2012 Toyota RAV4 Owner Complaints

My 2012 Toyota RAV4 (Super White / Blizzard Pearl paint) is experiencing severe and recurring paint peeling caused by a known manufacturing defect in which the factory paint primer failed to properly adhere to the base metal layer. The peeling first began in 2023 following freezing weather in Austin, TX. It occurred again in 2024 after another freeze event, and then once more in 2025, at which point a large section of roof paint peeled off completely, exposing bare metal. I attempted to repair the damage with spray paint but the new paint continues to peel off as well, because the underlying adhesion defect was never corrected. This confirms the failure is rooted in the original factory primer, not in external damage or neglect. This poses a direct safety hazard to other drivers and pedestrians when paint debris becomes airborne at highway speeds, and the exposed bare metal is now vulnerable to rust and further structural deterioration. Toyota formally acknowledged this defect and created Customer Support Program ZKG to address it across nearly 1.74 million vehicles, including the RAV4. In July 2022, Toyota confirmed in writing that 'sunlight/ultraviolet exposure over time degrades the adhesion between the factory-applied paint primer coat layer and the base metal electrodeposition layer, causing paint to peel from the metal body panel.' Freeze-thaw cycles accelerate this exact failure mode by forcing moisture under already-weakened paint edges, causing rapid and widespread delamination — consistent with what I experienced after the 2023, 2024, and 2025 Austin winter weather events. I was not properly notified about Program ZKG and missed the coverage window as a result. Toyota has declined to provide goodwill assistance. Given that Toyota knowingly sold vehicles with a defective paint system, failed to adequately notify all affected owners, and that the ongoing peeling creates an active road safety hazard with bare metal now exposed on the roof, please investigate.

NHTSA ID

11744656

Incident

Jan 30, 2023

My vehicle is a 2012 rav 4 sport, color Barcelona Red. Said color and model has been know to have clear coat and paint issues. My vehicles clear coat and paint in the top has been peeling at an alarming rate, a year or so ago it started, but the last 6 months have been excrutiating. This problem poses a risk to me as if the issue continues on, oxidation might occur and possibly lead to holes in the surface. To other paint flying off from the vehicle might distract them in the porcess of driving and the glare produces by it might impact others vision. Other areas that have been affected include, hood and side mirrors.

NHTSA ID

11735644

Incident

Jun 16, 2025

The contact owns a 2012 Toyota Rav4. The contact stated that while driving at various speeds, the vehicle shuddered abnormally. The contact stated that the vehicle was consuming an excessive amount of engine oil. Several unknown warning lights were illuminated. The vehicle was taken to a local Auto Zone, where it was scanned with an OBD2 scanner and DTC: P0607, P1603, and P1604 were retrieved. The vehicle was taken to another local independent mechanic, where it was diagnosed with an unknown electrical failure. The vehicle was not repaired due to the cost. The local dealer was not contacted. The vehicle was not repaired. In addition, the contact related the failure to an unknown recall; however, the VIN was not under recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 138,000

NHTSA ID

11715035

Incident

Jan 15, 2020

Mileage

138,000 mi

The small pipe that's part of the Upper Radiator Coolant Hose Connector Adapter broke off and drained coolant from the vehicle. This small pipe had deteriorated and become brittle leading to the failure.

NHTSA ID

11702129

Incident

Nov 30, 2025

The windshield pump is not working front and back The wipers turn but no liquid comes out though the tank is full It does not make the sound it normally does when it pumps the windshield liquid Dealer wants almost $200 just to look at it and verify the problem

NHTSA ID

11687761

Incident

Sep 3, 2025

I have a 2012 Toyota Rav-4 Limited . I have had the vehicle since 2020. Ever since I bought the vehicle it fogs up. All the windows fog up and it does not matter what setting I have it on, de-foggers, fan, fresh air, AC, etc. nothing resolves the problem.It is very dangerous as I cannot see where I am going. I cannot use the front de-foggers in bad weather because it makes the afore mentioned problem worse.I have to put the windows down to see and this remedy is not feasible. I have researched and a lot of other people are experiencing this same safety issue in this model vehicle. I love the vehicle but dread bad weather as it is a struggle to see . Please help.

NHTSA ID

11675227

Incident

Jul 20, 2020

Unknown

NHTSA ID

11663987

Incident

May 29, 2025

While at the end of a car wash with the car in neutral, the car accelerated by itself. It reached 60 mph for over a half mile, and was unresponsive to steering and brakes. The left front wheel was severely damaged. Fortunately, there were no accidents.

NHTSA ID

11660962

Incident

Apr 17, 2025

Over the last several years, I have experienced a minimum of four, possibly one or two more, incidents of this vehicle accelerating at a high rate while I have had my foot on the brake. In all of these cases, I was braking to come to a stop - braking quickly and hard in a couple cases. While braking and slowing, my engine revved/accelerated at a very high rate. In all of these incidents, I changed gears to neutral, and the acceleration stopped. These incidents were random and very far apart from one another in terms of time. In all cases, my foot was firmly (and only) on the brake pedal, and my floor mat was in the proper position and secure. There was nothing in contact with the acceleration pedal. On Monday, March 10, 2025, I got into my car in our garage to go to work. The car started normally. When I put my car into reverse, the engine started revving/accelerating at a very high rate and it was lurching, like it was trying to move. Luckily, my foot was firmly on the brake, and the brake held. I quickly put the car back into park, and the engine began revving/accelerating at an even higher rate. I then turned the car off. Again, I checked my floor mat, and it was in place and secured, my foot was only on the brake pedal, and there was nothing touching the acceleration pedal. This was a frightening experience, and at that point I decided that I would never drive this car again. If I did not have my brake firmly engaged, my car would have shot out of my garage when I put it in reverse. Upon researching the problem, my husband and I read about the unintended acceleration that many people have experienced with Toyotas, causing numerous deaths and injuries, and about the class action law suit with Toyota. Although the investigation seemed to chalk the incidents up to "user error" - foot being on the wrong pedal, floor mats affecting the acceleration pedal, etc. - I know with 100% confidence that none of these were the case. I will be notifying Toyota, as well.

NHTSA ID

11650394

Incident

Mar 10, 2025

Constant brake issues Sun visors won't stay in place (breaks) Massive oil consumption (not leaking) Oil on dipstick appears black & burnt quickly after adding or replacing oil

NHTSA ID

11649352

Incident

Jun 1, 2023

No accident but dealer mechanic says I need a new transmission as torque converter is the problem. . Car has 107500 miles and has had routine maintenance. I have since learned that there were dealer service bulletins on this issue and some owners got repairs. My vehicle, a 2012 RAV4, was not included in the bulletin. I read many situations like mine on the RAV4world website and other social media. Toyota needs to be held accountable for the thousands in repair costs owners are experiencing for a design flaw. The safety issue is the transmission could fail prematurely.

NHTSA ID

11617637

Incident

Sep 24, 2024

The contact owns a 2012 Toyota Rav4. The contact stated that while his wife was driving at 65 MPH, the air bags deployed without warning or impact. The driver sustained burns to the neck, skeletal injuries, and bruises. The passenger sustained skeletal injuries, cuts, bruises, and throat issues. Medical attention was provided to both occupants. A police report was filed. There was no reported fire or crash. The vehicle was towed to a tow plaza. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, who opened a case. The failure mileage was approximately 132,000.

NHTSA ID

11609926

Incident

Aug 11, 2024

Mileage

132,000 mi

Over the last 4 years I have had 2 prior occurrence where I've lost power turning or stopping, causing the engine to stall. Both times the vehicle was taken to our mechanic and he replaced the connectors to the battery. On January 18th, 2024, while turning off of a rural highway onto the street we live on I again lost power and the engine stalled and smelled a faint electrical smell. I called my mechanic and he said he could get it in on January 22nd. We checked all connections to the battery, made sure the battery terminals were clean. The morning of January 22nd, while on my way to the mechanic the vehicle in front of me stopped quickly. I started to stop a little quicker than normal, causing the front of the vehicle to tip down. I immediately lost power and the engine died, causing me to rear end the vehicle in front of me. The collisions was at slow speed, but it also caused disproportionate damage to my vehicle. Over the weekend of January 20th, we became aware if a recall for 2013 to 2018 Rav4s regarding the tops of newer batteries being smaller and causing problems with the battery shifting causing loss of power and potential fires. We strongly believe this recall needs to be extended to the 2012s.

NHTSA ID

11587409

Incident

Jan 22, 2024

The contact owns a 2012 Toyota Rav4. The contact stated that while driving at an undisclosed speed, the check engine, traction control, and 4WD drive warning lights illuminated. The contact stated that the failure had been reoccurring for approximately two months. The dealer was contacted and made aware of the failure and a service appointment was scheduled. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 125,000.

NHTSA ID

11552920

Incident

Aug 7, 2023

Mileage

125,000 mi

after stepping on the breaks the car the vehicle revs and moves forward

NHTSA ID

11546369

Incident

Aug 5, 2023

I took the Rav4 to the dealership for a oil change and wheel alignment 0n 6-6-23. On 6-9-23 I took it back because on the freeway sometime it would start wobbling. They check it out and said the tow arms have play and movement. I said you gave it a 4 wheel alignment and didn`t see that. He recommend to change both rear tow arms and wanted to charge me $1,000. I did not think that was right after 3 days.

NHTSA ID

11533220

Incident

Jun 9, 2023

The contact owns a 2012 Toyota Rav4. The contact stated that upon activating the windshield wipers, the wipers responded erratically. The contact stated that the wipers moved significantly slowly, changed direction, and paused in the center of the windshield. No warning lights were illuminated. The contact stated that the vehicle had previously been repaired under NHTSA Campaign Number: 15V577000 (Visibility/Wiper) however, the failure reoccurred. The vehicle was not diagnosed nor repaired by a dealer or an independent mechanic. The manufacturer was notified of the failure, and a case was filed. The failure mileage was 112,000.

NHTSA ID

11528402

Incident

Jun 15, 2023

Mileage

112,000 mi

While in transit I observed my rav4 engine light 4wd light and traction control light all come on and truck kinda felt like gear slip weather was clear. I continued and went across a railroad track and all of sudden truck completely shuts down and started smoking. I i coasted to side of road had it towed to my designated location Thought was on fire. After inspection following day it showed top radiator hose coupling broke causing antifreeze to spew from radiator ... I replaced the hose thinking all would be repaired. Antifreeze and water was replaced And tried to crank it sputtered and wouldn't start . Now it still won't start. It has only 135k miles on it and I know it should be more

NHTSA ID

11521865

Incident

Apr 21, 2023

The left rear toe arm bracket became detached from the rear subframe. This caused the vehicle to drive erratically. There is minimal to no rust on the vehicle. The failure happened without warning after hitting a small pothole.

NHTSA ID

11514315

Incident

Mar 27, 2023

Severe chipping on the top of the vehicle. If the vehicle goes over 40 mph, it chipps the paint on the other vehicles which is a hazard.

NHTSA ID

11512847

Incident

Mar 20, 2023

On Friday, 1/20, I got in my vehicle, turned it on and the engine maintenance light came on. First and only time in the few months I have owned it. While driving home in heavy traffic from work in Lutz, my RAV4 uncontrollably accelerated at a full stop lurching forward towards the vehicle in front of me. It did this 4 times on my drive home to Spring Hill nearly causing multiple potentially catastrophic accidents. I stayed in the far-right lane for the duration of my drive home with the exception of two left hand turns I had to make. Each time I came to a stop I kept further distance from the vehicle in front of me. I put it in neutral, pressed firmly on the brake, once at a full stop the engine was still revving up to 4-5,000 rpms. I steered the wheels to the right to avoid the vehicle in front of me in preparation that it would not stop accelerating. It was/is not a floor mat issue, those clip into place, it was not me accidentally pressing on the gas pedal. I have 30+ years of a good driving record and experience in all types of conditions. This is something seriously mechanically and electrically wrong. This put myself and any other vehicle or pedestrian around me at great risk of major collision or bodily injury. Since this is an intermittent problem, like the abundance of other complaints, neither my mechanic nor the Toyota dealership can reproduce it.

NHTSA ID

11509305

Incident

Jan 20, 2023

The car lost all power to the wheels without warning. Fortunately the car was stopped at a red light but still had to be pushed out of the way in traffic with the help of strangers. The car was inspected by a Toyota service specialist who said that the splines had sheared off of the rotor and the entire motor would need to be replaced. There were no warnings (no lamps, no messages, no sounds) prior to the failure.

NHTSA ID

11467056

Incident

Apr 19, 2022

Check EV System - Have your vehicle checked by a dealership immediately Warning has come on several times in the past few days. RAV4 EV forum indicates this is a problem that can make the vehicle stop while driving - very dangerous. There was a recall issued for this problem in 2015, and your site indicates there are no outstanding recalls on this vehicle. Please help resolve this potentially severe problem. Thanks.

NHTSA ID

11455086

Incident

Mar 2, 2022

Inaudible turn signal prompt: Older drivers who drive for miles with their turn signal on is the subject of many a cartoon and common source of highway frustration. It is also a safety issue when a vehicle does not perform the turn that it is apparently signaling to make. I find myself being one of those older drivers who leaves their turn signal on. I have moderate hearing loss and do wear hearing aids, but not all the time. Perhaps my RAV4's audible prompt is quieter than others, but with road noise and the radio on I often do not hear it. A simple solution to this problem would be the ability to control the volume of the audible turn signal prompt so it could be "cranked up" to be easily heard. If dashboard lights have a dimmer control, why don't turn signal prompts have a volume control? It seems like a simple solution and with today's touch control panels one that could be added for very little cost. Thanks for considering my recommendation. It is a common safety problem that has a simple and low-cost solution.

NHTSA ID

11445415

Incident

Dec 14, 2021

Poor winter visibility: This is an issue with this vehicle but also with almost all other vehicles with internal combustion engines. During cold weather the defroster is ineffective until the engine warms up and provides heat. This results in two unsafe conditions 1) warming the engine up while parked, which exposes the vehicle and driver to theft ("carjacking" is an increasing crime in our area) and increases carbon emissions, or, 2) driving the vehicle while the engine is cold and having poor forward visibility. If defrosters were equipped with electric heating elements, defroster heat would be provided almost immediately. I was told that VW provided this feature for several years and it was very effective. The electric heating element could be thermostatically controlled so it would turn off once the engine starts providing heat. Since a household toaster can be purchased for $25, it should not cost manufacturers more than $15 to add an electric heating element to the defroster. Thank you for considering this recommendation. I am embarrassed to admit to the times when I drove while peering through a small patch of clear windshield . . . reasonably safe for seeing directly forward but definitely not safe for seeing side traffic or crossing pedestrians.

NHTSA ID

11445409

Incident

Dec 27, 2021