2019 Toyota Highlander Powertrain (other) Problems

The contact owns a 2019 Toyota Highlander. The contact stated that while his wife was driving, the engine made an abnormal sound. While making a turn, the vehicle experienced a loss of motive power, slowly responded, and the transmission failed to shift properly. The traction control warning light illuminated prior to the failure, and the check engine warning light illuminated after the failure. The vehicle was taken to the dealer for diagnostic testing. The dealer diagnosed the vehicle with transmission failure, and the contact was informed that the transmission required replacement. The vehicle was driven back to the residence. The contact stated that the vehicle was unsafe to drive due to the transmission failure. The failure mileage was approximately 84,820.

NHTSA ID

11775854

Incident

Oct 20, 2026

Mileage

84,820 mi

Transmission. I brought my 2019 Toyota Highlander to the Toyota dealer for an oil change. Reported a whirring sound when depressing the gas. After they inspected it, I was told it needs a new transmission. I don't know when it can malfunction when driving.

NHTSA ID

11775797

Incident

Nov 2, 2026

Whining in the transmission. Took to a certified Toyota Mechanic and confirmed transmission is failing. Will need a total transmission replacement.

NHTSA ID

11775159

Incident

Oct 1, 2026

The component that failed was the transmission. My safety was at risk because I was going uphill and the engine surged then the transmission seized, almost causing a rear-end incident with my family in the car. The dealer confirmed that the transmission has failed. No incident happened so only the dealer needs to be involved at this time. There were no warning lamps indicating to me that the transmission failed. Upon discovering that the transmission was not downshifting (based on the engine not downshifting uphill), I put the car into manual mode to determine if I could manually shift down or not, it would not downshift. Attempting to downshift to gears 4, 3, 2, or 1 was not possible, the lowest gear was gear 5 and the engine had no torque to get up the hill that it was seized on. The 2019 Toyota Highlander was serviced for the automatic transmission fluid at 100K miles and failed at about 120,450 miles.

NHTSA ID

11774232

Incident

Oct 18, 2026

My transmission failed while driving. The gears began to stick and then I lost all driving capability while on a state highway.

NHTSA ID

11773893

Incident

Oct 19, 2026

The transmission has been making a whining noise for a little while now. After having it diagnosed by Toyota, the entire transmission has to be replaced. According to multiple reports on the internet, the 8 speed transmission in the 2017 to 2026 model will fail prematurely do to defective components. Toyota has even replaced multiple model year transmissions under a specific TSB but has not included later model years. I know have to spend $10,500 to replace the transmission at Toyota.

NHTSA ID

11773877

Incident

Aug 1, 2026

Transmission is making a whining noise, took it to the dealer and they confirmed the transmission needs to be replaced. Looked online and there appear to be thousands of these cases with the transmission going out on Toyota Highlanders between 2017-2021

NHTSA ID

11772805

Incident

Oct 16, 2026

The vehicle began making a whining noise several months ago. After doing some research this vehicle has the UA80 transaxle that has a known defect that produces the whining noise and eventual damage. There are other years of this vehicle that are subject to a recall/repair for this same transaxle issue, but not for the 2019 even though it's the same transaxle with the same assembly defect. This is a known issue by the manufacturer. The end result without repair will be a transaxle failure while in gear / loss of propulsion. This vehicle has not been taken to a dealer for inspection yet. If a request for inspection is made, the vehicle can be made available. Also, no warning lamps or messages gave any early indication of an issue, only a whining noise was noticed.

NHTSA ID

11772411

Incident

Nov 17, 2025

I started hearing a faint sound and initially thought it was odd, but certainly sounded different and could not really tell where it was coming from. Upon taking it to the dealer for diagnosis, I learned that the transmission will need full replacement. I also took it to an independent shop to get a second opinion and much to my dismay, they confirmed the same.

NHTSA ID

11772392

Incident

Oct 16, 2026

Car experiences pulling, squealing, and eventually just completely stopped in the middle of the road. Car is 7 years old w/ ~90k miles and was serviced at the dealership until the most recent inspection. Towed to nearest shop and transmission is shot. Similar to every other complaint listed online. Now being quoted ~$9k to repair/replace on a car worth ~$20k.

NHTSA ID

11772205

Incident

Oct 19, 2026

I am filing this complaint regarding a transmission failure in my 2019 Toyota Highlander at approximately 150,000 miles that resulted in a complete loss of propulsion while driving on the highway. My husband was driving to work toward River Forest, Illinois, when he initially noticed that the vehicle would not accelerate beyond approximately 60 mph. After attending practice, he decided to return home rather than continue to the office because of the vehicle’s performance. While driving home on the highway, the vehicle progressively lost the ability to maintain speed. Despite traveling at approximately 60 mph, the vehicle slowed to approximately 30 mph, then 20 mph, and eventually lost propulsion completely. This created a serious safety concern because the vehicle could no longer maintain highway speeds or continue driving normally, potentially exposing the driver and surrounding motorists to a collision. The vehicle was subsequently taken to an independent repair facility for evaluation, and a transmission failure is suspected. The estimated cost to replace the transmission is approximately $5,000 to $10,000. I contacted Toyota Corporate to report this failure and request assistance. Although a case number was assigned, Toyota representatives informed me that they would not escalate the concern without historical maintenance documentation. We purchased the vehicle in 2024 and do not have access to its complete maintenance history. I am requesting that NHTSA investigate whether this transmission failure and sudden loss of propulsion represent a broader safety defect affecting Toyota Highlander vehicles.

NHTSA ID

11771663

Incident

Sep 22, 2026

The contact owns a 2019 Toyota Highlander. The contact stated that while driving at various speeds, a loud grinding and humming sound was heard intermittently from underneath the vehicle. The vehicle was taken to an independent mechanic, who diagnosed a transmission failure and warned that the transmission could experience a complete failure. The vehicle was not repaired. The mechanic contacted the manufacturer, who confirmed that the VIN was not included in a recall. The manufacturer contacted the dealer on the contact's behalf; however, no further assistance was provided. The failure mileage was approximately 65,000.

NHTSA ID

11771372

Incident

Oct 15, 2025

Mileage

65,000 mi

Transmission had problems with shifting gears - can hear a banging noise while shifting gears. Reported to dealer and they indicated diagnostics report showed purge valve issues. Nothing showing transmission errors. 9/20/26 significant transmission Issues occurring with eco mode turning on and off problems with shifting and no power with RPM up to 5 let off gas pedal and eco shift then transmission accelerated. Problem repeated for 40 miles on Interstate 95 with family and animals. Engine lights finally come on stating AWD error traction control On and off visit dealer an 1/8 mile from Haley Toyota Richmond VA - $280 diagnostics show transmission failure, needs to be replaced for $12000 at 87K miles warranty expired no assistance offered and "0" transmissions available throughout the United States- - $470 out of pocket tow truck to get it to a local transmission shop in Waldorf MD 25 miles from home. Definitely a safety issue when there is no acceleration on a major highway and now error codes to indicate there is a major transmission problem!

NHTSA ID

11771267

Incident

Jul 23, 2026

The contact owns a 2019 Toyota Highlander. The contact stated that driving the vehicle lost power and failed to properly accelerate while depressing the accelerator pedal. There was an abnormal whining sound coming from the transmission and the vehicle lunged forward and unintendedly accelerated. The vehicle was taken to the local dealer and was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not yet repaired. The contact was informed that the transmission was on back order from the manufacturer. The manufacturer was notified of the failure. The failure mileage was 74,000.

NHTSA ID

11769592

Incident

Sep 24, 2026

Mileage

74,000 mi

While driving along, the car suddenly begun not too shift in the middle of an intersection. Fortunately for me, this occurred in the middle of the night when there were not many cars around, otherwise serious injury would likely have occurred since it was in a busy area. I had the car towed to an independent shop first who indicated that the problem was likely a transmission failure. I subsequently had it towed to the Toyota Dealership in Wilkes-Barre PA (Motor World), who confirmed it was complete failure of the transmission, with metallic particles circulating throughout its entirety. According to Toyota, the transmission fluid in this type of car is meant to last the life of the vehicle and regular flushes should not be required. Certainly this appears to not be the case. There were no warnings of obvious symptoms that I could appreciate as a lay person. Toyota is quoting me close to $9000 for the transmission replacement, and I am also currently incurring considerable expense from rental vehicles while I figure out the outcome.

NHTSA ID

11769486

Incident

Sep 26, 2026

The vehicle has a loud whining noise coming from the front of the car. The noise is only heard when I am pressing the accelerator but once I let off it goes away. I took the car into the dealership for inspection and was told it was the transmission that needs to be replaced. Toyota is refusing to assist with the repair because it is out of warranty. Even though they know this is a known issue.

NHTSA ID

11768514

Incident

Sep 28, 2026

Catastrophic mechanical transmission failure in 2019 Toyota Highlander. Diagnosed by Toyota dealership. Said to be the same issue as the recalls submitted for 2018 and 2021 Highlanders due to them having the same transmission

NHTSA ID

11768407

Incident

Oct 1, 2026

I was driving on the highway and the car stopped allowing me to accelerate which almost caused major issues with an accident. I was luckily able to pull off and coast to a safe area to stop. No warning lights ever came on. It appears to be a transmission failure. I’m very lucky it didn’t occur 5 minutes prior. Currently at dealership for inspection.

NHTSA ID

11768266

Incident

Sep 30, 2026

2019 Toyota Highlander XLE, 137K miles. Always maintained, never any issues whatsoever, family loved our 'forever' car, UNTIL the dreaded whining noise began underneath the front floorboard. No warning, no indication, just started while driving on the highway and increasingly became louder over the two additional months I drove it. Quick online search indicates this is a very common issue. Brought to a local dealership in Southern NH, where it was quickly diagnosed as a failing transmission in need of replacement. No warranty, out of pocket cost approx. $8K. Just so happened they had a spare, remanufactured transmission already in house, since this was becoming a 'common issue'. They even had what sounded like a dedicated technician that did at least one replacement a week and had the repair time down to a science. No other warning signs, no software codes, no jerking or slipping while driving, just the noise that increased as the gas pedal was pressed. Well known issue, yet no recall for the 2019 year. Toyota forums indicate the replacement transmissions fail as well after accumulating some miles, which might explain why they only offered me a 1-yr warranty if I had replaced mine. It's for this reason I traded in this Highlander vehicle, as this vehicle was no longer safe or suitable for any long distance family driving. It was also my wife's primary vehicle to transport my young daughters, and I believed that the Highlander would have soon left them stranded. I even purchased AAA tow service for the first time in my life at [XXX], all because of this known transmission issue. I now warn everyone who is searching for this SUV to be very aware. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11767910

Incident

Jun 18, 2026

The transmission developed a faint whining noise, first noticed September 2026 around 84,000 miles, along with some hesitation during operation. A Toyota dealer diagnosed internal bearing failure inside the transmission and recommended full replacement. An independent shop also quoted full replacement. Estimates ranged $8,500–$10,000. Vehicle not yet repaired; available for inspection. Safety risk: the noise is faint enough that a driver could reasonably dismiss it as imagined, unlike a loud noise or dashboard warning. No warning lamps or messages appeared at any point. This absence of a clear warning means affected drivers may keep driving unaware a component is failing internally. The vehicle also experienced hesitation during operation, which could affect safe acceleration, for example when merging into traffic. Based on documented failures of this transmission design in other vehicles, continued driving risks progression to slipping or sudden loss of motive power, with less chance a driver recognizes the need to stop before that happens. Inspected by a Toyota dealership and an independent repair shop; not inspected by manufacturer corporate, police, or insurance.

NHTSA ID

11767679

Incident

Sep 3, 2026

Stated hearing a whining noise when accelerating. Research shows this is a known issue witg 8 speed transmission especially Around 60k-80k miles.

NHTSA ID

11767580

Incident

Sep 18, 2026

The contact owns a 2019 Toyota Highlander. The contact stated that while operating the vehicle, there was a whining sound coming from the engine compartment. Additionally, the vehicle experienced hard, rough, and jerky shifting. The check engine warning light illuminated later and the message "Traction Control Off" was displayed. The vehicle was immediately driven to the local dealer and was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The contact stated that during routine maintenance the transmission fluid was flushed and refilled by the local dealer. The manufacturer was notified of the failure. The failure mileage was 80,000.

NHTSA ID

11767343

Incident

May 1, 2026

Mileage

80,000 mi

When I accelerate my car makes a whining noise. I had the transmission flushed and it did not help. My Toyota dealership said to drive it until it gets worse.

NHTSA ID

11766733

Incident

May 1, 2026

My 2019 Highlander was driving totally normal, when all of a sudden the transmission started slipping and then would no longer accelerate. I was on a windy back road in Alaska with no service, so after letting it sit for a bit I tried to drive it again. It then drove maybe 1/2 more miles before slipping completely and no longer accelerating. No check engine lights came up. I got it towed to my house where a mechanic took a quick scan and said there was a number of transmission codes popping up.

NHTSA ID

11764218

Incident

Aug 24, 2026

UA80 Transmission failure. Was driving on highway when the transmission failed and lost power to the vehicle. Car was taken to Sunshine Toyota (Batte Creek MI) in 2022 and the transmission was recommended to be replaced due to a defect at 67,000 miles. The car was then sold off, and I acquired it through another dealer.

NHTSA ID

11762738

Incident

Aug 31, 2026