2004 Volkswagen Jetta Electrical Problems

The contact owns a 2004 Volkswagen Jetta. The contact stated that while driving at an undisclosed speed while it was raining, the windshield wipers were activated; however, the wipers failed to function as intended. The contact stated that the wipers failed to operate. In addition, the contact stated the brake lights failed to function as intended. The contact was informed that the brake lights failed to activate while the brake pedal was depressed. The contact stated that the front driver's side window was closed; however, the driver's front side window was independently lowered. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with an electrical system failure. The contact stated that the battery, the alternator, the fuses, and the windshield wiper motor were all replaced; however, the failure reoccurred. The failure became a persistent failure. The manufacturer was not made aware of the failure. The failure mileage was unknown.

NHTSA ID

11684740

Incident

Sep 3, 2023

Unknown, very complex. Multiple issues. Have been addressed as well as parts been replaced however other issues arised that are definitely safety concerns between electrical issues engine motor etc

NHTSA ID

11617038

Incident

Sep 18, 2019

ALTERNATOR WIRE MELTED PART OF THE BATTERY TOP FUSE BOX. CABLE WAS VERY HOT AND MAY HAVE CAUGHT FIRE IF I HADN'T SMELLED IT FIRST. HAD TO REPLACE THE ALTERNATOR CABLE HARNESS AND FUSE BOX PANEL.

NHTSA ID

11090178

Incident

Apr 19, 2018

Mileage

123,414 mi

WHILE DRIVING DOWN ROAD EARLY IN MORNING APPROX 2 MILES FROM HOUSE I JUST LEFT FROM MY 2004 JETTA SHUTS DOWN TOTAL LOSS OF ALL POWER I PULLED CAR OVER IN A CHURCH PARKING LOT I SMELLED SMOKE AND COULD SEE SMOKE COMING FROM FIRE WALL I RAISED HOOD AND PULLED BATTERY CABLE OFF I COULD SEE SMPOKE FILLING INSIDE OF MY CAR WALKED AROUND TO DRIVER DOOR TO GET MY PHONE AND I SEEN FUSE BOX ON FIRE.ANOTHER VEHICLE STOPPED TO HELP ME AND HE APPROACHED MY CAR AND THEN CALLED POLICE ,FULL FLAMES WERE COMING FROM MY CAR WITHIN 5 MIN SO I STOOD BACK AND WATCHED MY CAR BURN .FIRE DEPT SHOWED UP AND PUT FIRE OUT MY CAR IS A TOTAL LOSS. IVE HAD ISSUES WITH ALTERNATOR,FUEL PUMP,AIR BAG LIGHT, HEADLIGHTS ARE REALLY DIM EVEN ON BRIGHT.NOTHING BUT ISSUES WITH THIS CAR SINCE I GOT IT. 115.000 MILES ONLY ON THIS CAR .SO MANY ISUES I CAN SEE WHY ITS LOW MILAGE

NHTSA ID

11076395

Incident

Mar 3, 2018

Mileage

115,000 mi

THE INSULATION ON THE WIRING OF THE LEFT HEADLIGHT IS DETERIORATED AND FALLING OFF LEAVING THE WIRES BARE AND AT RISK OF SHORTING OUT.

NHTSA ID

11067245

Incident

Feb 6, 2018

Mileage

137,000 mi

PASSENGER SEAT (FRONT SEAT) HEATING ELEMENT IS BURNING THE UPHOLSTERY. THE SEAT HEATER WON'T SHUT OFF. THIS HAS HAPPENED MORE THAN ONCE; EACH TIME THE CAR WAS OPERATING.

NHTSA ID

11065541

Incident

Jan 25, 2018

Mileage

112,000 mi

HEATED SEAT MODULE MELTED A HOLE THROUGH MY LEATHER.

NHTSA ID

11047032

Incident

Nov 16, 2017

Mileage

150,900 mi

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 65 MPH, ALL THE WARNING INDICATORS STARTED TO FLASH ON THE INSTRUMENT PANEL. THE DOOR CHIME SOUNDED AND THE VEHICLE STALLED. THE CONTACT COASTED THE VEHICLE ONTO THE SHOULDER. THE CONTACT HAD THE VEHICLE JUMP STARTED AND DROVE TO A NEARBY PARKING LOT. THE FAILURE OCCURRED TWO OTHER TIMES AND THE VEHICLE WAS REPAIRED BY AN INDEPENDENT MECHANIC. THE FUSE BOX MELTED AND HAD TO BE REPLACED. THE VEHICLE OPERATED NORMALLY AFTER THE REPAIRS WERE COMPLETED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 74,000.

NHTSA ID

11011993

Incident

Jul 31, 2017

Mileage

74,000 mi

ON 12/18/2016 I WAS DRIVING THIS CAR BACK FROM THE MOVIES AT 2:30 A.M. ONCE THE MOVIE HAD ENDED IT WAS STORMING AND SLEETING. I STARTED TO NOTICE SYSTEMS SHUTTING DOWN AS INDICATED BY VARIOUS DASH LIGHTS SUCH AS ABS, AIRBAG, AMONG OTHERS. EVENTUALLY THE RADIO, INTERIOR LIGHTS SHUT OFF. THE WINDSHIELD WIPERS SLOWED AND THE HEADLIGHTS DIMMED, AND EVENTUALLY THE CAR DIED GOING 50 MILES AN HOUR IN SLEETING CONDITIONS LEAVING ME WITH NO ABS, NO AIRBAG SYSTEM (AT LEAST PER WHAT THE DASH LIGHTS INDICATED) AND, OF COURSE, NO POWER STEERING. I INSPECTED THE VEHICLE THIS MORNING AND FOUND THE ALTERNATOR WIRE COMING INTO THE HIGH AMPERAGE FUSE BOX THAT SITS ON TOP OF THE BATTERY HAD MELTED AND DISCONNECTED THE CIRCUIT, DISABLING THE ALTERNATOR FROM CHARGING THE BATTERY, AND LETTING THE BATTERY DIE. THE INCIDENT DID NOT CAUSE A CRASH, BUT IT COULD HAVE IF THERE WAS ANYONE ELSE AROUND ME AS I HAD TO CUT ACROSS A COUPLE LANES WITH NO ENGINE POWER AND NO POWER STEERING TO GET TO THE SHOULDER. *TR

NHTSA ID

10936056

Incident

Dec 18, 2016

Mileage

228,000 mi

ALTERNATOR CABLE MELTED THE FUSE BLOCK AND WIRES ABOVE THE BATTERY. I WILL NEED TO REPLACE THE ALTERNATOR, ALTERNATOR WIRING HARNESS, THE FUSES, AND POSSIBLY THE BATTERY. MY CAR HAS SHUT DOWN WHILE DRIVING AND THIS IS DANGEROUS NOT JUST FOR ME BUT FOR OTHERS ON THE ROAD AROUND ME. TOO MANY VW OWNERS ARE EXPERIENCING THIS EXACT SAME ISSUE. VW PLEASE TAKE OWNERSHIP OF THIS ONGOING SAFETY ISSUE. THIS SAME ISSUE IS BEING ADDRESSED IN A CLASS ACTION FOR BEETLES.

NHTSA ID

10895343

Incident

May 5, 2016

Mileage

70,000 mi

INSTRUMENT CLUSTER STOPPED WORKING. VEHICLE MILEAGE, AND SPEEDOMETER DO NOT WORK AT ALL. MILEAGE WHEN OCCURRED 48,800. EVERY SPEED SENSOR WAS REPLACED WITH NO CHANGE. I HAVE NO WAY OF KNOWING HOW FAST I AM GOING, OR HOW MANY MILES ARE ON MY CAR WITHOUT TRACKING THEM MYSELF. THIS IS A COMMON PROBLEM WITH MULTIPLE VW'S AND AUDI'S WITH NO APPARENT SOLUTION. I HAVE SPENT HUNDREDS OF DOLLARS TRYING TO FIX THIS PROBLEM AND STILL AM WITHOUT A SPEEDOMETER AND ODOMETER.

NHTSA ID

10885722

Incident

Jul 18, 2008

Mileage

48,800 mi

MY (GENERATOR CABLE - S177) ALTERNATOR CABLE MELTING THE FUSE BOX AND WIRES ABOVE THE BATTERY. MY CAR NEEDED A NEW ALTERNATOR. MY CAR DOES NOT ALWAYS START EVEN WITH A NEW BATTERY AND ALTERNATOR. MY CAR HAS SHUT DOWN WHILE DRIVING ON THE HIGHWAY. VW ADMITS THIS IS A KNOWN PROBLEM BUT WILL NOT DO ANYTHING ABOUT IT. I AM THE SECOND OWNER OF THIS VEHICLE. THOUSANDS OF PEOPLE ARE HAVING THIS SAME PROBLEM.

NHTSA ID

10885715

Incident

Aug 11, 2014

Mileage

50,000 mi

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE VEHICLE STALLED, BACK FIRED, AND IT WAS LEAKING COOLANT UNDER THE WATER PUMP. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. PRIOR TO THIS FAILURE THAT THE VEHICLE HAD EXPERIENCED LEAKING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THE WATER PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 14E007000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 156,000.

NHTSA ID

10854705

Incident

Aug 5, 2015

Mileage

156,000 mi

OVER THE PAST FEW DAYS IT HAS BEEN RAINING HEAVILY & ALTHOUGH IT HAS HAPPENED TO ME ONCE BEFORE THIS TIME IS WHAT WORSE. MY CAR IS LEAKING FROM SOMEWHERE & ITS COMING ON THE INSIDE. MY CARPETS ARE CONSTANTLY WET, MY AIRBAGS ALONGSIDE WINDSHIELD LEAK, AND THE HANDLE WHERE YOU OPEN THE HOOD OF THE CAR IS LITERALLY A STREAM OF WATER ENTERING THE CAR DURING HEAVY RAINFALL. THE AIRBAG LIGHT HAS COME ON AND THE CHECK ENGINE. I WAS MORE CONCERNED WITH THE CHECK ENGINE LIGHT SO I WENT AND GOT IT CHECKED. THE CODE CAME UP AS U0155 - WHICH REFERS TO (LOST COMMUNICATION WITH INSTRUMENT PANEL CLUSTER (IPC) CONTROL MODULE) MEANING MY ENTIRE DASHBOARD NEEDS TO BE REPLACED BECAUSE OF THIS LEAKING ! I HAVE TAKEN MY CAR ON MULTIPLE OCCASIONS TO VW DEALERSHIP FOR SERVICING (NEVER FOR THIS PROBLEM) AND THEY NEVER ONCE TOLD ME ANYTHING ABOUT CLEANING THE SUNROOF DRAINS EVERY TWO YEARS AS MAINTENANCE, IT IS VISIBLE TO THE NAKED EYE THAT MY SUNROOF IS MESSED UP BECAUSE WHEN I PURCHASED IT THE LINING ON THE CAR AROUND THE SUNROOF IS DROOPING AND I CANNOT OPEN THE SUNROOF BECAUSE OF THIS. I NEVER THOUGHT OF IT AS A BIG DEAL BECAUSE I DON'T USE A SUNROOF BUT HOW WAS I SUPPOSED TO KNOW THERE WAS A LEAK WITHOUT ANYONE TELLING ME THAT WAS EVEN POSSIBLE. I LOOKED UP THIS PROBLEM ONLINE, THAT'S HOW I KNOW WHAT'S WRONG WITH MY CAR. I REFUSE TO GET IT "DIAGNOSED" AND SPEND OVER 200$ ON JUST A DIAGNOSIS WHEN I ALREADY KNOW WHAT THE PROBLEM IS AND THEY'LL END UP CHARGING WAY MORE TO ACTUALLY FIX THE PROBLEM. THIS IS MY FIRST CAR AND I DON'T KNOW MUCH OF ANYTHING ABOUT CARS EXCEPT KEEPING UP WITH OIL AND FILTER CHANGES, FUEL INJECTORS, AND CHANGING MY TIRES WHEN THE TREAD IS GETTING LOW. I HAVE DONE ALL OF THAT AT EACH CHECKPOINT SINCE I PURCHASED AT 63,000 MILES. THERE IS SO MUCH CONDENSATION INSIDE I CAN BARELY SEE OUT MY WINDOWS, I HAVE SIT FOR AT LEAST A HALF HOUR CAR ON TO BE ABLE TO SEE & DRIVE.

NHTSA ID

10836971

Incident

Feb 2, 2016

Mileage

91,000 mi

I WAS DRIVING MY VW JETTA 2004 TDI ON A HIGHWAY, I WAS USING MY HIGH BEAM AND LOW BEAM HEADLIGHTS TO YIELD TO INCOMING TRAFFIC WHEN ALL OF A SADDEN MY HEADLIGHTS WENT OFF, I HAD TO STOP IT WAS VERY DARK AND DANGEROUS ROAD, I MOVED AND WIGGLE THE LEVER TO SEE IF I COULD MAKE IT COME ON AGAIN, EVENTUALLY IT DID, IT DID THAT ABOUT 4 TIMES,EVERY TIME IT SCARED THE ... OUT OF ME COULD NOT SEE ROAD. TOOK IT TO A MECHANIC, REPLACED THE TURN SIGNAL HIGH BEAM LOW BEAM AND CRUSE CONTROL LEVER, ITS ALL IN ONE LEVER. I LOOKED ON LINE TO SEE IF SOMEONE ELSE HAVE THE SAME PROBLEM AND IT SEEMS THAT IS A COMMON PROBLEM WITH THIS VEHICLE.

NHTSA ID

10823126

Incident

May 18, 2015

Mileage

122,000 mi

THE HIGH VOLTAGE FUSE BOX, THAT SITS ON TOP OF THE BATTERY MELTED DUE TO HEAT AND POOR DESIGN. THIS CAUSED A SHORT AND COMPLETE LOSS OF POWER TO MY VEHICLE. THIS WAS BOTH DANGEROUS AND FRIGHTENING! I WAS ON THE FREEWAY GOING 60MPH AND COULD HAVE EASILY LOST CONTROL OF THE VEHICLE, CAUSING AN INJURY OR FATAL ACCIDENT. I FOUND 44 SIMILAR COMPLAINTS REGARDING THIS SAME ISSUE AND AM SURPRISED THAT THIS PUBLIC AGENCY HAS FAILED TO TAKE ANY ACTION ON THIS, AND DEMANDING A RECALL, AND THUS RESOLVING A DANGEROUSLY REOCCURRING ELECTRICAL ISSUE.

NHTSA ID

10820663

Incident

Dec 12, 2015

Mileage

70,000 mi

I HAVE REPLACED MY BATTERY TWICE AND MY ALTERNATOR ONCE. MY CAR COMPLETELY SHUTS DOWN WHEN I PART IT. I HAVE ALSO TURNED ON MY CAR AND THEN COMPLETELY SHUTS DOWN BY ITSELF, YET IF I JUMP START IT WILL TURN ON. I'M NOT ABLE TO TURN MY CAR BACK ON, AS THOUGH SOMETHING IS DRAINING MY BATTERY. THIS HAS BEEN OCCURRING FOR OVER ONE YEAR NOW AND I'M GETTING STRANDED AT MY LAST DESTINATION AND HAVE HAD TO GET TOWED TO THE MECHANIC SHOW. IT'S GETTING VERY EXPENSIVE AND RIDICULOUS. THE MECHANIC HAS DONE HIS DUE DILIGENCE BUT PROBLEM IS STILL OCCURRING. I'M AFRAID TO DRIVE ON THE HIGHWAY IN FEAR MY CAR WILL SHUT DOWN! *TR

NHTSA ID

10777794

Incident

Sep 23, 2015

Mileage

97,000 mi

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 50 MPH, THERE WAS SMOKE COMING FROM THE HEATED SEATS ON THE FRONT PASSENGER SIDE THE CONTACT STATED THAT THERE WAS A HOLE BURNED INTO THE FRONT PASSENGER SEAT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED . THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. UPDATED 05/31/17*LJ UPDATED 06/02/2017*JS

NHTSA ID

10679573

Incident

Dec 15, 2014

Mileage

180,000 mi

THE BATTERY FUSE BOX MELTED DUE TO CORROSION ON THE TERMINAL OF THE ALTERNATOR WIRE, THIS IS A VERY COMMON PROBLEM WITH THIS CAR AND CARS OF SIMILAR MAKE (AUDI A4, TT ETC.) AND CAN LEAD TO FIRES. *TR

NHTSA ID

10597643

Incident

Jun 3, 2014

Mileage

90,000 mi

ALTERNATOR WIRING HARNESS OVERHEATED MY BATTERY FUSE BOX AND MELTED IT. THE VEHICLE BATTERY LIGHT CAME ON SO I PULLED OVER, TURNED THE VEHICLE OFF, AND INSPECTED THE BATTERY, NOTICING THE DAMAGE (MELTED PLASTIC, SMOKE). *TR

NHTSA ID

10554293

Incident

Jul 1, 2013

Mileage

110,000 mi

HEADLIGHTS DIMMING- TO POINT WHERE YOU CAN NOT TELL THEY ARE ON. ENGINE LIGHT COMES ON DESPITE ALL DIAGNOSTICS STATING ALL IS OK WITH CAR. PERIODICALLY FAILS TO START-DESPITE DIAGNOSTICS THAT STATE STARTER, BATTERY, DRAIN ALTENATOR ALL GOOD AND FUNCTIONING PROPERLY. CAR JUMPS EASILY WITH "BOOST". *TR

NHTSA ID

10490419

Incident

Dec 24, 2012

Mileage

122,642 mi

2004 VW JETTA GLS TDI OPERATING AT 75MPH ON INTERSTATE ON CRUISE CONTROL WHEN THE ENGINE SHUTOFF COMPLETELY. THE VEHICLE STILL HAD ELECTRICAL POWER AND ENGINE WOULD CRANK BUT WOULD NOT START. I ROLLED THE VEHICLE OFF TO THE SIDE OF THE ROAD AND ATTEMPTED TO RE-START THE ENGINE AND IT FINALLY CRANKED AND DROVE VEHICLE APPROXIMATELY 500 MILES BEFORE EXPERIENCING SIMILAR ISSUE. SINCE THAT TIME VEHICLE HAS HAD SAME ISSUE OVER 10 TIMES. DEALER HAS INSPECTED VEHICLE THREE TIMES AND HAS NOT DISCOVERED ISSUE. *TR

NHTSA ID

10465504

Incident

Apr 30, 2012

Mileage

118,000 mi

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN JETTA. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE, THE ENTIRE ELECTRICAL SYSTEM INCLUDING THE LIGHTING AND INSTRUMENT PANEL FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC. THE PRIVATE MECHANIC CONFIRMED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 90,000.

NHTSA ID

10449619

Incident

Feb 24, 2012

Mileage

90,000 mi

I HAVE A 2004 VW JETTA. IT HAS ABOUT 48,000 MILES ON IT. A LITTLE OVER A YEAR AGO, IT DEVELOPED AN ELECTRICAL PROBLEM. IT PROGRESSES FROM THE DASHBOARD LIGHTS FLICKERING INITIALLY & THE TRIP MILEAGE GOING AWAY, TO BEEPING 3 TIMES, AND EVENTUALLY TO STALLING WHEN I STOP. IT'S PROGRESSIVE, THE LONGER IT HAPPENS THE MORE FREQUENTLY IT HAPPENS. THIS MAKES THE CAR UNRELIABLE AND DANGEROUS. I'VE TAKEN THE CAR TO THE DEALERSHIP 4 TIMES. THE FIRST 2 TIMES, THEY SAID IT WAS A SHORT. I WAS CHARGED FOR THE SERVICE. THE NEXT TIME THEY SAID IT WAS THE IGNITION SWITCH. I PAID FOR THE PART BUT NOT THE LABOR. THE LAST TIME, THEY SAID IT WAS THE FUEL PUMP RELAY SWITCH. I WASN'T CHARGED. I GOT THE CAR BACK THURSDAY. THE PROBLEM REOCCURRED SATURDAY. I SPOKE TO VW CORP. PRIOR TO THE THIRD & FOURTH TIMES I TOOK IT TO THE DEALER. THE FOURTH TIME, I ASKED FOR OTHER OPTIONS, BUT ALL THEY WOULD DO IS TELL ME TO TAKE IT IN FOR REPAIRS. I SPOKE TO THEM AGAIN TODAY. THEY SAID TO TAKE IT IN TO THE DEALER ONCE MORE. I POINTED OUT THAT I HAD JUST DONE THAT LAST WEEK. THEY STILL INSISTED I RETURN IT TO THE DEALER. THEY SAID EVENTUALLY, THEY MIGHT GIVE ME CREDIT FOR THE CAR TOWARDS A NEW CAR. THEY WOULDN'T SPECIFY HOW MANY MORE TIMES I'LL HAVE TO TAKE IT IN TO BE CONSIDERED FOR THE CREDIT. THEY DIDN'T SAY HOW MUCH CREDIT THEY WOULD OFFER. I DON'T WANT ANOTHER VW. I ASKED THAT, AS THE CAR WAS UNRELIABLE & THEY COULDN'T FIX IT, THAT THEY BUY IT BACK FROM ME AT THE BLUE BOOK PRICE. THEY SAID THAT WOULD NEVER HAPPEN. DO YOU HAVE REPORTS OF SIMILAR PROBLEMS WITH 2004 VW JETTAS? DO YOU HAVE ANY SUGGESTIONS AS TO WHAT MY RIGHTS ARE RELATIVE TO THIS SITUATION? *TT

NHTSA ID

10445877

Incident

Jan 30, 2012

Mileage

48,000 mi

AFTER SERVICE BY VW FOR WINDOW GLASS CLIP RECALL THE TRACTION CONTROL LIGHT WILL NOT TURN OFF. NO TRACTION CONTROL FOR THE VECHICLE. *TR

NHTSA ID

10410884

Incident

Feb 10, 2011

Mileage

79,000 mi