2019 Toyota Highlander Engine Problems

I am writing to formally document a series of unresolved mechanical issues with my vehicle, culminating in a complete transmission failure, and to request assistance in resolving this matter. The timeline of events is detailed below: *Winter 2024: I first noticed a persistent buzzing sound originating from the engine compartment. Because this symptom primarily occurred during low ambient temperatures, I initially attributed it to the cold weather. The mileage on this vehicle was around 50k miles. *Spring 2024: I contacted the dealership to report the noise. I was advised that the issue was likely related to a worn belt. Subsequent inspection, however, proved this diagnosis to be incorrect, and the root cause of the noise remained unresolved. *Fall 2024: The engine buzzing returned. Concurrently, a severe driveability issue emerged. On multiple occasions after shifting from Park to Drive, the vehicle failed to engage the gear properly, behaving as though it were in Neutral and preventing any acceleration. This would occur while driving and stopped at redlights, which posed a major safety concern as I was transporting my newborn and young child with me. * February 2025: The vehicle became entirely inoperable. Unfortunately, this failure occurred around 62k miles, AFTER my 60k mile warranty expired, (which i was unaware of). Given that these symptoms began during the winter of 2024 and were reported to the dealership early on, it is clear that the initial diagnostics failed to identify a developing and critical transmission defect. I conducted research and discovered this is a recurring issue with Toyota Highlanders, and other vehicles with the model UA80 transmission. Toyota posted a service bulletin, extending vehicles from 2017 & 2018 but have yet to address the 2019 through current models to date with reports of the same transmission issues.

NHTSA ID

11751157

Incident

Feb 10, 2025

The car is was a 2019 Toyota Highlander with approximately 125,000 miles. White Smoke started appearing in the exhaust. Quickly after that, the check engine light appeared and started blinking, meaning the engine was misfiring. We brought to the dealership, and they found that cylinder 4 of the engine was damaged (scoring on the inside of the cylinder wall). The engine was releasing metal particles in the oil. Further, the cylinder would not hold oil or coolant pressure, and was burning both oil and coolant. The only fix was to replace or rebuild the engine.

NHTSA ID

11749690

Incident

Apr 15, 2026

My transmission is now missing the 3rd gear and left me and my kids stalled in traffic as I was turning in oncoming traffic. Toyota dealership confirmed that was the problem upon inspection.

NHTSA ID

11727156

Incident

Mar 5, 2026

Our 2019 Toyota Highlander currently has 54,605 miles. In August 2025, when the vehicle had 50,236 miles, we brought it to the Toyota dealership to address a whining noise coming from the transmission. At that time, the vehicle was still under the manufacturer’s warranty. The dealership performed a transmission service during that visit. Within the following weeks, however, the whining noise returned, and the vehicle began experiencing hard and delayed shifting. Our children and grandchildren have recently moved to Washington, and we had planned to drive there to visit them. Unfortunately, we are now reluctant to drive the vehicle due to safety concerns, as we have been advised that the transmission may be failing. The dealership has now recommended a full transmission replacement. Because the original concern was reported while the vehicle was still under warranty, we believe the issue should have been properly diagnosed and resolved at that time. However, the problem was not addressed, and the vehicle is now outside the warranty period, with Toyota declining to cover the cost of the replacement transmission. Given that the problem was first reported while the vehicle was under warranty, we are requesting that Toyota reconsider covering the transmission repair or replacement.

NHTSA ID

11723801

Incident

Aug 11, 2025

Tramision it no good make nose and power go off transmisión lose power and make smoke

NHTSA ID

11720836

Incident

Dec 25, 2025

Bought car in April 2025. Has 80,000 miles. Transmission failed.

NHTSA ID

11714590

Incident

Jan 29, 2026

1. What component or system failed or malfunctioned? System: Power Train: Automatic Transmission Specific Component: UA80 8-Speed Automatic Transmission (Internal Failure) Available for Inspection: Yes, the vehicle is currently available. 2. How was your safety or the safety of others put at risk? While merging onto the highway, the transmission failed to upshift, resulting in a sudden and unexpected loss of acceleration. The vehicle could not reach or maintain highway speeds (speed limit). This created an immediate hazard as I was unable to keep up with the flow of traffic, forcing me to make an emergency exit across multiple lanes while moving significantly slower than other vehicles. The loss of motive power increased the risk of a high-speed rear-end collision. 3. Has the problem been reproduced or confirmed by a dealer? Yes. The problem was confirmed by Heritage Toyota Service. The technicians confirmed an internal transmission failure. A secondary consultation with a transmission specialist (AAMCO) also identified the failure as a known mechanical defect common to this transmission model. 4. Has the vehicle been inspected by the manufacturer... or others? Yes, it has been inspected by the authorized Toyota Dealership listed above. I have also reported the issue to Toyota Brand Engagement (National), but a corporate field inspection (DSPM) has not yet been performed. 5. Were there any warning lamps... or other symptoms? Symptoms: A distinct whining noise from the engine/transmission area that increased with vehicle speed. Prior Events: The vehicle was taken to the dealer specifically for this noise. The dealer performed a fluid change and released the vehicle. The catastrophic failure (loss of power) occurred less than 24 hours after leaving the dealership. No dashboard warning lights illuminated prior to the loss of power.

NHTSA ID

11713876

Incident

Jan 28, 2026

2019 highlander has a winding sound coming from engine area, no warning lights turned on but winding sound only occurs when in drive and accelerating. vehicle has 90000 miles and winding sound started around 80000 miles. i brought highlander to toyota service and they stated they heard the sound but didnt diagnose it.

NHTSA ID

11712316

Incident

Feb 1, 2025

In early January 2026 there was rough/delayed shifting, whining noises, and fluid leaks. Probably linked to the faulty UA80E/F transmission type. The check engine light came on 1/15/26, I took it into a local repair shop. The mechanic flushed and changed the transmission fluid, replaced all of the spark plugs and the serpentine belt. I picked it up on 1/16/26. There was still shuddering, strange sounds (whining/grinding), and hesitation. On 1/20/26 I drove it and the rough/delayed shifting, whining noises, hesitation and burning smell started happening. The car completely broke down on the freeway and wouldn't drive at all. I had to slowly pull over to the shoulder of the freeway and have the car towed to the repair shop. They inspected it and said I need a new transmission, and it cannot be fixed. I believe the next steps are to have it towed to the toyota dealership to have it looked at.

NHTSA ID

11712131

Incident

Jan 20, 2026

Transmission failure resulted in sudden loss of power while driving, creating a safety risk in traffic. Vehicle was unable to accelerate and required immediate repair. Put myself and my children at risk, as the car suddenly died while I was driving it. Prior to this, there were not issues. Has been routinely maintained and only has approx 83k miles. Toyota agreed that the transmission is the only issue with my car but won't cover the cost to replace it (10k) or the cost of a loaner vehicle. I have been without a car for almost a month while the (refurbished) transmission is on backorder.

NHTSA ID

11711297

Incident

Dec 14, 2025

Initially had issues with acceleration with RPM’s going high with car moving very slowly. Five days after that started, car broke down 3 times in one trip & would not drive or go in reverse. Per dealership, the car needs a new transmission even though it’s only a 2019 with 110,000 miles.

NHTSA ID

11710131

Incident

Jan 4, 2026

The contact owns a 2019 Toyota Highlander. The contact stated that while driving on several occasions at various speeds, the contact heard abnormal buzzing sounds coming from underneath the vehicle. The vehicle was taken to a dealer; however, the failure could not able to be replicated. The contact stated that a day or two days later, while stopped at an intersection, and attempting to accelerate, the vehicle failed to accelerate as intended. There were no warning lights illuminated. The vehicle was pulled over to the side of the road and restarted; however, the failure persisted. The vehicle was towed to a dealer, where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 59,000.

NHTSA ID

11706566

Incident

Nov 24, 2025

Mileage

59,000 mi

The car randomly shuts off, while waiting in line or when the break is depressed. The vehicle won’t start, battery is completely dead and then comes back randomly.

NHTSA ID

11706378

Incident

Dec 21, 2025

•What component or system failed or malfunctioned, and is it available for inspection upon request? Transmission and power train failure during normal operation. Vehicle was occupied by mother and two small children. Vehicle produced a whining noise, delay in shifting and power failure. No warning lights appeared to give any indication of failure prior to occurring. Vehicle is available for inspection. •How was your safety or the safety of others put at risk? Vehicle stalled during normal operation. No warning indicators were present. No ability to proceed to shoulder. Traffic hazard in middle of road. Possibility of being rear ended increased. Exiting the vehicle in traffic to determine fault increase probability of being struck. Two young children seated to the rear should vehicle be rear ended due to sudden stop could cause catastrophic injuries or death. •Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, vehicle was taken and diagnostic conducted by Glendora Toyota. Vehicle was kept overnight. Dealer determined that vehicle had a transmission failure. Multiple articles and bulletins by Toyota indicating and acknowledging transmission failures in 2019 Toyota Highlander. •Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Vehicle has only been inspected by Glendora Toyota service personnel. •Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No warning lights or indicators. Whining noise was heard prior and taken to Glendora Toyota for diagnosis. They advised no problems with vehicle.

NHTSA ID

11702607

Incident

Dec 1, 2025

The contact owns a 2019 Toyota Highlander. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. The contact was able to pull over to the shoulder of the roadway, where the vehicle failed to restart. The check engine warning light was illuminated. The vehicle was towed to the dealer and diagnosed with head gasket failure, resulting in damage to the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 124,000.

NHTSA ID

11695320

Incident

Oct 20, 2025

Mileage

124,000 mi

Started noticing a whining noise when accelerating. This appears to be drive shaft/transmission issue. Was quoted 7k to remove and replace. This should be an active recall for this issue what is Toyota doing?

NHTSA ID

11692580

Incident

Oct 10, 2025

The car only has 73, 000 miles on it and Toyota said it needs a new transmission. The car starting making a "whining" sound on acceleration so we took it into Toyota for diagnostic. We also found out that the Rav 4, Sequoia and Tacoma were all recalled for this same year for transmission issues. Toyota is trying to charge us $10,000 to have the transmission replaced since it is no longer under warranty.

NHTSA ID

11688640

Incident

Sep 19, 2025

Whining sound when when pushing the gas to accelerate. When you let go of the gas it stops.

NHTSA ID

11668011

Incident

Jun 2, 2025

Hello, it seems that my vehicle is having a whirling noise when accelerating at different RPMs. When I researched, it isn’t an isolated incident because many others online are experiencing the same issue with most of them being told that the transmission must be replaced. And further investigation, I found that the issue could be the trans axle assembly component which can cause issues if not replaced.

NHTSA ID

11661323

Incident

May 15, 2025

Upon acceleration, the engine revved high and a whine sound started once the car (2019 Highlander XLE) approached 25-40 miles per hour. It appears that this is a transmission issue that Toyota was aware about years before selling the 2019 (and later) Highlander and other models (according to consumer complaints online). The car has 92,700 miles on it and is thus out of warranty. It had a recall in 2020 though I do not know exactly what was allegedly fixed. Had Toyota disclosed these serious transmission issues, I would not have purchased the car. My local mechanic has advised that the transmission will need to be replaced at a high cost.

NHTSA ID

11661165

Incident

May 12, 2025

Needs transmission at 90,000 miles - original owner - well maintained car- manufacture defect according to dealer According to various websites other 2019 Toyota Highlanders have had similar issues Had 2009 Highlander that lasted til almost 200,000 with no Issues

NHTSA ID

11655388

Incident

Apr 18, 2025

[XXX] Dear staff there are other people complaining of ENGINE MISFIRE also [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11643789

Incident

Feb 19, 2025

2GR engine family in general used in Toyota and Lexus, may have a MANUFACTURING defect as per google about the 2GR-FE engine subtype Yes, the Toyota 2GR-FE engine, a 3.5L V6 found in many Toyota and Lexus models, is known to have a recurring issue with head gasket leaks, particularly where coolant leaks externally from the engine block due to corrosion around the cylinder head where the coolant port is located; this is considered a common problem with this engine type. Key points about the 2GR head gasket issue: Leak location: Coolant typically leaks outside of the engine block, visible as stains on the block surface, rather than internally into the combustion chambers. Cause: Corrosion around the cylinder head near the coolant port, often exacerbated by road salt and old, acidic coolant. Prevention: Regularly changing coolant and occasionally hosing down the engine block, especially if you live in a region with heavy winter road salt. Repair: Replacing the head gasket usually requires removing the engine, making it a major repair job. So TOYOTA should be held liable for REPAIR COSTS and LABOR as well as the PAIN and SUFFERING a consumer has to go through, seeing all the drama of the TOYOTA

NHTSA ID

11643457

Incident

Feb 18, 2025

Dear Staff, after SEVERAL payments made for DIAGNOSTICS i feel like I should commit suicide maybe because of this TOYOTA I can not afford to pay DIAGNOSTICS every single day to HEAR the SAME STORY over and over I understand there is a ENGINE CHECK LIGHT, I need it repaired PLEASE instead of having to pay DIAGNOSTIC FEES which ADVANCE AUTOPARTS doesnt even charge and TOYOTA takes $172 DIAGNOSTIC FEES when they can not even themselves RULE OUT the PROBLEM in their ENGINEERING or MANUFACTURING PLEASE look out for similar issues, ENGINE problems in 2GR-FKS engines as more people experiencing issues will CONFIRM its TOYOTA's fault They should either shut down their manufacturing in Japan or BRING BACK the STANDARDS of JAPANESE AUTOMOTIVES

NHTSA ID

11643328

Incident

Feb 18, 2025

ENGINE CHECK LIGHT coming on constantly Cylinder 3 misfire reported under DIAGNOSTICS of ADVANCE AUTOPARTS 500 Rte 291, Lee's Summit, MO 64063 another workshop said NO MISFIRE however now it says Engine Misfire 1, 3, 5, 6 4 cylinders misfiring as per diagnostic on 02/15/2025

NHTSA ID

11643065

Incident

Feb 15, 2025