Owner-reported complaints naming the other system, filed with NHTSA
Data refreshed
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above. Every record below is an owner-reported complaint about the 2004 Toyota Highlander submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 9 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
My car malfunctioned my tire locked up while I was driving on the high way causing me to spin out of control and skid all the way into a guard rail totalled my car out and not one air bag went off
TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHILE DRIVING VARIOUS SPEEDS, WHILE DEPRESSING THE BRAKE PEDAL, THE PEDAL TRAVELED TO THE FLOOR. THE TRACTION CONTROL, CHECK ENGINE, VSC, AND BRAKE INDICATORS ILLUMINATED. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 10V499000 (SERVICE BRAKES), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE CONTACT OBSERVED BRAKE FLUID LEAKING FROM THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 157,489.
I TOOK MY 2004 TOYOTA HIGHLANDER V6 TO LONGO TOYOTA FOR BRAKE BOOSTER RECALL IN NOVEMBER 2010. THEY KEPT MY CAR NEARLY 7 WEEKS BEFORE REPAIR WAS COMPLETED. A FEW DAYS AFTER PICKING UP MY VEHICLE, WHILE I WAS PARKED DROPPING OFF MY PASSENGER, MOST OF THE CONTROL PANEL LIGHTS ILLUMINATED (BRAKES, ABS, TRAC OFF, VSC, CHECK ENGINE). I REPORTED THIS TO THE DEALER. THEY SAID TO BRING THE CAR BACK. I TOOK THE CAR BACK AND DIAGNOSTIC TESTS WERE RUN AND CONCLUDED THAT A CODE WAS STORED BUT IT WAS NOTHING SPECIFIC THAT HAD FAILED. BRAKE SYSTEM WAS BLED. IN JUNE 2011, THE LIGHT CLUSTER ("CHRISTMAS TREE" IS HOW THE DEALER REFERS TO IT) ILLUMINATED AGAIN WHILE I WAS ATTEMPTING TO PICK UP MY CAR FROM MY LOCAL TOYOTA DEALER (BOB SMITH TOYOTA). AGAIN, THE CAR WAS LEFT. AGAIN IT WAS REPORTED TO ME THAT THE SYSTEM HAD STORED A CODE BUT NO SPECIFIC COMPONENT WAS IN FAILURE AND THE BRAKES WERE BLED. APPROXIMATELY, JULY 20, 2011 AND JULY 23, 2011, THE LIGHTS ILLUMINATED AGAIN, ONLY FOUR OF THEM (TRAC OFF, VSC, ABS, BRAKES). I CONTACTED THE TOYOTA DEALER ON TUESDAY, JULY 26 AND WAS FORCING THE ISSUE ON JULY 29, 2011 AND MADE AN APPOINTMENT FOR AUGUST 1, 2011. ON JULY 31, 2011, THE SAME FOUR LIGHTS ILLUMINATED WHILE DRIVING AND STAYED ON. I STOPPED, TURNED OFF THE ENGINE, RESTARTED THE VEHICLE, AND EXPERIENCED A VERY SPONGY, SQUISHY BRAKE PEDAL. I CONTACTED TOYOTA MOTOR CORPORATION TO FURTHER ADDRESS THE CONCERN OF MY VEHICLE NOW BEING UNSAFE AS A RESULT OF THEIR RECALL. TOYOTA MOTOR CORPORATION WAS VAGUE AND SAID THAT THE MATTER COULD ONLY BE ADDRESSED BY LONGO TOYOTA, THE DEALER THAT PERFORMED THE RECALL, SINCE THE PARTS WARRANTY WOULD ONLY BE WITH THEM. IN CONTACTING BOB SMITH TOYOTA, THE SERVICE ADVISORS SWEARS THAT THE PROBLEM CAN BE RESOLVED BY THEM. IT APPEARS THAT PERFORMING THE RECALL WEAKENED THE INTEGRITY OF MY BRAKE SYSTEM. AS ONE REPRESENTATIVE SAID, "YOU WILL NOT HAVE A CATASTROPHIC FAILURE AND YOU WILL STILL BE ABLE TO STOP. IT WILL JUST TAKE LONGER." *KB
I HAVE A 2004 4 CYL HIGHLANDER, AND I CAN COMPLETELY UNDERSTAND THE OTHER COMPLAINERS SITUATION AS I AM EXPERIENCING THE SAME PROBLEM. IT HAPPENED AT AROUND 60K MILES AND THE DEALER SAID IT WOULD COST ABOUT $600. TO FIX. I DIDN'T. I JUST HAD TO PLAY AROUND WITH THE KNOB WHEN I NEED TO USE IT. *TR
THE CHECK ENGINE, VSC, TRAC-OFF LIGHTS APPEARED ON MY DASHBOARD OF MY 2004 TOYOTA HIGHLANDER ON OR AROUND MARCH 7, 2010. ON MARCH 9, I WENT TO MY LOCAL MECHANIC WHOSE TOYOTA DIAGNOSTIC MACHINE INFORMED THEM THAT SINCE THIS VEHICLE HAD UNDER 80,000 MILES - IT WAS STILL COVERED BY MY ORIGINAL WARRANTY. I MADE AN APPOINTMENT WITH SUNRISE TOYOTA, IN OAKDALE, NY WHERE I PURCHASED THIS HIGHLANDER. AFTER SHOWING SUNRISE TOYOTA SERVICE REP: CHARLES SALVATO THE DIAGNOSTIC PRINTOUTS - HE REFUSED TO ADDRESS THE PROBLEM BECAUSE THE PREVIOUS MECHANIC INADVERTENTLY CLEARED THE WARNING LIGHTS. THEY WOULDN'T ACCEPT THE DIAGNOSTIC PRINTOUTS AS PROOF OF A PROBLEM NOR WOULD THEY AGREE TO CHECK-OUT OR RE-RUN THE DIAGNOSTIC TEST. AFTER FORMALLY COMPLAINING, I DID HEAR FROM A BOB JOHNSON AT SUNRISE TOYOTA WHO ASK ME TO STOP IN. WHEN I DID STOP BY, I WAS TOLD HE WAS AT AN ALL DAY MEETING. MY DISTINCT FEELING IS THAT THEY ARE HOPING TO LET THE CLOCK RUN OUT (LET THE MILEAGE GO OVER 80,000) SO THAT NOTHING HAS TO BE DONE. I AM ASKING FOR NHTSA'S ASSISTANCE WITH THIS IMPORTANT SAFETY CONCERN. A CONCERN, I FEEL,TOYOTA IS STILL RESPONSIBLE FOR. THANK YOU FOR YOUR ASSISTANCE IN THIS MATTER. *TR
2004 HIGHLANDER, HAVING SAME PROBLEMS AS ALL OTHER REPORTED PROBLEMS FOR THIS VEHICLE. HESITATION, STEERING SHAFT REPLACEMENT, 2 WHEEL BEARING REPLACEMENTS, LOUSY ORIGINAL TIRES, BAD SODERING OF HEAT/AIR BOARD LEADING TO NOT WORKING PROPERLY, CAN NOT HAVE BACK WINDOWS DOWN DUE TO NOISE AND VEHICLE SHAKING, HAD REAR WIPER MOTOR REPLACED WITHIN 1ST MONTH OF OWNERSHIP. WHILE I DID PURCHASE THE EXTENDED WARRANTY, WHICH DID COVER THE COST OF THE WHEEL BEARING REPLACEMENT, IT DID NOT COVER THE COST OF HAVING TO REPLACE THE TIRES DAMAGED BY THE BAD BEARING - AND TOYOTA DOES NOT CARE. IN THEIR RACE TO BECOME THE NUMBER ONE CAR MAKER, THEY HAVE GIVEN UP ON BEING THE SAFEST, MOST RELIABLE CAR MAKER - AND THEY HAVE CERTAINLY GIVEN UP ON BEING CUSTOMER FRIENDLY. ACCORDING TO SEVERAL TOYOTA DEALERS, THEY DON'T HAVE TO, SINCE THEY CONTINUE TO BE POPULAR SELLING VEHICLES. I AM GETTING NERVOUS AS THE TIME FOR MY WARRANTY COMES DUE TO EXPIRE - AND FOR THE FIRST TIME AM SERIOUSLY CONSIDERING TRADING IT IN BEFORE THAT HAPPENS. THAT WAS NOT THE INTENT WHEN I BOUGHT THE VEHICLE, BUT AFTER READING ALL THE PEOPLE HAVING ALL THE SAME PROBLEMS, I AM VERY CONCERNED. *TR
THE GPS IN MY 2004 TOYOTA HIGHLANDER GOES ON AND OFF WITHOUT WARNING. WHEN IT DOES IT DISABLES THE DEFROSTER, AC AND HEAT. I DON'T CARE ABOUT THE GPS, BUT WHEN IT DISABLES MY DEFROSTER, IT IS A SAFETY ISSUE. IT SHOULD HAVE BEEN A RECALL FROM THE MANUFACTURER. TOYOTA HAS INFORMED ME A NEW GPS WILL COST $5,000.00. I CAN PUT A USED ONE IN FOR $1,500.00. THIS IS AN UNFAIR PRICE TO HAVE A NECESSARY SAFETY FUNCTION, THE DEFROSTER, TO WORK. DEFROSTER ARE REQUIRED FOR STATE INSPECTION. DO YOU HAVE ANY SUGGESTIONS FOR TOYOTA TO ADDRESS THIS ISSUE? *TR
I HAD A FLAT TIRE ON MY 2004 TOYOTA HIGHLANDER. MY HUSBAND AND I WERE GOING THROUGH THE TIRE REPLACEMENT STEPS AND HAD THE VEHICLE JACKED WITH THE MANUFACTURER PROVIDED JACK. AFTER REMOVING THE LUG NUTS, I WENT TO REMOVE THE FLAT TIRE FROM THE WHEEL STUDS. THE JACK POPPED OUT OF PLACE AND BENT, AND IS NOW UNUSABLE. WE HAD TO FIND A HEAVY DUTY JACK TO LIFT THE VEHICLE TO GET THE TIRE OFF AND PUT THE SPARE TIRE ON. SPARE WAS PLACED AND PROPERLY TIGHTENED. NOW, THERE IS A SCRAPING SOUND WHEN DRIVING THE VEHICLE AT ANY SPEED. I HAD FLAT FIXED AND WHEN TIRE COMPANY REMOVED SPARE, ONE WHEEL STUD FOR FRONT PASSENGER SIDE BROKE OFF. TIRE COMPANY SAYS THEY'VE SEEN THIS NUMEROUS TIMES WITH HIGHLANDERS; THE INTEGRITY AND/OR MACHINING OF THE WHEEL STUD APPEARS DEFECTIVE. *JB
JACK SUPPLIED WITH VEHICLE IS INADEQUATE FOR SIZE/WEIGHT OF VEHICLE PARTICULARLY ON VEHICLES EQUIPPED WITH OPTIONAL 16" WHEELS. *JB
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .