2022 Toyota Highlander Brakes Problems

Component or system that malfunctioned: The braking system on my 2022 Toyota Highlander Hybrid, specifically the transition between regenerative braking and hydraulic friction braking, appears to malfunction intermittently. During braking, the vehicle sometimes lurches or surges forward instead of slowing smoothly, especially at low speeds or when braking downhill. The vehicle is available for inspection upon request. How safety was put at risk: The unexpected forward surge while braking increases stopping distance and creates uncertainty about braking performance, particularly in traffic or parking situations. This creates a risk of rear-end or low-speed collisions and reduces my confidence in the braking system. Problem reproduced or confirmed by dealer or service center: The vehicle was inspected by a Toyota dealership, and a Technical Service Bulletin (TSB) software update intended to address braking behavior was performed at approximately 50,000 miles. However, the braking problem continues unchanged after the repair. I had to pay the dealer to perform this TSB update. The dealer was initially reluctant to apply the TSB and did not associate my braking complaint with the known issue. I had to research the TSB myself and request that it be applied. The invoice notes that the dealer reproduced the issue. Vehicle or component inspected by manufacturer or others: The vehicle has been inspected by a Toyota dealership service department. It has not been inspected by police or insurance representatives, as no accident has occurred. Warning lamps or prior symptoms: No warning lights or messages appear when the problem occurs. The issue happens intermittently without warning and has occurred since the vehicle was new. The condition appears to be getting progressively worse. The issue seems more likely to occur when braking while the hybrid battery is near or at full charge, suggesting a possible problem in the transition between regenerative and friction braking.

NHTSA ID

11718753

Incident

Jan 1, 2023

When I am slowing down and coming to a stop, my car will surge forward. It feels like my brakes stop working for a second and that I pressed the accelerator. It has happened on flat road, hills and turns.

NHTSA ID

11696000

Incident

Oct 27, 2025

I reported twice to Tustin Toyota that my car seemed to have a strange braking issue. It felt like the car lurched/lunged forward as I was braking. Every time I brought it into service, I verbally mentioned it to the technician checking my vehicle in. I was repeatedly told there was no issue. Turns out there is an active bulletin (T-SB-0059-23) that came out but now my vehicle is out of warranty and they won't fix it unless I pay out of pocket. Why was the dealership not aware. Why is this not a recall for all affected years regardless of warranty? There have been multiple reports online with people have the same issue.

NHTSA ID

11693589

Incident

Jun 12, 2024

While driving my 2022 Toyota Highlander (VIN: [XXX] , 29,427 miles), I have experienced multiple recurring safety defects that Toyota has been unable or unwilling to repair under warranty. •Front collision sensors frequently trigger without any object present, creating a risk of unexpected emergency braking at freeway speeds. •Transmission hesitates and surges unpredictably, sometimes propelling the vehicle into traffic. •In heavy rain, my windshield wipers activated on their own and multiple system failure warnings appeared (including ABS failure), nearly causing a crash. •Persistent startability issue when fuel is below half a tank. •Seatbelt malfunction caused a passenger to strike their head. •Seat heater failure, seat separation, persistent coolant odor, and nonfunctional factory wireless charger since purchase. These defects are intermittent but recurring, and their unpredictability increases the danger. Toyota and the dealer have failed to duplicate the issues during short test drives, but they continue to occur during normal operation. This vehicle remains under factory and extended warranty, yet repairs have been denied. I believe these defects pose a serious risk to myself, my passengers, and others on the road. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11679297

Incident

Aug 8, 2025

When applying the brakes at speeds less than 40 miles per hour, the car will surge forward at a point during braking process. This happens regularly but not every time brakes are applied. This is an issue as the car surges forward during braking.

NHTSA ID

11662460

Incident

May 21, 2025

Car lunges forward while constant braking. Problem is not consistently repeatable and occurs at various speeds, road conditions, and weather conditions. It seems to be in the transition between regenerative braking and mechanical braking from the hybrid system. The car will coast for a brief moment while braking increasing the stopping distance and time required to come to a complete stop. We've noticed this issue since we bought the car

NHTSA ID

11658668

Incident

May 1, 2025

Sudden acceleration when applying the brakes. This has happened several times

NHTSA ID

11632035

Incident

Dec 22, 2024

We have noticed that when we brake the vehicle, it intermittently LURCHES FORWARD very fast while you are breaking and trying to stop! This is extremely unsafe! We need to stop and brake and not go forward. It does this unexpectedly with no notice and does not always do it consistently but we have noticed it is getting worse and worse and we are worried we will hit another car in front or even a person because the car will not stop on time. When I looked online, this is a well known issue on Toyota Highlanders, especially hybrids like ours and Toyota has done nothing to fix this dangerous problem. They have even told car owners to drive slower but I can tell you it doesn’t seem to matter if I’m going 25 mph or faster or slower- the car gives no notice and goes FASTER while you are trying to stop!!!!! Please help us Toyota Highlander owners!!!! This car gives us no warning whatsoever. It is not consistent. But when it does this it is VERY scary!

NHTSA ID

11620788

Incident

Oct 19, 2024

When braking the brakes will occasionally “quit”, causing unexpected acceleration. They kick back on if I stomp hard on the brake, causing the occupants to jolt forward. It could easily cause a collision if an unexpected vehicle or pedestrian were in the way, and could cause a rear end collision were I to have someone following close behind and hard brake unexpectedly. This has been reported to the dealership but they have been unable to replicate it. It happens intermittently, primarily when braking on a slight downhill slope. The issue has been since the vehicle was new. No warning lights or alerts activate inside.

NHTSA ID

11617056

Incident

Sep 28, 2024

Degenerative breaking. When breaking sometimes it jolts- seems to lose braking power. This is a safety hazard. It could cause a crash.

NHTSA ID

11611935

Incident

Aug 1, 2024

Loss of brake sensation when slowing down through 20-25mph. Brake pedal takes a sudden plunge and car surges forward, forcing the driver to suddenly have to push hard on the brakes in order to stop. Usually happens under moderate braking, especially when there is a slight downhill grade. Toyota dealer confirms that it happens but says there are no codes and there is nothing they can do. Toyota dealer service advisor has had it happen to him while driving. This happens regularly, as often as 2-3 times per week, and can be reproduced.

NHTSA ID

11602454

Incident

Jul 15, 2024

When I brake, the SUV feels like it accelerates/surges forward rather than slowing down. I need to apply the brakes hard to then stop the vehicle. I never know when it will happen but it happens very often.

NHTSA ID

11590803

Incident

May 26, 2024

when I slow down to make a right or left turn I apply pressure to the brake pedal and my vehicle brakes feel like they are "gulping: or not holding, causing my vehicle to lurch forward slightly. This has been happening since I purchsed in July 2022. I replaced my tires last month thinking it was the tires, but the vehicle still lurches forward when braking in a turn. I will put the last time this occurred in your details below

NHTSA ID

11589486

Incident

May 18, 2024

See attached document for complaint

NHTSA ID

11585885

Incident

Jul 25, 2023

On March 16, 2024 this vehicle experienced a complete brake system failure. This is a very serious braking issue and the vehicle has had several braking incidents leading up to the complete failure. Toyota Motor Corp has dismissed the issue each time as there have been no codes or warning lights prior to this incident. We filed a complaint concerning this braking issue on June 12, 2023, Ref#11526496 Since that first report there have been several other incidents where the brake pedal went soft and depressed to the floor as the vehicle accelerated forward. Since the complete system failure occurred on a Saturday, as of this writing, it has not yet been reported to the service department. We filed a complaint with Toyota Motor Corp stating that this is a very serious safety concern that could lead to injury or death and they dismissed it.

NHTSA ID

11577882

Incident

Mar 16, 2024

Brakes vibrate at highway speeds above 60 mph. Car does stop but steering wheel and seat noticeably shake. Car only 1 year old and started during winter. Seems to be related to TSB-0072-18 but does not cover my vehicle year.

NHTSA ID

11571397

Incident

Jan 7, 2024

Occasionally when slowing to a stop, the brakes feel like they slip and i begin to speed up suddenly. Pressing hard on the brakes stops the car again. This is a safety issue if for example you were braking for someone in a crosswalk or a car in front of you. The dealer was unable to reproduce the issue. It happens maybe once a week, for the last several months. They examined the brakes and said they are fine. No warning lights.

NHTSA ID

11561547

Incident

Dec 22, 2023

Unexpected brake failure; While driving at a slow 20 to 30 mph speed lightly braking anticipating a stop at a stop sign my car will unexpectedly surge and jolt the car forward while I'm applying maximum brake force to the peddle. I took it to the local Toyota dealer they checked it out and couldn't find or replicate the problem. I was told that possibly my driving habits or I may have my foot on the brake while still on the accelerator?? When this happens there are NO warning indicators or audible sounds either lit on the instrument panel prior to or after the event. This event on this day propelled my car approximately 6 ft past the crosswalk into the intersection of a four way stop.

NHTSA ID

11543904

Incident

May 11, 2022

A few months after the winter of 2022/2023 the car started making noise and shaking while breaking, the car was taken for regular maintenance at the dealer and I was told everything was fine on April/2023, it just got worse over time and the breaks are now failing and not stopping properly due to huge clusters of rust in the rotors. Car was taken again to the Toyota dealership and they said the warranty does not cover the rotors as they are considered wear and tear parts, rotor isn't worn but has increased in thickness in the areas were the clusters of rust are. After speaking to another mechanic I was told it happened because of the low quality steel of the rotors used by Toyota, which do not perform well in a climate where salt and other chemicals are used to treat the roads. The breaking quality has reduced so much the vehicle is taking twice as long to stop putting myself and others at risk.

NHTSA ID

11536014

Incident

Aug 1, 2023

The brake system on the 2022 Toyota Highlander Hybrid malfunctioned momentarily this weekend (7/8/23 was date of incident) in North Kington, RI. While coming to a gradual stop at a stop light, the brakes momentarily stopped working and felt like the car lunged forward before the auto braking system activated since there was a stopped vehicle in front of us. My foot was on the brake pedal but the brakes just stopped working for a moment. I've read in other toyota forums that this has happened to others with 2022 hybrid highlander models. The same issue happens when applying the brakes going down hill and going over a bump. I'm bringing the vehicle to the toyota dealer this week. No warning lights ahead of the problem.

NHTSA ID

11531300

Incident

Jul 8, 2023

While driving on the highway at an average speed of 40-60 mph and applying the brakes, I experience a noticeable shaking in the whole car and can also feel the tires shaking. I took my car to the Toyota dealer, and they confirmed that the rotors and brake pads are in good condition. However, I still do not feel safe driving my car at this point.

NHTSA ID

11531016

Incident

Jul 3, 2023

On June 26 2023 the vehicle didn't stop automatically when another car was in view in the intersection, the automatic breaking system didn't work and the air bags didn't deploy,

NHTSA ID

11529595

Incident

Jun 26, 2023

When I am slowing down to a stop usually when im going down hill the brakes will fail and the car lunges forward. It will fell like I am stepping on air. I have taken ot to the dealership but they have been unable to duplicate the issue so I dont know what else to do. At the begining it was pretty rare but now it is happening more often

NHTSA ID

11529390

Incident

Jun 24, 2023

While driving in town and coming to a stop sign at a four way intersection I applied the brakes at under 15 to 20mph to stop and my vehicle lurched forward and my brakes were unresponsive. The brake peddle got very spongy for a split second and immediately returned to normal. When I finally stopped my Highlander was half way out into the intersection. This is about the third time it has happened since I got the car in April 14, 2022. Each time it has happened I remember the roadway surface being very rough and full of small potholes or a uneven braking surface.

NHTSA ID

11523954

Incident

May 16, 2023

On multiple occasions the breaks appear to momentarily slip, resulting in the car lunging forward. This tends to happen when slowly decelerating, especially when going down hill. It happens at random, regardless of weather or road conditions. I reported the issue to Toyota two services ago and they stated they were unable to replicate the issue despite driving my car 20 miles. Their best guess was that the ABS system is engaging briefly (Ok. That's an issue. They say there's nothing they can do). Both my husband and I have experienced this issue. It's incredibly unnerving and I'm worried it has potential to cause an accident. I have noticed an increase in occurrence over the past few months. I try to document the date and time of each incident. Additionally, the few times I've needed to brake suddenly (rare because I stay pretty far behind the car in front of me at all times, especially given my concerns) the breaks take a moment to register. When you need to break immediately and press on the breaks firmly to do so, they should respond instantly. That does not happen here. There's a few moments of no response before they finally engage. All in all, the breaks/breaking system on this car really worry me.

NHTSA ID

11522174

Incident

May 13, 2023