2010 Toyota Sienna Powertrain (other) Problems

Massive Oil Leak and Loss of Oil Pressure: Oil line burst while driving on the HWY coming back home from a work. Loss nearly all of the oil, but there were no warning lights. Pulled over into gas station. Checked dip stick, completely dry! Catastrophic oil leak without warning. Could have been stalled on the HWY and caused major ACCIDENT. Tried to refill oil but it all leaked out as soon as I started engine. Research around the web and find out that this is a known issue to Toyota for using rubber VVTI oil line - Part # 15772-31030 Now this part is made all metal!

NHTSA ID

11492041

Incident

Nov 1, 2022

TL* THE CONTACT OWNS A 2010 TOYOTA SIENNA. THE CONTACT STATED THAT WHILE SLOWING DOWN, A LOUD BOOMING NOISE OCCURRED AND THE VEHICLE SUDDENLY LOSS AUTOMOTIVE POWER AND CAME TO A ROLLING STOP. UPON INSPECTION, PART OF THE TRANSMISSION WAS DETACHED AND ON THE GROUND NEARBY. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE TRANSMISSION HAD EXPLODED. THE CONTACT INDICATED THAT PIECES OF THE TRANSMISSION HAD DISLODGE FROM THE TRANSMISSION CASING. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE VEHICLE WAS NOT YET REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE LOCAL DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 80,000.

NHTSA ID

11349190

Incident

Aug 11, 2020

Mileage

80,000 mi

TL* THE CONTACT OWNS A 2010 TOYOTA SIENNA. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE BEGAN TO SHAKE AND THEN STALLED. ALL THE WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS ABLE TO COAST OVER TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. AN INDEPENDENT MECHANIC CAME TO THE CONTACT'S HOME AND DIAGNOSED THAT THE GEAR SHIFTER FAILED AND CAUSED THE TRANSMISSION TO FAILED. THE PARTS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT TAKEN TO A DEALER AND WAS NOT REPAIRED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 17V657000 (POWER TRAIN). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 82,000.

NHTSA ID

11217758

Incident

May 30, 2019

Mileage

82,000 mi

TL* THE CONTACT OWNS A 2010 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V657000 (POWER TRAIN); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. MARINA DEL REY TOYOTA (4636 LINCOLN BLVD, MARINA DEL REY, CA) WAS CONTACTED AND REFUSED TO PERFORM THE REPAIR BECAUSE THE TECHNICIAN STATED THAT THE VEHICLE WAS MODIFIED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ID

11065872

Incident

Oct 18, 2017

TOYOTA OF MARINA DEL REY SAYS THE RECALLED SOLENOID IS STILL BACKORDERED A MONTH LATER

NHTSA ID

11060794

Incident

Dec 1, 2017

Mileage

44,000 mi

MARINA DEL REY TOYOTA HAS BEEN UNABLE TO OBTAIN THE PART REPLACING THE SHIFT SOLENOID FOR THE RECALL

NHTSA ID

11060765

Incident

Dec 1, 2017

TL* THE CONTACT OWNS A 2010 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 17V657000 (POWER TRAIN) AND 14V273000 (TIRES); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. OURISMAN CHANTILLY TOYOTA-SCION IN CHANTILLY, VIRGINIA WAS MADE AWARE OF THE RECALL AND STATED THAT THE PARTS WERE UNAVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ID

11055891

Incident

Oct 21, 2017

TL* THE CONTACT OWNS A 2010 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V657000 (POWER TRAIN). THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. BILL KIDD TOYOTA (107 INDUSTRY LN, COCKEYSVILLE, MD 21030, (410) 666-5030) AND THE MANUFACTURER WERE NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ID

11055520

Incident

Dec 18, 2017

TL* THE CONTACT OWNS A 2010 TOYOTA SIENNA. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED WITH THE KEY REMOVED FROM THE IGNITION, A CHILD IN THE VEHICLE WAS ABLE TO MOVE THE GEAR SHIFT LEVER FROM THE PARK POSITION TO REVERSE. THE VEHICLE WAS ABLE TO ROLL BACKWARDS. THE VEHICLE WAS NOT INVOLVED IN A CRASH. THE VEHICLE WAS TAKEN TO THE DEALER BUT THE FAILURE WAS UNABLE TO BE DUPLICATED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 168,837.

NHTSA ID

10898765

Incident

Aug 25, 2016

Mileage

168,837 mi

MY VEHICLE IS 2010 TOYOTA SIENNA XLE AND HAVE 50,000 MILES. WHILE DRIVING VEHICLE ON HIGHWAY SUDDENLY CAR STOPPED ENGINE RAVS BUT CAR WONT MOVE. WE TOWED THE CAR TO DEALER AND DEALER SUGGESTED VAN NEEDS NEW TRANSMISSION AND WE CONTACTED TOYOTA CORPORATION AND THEY WONT COVER THIS UNDER WARRANTY.

NHTSA ID

10873629

Incident

Jun 9, 2016

Mileage

49,500 mi

ABOUT 20 MINUTES AWAY FROM HOME WE HEARD SOME "GROWLING" AND "TICKING" NOISE FROM THE ENGINE. NO INSTRUMENT WARNING LIGHTS CAME ON. AS WE PULLED INTO OUR STEEP DRIVEWAY, THE OIL PRESSURE LIGHT STARTED TO BLINK. WE SHUT THE ENGINE. UPON INSPECTION, THE OIL DIPSTICK APPEARED DRY. I ADDED ABOUT 4 QTS OF OIL, AND STARTED THE ENGINE. IT SOUNDED NORMAL, AND NO WARNING LIGHT WAS DISPLAYED. I BROUGHT THE CAR TO A LEVEL AREA AND CHECKED OIL AGAIN. I ADDED ANOTHER QUART - OIL WAS BETWEEN THE MARKS ON THE DIPSTICK. I NOTICED LIGHT DRIPPING FROM THE FRONT AREA OF THE ENGINE, NEAR THE OIL COOLER. I THEN DROVE THE CAR TO THE AUTO REPAIR SHOP (ABOUT 4 MILES AWAY). ENGINE SOUNDED OK, NO WARNING LIGHTS. NEXT DAY I WAS TOLD THAT THE OIL LINE TO THE OIL COOLER IS LEAKING, AND THERE'S DAMAGE TO THE ENGINE DUE TO RUNNING WITH NO OIL. I ASSUME THAT THE ENGINE OPERATED WITH NO OIL WHEN WE HEARD NOISES - BUT HOW COULD THE OIL LEAK OUT AND RUN THE ENGINE DRY FOR 15 MINUTES *BEFORE* THE LIGHT CAME ON? HOW COMMON IS THE PROBLEM OF THE OIL-COOLER HOSE FAILING? DOES THIS MODEL SHARE THE SAME ENGINE AS THE LEXUS RX350? IF SO - IS THE PROBLEM RELATED (I READ THAT MANY RX350 OWNERS COMPLAINED ABOUT THIS) ?

NHTSA ID

10861960

Incident

Apr 26, 2016

Mileage

96,000 mi

THIS IS THE SECOND TIME I HAD TO REPLACE MY TRANSMISSION IN MY SIENNA. EACH TIME IT HAPPENED, I WAS ON VACATION. THE FIRST TIME I REPLACED IT WAS LESS THAN 2 YEARS AGO, APRIL 2014. THERE WAS AN ISSUE WITH THE CAR SHIFTING HARD AND HUMMING ON ACCELERATION. LUCKILY I MADE IT HOME AND WAS ABLE TO FIX IT. SPENT $1, 404.43 WHICH WAS 30% OF THE COST, TOYOTA PAID FOR 70% OF IT. NOW MARCH OF 2016, THE CAR LURCHED, WAS SMOCKING AND SLOWED DOWN WHILE I WAS ON VACATION IN THE MIDDLE OF THE ROAD. LUCKILY I WAS ABLE TO GET IT TO RIGHT OUTSIDE OF THE HOTEL ROOM. PAID TOWING TO GET THE CAR TO AN OVERNIGHT LOCATION, MIKE ERDMAN TOYOTA. UNFORTUNATELY, THEY WERE NOT ABLE TO FIX IT WITHIN THE WEEK THAT I WAS ON VACATION. I HAD TO COME HOME AND DRIVE BACK TO 224 MILES TO GET THE CAR. THIS TIME, I AM PAYING $3600.00. I SAW ANOTHER COMPLAINT SIMILAR TO MINE ON THIS SITE. UNFORTUNATELY, I WILL HAVE TO GET RID OF THE CAR BECAUSE I AM AFRAID FOR MY SAFETY. WHEN A CAR STALLS ON YOU ON THE TURNPIKE OR IN THE MIDDLE OF THE RODE, IT IS TIME TO CUT YOUR LOSES. I AM VERY DISAPPOINTED BECAUSE MY FAMILY HAVE BEEN TOYOTA OWNERS BUT WILL NOW HAVE TO LOOK FOR A NEW COMPANY.

NHTSA ID

10852296

Incident

Mar 22, 2016

Mileage

91,000 mi

GRINDING NOISE FROM TRANSMISSION WHEN IN LOW GEAR FROM STOP. HAD DEFECTIVE X MISSION IN TWO OTHER 2010 TOYOTA AND RETURNED UNDER LEMON LAW. QUOTE FROM INDIVIDUAL NAT TOYOTA CORPORATE OFFICE IN 2010 STATED THEY WERE INCURRING DIFFICULTIES WITH TRANSMISSIONS IN THIS VEHICLE AT THE TIME. 3 RDE SIENNA APPEARED FINE UNTIL RECENTLEY AND DISCOVERED THAT THEY STATED TRANSMISSION FAILURE AND NEEDS REPLACING. CALLED TOYOTA AND THEY CLAIM EXCEEDED WARRENTY TO BAD SO SAD. MA 10/26/2015 UPDATED 12/05/2017*CN

NHTSA ID

10735712

Incident

Jul 22, 2015

Mileage

143,683 mi

STOPPED AT RED LIGHT. WHEN I PROCEEDED TO DRIVE, I STARTED TO HEAR LOUD, CLANGING/THUDDING NOISES COMING FROM ENGINE, THEN I HEARD ONE LARGE THUD. THE TRANSMISSION GEARS HAD SEIZED (COMPLETELY LOCKED UP), CAUSING SUCH TENSION/FRICTION THAT IT CAUSED TRANSMISSION COVER TO EXPLODE. PARTS WERE FALLING OUT OF TRANSMISSION AND TRANSMISSION FLUID EMPTIED ENTIRELY ON THE ROAD. I WAS TOLD BY A TRANSMISSION MECHANIC THAT IT WAS A MIRACLE I WAS ABLE TO MANEUVER CAR TO SAFETY ON SIDE OF ROAD. *TR

NHTSA ID

10679520

Incident

Jan 12, 2015

Mileage

66,200 mi

AT VEHICLE START- COLD AMBIENT TEMPS -APPROX 20F AND LOWER, ENGINE GOES TO ABOUT 1800 RPM AND STAYS THERE FOR ABOUT 2 MINUTES BEFORE DROPPING DOWN TO ABOUT 1100 RPM. AFTER SHFITING AND THE DRIVER TAKING THE FOOT OFF THE BRAKE PEDAL THE VEHICLE HAS A TENDENCE TO LURCH DUE TO THE HIGH ENGINE SPEED. THIS IS A SURPRISE EVENT EVERY TIME I OR MY WIFE START THIS VEHICLE AND I CONSIDER IT A SAFETY RELATED ISSUE. AS A COMPARISON, MY 2003 CHEVY TRAILBLAZER COLD ENGINE RPM NEVER GOES ABOVE 900 RPM AND DOES NOT EXHIBIT THIS LURCH TENDENCY. I COMPLAINED TO THE TOYOTA DEALER SERVICE MANAGER, AND HE OFFERED NO RESOLUTION- BASICALLY "...THAT'S THE WAY IT IS." THE DEALER HAS NO KNOWN PROCEDURE TO ADJUST THE COLD START ENGINE SPEED TO A LOWER LEVEL. I HAVE A DOCUMENTED SERVICE REPORT. *TR

NHTSA ID

10305120

Incident

Nov 30, 2009

Mileage

4,500 mi