2015 Toyota Sienna Problems

In August 2025, AutoNation Toyota on Sahara, checked the VIN of my Toyota Sienna and contacted Toyota while I was present. Toyota confirmed a broken fuel-door hinge was covered under a Customer Support Program. Instead, AutoNation attempted to repair, rather than replace, the hinge. This caused the metal fuel cap door to end up bent, paint to be gouged out from the bottom of the fuel door area, misalignment of the fuel door, and therefore issues with the door’s sensor reading correctly. I took the van back until they received shipment of a new fuel cap door. After the attempted repair, since the fuel door no longer aligned, the safety sensors repeatedly activated which strained the sliding-door ECU. The passenger sliding door began freezing intermittently, forcing my children to exit through the trunk several times. Finally, the door opened on its own as I was driving down the street. These issues did not exist prior to dealership service and presented a clear safety concern. Between October and December, I received conflicting explanations from Gerald, James, Ivan, and Rudy at AutoNation Toyota regarding whether the issue involved the fuel door, ECU, motor, or general wear and tear. AutoNation repeatedly failed to return my calls or respond to the emails I sent them. Toyota Corporate also informed me the dealership was also not responding to their outreach attempts after I contacted them due to not being able to get ahold of AutoNation Toyota. I emailed four managers on October 15 with detailed documentation and received no response. My vehicle remains unsafe, unrepaired, and in the possession of AutoNation Toyota. I approve allowing it to be inspected. While at AutoNation, the vehicle driver could not open the passenger sliding door after AutoNation's attempted repair. They have had my van for 4 months now so no one else has looked at or inspected it. There were no warning lamps, messages or other symptoms of the problem prior to the failure.

See attached document for complaint.

Odometer Fraud. The contact purchased a 2015 Toyota Sienna. The vehicle was a private sale. The contact stated that at the time of purchase, the mileage was 92,862. The contact later purchased a Carfax Report which indicated that the last odometer report in 2024 showed that the mileage was 205,000. The seller was made aware of the mileage discrepancy.

In August 2025, AutoNation Toyota on Sahara, checked the VIN of my Toyota Sienna and contacted Toyota while I was present. Toyota confirmed a broken fuel-door hinge was covered under a Customer Support Program. Instead, AutoNation attempted to repair, rather than replace, the hinge. This caused the metal fuel cap door to end up bent, paint to be gouged out from the bottom of the fuel door area, misalignment of the fuel door, and therefore issues with the door’s sensor reading correctly. I took the van back until they received shipment of a new fuel cap door. After the attempted repair, since the fuel door no longer aligned, the safety sensors repeatedly activated which strained the sliding-door ECU. The passenger sliding door began freezing intermittently, forcing my children to exit through the trunk several times. Finally, the door opened on its own as I was driving down the street. These issues did not exist prior to dealership service and presented a clear safety concern. Between October and December, I received conflicting explanations from Gerald, James, Ivan, and Rudy at AutoNation Toyota regarding whether the issue involved the fuel door, ECU, motor, or general wear and tear. AutoNation repeatedly failed to return my calls or respond to the emails I sent them. Toyota Corporate also informed me the dealership was also not responding to their outreach attempts after I contacted them due to not being able to get ahold of AutoNation Toyota. I emailed four managers on October 15 with detailed documentation and received no response. My vehicle remains unsafe, unrepaired, and in the possession of AutoNation Toyota. I approve allowing it to be inspected. While at AutoNation, the vehicle driver could not open the passenger sliding door after AutoNation's attempted repair. They have had my van for 4 months now so no one else has looked at or inspected it. There were no warning lamps, messages or other symptoms of the problem prior to the failure.

I have had this car for 7 years. Started having issues a year ago and despite bringing it to Toyota 2x, they cannot tell me what the issue is. I will be driving on a regular flat paved road when the car will suddenly brake and pull me towards the side of the road. I get the ABS code sometimes and also the slip indicator light. I've explained this each x I've brought it in and they have told me it's due to me "driving too fast" or "accidentally having my foot on the brake." LOL I am a typical soccer mom and drive conservatively and don't brake when I don't have to. It will do it on curving roads as well as straight roads. When this happens, it is terrifying! I have gone to different mechanics as well and no one can determine this issue. I've replaced the ABS sensors on this and am still having this issue. I don't know what else to do, as this is unsafe and unsafe to the extent that I no longer allow my 17 year old to drive it. Please help!!!!!!!!

The contact called on behalf of his mother who owns a 2015 Toyota Sienna. The contact stated while his mother was driving 15 MPH, the brake pedal was depressed but failed to respond, causing the vehicle to crash into the rear of another occupied vehicle. There was no warning light illuminated. The air bags did not deploy. Both the contact's mother and the other driver received assistance from emergency units. The contact's mother sought medical assistance and was informed that she had sustained soreness in the neck muscle. The contact was unsure whether the other driver sustained any injuries. The vehicle was towed to a tow lot. The vehicle was then towed to an autobody shop but was not repaired. The vehicle was then towed to the residence. A police report was filed. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed nor repaired. The failure mileage was approximately 93,955.

The front tires are wearing out to an unsafe tread in under 15000 miles due to the suspension in the front of this vehicle. If people are not vigilant the tires become unsafe quickly due to poor engineering on the front end.

I bought this carseat in March and began using it August 2nd for my infant who was born July 31st. The straps have slowly become an issue. We try so hard to tighten the straps but to no avail. This puts my child at risk if we were to get in accident as he is not secure and the straps are still loose. I did reach out to graco who informed me I had to do a warranty claim. I am not sure yet if thet plan to do anything in regaurds to this issue.

I am submitting this complaint to request that the National Highway Traffic Safety Administration (NHTSA) document and evaluate what may be a broader defect affecting certain Toyota Sienna vehicles and determine whether it presents a potential safety-related defect trend. My 2015 Toyota Sienna was diagnosed by an authorized Toyota dealership with an external rear-bank head gasket leak. A head gasket is a critical engine component, and failure can result in coolant loss, engine overheating, reduced engine performance, stalling, or complete vehicle disablement. These conditions may create a safety risk, particularly if they occur while driving in traffic or at highway speeds. An authorized Toyota dealership confirmed the diagnosis and submitted a goodwill assistance request to Toyota. The dealership noted my history as a repeat Toyota customer and recommended that assistance be provided. Toyota denied the goodwill request based on the vehicle's age and mileage. I subsequently appealed through Toyota's customer relations process, and the denial was upheld. I understand that NHTSA does not resolve individual warranty or customer-assistance disputes. My purpose in submitting this complaint is to request that NHTSA determine whether similar reports exist involving premature head gasket failures in this model year or related vehicles and, if warranted, evaluate whether a broader defect trend exists that could present a safety concern. Potential safety consequences include engine overheating, loss of power, stalling, and unexpected vehicle disablement. The vehicle has been maintained in accordance with manufacturer recommendations and has not experienced any overheating event that would reasonably explain a premature head gasket failure. Thank you for your consideration and for documenting this complaint as part of NHTSA's review of potential vehicle safety issues. Respectfully, Vehicle Owner

i am having repeated issue with Toyota sienna engine 1. Engine oil leaks through timing chain cover 2. Engine coolant leak Engine oil leak keep repating even I fixed earlier and leaks again due poor engine design same issue fixed on Nov/22/20 - 59k

On April 15, 2026 Report filed with NHTSA from an accident-causing property damage due to a failure in the shifter mechanism while the vehicle was parked, ignition off, no keys in the vehicle and the brake pedal was NOT pressed. Manufacture initiated an investigation after we contacted their customer care line. Our vehicle was taken to a Toyota dealership on March 11, 2026. We received an email on April 13, 2026 stating Toyota's inspection did not identify any evidence that this incident was a result of a concern with the operation of our vehicles gear shift lever. We retrieved our vehicle from the dealership on April 20, 2026. On April 21, 2026 From our driveway the shift lever fell out of park into drive with the ignition off, no keys, and the brake pedal not pressed. Toyota claims no responsibility! How is this possible when they know there are active recalls for the same issue on earlier models? This is a massive public safety risk considering the vehicle can rollaway without the ignition even being on! I will continue to report this issue every time the Shift lever falls out of park until resolved.

On April 15, 2026 Report filed with NHTSA from an accident-causing property damage due to a failure in the shifter mechanism while the vehicle was parked, ignition off, no keys in the vehicle and the brake pedal was NOT pressed. Manufacture initiated an investigation after we contacted their customer care line. Our vehicle was taken to a Toyota dealership on March 11, 2026. We received an email on April 13, 2026 stating Toyota's inspection did not identify any evidence that this incident was a result of a concern with the operation of our vehicles gear shift lever. We retrieved our vehicle from the dealership on April 20, 2026. On April 21, 2026 From our driveway the shift lever fell out of park into drive with the ignition off, no keys, and the brake pedal not pressed. Toyota claims no responsibility! How is this possible when they know there are active recalls for the same issue on earlier models? This is a massive public safety risk considering the vehicle can rollaway without the ignition even being on! I will continue to report this issue every time the Shift lever falls out of park until resolved.

My 2015 Toyota Sienna has “Sticky” steering. When on a curve, like an highway curved ramp, the steering locks in place. I have to pull the steering wheel back to keep the car on track. When it sticks I can literally let go on a curve and it will hold it’s position. Even when driving straight this occurs. The steering wheel will stick in place requiring me to turn it to get the steering wheel to come back to the desired or correct position. I’m seeing that this is a regular problem for Toyota steering across multiple models. Having your steering get stuck in place has the potential to be a very serious safety issue. This may cause an accident and resulting death. The complete repair for this safety issue to the consumer is over $3000.00. This is ridiculous! This is my first Toyota. I think their reliability night be really over rated.

The power steering has a notch or almost a stickiness when turning. In turns around interstate ramps the steering almost locks in place requiring physical effort to get the steering to straighten back out. Even driving in a straight line one can feel this notch like feeling where the steering wheel is not operating in a smooth manner. This gives me a serious concern over the safety of driving this vehicle. In researching this specific issue it is notable that Toyota issued a large scale recall on other models for steering issues exactly as I’m experiencing on my vehicle. It appears this overall safety concern extends beyond the vehicles listed in Toyota’s original power steering safety issue recall.

Rain water leaking into the parked vehicle on the driver and passenger seat belts, potentially weakening the belts and creating odor.

Water intrusion from front sunroof when vehicle is parked at a 5% grade with the nose downward. Multiple vehicles exhibit this issue. Toyota is not creating any TSB and will mot even remedy it even if we have an extended warranty. Here is a link to the discussion thread: [XXX] I have not posted on this thread but I have the exact same issue for years. Toyota dealerships want me to first pay $1000 in labor to pull down the headliner and test. Then ask the warranty to cover the assembly, if they don't cover it... then I am on the hook for the work. The missing seam sealer is a common issue that will not manifest inside the 3yr / 36k mile warranty. My issue started around 2020 that I noticed and every dealership would not help me other than place a large burden on me. This can impact the electrical and the airbag curtains. The issue needs to have a seal sealer added to the sunroof assembly as the fix. As a family vehicle, this is a dangerous issue for multiple occupants in a single 7 or 8 person hauler minivan. Please ask Toyota remedy this issue that has been going on for over a decade. Please ask them to stop forcing customers to have sunroofs and panoroofs... when they can't build it correctly. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Water intrusion from front sunroof when vehicle is parked at a 5% grade with the nose downward. Multiple vehicles exhibit this issue. Toyota is not creating any TSB and will mot even remedy it even if we have an extended warranty. Here is a link to the discussion thread: [XXX] I have not posted on this thread but I have the exact same issue for years. Toyota dealerships want me to first pay $1000 in labor to pull down the headliner and test. Then ask the warranty to cover the assembly, if they don't cover it... then I am on the hook for the work. The missing seam sealer is a common issue that will not manifest inside the 3yr / 36k mile warranty. My issue started around 2020 that I noticed and every dealership would not help me other than place a large burden on me. This can impact the electrical and the airbag curtains. The issue needs to have a seal sealer added to the sunroof assembly as the fix. As a family vehicle, this is a dangerous issue for multiple occupants in a single 7 or 8 person hauler minivan. Please ask Toyota remedy this issue that has been going on for over a decade. Please ask them to stop forcing customers to have sunroofs and panoroofs... when they can't build it correctly. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact called on behalf of his mother who owns a 2015 Toyota Sienna. The contact stated while his mother was driving 15 MPH, the brake pedal was depressed but failed to respond, causing the vehicle to crash into the rear of another occupied vehicle. There was no warning light illuminated. The air bags did not deploy. Both the contact's mother and the other driver received assistance from emergency units. The contact's mother sought medical assistance and was informed that she had sustained soreness in the neck muscle. The contact was unsure whether the other driver sustained any injuries. The vehicle was towed to a tow lot. The vehicle was then towed to an autobody shop but was not repaired. The vehicle was then towed to the residence. A police report was filed. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed nor repaired. The failure mileage was approximately 93,955.

I have had this car for 7 years. Started having issues a year ago and despite bringing it to Toyota 2x, they cannot tell me what the issue is. I will be driving on a regular flat paved road when the car will suddenly brake and pull me towards the side of the road. I get the ABS code sometimes and also the slip indicator light. I've explained this each x I've brought it in and they have told me it's due to me "driving too fast" or "accidentally having my foot on the brake." LOL I am a typical soccer mom and drive conservatively and don't brake when I don't have to. It will do it on curving roads as well as straight roads. When this happens, it is terrifying! I have gone to different mechanics as well and no one can determine this issue. I've replaced the ABS sensors on this and am still having this issue. I don't know what else to do, as this is unsafe and unsafe to the extent that I no longer allow my 17 year old to drive it. Please help!!!!!!!!

I was at a stop light when I slowly started to lift my foot from the brake pedal. The engine started revving up and accelerate. I pressed the brake pedal normal , then harder when it would not stop revving. I looked down to see if I was hitting the gas pedal by accident. I was not, about after 5 seconds it stop revving. I went about a foot and nobody was in front of me. I going to have it checked out by my dealer. This happened before and I thought it was driver error .When I thought I was hitting the gas pedal and brake pedal. I searched for incidents like mine, but could not find something exactly just similar. I did not look at the dashboard so i do not know if there was a message . So I'm reporting this incident to get answers and alert others of this issue.

The front tires are wearing out to an unsafe tread in under 15000 miles due to the suspension in the front of this vehicle. If people are not vigilant the tires become unsafe quickly due to poor engineering on the front end.

I have a 2015 Toyota Sienna LE that I purchased new from the dealer. The original Michelin tires had excessive wear after less than 2yrs and ~28K miles. I replaced these with Continental tires(rated for 70K miles) and after 2years and at ~63K on the vehicle miles I had to replace those with General Altimax (rated for 75K miles). Each time tires were replaced it received and alignment. I now need to replace the third set of tires at ~88k for set number four. Additionally I had to replace the Rank and Pinion (Complete unit), both tie rods and both suspension control arms and ball joint assembly and a wheel alignment. Can is adult driven mostly in town but has one long road trip on it (6K miles). This will be the fourth set of tires on a vehicle with less than 100K miles along with 5-6 alignments. All tires have been maintained and rotated. This has to be a vehicle defect as I have multiple tire manufactures, all rated for more than double the tire life I'm getting. I have $2000 in tires so far (not counting the originals) $1250 in replacing the front end components noted and now have to spend another $1k on tires.

The slide door latch stopped working. The sliding door doesn't latch properly and I have to manually close the door and lock it to know it's secure. If it's not locked a slight push will cause it to pop open. My mechanic said there is a recall associated with the replacement part. I can't find the recall. However, I did find a related TSB (TSB-0244-17).

Passenger sliding door jammed and would not open! Serious safety hazard as passengers unable to rapidly exit in an emergency!

There is an EVAP emission leak and the P0456 error states the gas cap is faulty. I had it replaced and replaced again. So I am waiting for another brand new gas cap-3rd brand new one. So 4th overall for this van. A smoke test was done and there is no leaks per the test. So if this continues after the brand new gas cap, then there should be a recall as the gas cap is an issue. Started to happen after 95,000 miles. The AWD is shut off and goes to 2 wheel drive, traction control is turned off, Check Engine light comes on and Message Check AWD system comes up on the screen. Any recommendations

On a warm day after driving the van about 15 minutes then stop for 15 minutes or more. It is taking longer than usual to crank the van. I have search around online. It seems like a common problem Sienna's fuel pump. People on "SiennaChat - https://www.siennachat.com/threads/engine-starts-great-cold-or-hot-long-crank-when-warm.59549/page-2 " website is talking about it. My concern is that one day it could stall while driving on the highway. Since, it is fuel related issues. Without fuel supply engine will halt.

IN JANUARY 2021, WHILE SITTING IN THE DRIVEWAY AN EIGHT INCH CRACK APPEARED IN THE MIDDLE OF THE WINDSHIELD. THE WINDSHIELD WAS REPLACED IN SEPTEMBER 2020 AFTER PURCHASING THE VEHICLE AS A REPO. THE WINDSHIELD THAT WAS REPLACED WAS CRACKED THE ENTIRE WIDTH OF THE GLASS IN THE EXACT SAME PLACE WHERE THE NEW CRACK HAS APPEARED. THE VEHICLE WAS TAKEN TO THE REPAIR SHOP AND IT HAS BEEN DETERMINED THAT THERE IS NOT ENOUGH SUPPORT FOR THE WINDSHIELD BUILT INTO THE FRAME CAUSING THE DAMAGE TO REAPPEAR. SINCE THEN THE CRACK HAS CONTINUED UP THE WINDSHIELD AND IS NOW APPROXIMATELY 14 INCHES.

TL* THE CONTACT OWNS A 2015 TOYOTA SIENNA. WHILE THE VEHICLE WAS PARKED IN THE DRIVEWAY, THE REAR PASSENGER SIDE QUARTER PANEL WINDOW EXPLODED WITHOUT WARNING. THE DEALER (COURTESY TOYOTA OF BRANDON, 9210 E ADAMO DR., TAMPA, FL 33619, (813) 639-8045) WAS CONTACTED, BUT THE VEHICLE WAS NOT TAKEN IN FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 37,857.

THE DASHBOARD SPEEDOMETER AND TACHOMETER GAUGES CANNOT BE ILLUMINATED WITHOUT TURNING ON PARKING OR HEADLIGHTS. THESE GAUGES CANNOT BE SEEN DURING THE DAY WHEN THE DASHBOARD IS SHADOWED. ISSUE HAS BEEN REPORTED ON SIENNA CHAT BOARDS AND NUMEROUS TOYOTA SERVICE DEPARTMENTS.

IN DAYLIGHT, WHEN HEADLIGHTS ARE OFF OR AUTOMATIC, THE SPEEDOMETER DOES NOT ILLUMINATE. WITH HEADLIGHTS ON, ILLUMINATION IS VERY FAINT AT ITS MAXIMUM SETTING. THE DISPLAY IS SO DARK THAT IT CANNOT BE RELIABLY READ. WITH SUNGLASSES, IT IS IMPOSSIBLE TO READ THE SPEEDOMETER. NOTE, THIS IS AN ANALOG SPEEDOMETER, AND THIS MODEL DOES NOT HAVE AN ADDITIONAL DIGITAL SPEED DISPLAY. AN INTERNET SEARCH INDICATES THAT THIS PROBLEM IS UNIVERSAL FOR THIS MODEL/YEAR (NOT A DEFECT IN MY VEHICLE). IT CREATES A HAZARD BECAUSE ONE CANNOT EASILY DETERMINE SPEED. (AT NIGHT THERE IS NO PROBLEM, SINCE THE DASHBOARD LIGHTING IS SUFFICIENT IN THOSE CONDITIONS.)

I have requested urgent warranty evaluation regarding two Kumho Solus TA51a tires installed on my Toyota Sienna (Model: Kumho Solus TA51a, Size: 235/60R17 102H, DOT: 1824) Both front tires are exhibiting abnormal tread chunking and visible surface shredding. The tires are relatively new (purchased about 1-1.5 years ago) and have not been heavily used (only riding this car occassionally, about 5000-7000 miles per year). Our 2 rear tires are Kumho tires of different model, and although older, they are performing fine and do not experience these issues so it seems to be an issue on this particular Solus TA 51a model Kumho tires. Because this is our family vehicle and we transport our children in it regularly, we are very concerned about the safety of continuing to drive on these tires. I also returned to the tire shop that sold and installed the tires. After inspecting them, the owner advised me to contact Kumho for a warranty evaluation, informing me that he received similar complaints from other customers (especially Toyota Sienna owners) using this tire model. While I no longer have the original purchase receipt, the dealer can verify that the tires were purchased from and installed by his shop. I reached out to Kumho Tires USA by completing their online contact form 2 wks ago, which informed a response within 48 hours, but I have not received any response. I called and left a voice message in their warranty department, and in their general customer service line earlier this week, but still not response. I even completed another contact form and also reached out by email, but still no response. Then I remembered my mom recently sharing a concern about her tires, and just found out that she had same 'chunking' issues on her tires, which happened to be the same Kumho Solus TA51a tires from the same tire shop. Her car is Toyota Camry, not a Sienna, so this is happening on this specific tire model across all types of cars they are installed to. Please help!

We recently had two Dunlop P 235 / 50 R 19 tires fail on our car. On 11/5/21, the front passenger-side tire tread and belt began to unravel while driving at freeway speed. This happened suddenly, with no warning lights, and we became aware of the problem when we heard a loud thumping noise from the unraveled tire striking the underside of the vehicle. We immediately exited the freeway, found a tire shop, and had the tire replaced. The following week, I inspected the other tires and found that the front drive-side tire was failing in exactly the same way. We immediately had that one replaced too. Neither tire shop that replaced the tires could identify a cause of the tire failures other than possible defects in the tires.