2004 Volkswagen Jetta Fuel system Problems

VEHICLE UNDER MULTIPLE OCCASIONS HAS STALLED OUT AT VARIOUS SPEEDS, LOCATIONS, AND DRIVING STYLES/ROADS AT OR UNDER A QUARTER OF A TANK

NHTSA ID

11140488

Incident

Sep 25, 2018

Mileage

168,000 mi

WHILE DRIVING DOWN ROAD EARLY IN MORNING APPROX 2 MILES FROM HOUSE I JUST LEFT FROM MY 2004 JETTA SHUTS DOWN TOTAL LOSS OF ALL POWER I PULLED CAR OVER IN A CHURCH PARKING LOT I SMELLED SMOKE AND COULD SEE SMOKE COMING FROM FIRE WALL I RAISED HOOD AND PULLED BATTERY CABLE OFF I COULD SEE SMPOKE FILLING INSIDE OF MY CAR WALKED AROUND TO DRIVER DOOR TO GET MY PHONE AND I SEEN FUSE BOX ON FIRE.ANOTHER VEHICLE STOPPED TO HELP ME AND HE APPROACHED MY CAR AND THEN CALLED POLICE ,FULL FLAMES WERE COMING FROM MY CAR WITHIN 5 MIN SO I STOOD BACK AND WATCHED MY CAR BURN .FIRE DEPT SHOWED UP AND PUT FIRE OUT MY CAR IS A TOTAL LOSS. IVE HAD ISSUES WITH ALTERNATOR,FUEL PUMP,AIR BAG LIGHT, HEADLIGHTS ARE REALLY DIM EVEN ON BRIGHT.NOTHING BUT ISSUES WITH THIS CAR SINCE I GOT IT. 115.000 MILES ONLY ON THIS CAR .SO MANY ISUES I CAN SEE WHY ITS LOW MILAGE

NHTSA ID

11076395

Incident

Mar 3, 2018

Mileage

115,000 mi

THE CAR RANDOMLY STALLS WHILE DRIVING WHETHER AT HIGHWAY SPEEDS OR IN TOWN. THIS CAUSES A LOSS OF POWER STEERING AND POWER BRAKES WHICH IS INHERENTLY DANGEROUS IN CERTAIN SITUATIONS. IT HAS BEEN DOING THIS REGULARLY WITH THE PREVIOUS OWNER FOR THE LAST 3 OR 4 YEARS AND HAS DONE IT 4 TIMES WHILE UNDER MY OWNERSHIP SINCE SEPTEMBER 2017 IT USUALLY HAPPENS WHILE THERE IS LESS THAN 1/4 TANK OF FUEL. WHEN IT HAPPENS THERE IS NO CHECK ENGINE LIGHT NOR DOES THE ECU STORE ANY CODES FROM THE PROBLEM. PREVIOUS OWNER MADE SEVERAL REPAIRS INCLUDING A FUEL PUMP AND FILTER, ENGINE SPEED SENSOR AND ALTERNATOR WIRING HARNESS IN AN ATTEMPT TO FIX THE ISSUES WITH NO SUCCESS. THIS ISSUES ALSO COMES UP REGULARLY ON SEVERAL VW FORUMS AND NO ONE SEEMS TO HAVE AN ANSWER. THIS IS A KNOWN AND REGULAR ISSUE WITH NO CONSISTENT REPAIR AND NEEDS TO BE REMEDIED.

NHTSA ID

11046653

Incident

Nov 16, 2017

Mileage

145,000 mi

RANDOMLY STALLS ON THE FREEWAY WHEN DOWN TO 1/4 TANK OF GAS. AFTER PULLING OVER AND TURNING OFF THE KEY AND TURNING THE KEY BACK ON, IT WILL START AND RUN GREAT. THIS HAPPENS ABOUT EVERY OTHER TIME THE CAR GETS DOWN TO ABOUT 1/4 TANK. NO SHOP CAN DUPLICATE THE PROBLEM OR CORRECT IT. I HAVE TRIED THE IGNITION COIL, GROUNDS, FUEL PUMP... NO FIX. THERE ARE COUNTLESS THREADS ON VARIOUS VW FORUMS ABOUT THIS SAME PROBLEM. IT IS VERY DANGEROUS TO STALL ON THE FREEWAY. SOMETHING NEEDS TO BE DONE TO CORRECT THIS.

NHTSA ID

11012200

Incident

Jul 25, 2017

Mileage

165,000 mi

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE HAVING THE VEHICLE SERVICED BY AN INDEPENDENT MECHANIC, THE CONTACT WAS INFORMED THAT THE VEHICLE WAS LEAKING FUEL INTO THE ENGINE COMPARTMENT. AN INDEPENDENT MECHANIC STATED THAT THE TANDEM PUMP BECAME INOPERABLE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 220,000. UPDATED 10/9/15 *LN THE CONSUMER BELIEVED HIS VEHICLE SHOULD HAVE BEEN INCLUDED IN THE FUEL SYSTEM RECALL. HOWEVER, HIS PRODUCTION YEAR WAS NOT INCLUDED. UPDATED 04/11/16.*JB *CN

NHTSA ID

10759094

Incident

Aug 1, 2008

Mileage

220,000 mi

VW CORP REJECTED CATALYTIC CONVERTER REPLACEMENT WHEN WE IDENTIFIED THAT THE FLEX PIPE WAS LEAKING/LOUD AND WAS OVER THE MILEAGE WARRANTY (VW EXTENDED THE PART WARRANTY TO 10YRS OR 120K MILES) OUR CAR HAD 120,110 MILES. THERE WAS NO LOCAL VW DEALERSHIP TO ID REPAIRS NEAR WHERE I WAS WORKING. THE PART DID FAILED BEFORE THE 120K MILES; AND HAS BEEN LEAKING OR DAMAGED FOR SOMETIME. SINCE IT WARMED UP AND I HAD THE WINDOWS DOWN I WAS ABLE TO HEAR THE LEAK. THIS PART WAS REPLACED UNDER WARRANTY PREVIOUSLY AND WAS A RECALL ITEM ON THIS MODEL AND YEAR. IS THERE A "RANGE" ON MILEAGE THAT THE VW IS REQUIRED TO TAKE INTO ACCOUNT FOR TRAVEL TO NEAREST VW DEALER LOCATION FOR REPAIRS OR WRITTEN WITHIN THE CURRENT EMISSIONS WARRANTY LAW?? *TR

NHTSA ID

10583941

Incident

Mar 3, 2014

Mileage

119,000 mi

A LITTLE UNDER 3 YEARS AGO (OCT. 2010) I STARTED NOTICING A FAINT GAS SMELL COMING FROM MY CAR. OVER A 2 WEEK PERIOD THE SMELL GRADUALLY GOT STRONGER AND MY MPG SLOWLY DECREASED. AFTER TAKING MY CAR INTO A SHOP IT WAS DETERMINED THERE WAS A CRACK NEAR THE FUEL PUMP GASKET AND THE FUEL PUMP NEEDED TO BE REPLACED. NOW 2 WEEKS AGO (MAY 2013) THE EXACT SAME SYMPTOMS STARTED UP AGAIN AND AFTER TAKING MY CAR BACK TO THE SHOP THEY TOLD ME THE EXACT SAME THING. THERE WAS A SMALL CRACK NEAR THE GASKET ON MY FUEL PUMP AND IT NEEDED TO BE REPLACED. THERE IS AN OBVIOUS DESIGN FLAW TO CAUSE ME TO REPLACE 2 FUEL PUMPS IN A 3 YEAR SPAN. *TR

NHTSA ID

10522615

Incident

Oct 1, 2010

Mileage

100,000 mi

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING AT UNKNOWN SPEEDS, HE NOTICED A STRONG FUEL ODOR. UPON INSPECTION, IT WAS FOUND THAT THE FUEL PUMP HAD FAILED. THE MANUFACTURER ADVISED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 04V586000 (FUEL SYSTEM, DIESEL). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 145,000 AND THE CURRENT MILEAGE WAS 146,177.

NHTSA ID

10514861

Incident

May 28, 2013

Mileage

145,000 mi

WE ARE THE ORIGINAL OWNERS OF A 2004 JETTA WITH 2.0 ENGINE WITH 98K AS OF APR 2013. WITHOUT ANY WARNING OR CLUES FROM VW DEALER OR AUTO SHOP, THE CAR WOULD NOT START; CAR WOULD TURN OVER THE ENGINE BUT NO FUEL PRESSURE. DEPENDING ON SEASON (WINTER) AND LOCATION (MIDDLE OF NO WHERE) THIS CAN CAUSE A HAZARD FOR THE DRIVER AND PASSENGER. THE CAR WOULD START AFTER LEAVING IT ALONE FOR 2-3 HRS AND TRY RESTARTING. THE WARNING SEEMS TO BE WHEN THE INTERIOR LIGHT DOES NOT COME ON WHICH MEANS THE SWITCH IS ACTING UP; THE FUEL SYSTEM IS AT A LOW PRESSURE WILL CAUSE A NO START. UNDER VW NEW CAR AND INDEPENDENT SHOPS CAN NOT DUPLICATE; MANY ON-LINE OWNERS HAS HAVE POINTED THE FINGER AT A DOOR LATCH/PRIMING CIRCUIT BOARD THAT CONTROLS THE FUEL PUMP PRIME WHEN THE DRIVER DOOR IS OPENED. GOOD PICS ON THE CIRCUIT BOARD FAILED/CRACKED SOLDER JOINT. THIS DOOR LATCH PRIMING IS USED ON MANY VW GROUP CARS; WE OWN A CAYENNE AND I CAN HEAR THE PRIMING. PLEASE CONSIDER A RECALL OF THIS VW PART OR TELLING VW TO STOP PLACING THE FUEL PUMP PRIMING CIRCUIT IN THE DRIVER DOOR LATCH. THE IGNITION KEY SEEM TO BE WHAT OTHER CAR MAKERS USE. *TR

NHTSA ID

10509326

Incident

Apr 1, 2008

Mileage

26,000 mi

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN JETTA. THE CONTACT STATED THAT A FUEL ODOR WAS BEING EMITTED FROM THE VEHICLE. UPON INSPECTION, IT WAS FOUND THAT FUEL WAS LEAKING AROUND THE AREA OF THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER AND INFORMED THE CONTACT THAT THE DIESEL FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE AND ALTHOUGH THE PART NUMBER FOR THE FAILED COMPONENT WAS THE SAME AS IN THE RECALL, THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 04V586000 (FUEL SYSTEM, DIESEL). THE FAILURE AND CURRENT MILEAGES WERE 172,000.

NHTSA ID

10491780

Incident

Jan 1, 2013

Mileage

172,000 mi

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE VEHICLE EMITTED A STRONG FUEL ODOR, THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT THE SUPPLY LINE CRACKED AND AS A RESULT, THE FUEL NECK TO SPILL OVER TOP OF THE TANK AND GROUND. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN (NHTSA CAMPAIGN ID NUMBER: 05V154000 FUEL SYSTEM, GASOLINE: DELIVERY: FUEL PUMP) THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 110,000.

NHTSA ID

10472999

Incident

Aug 27, 2012

Mileage

110,000 mi

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE FUEL PUMP WAS LEAKING AND CAUSING THE VEHICLE TO BECOME RESISTANT TO STARTING. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 04V586000 (FUEL SYSTEM, DIESEL). THE CONTACT CALLED THE DEALER REGARDING THE RECALL AND THE DEALER INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE CONTACT WAS CONCERNED THAT THE VEHICLE COULD POTENTIALLY CAUSE A FIRE. THE FAILURE MILEAGE WAS 90,500. UPDATED 06/24/11 *BF THE CONSUMER DISPUTED THE DEALERS RESPONSE SINCE HE BELEIVED HIS VIN FELL IN THE PUBLISHED VIN RANGE OF THE RECALL DESCRIBED IN VW'S DOCUMENTATION PROVIDED TO NHTSA. UPDATED 06/30/11

NHTSA ID

10404342

Incident

Jun 11, 2008

Mileage

90,500 mi

MY 2004 VW JETTA 1.8 TURBO WHICH I PURCHASED NEW IS HAVING TRANSMISSION PROBLEMS. MY CAT HAS ONLY 66,000 MILES IN IT AND HAS BEEN WELL MAINTAINED. IN THE PAST TWO YEARS I HAVE REPLACED THE FUEL PUMP, BATTERY, CATALYTIC CONVERTER, NUMEROUS VACUUM LEAKS ECT...BUT A TRANSMISSION???? VOLKSWAGEN NEEDS TO ISSUE A RECALL AS THIS IS WAY TO COMMON!! PLEASE HELP! *TR

NHTSA ID

10398143

Incident

Apr 19, 2011

Mileage

66,000 mi

ON MARCH 25, 2007, I WOKE UP TO A STRONG FUEL LEAKAGE ODOR, SEEKING FOR AIR, ALMOST FINDING IT IMPOSSIBLE TO BREATHE PROPERLY, FORCING ME TO EVACUATE MY HOUSE AT LATE HOURS OF THE NIGHT THE GAS SMELL WAS COMING FROM MY CAR IN THE GARAGE. I CALLED DEALER, EXPLAINED MATTER. DEALER TOLD ME MY CAR WAS NO LONGER UNDER WARRANTY FOR THIS KIND OF SERVICE/OR REPAIR. THE CAR HAD 49,419 MILES AND WAS 4 YEARS OLD BUT VOLKSWAGEN WARRANTY IS COVERED FOR 50,000 MILES OR 5 YEARS WHICHEVER OCCURS FIRST. I CALLED VOLKSWAGEN BUT THEY ONLY CONFIRMED THE DEALER'S STATEMENT. TOOK CAR TO LOCAL SHOP, THEY REPLACED FUEL TANK AND FUEL PUMP ON MARCH 26, 2007, COST $754.11. THREE MONTHS AFTER THE STRONG GAS SMELL CAME BACK ONLY DIFFERENCE THE ENGINE LIGHT CAME ON AND SMELL WAS NOT AS STRONG. I TOOK CAR TO A DIFFERENT SHOP ON MAY 22, 2008 THEY REPAIRED GAS TANK AND FUEL PUMP SEAL COSTING ME $316.20. THIS APRIL RECEIVED A LETTER FROM VOLKSWAGEN FOR FAULTY CATALYTIC CONVERTER, RESEARCHED CONNECTION TO POTENTIAL GAS LEAK AND FOUND IN DISBELIEF THE GAS LEAK RECALL ON 2005, WHICH I WAS NOT NOTIFIED IN 2005 OR 2007. *TR

NHTSA ID

10334704

Incident

Mar 25, 2007

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN JETTA. WHILE DRIVING AT SPEEDS OF 40 MPH, THE VEHICLE CAUGHT ON FIRE. THE POLICE AND FIRE DEPARTMENT WERE CALLED TO THE SCENE WHERE THE FIRE WAS EXTINGUISHED AND A FIRE REPORT WAS FILED ACCORDINGLY. THE MANUFACTURER ADVISED THERE WERE NO RECALLS ON THE VEHICLE AND WOULD NOT PROVIDE ANY ASSISTANCE. THE CONTACT INQUIRED ABOUT NHTSA CAMPAIGN ID NUMBER 04V586000 (FUEL SYSTEM, DIESEL) HOWEVER, THE MANUFACTURER ADVISED THEY HAD NO KNOWLEDGE OF THE RECALL. THE CURRENT AND FAILURE MILEAGES WERE 70,000.

NHTSA ID

10330125

Incident

May 12, 2010

Mileage

70,000 mi

I AM THE OWNER OF A 2004 VOLKSWAGEN JETTA GLI, WHICH I GARAGE AT MY CONDOMINIUM. IN MARCH 2006, THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION ISSUED A RECALL OF VOLKSWAGEN AND AUDI 2003 CARS WITH 1.8L TURBO ENGINES DUE TO ELECTRICAL FAILURE OF THE FUEL PUMPS. I RAISE THE POSSIBILITY OF MY CAR BEING INVOLVED IN THE MANUFACTURING MALFUNCTION, BUT NOT INCLUDED IN THE RECALL. 07/17/2009: CAR TOWED TO VOLKSWAGEN AUTOBARN OF EVANSTON. COSTS: $74.15. 07/25/2009: INFORMED THAT THE CAR REQUIRED A NEW BATTERY AND FUEL PUMP. PARTS & LABOR COSTS: $905.85. AFTER PAYING FOR THE REPAIRS AND WAITING FOR DELIVERY, THE CAR WOULD NOT START. 07/27/2009: RETRIEVED THE CAR AFTER VW AUTOBARN SERVICE INSTALLS A SECOND FUEL PUMP, DUE TO A DEFECT IN THE PREVIOUS PART. I DROVE THE CAR HOME AND PARKED UNDERGROUND. 07/28/2009: I DROVE TO THE FAA REGIONAL OFFICE IN DES PLAINES, IL. AT APPROXIMATELY 18:30, I ATTEMPTED TO LEAVE HOWEVER, THE CAR DID NOT START IN THE SAME FASHION THAT LED TO THE INITIAL REPAIR. THE CAR IS TOWED BACK TO VOLKSWAGEN. 08/17/2009: INFORMED BY THE VW AUTOBARN SERVICE MANAGER THAT THEY HAVE GONE TO EXTRAORDINARY EFFORTS TO REPAIR THE CAR: DRIVEN THE CAR ON MULTIPLE OCCASIONS INCLUDING TAKING IT HOME OVERNIGHT; COMMUNICATED WITH THE GERMAN SERVICE OFFICE TO PURSUE OTHER POSSIBLE CAUSES FOR FUEL PUMP FAILURES. COSTS FOR TOWING, FUSES, RELAY SWITCHES, LEADS, CONNECTORS AND TECHNICIAN LABOR: $574.11. AFTER PAYING FOR THE ABOVE REPAIRS, AGAIN, THE CAR WOULD NOT START. 08/28/2009: INFORMED THE FUEL IN THE CAR CONTAINED 40% ALCOHOL AND IS THE CAUSE OF FAILURE OF THE THREE PREVIOUS FUEL PUMPS. MOREOVER, I WAS RESPONSIBLE FOR VOIDING THE WARRANTY OF THE PREVIOUS FUEL PUMPS AND NOW FINANCIALLY RESPONSIBLE FOR $1400 IN NEW CHARGES, INCLUDING THE COST OF A FOURTH FUEL PUMP. I LAST PURCHASED 12.63 GALLONS PREMIUM FUEL ON JUNE 26 WITHOUT ISSUE UNTIL JULY 17. *TR

NHTSA ID

10288877

Incident

Jul 17, 2009

ELECTRONIC FUEL PUMP CRACKS AND LEAKS FUEL ONTO LIVE ELECTRICAL CONNECTIONS TO FUEL PUMP LOCATED UNDER REAR PASSENGER SEAT. BY TIME YOU SMELL GAS INSIDE OF VEHICLE, GAS HAS PUDDLED ABOUT 1/4" DEEP ON THE ELECTRICAL CONNECTIONS POWERING THE FUEL PUMP. DEALER WARNS NOT TO DRIVE DUE TO RISK OF FIRE OR EXPLOSION. HAPPENED FIRST IN MAY OF 2007 AT 64,000 MILES. VW UNCONCERNED AND DID NOT REMEDY. HAPPENED AGAIN MAY OF 2009 AT 96,000 MILES. VW AGAIN UNCONCERNED. I ASSUME IT MUST BE SAFE TO DRIVE. DOES SOMEBODY HAVE TO DIE FIRST? *TR

NHTSA ID

10272337

Incident

May 28, 2009

Mileage

64,000 mi

MY CAR LITERALLY TURNED OFF WHEN I WAS TURNING A CORNER...LUCKILY I WASN'T ON THE FREEWAY. THE BATTERY WAS FINE. IT TURNED OUT TO BE THE LIFT FUEL PUMP FOR MY 2004.5 VOLKSWAGEN JETTA TDI PD BEW. I WAS CHARGED $400 BY A LOCAL VW MECHANIC. THE DEALERSHIP WOULD CHARGE $800. IF I HAD IT DONE IN TDI CLUB, IT WOULD BE AROUND $200. *TR

NHTSA ID

10256464

Incident

Dec 29, 2008

Mileage

88,500 mi

NOISE STARTED, A HIGH-PITCHED WHINING. TOOK MY CAR TO MY MECHANIC AND IT IS THE SAME DARNED THING IT WAS IN FEBRUARY, 2008! THE FUEL PUMP. HE TELLS ME HE CHANGES THEM OUT ON VW'S ALL THE TIME. THE PART IS A VW DEALER PART ONLY AND IT'S DEFECTIVE, JUST LIKE THE 2003 VW PASSAT PUMPS WERE! *TR

NHTSA ID

10253873

Incident

Jan 5, 2009

Mileage

85,550 mi

CAR WAS SMELLING OF GAS. LOOKED UNDER CAR AND FOUND GAS LEAKING FROM UNDERNEATH CAR. TOOK IT TO CAR DEALERSHIP AND THEY SAID THE FUEL PUMP HAD TWO SMALL PIN HOLES IN IT. REPLACED IT AT NO COST. *TR

NHTSA ID

10248385

Incident

Oct 30, 2008

Mileage

69,990 mi

THE LATEST INCIDENT WITH THIS 2004 VW JETTA IS ONE IN WHICH EVERYTHING ELECTRIC STOPS WORKING. NO A/C, NOT LIGHTS, NO BLINKERS, NO WINDOWS, NO HORN - AND THERE IS A SMELL OF SMOKE IN THE CAR. THIS FIRST HAPPENED IN JANUARY/08 AND THE DEALERSHIP SAID IT WAS WIRING. NOW IT HAPPENED AGAIN! OCCURS JUST WHILE DRIVING ALONG. CAR SMELLS LIKE SMOKE AND EVERYTHING STOPS WORKING. I GET THE RUNAROUND FROM THE DEALER, VISTA VW IN POMPANO BEACH, FL. THEY ALWAYS SEEM TO FIND SOMETHING WRONG WITH THE CAR NOW THAT IS NOT UNDER WARRANTY. PLEASE INVESTIGATE THIS - THERE IS SOMETHING WRONG WITH THESE JETTA'S! I HAVE FOUND 100'S OF COMPLAINTS ON CONSUMER SITES ABOUT THIS CAR. I AM TIRED OF PAYING MY HARD EARNED DOLLARS TO THE DEALER WHEN THIS IS AN ISSUE WITH THE MANUFACTURER OF THIS CAR. I ADVISED THE DEALER OF THIS WHEN I TOOK IT IN IN JANUARY; HIS RESPONSE WAS, TOO BAD, YOU DO NOT QUALIFY FOR THE CAR LEMON LAW SINCE THE CAR IS OUT OF WARRANT AND PURCHASED IT IN DEC/05. PLEASE DO SOMETHING FOR US CONSUMERS THAT ARE TIRED OF BEING MANIPULATED AND OVERCHARGED FOR ISSUES THAT SHOULD BE THE RESPONSIBILITY OF THE AUTO MANUFACTURER. PLEASE LET ME KNOW IF THERE IS ANYONE OTHER AGENCY I CAN CONTACT. I WILL NOT GIVE UP ON THIS AND HOPE YOU CAN ASSIST ME. THANK YOU. *TR

NHTSA ID

10242435

Incident

Sep 15, 2008

CAR STARTED NORMALLY, PULLED TO ENTRANCE TO ROAD, ENGINE STALLED SUDDENLY AND WOULD NOT RESTART. AFTER SEVERAL ATTEMPTS, ENGINE STARTED AND RAN NORMALLY. AFTER 10 MILES, STOPPED AT CONVENIENCE STORE. ENGINE STARTED NORMALLY AND ABRUPTLY STALLED WHILE ENTERING INTERSTATE HIGHWAY. AGAIN DIFFICULT TO RESTART, BUT FINALLY DID. RAN FINE FOR NEXT 45 MILES. A THIRD STALL HAPPENED THE NEXT MORNING. ALL THREE STALLS HAPPENED WITHIN 30 TO 90 SECONDS OF STARTUP. SUSPECT THAT THE IN-TANK "LIFT PUMP" WAS FAILING INTERMITTENTLY. THERE WOULD BE ENOUGH FUEL IN THE FILTER TO RUN ENGINE FOR A WHILE WITHOUT THE LIFT PUMP FUNCTIONING. THE LIFT PUMP HAS NOW BEEN REPLACED. *TR

NHTSA ID

10240281

Incident

Aug 26, 2008

Mileage

77,000 mi

TL*THE CONTACT OWNS A 2004 VOLKSWAGEN JETTA. THE CONTACT NOTICED A LEAK AND SMELLED FUMES IN THE PASSENGER COMPARTMENT. THE DEALER STATED THAT THE FAILURE WAS CAUSED BY THE DIESEL FUEL SYSTEM. SHE FOUND A RECALL ON THE EXACT SAME FAILURE ON THE MANUFACTURER'S WEBSITE; HOWEVER, THE DEALER STATED THAT HER VIN WAS NOT INCLUDED AND REFUSED TO MAKE A REPAIR. THE FAILURE MILEAGE WAS 82,000 AND CURRENT MILEAGE WAS 84,000. UPDATE 04-02-08 *BF

NHTSA ID

10219563

Incident

Feb 21, 2008

Mileage

82,000 mi

ON 2/4/08 AT 7:30 A.M. I GOT IN MY 2004 VW JETTA WAGON AND ALTHOUGH IT WAS TURNING OVER, IT WOULD NOT START AT ALL. IT HAD OPERATED PERFECTLY THE NIGHT BEFORE. I HAD IT TOWED TO OUR MECHANIC THAT WE HAVE USED FOR NEARLY 10 YEARS. THE MECHANIC CALLED & SAID IT WAS THE IN-TANK FUEL PUMP AND THE ASSOCIATED COMPONENT. HE STATED HE HAS HAD A LOT OF THESE BROUGHT TO HIM IN VW'S AND THIS IS A COMMON FAILURE. HE STATED WHEN HE CALLED ABOUT THE PART THEY SAID, "OH YES, WE HAVE THAT PART IN STOCK NO PROBLEM." HE REPLACED THE FUEL PUMP ON 2/6/08 AND AGAIN STATED THIS SEEMED TO BE A COMMON FAILURE IN VW'S. HE ALSO STATED THE MILEAGE ON OUR 2004 VW JETTA WAGON WAS NOT SUFFICIENT TO WARRANT SUCH A FAILURE UNLESS THERE WAS A PROBLEM WITH THE MECHANISM AND SUGGESTED I REPORT THE FAILURE. THE REPAIR COST WAS $697.59 TOTAL. *TR

NHTSA ID

10217455

Incident

Feb 4, 2008

Mileage

61,710 mi

AFTER DRIVING 800 HIGHWAY MILES FROM FLORIDA, WITH 400 MILES LEFT TO GO WE STOPPED FOR THE NIGHT. THE NEXT MORNING THE CAR WAS BUCKING AND REFUSED TO RUN. WE ADDED A FUEL ADDITIVE AND MANUAL SHIFT IN ORDER TO KEEP THE CAR RUNNING AND GET IT HOME. ON AUG. 27TH WE CHANGED THE FUEL FILTER AND TOOK THE CAR FOR A TEST DRIVE. THE CAR STALLED WHEN GOING UP A HILL APRROX. 500 FT FROM HOUSE. IT WOULD NOT RESTART. THE CAR WAS TOWED TO THE DEALER ON AUG. 28TH AND IS STILL THERE ON SEPT. 20TH. SO FAR THEY HAVE REPLACED THE FUEL IN THE TANK AND THE FUEL FILTER, AND THE EGR VALVE WAS REPLACED. THE CAR IS STILL RUNNING SLUGGISH AND BUCKING. THEY CAN'T FIND OUT WHAT IS WRONG WITH IT. NEXT THEY WANT TO TAKE APART THE INTAKE MANIFOLD EVEN THOUGH THEY ARE NOT SURE THAT IS THE PROBLEM. THE CAR IS A 2005 AND HALF JETTA DIESEL WITH 63,000 MILES ON IT. THE CAR IS UNSAFE TO DRIVE AND IS THE CAR I DEPEND ON TO TAKE MY CHILDREN BACK & FORTH TO SCHOOL (A 20 MILE TRIP ONE WAY). *TR

NHTSA ID

10203622

Incident

Aug 26, 2007

Mileage

63,000 mi