RoadVitals

2007 Van Hool T2140 Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
3
Latest Jan 23, 2010
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2007 Van Hool T2140, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Engine3100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Engine

Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.

3
reports

From owner reports, verbatim

VAN HOOL T2140 2007 THERE ARE POSSIBILITY TO HAVE TURBO FAILURE BY INSTALLING DEFECTIVE TURBO INTAKE PIPE BY MANUFACTURE. THERE ARE INSTALLATION DIFFICULTIES WHEN CONNECTING TURBO CHARGER AND TURBO PIPE BECAUSE OF LIMITED SPACE IN ENGINE COMPARTMENT. THE WALL OF VEHICLE WAS INTERRUPTED TO LOCATE THE TURBO PIPE. VAN HOOL MANUFACTURE TRIM(CUT) THE PIPE TO INSTALLED. BECAUSE OF THAT ,PIPE LOST 90% OF THICKNESS. ORIGINALLY ABOUT 7MM IN DIAMETER OF THE PIPE BECAME 1MM IN DIAMETER. IT HAS BEEN COVERED BY RUBBER ATTACHED ON THE WALL TO BE HIDDEN. IT CAN NOT SEE BY REGULAR INSPECTION UNLESS YOU TAKE OUT PIPE. THE MANUFACTURE MUST RECALL THIS PIPE TO REPLACE. WE HAD TURBO FAILURE IN ONLY 90,000 MILES OF VEHICLE OPERATION CAUSED BY THE INTAKE PIPE LEAK. *TR UPDATED 10/27/10 *BF UPDATED IVOQ 11/01/10.*JB

NHTSA ID 10301981 · filed Jan 23, 2010

WITH CUMMINS ISM450 ENGINE POSSIBILITY OF A TURBO CHARGER FAILURE PROGRESSING TO AN ENGINE COMPARTMENT FIRE BY ALLOWING LUBRICATION OIL TO ENTER THE EXHAUST SYSTEM. CURRENTLY VEHICLE DOES NOT HAVE ANY WARNING SYSTEM AND PROTECTION TO PREVENT AN ENGINE TO BE FIRE. IN 2006, DETROIT DIESEL SERIES 60 ENGINE MADE RECALL TO SOLVE THIS PROBLEM TO MEET NATIONAL TRAFFIC AND MOTOR VEHICLE SAFETY ACT. CUMMINS DEALER OR ANY VEHICLE MANUFACTURER WHICH INSTALLED CUMMINS ISM450 MUST RECALL THE VEHICLE TO INSTALL 1)BAROMETRIC PRESSURE SENSOR 2)PIGTAIL HARNESS 3)REPROGRAM ECM(ELECTRIC CONTROL MODULE) SAFETY IS MOST IMPORTANT FOR THE VEHICLE, IT MUST DONE BEFORE VEHICLE CATCH ON FIRE OR BIG ACCIDENT HAPPENS. *TR UPDATED 10/27/10 *BF UPDATED 11/01/10

NHTSA ID 10301966 · filed Jan 22, 2010

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .