when pulling out into traffic and truck does not go almost get hit by oncoming traffic and cause an accident and could end up deadly when the truck just losses the possibility to be limited to truck not being able to accelerate because it is having issues with the computer communicating with the sensor on the truck.

The front right strut/shock is leaking and now both have to be replaced at only 48,000 miles and 4 years old.

Death wobble at 50 mph. Factory stock suspension 11,500 miles on vehicle

The contact owns a 2022 Ram 2500. The contact stated that while driving 30-35 MPH, the steering wheel failed to turn to the left or the right. There were no warning lights illuminated. The contact associated the failure with NHTSA Action Number: PE26002. The vehicle was taken to an independent mechanic who determined that there was a loss of power steering assist function, which was caused by water intruding into the power steering module connector. The vehicle was towed to the local dealer, where it was diagnosed with a loss of power steering assist caused by water intrusion into the power steering module connector. The dealer informed the contact that there was no warranty coverage on the vehicle. The vehicle was not repaired. The manufacturer confirmed that there was no warranty coverage for the repair. The failure mileage was approximately 14,900.

The contact owns a 2022 Ram 2500. The contact stated that while driving approximately 70 MPH, the steering wheel jerked to the right and the traction control warning light illuminated. The contact stated that while the vehicle was parked, the electronic stability control, Forward Collision Avoidance, check engine, and power steering warning lights were illuminated. The vehicle was taken to a dealer, where it was diagnosed and determined that there was water intrusion in the rack and pinion, causing corrosion of the electronic power steering system and several other unknown components that needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 31,000.

Clock spring is broken. You can hear it popping when turning the steering wheel. I see other years are covered by my vin is not.

My screen on my truck went out and had to be reset manually, next my heated steering wheel stopped working. The problem is the cool spring in my steering wheel. Upon research there is a common problem with this said coil spring. This can cause multiple problems including loss of air bag function and front end collision indicator which comes on time to time saying it’s disabled due to this same said coil. Why this is not a recall and the owner’s responsibility is unknown. There is also no indicator telling you if the airbag may or may not deploy when need from this issue.

While driving the rear tail gate drops. This has happened on several different occasions. Once it dropped while towing a trailer and I damaged the tailgate on the trailer tongue jack. There is no indicator in the cab of the truck to inform you that the tailgate has dropped, unlike the door indicators. I am positive that the tailgate was up and latched, so it’s not an instance where the tailgate is not fully closed. This could lead to other vehicles or motorcycle riders hitting objects that may fall out of the open tailgate, causing damage or injuries.

The contact owns a 2022 Ram 2500. The contact stated that while driving approximately 35 MPH on the local roadway, the tailgate unexpectedly detached and remained suspended by the support cables. Due to the failure, the rear-view camera became inoperable. The vehicle was taken to the dealer, but was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 40,000.

The ABS, traction control, and 4x4 lights all came on at the same time. None are operable. During my research I was able to find recall 75b that aligns with the exactly with my current set of issues. 24v-653 is the NHTSA recall number associated. I need that recall added to my vehicle so I can get the very unsafe issue fixed

The rear passenger side seatbelt is locked. Our son was exiting the car ( and told us he couldn’t get his belt to retract. We also tried to get the belt to retract but were unable to do so. The truck has not been in any accidents, no visible wear on the seatbelt. We typically use the rear seatbelts for our children but now we cannot ride with 5 passengers safely in the vehicle. We took the truck to a RAM dealership in Hendersonville, NC who told us we would need to pay nearly $600 to repair the belt. With the truck only being a few years old and no collisions or incidents, it seems like a manufacturer defect.

I was out plowing when my wipers stopped working. brought it in for service and they first said the wiper motor was bad cost for diagnoices was $169.00 issue was not the motor. after second trip for service they found a defaulty fuse box additional charge over $800.00. I have read severl other complaints about the fuse boxes causing issues such as lose fuses etc. Repair Estimate Service Advisor Jonnah Matthews (031) [email protected] PREPARED FOR [XXX] [XXX] Date 03/29/2025 03:53 PM 2022 Ram RAM PICKUP 2500 VIN [XXX] Mileage 40,478 RO# [XXX] Service Name Price [Primary]: DIAG2 - STANDARD DIAGNOSIS SYSTEM STANDARD DIAGNOSIS SYSTEM WIPER MOTOR IS INOP, WIPERS WILL NOT WIPE. INSTALLED IN ANOTHER TRUCK AND IT WORKED OKAY, PLEASE CHECK $0.00 Fuses: fuse box $798.88 Printed on March 29, 2025 Quote expires on April 28, 2025 Subtotal $798.88 Total $798.88 McGee Chrysler Dodge Jeep Ram of Barre 1365 U.S. Route 302 Barre, VT 05641 8024764724 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2022 Ram 2500. The contact stated while attempting to set the radio stations, the contact experienced failures with radio and other safety features which were controlled by the computer that controlled the radio. Additionally, the contact stated that the defroster, the back-up camera, and the hazard warning lights were inoperable. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the computer needed a software update. The vehicle was repaired. The contact stated that the software update failed to fix the vehicle. Additionally, the contact stated that the key fob failed to lock or unlock the doors. The manufacturer was informed of the failure. The failure mileage was approximately 2,200.

The contact owns a Rexing R4 MD 4-Channel Dash Camera purchased at Walmart. The camera was designed with a 4-channel dash camera system used to record the front, rear, left, and right sides of the vehicle simultaneously. The contact stated that after installing the camera on a 2022 Ram 2500, the unit failed to turn off as intended and remained continuously powered and overheated. The contact expressed safety concerns that the failure presented a fire hazard. The contact attempted to notify the manufacturer via email and telephone at 877-740-8004; however, no response was received, and the telephone number was recently out of service.

The Tire Pressure Monitoring System (as mandated by NHTSA) fails to function properly. The system can be inspected upon request by the NHTSA because the local dealerships cannot determine the problem and refuse to contact the manufacture. Operating vehicles with over/under inflated ties causes numerous driving difficulties as well as premature and unnecessary wear on the tires. If it wasn't a concern the NHTSA wouldn't have mandated TPMS. Dealership refuses to acknowledge there is a problem. They just inflate the tires to the manufacturer recommendation and say its fixed. 2-3 days later the system tells me I have low tires. When I Check my tires with a Digital Gauge the tire pressure is correct. Problem started 10 months after purchasing this vehicle new in Jan 2022. After confirming with the dealership the installation of aftermarket Tires/Wheels would NOT void my warranty, I had the Dealer installed a set of aftermarket tires/wheels. They were supposed to remove the TP Sensors from each tire/wheel and installed in the new aftermarket tires/wheels. At this point I don't know if its a Tire Sensor problem, a problem with the system ( I believe behind the rear seat) that relays the information to the Dash Cluster or the Uconnect5 System where the Tire Pressures can be set. Dealer states I MUST inflate ties to the Tire Pressure Label installed by the manufacture on the Door Jam. I know from 23 year military transportation experience and having a friend loose his life because of over inflating a tire in the Vehicle Maintenance Shop as well as a Commercial Driver License Instructor You always use the information on the side of the tire provided by the Tire Manufacture. The Tire Pressure Monitoring System is accessed through the UConnect5 Computer System where the owner can program features associated with the vehicle such as Temperature, Lighting, Radio Stations, Tire Pressures and a host of other features.

Bought 2022 Dodge Ram 2500 equipped with Firestone LT275/70R18E 125 tires on Dec2023. Truck has 21000 miles, sidewalls on all 4 tires are splitting and have a ring around them in the same exact spot on the sidewalls. Dealer said it appears to be a defect on all tires. Dodge referred me to Firestone, got no where with them. Tires appear the sidewalls could blow out on highway and unsafe. Caught defects before possible premature blowouts on all 4 tires due to premature cracking on sidewalls. No towing or hauling done with truck, never been off pavement either, truck parked under cover from sun etc. Dealer advised tires not worn and had great tread depth. Dodge Ram installed these tires to sell the truck but referred me to Firestone for replacement, still trying to get someone to own up to these defective tires besides me.

I purchased this 2022 Ram 2500 crew cab diesel 4x4 in June of 2023. The truck was purchased brand new with only 8 miles on it. The truck had the original OEM - Firestone Transforce HT LT275 70 R18 tires. The truck has 9500 miles on it now and I just noticed that all 4 tires have dry rot type cracking around a slightly depressed ring on the sidewall of the tires. This looks similar to the defective tires described in a voluntary recall of the same tires in 2021. These tires appeare to be defective. There is no reason that tires that are a few years old wth only 9500 miles on them should have this uniform dry rot type cracking on all 4 tires. I took the truck to Discount tire and the technician confirmed that the tires were not safe to operate so now I have to buy all 4 tires and I am replacing the spare as well. I should not have to buy a whole set of truck tires at 9500 miles! 2021 Recall information: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

What component or system failed or malfunctioned, and is it available for inspection upon request? FACTORY TRAILER BRAKE CONTROL UNIT. How was your safety or the safety of others put at risk? BRAKE CONTROL INTERMITTENTLY FAIL TO WORK. NOT ABLE TO STOP 15,000 LB TRAILER. WEIGHT PUSHS VEICHLE OUT OF CONTROL. Has the problem been reproduced or confirmed by a dealer or independent service center? NEVER DOES IT FOR THE DEALER OR INDEPENDENT SERVICE CENTER AND THEY TOW MY TRAILER AROUND SEVERAL TIMES. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? DEALER & SERVICE CENTER Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? NO NO HOW DO I GET HELP IT IS A 2022 RAM 2500 BROUGHT NEW BY ME AND STARTED HAVING TROUBLE OFF AND ON SINCE THE FIRST 1,000 MILES AND NOW HAVE 26,000 MILES. I READ ABOUT THE RECALLS ON THE 2024 2025 RAM 2500 3500 MODELS WITH AN ENGINEERING PROBLEM ON TWO DIFFERENT VENDORS MAKING CONTROLERS FOR FCA.

First issue (intermittent) the light control did not come on or operate the lights in the auto position to a high beam in limited visibility. The rotation knob for interior lighting would not work and the display was bright that affected seeing at night. No codes was generated and will be going to have the vehicle check out by dealership on Feb 8 2023. Second issue the truck demonstrated a short loss of power (a low grinding was heard) in two instances that resulted in low acceleration when turning across traffic lane.

The contact owns a 2022 Ram 2500. The contact stated that while attempting to exit the vehicle, the front driver's door became inoperable. The window and door actuator failed to function during the failure, requiring the contact to repeatedly pull the door handle and engage the actuator to exit the vehicle. The vehicle was taken to a dealer, where it was diagnosed that a piece of plastic near the wiring caused the wiring to fail, and the wiring needed to be replaced. The vehicle was not repaired. The contact expressed concern that the failure was hazardous due to a disability and presented a safety risk in the event of an emergency. The manufacturer was notified of the failure. The failure mileage was approximately 45,000.

While slowing for traffic, I was struck in the rear by a large pickup. On impact, the driver seat broke, causing the whole seat to tilt back to more than 45 degrees backwards tilt. This caused me to impact the seat at a greater impact than I would have had if the seat remained in place. The seat being in that position after the impact, made it so I could not reach the pedals (brakes) to stop the vehicle from rolling forward until I used the steering wheel to pull myself forward. Upon inspection after the collision, it was observed that part of the adjustment assembly detached from a bolt causing the seat to come loose from its proper position.