1996 Volkswagen Passat Electrical Problems

TL*THE CONTACT OWNS A 1996 VOLKSWAGEN PASSAT. THE CONTACT STARTED THE IGNITION AND THE ANTILOCK BRAKE SYSTEM WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. WHILE THE LIGHT WAS ILLUMINATED, THE AIR CONDITIONER UNIT, WINDSHIELD WIPERS, AND HEADLIGHTS WERE INOPERATIVE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THEY STATED THAT THE FAILURE WAS RELATED TO THE ELECTRICAL COMPONENT IN THE IGNITION SWITCH. THE VEHICLE HAS NOT BEEN REPAIRED. THE CONTACT WAS DISPLEASED TO KNOW THAT HIS VIN WAS NOT INCLUDED IN THE RECALL, ESPECIALLY SINCE THE FAILURES WERE IDENTICAL. THE RECALL NUMBER WAS UNKNOWN. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 120,000.

NHTSA ID

10236875

Incident

May 10, 2008

THE IGNITION SWITCH ON MY 1996 VW PASSAT WENT OUT WHILE DRIVING AT NIGHT, WHICH SHUT DOWN THE HEADLIGHTS. THIS IS EXACTLY THE SAME AS DESCRIBED IN NHTSA CAMPAIGN ID NUMBER : 02V256000 I WAS INFORMED BY VW CUSTOMER SERVICE THIS RECALL DIDN'T APPLY TO MY VIN#, DESPITE IT BEING A 1996 PASSAT. I THINK IT SHOULD. *TR

NHTSA ID

10210117

Incident

Jan 26, 2007

DT*: THE CONTACT STATED THE VEHICLE WOULD NOT START SOMETIMES AND THE WINDSHIELD WIPERS WORKED INTERMITTENTLY. THE VEHICLE FINALLY STARTED AFTER SEVERAL ATTEMPTS. THERE WAS A NHTSA RECALL, # 02V256000, REGARDING THE ELECTRICAL SYSTEM: IGNITION: SWITCH. THE MANUFACTURER INFORMED THE CONTACT THAT PREVIOUS RECALL REPAIR INFORMATION WAS AVAILABLE THROUGH THE DEALER. THE DEALERSHIP WAS NOT CONTACTED.

NHTSA ID

10165211

Incident

Aug 11, 2006

Mileage

150,000 mi

I HAVE HAD ONGOING ISSUES WITH ELECTRONIC AND EMISSIONS SENSORS FOR THIS VEHICLE AND RECENTLY SPENT $756.54 TO (AGAIN!) REPLACE SENSORS SO THAT THE VEHICLE WOULD PASS ITS ANNUAL EMISSIONS TEST (AS MANDATED BY THE EPA). I WROTE TO VW CUSTOMER CARE TO SEEK REIMBURSEMENT OF THIS (AND PAST) CHARGES AND WAS TOLD TODAY (7/13/06) THAT NO RECALLS OR SERVICE BULLETINS WERE ISSUED, SO NO REIMBURSEMENT WILL BE MADE. I TOLD THEM THAT NHTSA ISSUED RECALL 99V131 (WHICH ADDRESSES SOME OF THE AREAS) BUT VW TOLD ME THAT IT DID NOT APPLY, AS ALL REIMBURSEMENTS ARE VIN-SPECIFIC. CAN ANYONE PLEASE HELP? THANK YOU. *JB

NHTSA ID

10162287

Incident

Jun 23, 2006

DT*: THE CONTACT STATED THE HEADLIGHTS AND WINDSHIELD WIPERS BECAME INOPERABLE, THEN THE VEHICLE WOULD NOT START. THE VEHICLE HAS NOT BEEN SEEN BY A MECHANIC. THE RECALL, #02V256000 CONCERNING THE IGNITION SWITCH WAS PERFORMED ON THE VEHICLE IN AUGUST 2002. THE VEHICLE IS HAVING THE SAME PROBLEM AS INDICATED IN THE RECALL. THE MANUFACTURER WAS CONTACTED. *AK

NHTSA ID

10152844

Incident

Mar 16, 2006

Mileage

105,000 mi

CONSUMER HAD 1996 VW PASSAT IGNITION SWITCH REPLACED. AFTER ABOUT A YEAR SWITCH NEEDED TO BE REPLACED AGAIN. *TS THE FIRST TIME THE SWITCH WAS REPLACED IT WAS FREE OF CHARGE AND NOW THAT IT HAS FAILED AGAIN THE DEALER DOESN'T WANT TO REPLACE THE IGNITION SWITCH UNDER THE RECALL AGAIN BECAUSE THEY STATED THE VEHICLE WAS MORE THAN 8 YEARS OLD. *JB

NHTSA ID

10145318

Incident

Jun 30, 2004

MY 1996 VW PASSAT HAS LOST ITS ENTIRE INSTRUMENT CLUSTER, VERY UNSAFE WITH NO BACKING FROM VW. *JB

NHTSA ID

10132058

Incident

Aug 1, 2005

Mileage

84,000 mi

MY 1996 VW PASSAT HAS AN IGNITION SWITCH IS FAULTY. MY FIRST TIME WAS AT NIGHT AND MY LIGHTS WENT OUT. I PULLED OF THE ROAD AND RESTARTED THE CAR AND THE LIGHTS CAME ON. THE NEXT TIME THE LIGHTS WENT OUT AND THE WIPERS STOP. I HIT EVERY SWITCH AND WHEN I HIT THE IGNITION SWITCH EVERYTHING CARE ON. I CALLED DEALER AND HE SAID MY VIN WAS NOT COVERED UNDER THE RECALL. IF MY CAR IS HAVING THE SAME PROBLEMS AS THE RECALL WHY CAN'T THIS BE COVERED BY THE SAFETY RECALL?

NHTSA ID

10119386

Incident

Aug 8, 2004

Mileage

142,045 mi

IGNITION SWITCH REPLACED IN A 1996 PASSAT VR6. WAS A RECALL ON SWITCH. I WOULD LIKE A REFUND ON PARTS AND LABOR. *JB

NHTSA ID

10102658

Incident

Aug 24, 2004

Mileage

84,200 mi

CONSUMER'S VEHICLE EXPERIENCED THE SAME PROBLEMS AS STATED IN NHTSA RECALL 02V256000. ON CERTAIN PASSENGER VEHICLES, THE ELECTRICAL PORTION OF THE IGNITION SWITCH ASSEMBLY CAN FAIL, CAUSING THE HEADLIGHTS AND WINDSHIELD WIPERS TO BECOME INOPERATIVE. DEARSHIP INDICATED TO CONSUMER SORRY THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. *AK

NHTSA ID

10092792

Incident

Sep 20, 2004

CONSUMER STATED VEHICLE HAD THE VERY SAME PROBLEM AS MENTIONED IN RECALL 02V256000 CONCERNING IGNITION SWITCH. ALSO, THE ELECTRICAL PART OF THE SWITCH SHORTED OUT THE LIGHTS, AIR CONDITIONING, WINDSHIELD WIPERS, AND RADIO. TOOK VEHICLE DEALER, AND CONSUMER WAS GRANTED AN EXTENDED WARRANTY. HOWEVER, THE PROBLEM STILL EXISTS. *AK

NHTSA ID

10055343

HEADLIGHTS CONTINUALLY GO OUT. VOLKSWAGEN DEALERSHIP SUPPOSEDLY DID ELECTRICAL PART OF IGNITION SWITCH REPLACEMENT, BUT HEADLIGHTS STILL DID NOT WORK. FURTHER REAIRS BY AN INDEPENDANT MECHANIC WORKED FOR A SHORT TIME, THEN ONE OF THE LIGHTS WENT OUT AGAIN. THIS HAS BEEN ONGOING FOR OVER A YEAR. DEALERSHIP COMPLETELY UNINTERESTED.*AK

NHTSA ID

10036873

Incident

Apr 21, 2003

WHILE TRAVELING ON THE HIGHWAY AND WITHOUT PRIOR WARNING, THE CAME ON AND WENT OFF INTERMITTENTLY. *AK WINDSHIELD WIPERS WORKED INTERMITTENTLY. CONSUMER ALSO EXPERIENCED THE SAME DEFECTS AS STATED IN THE IGNITION SWITCH RECALL. *PH. THE CONSUMER STATED THE PROBLEM WAS FIXED UNDER THE RECALL REGARDING THE IGNITION SWITCH. *JB

NHTSA ID

10026984

Incident

Jul 10, 2003

Mileage

72,000 mi

1. MY CAR HAD IGNITION SWITCH FAILURE. THERE IS A RECALL ON IGNITION SWITCH FAILURES FOR THE YEAR/MAKE/MODEL OF MY CAR. WHEN I CONTACTED THE MANUFACTURER THEY SAID THE RECALL DOESN'T APPLY TO MY VIN. 2. DRIVERS DOOR WINDOW REGISTER HAS FAILED. MANY OWNERS OF SIMILAR VEHICLES HAVE REPORTED SAME.

NHTSA ID

10020684

Incident

Nov 1, 2002

WHEN DRIVING VEHICLE WITHOUT WARNING THE HEADLIGHTS, WINDSHIELD WIPERS, AND TURN SIGNALS WILL GO OUT. CAUSE IS UNKNOWN. PLEASE PROVIDE ANY FURTHER INFORMATION. MR

NHTSA ID

8022782

Incident

Nov 1, 2002

CONSUMERS NOTICE THE ELECTRICAL PORTION OF THE IGNITION SWITCH ASSEMBLY HAS FAILED CAUSING THE WINDSHIELD WIPERS TO BECOME INOPERATIVE. DEALER HAS BEEN CONTACTED. PLEASE PROVIDE FURTHER INFORMATION. MR

NHTSA ID

8022653

IGNITION SWITCH FAILURE RESULTS IN WINDSHIELD WIPER, WINDOWS, AND BLINKER FAILURE AS WELL AS THE ENGINE NOT STARTING OR STOPPING ONCE STARTED. VERY DANGEROUS AND PRONE TO SERIOUS ACCIDENT. MAY CAUSE PERSONAL INJURY AND HARM AND INJURY TO OTHERS IN AN HIGHWAY ACCIDENT. DT

NHTSA ID

769406

Incident

Jul 1, 1999

NHTSA# 15255-02-V-256-000 IGNITION SWITCH ASSEMBLY CAN FAIL CAUSING THE HEAD LIGHT, WIDSHIELD AND WIPERS TO BECOME INOPERATIVE. A RECALL HAS BEEN ISSUED ON SIMILAR MAKES AND MODELS, HOWEVER THIS VEHICLE IS NOT INCLUDE TO VIN# DEALER NOTIFIED TS

NHTSA ID

8021931

Incident

Oct 30, 2002

THERE IS A RECALL CAMPAIGN IN PROGRESS FOR PASSAT IGNITION SWITCH WITH NHTSA CAMPAIGN ID NUMBER 02V256000. I WOULD LIKE TO HAVE THIS CAMPAIGN EXTENDED TO INCLUDE MY VEHICLE AS I AM EXPERIENCING THE SAME SAFETY DEFECT THAT IS THE SUBJECT OF THE CURRENT CAMPAIGN. DT

NHTSA ID

769101

Incident

Oct 1, 2002

CONSUMER STATES WHILE DRIVING ALL VEHICLE'S HEADLIGHTS, TAILLIGHTS AND INTERIOR LIGHTS FAIL W/O WARNING. TS

NHTSA ID

8021577

Incident

Sep 16, 2002

IGNITION SWITCH FAILURE WITH FAILURE OF WINDSHIELD WIPER, HEADLIGHTS, TURNING SIGNALS AND AC/HEAT FAN. ALL EXCEPT FOR THE LETTER I CONSIDERED A SAFETY CONCERN. NHTSA POSTED A RECALL FOR THIS PARTICULAR YEAR AND MODEL BUT VWOA DO NOT HAVE RECORDS OF SUCH RECALL AND CHARGE FOR THE PARTS AND LABOR OF REPLACEMENT. DT

NHTSA ID

768889

Incident

Aug 1, 2002

THE IGNITION SWITCH CUTS OUT INTERMITTENTENTLY. ENGINE STILL RUNS BUT NO LIGHTS, WIPERS, ABS BRAKING, AND OTHER SAFETY FEATURES OPERATE. DT

NHTSA ID

768806

Incident

Oct 1, 2002

CALLED VW - NHTSA CAMPAIGN NUMBER 02V256000 DESCRIBING RECALL DOES NOT APPLY TO MY CAR?! RIDICULOUS! I HAD THIS EXACT THING HAPPEN TO ME, IN SNOWY WEATHER. I DROVE 60 MILES WITH MY HAND ON THE KEY SWITCH TWISTING IT SO LIGHTS AND WIPERS WOULD STAY ON! THIS RECALL NEEDS TO BE EXPANDED! MR

NHTSA ID

768472

Incident

Jan 1, 2000

RE: NHTSA RECALL CAMPAIGN NUMBER 02V256000 STATES THAT "ON CERTAIN PASSENGER VEHICLES, THE ELECTRICAL PORTION OF THE IGNITION SWITCH ASSEMBLY CAN FAIL CAUSING THE HEADLIGHTS AND WINDSHIELD WIPERS TO BECOME INOPERATIVE. IF SUCH FAILURES OCCUR WHILE THE VEHICLE IS IN USE AT NIGHT OR IN A RAINY OR SNOWY WEATHER, A CRASH COULD OCCUR. DEALERS WILL REPLACE THE ELECTRICAL PART OF THE IGNITION SWITCH ASSEMBLY. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING SEPTEMBER OR OCTOBER 2002. OWNERS SHOULD CONTACT VWOFA AT 1-800-822-8987. WELL, AT THIS WRITING IT IS OCTOBER 14, 2002 I HAVEN'T RECEIVED THE NOTIFICATION. THE PROBLEM STATED ABOVE HAPPENED TO MY CAR. BUT I WAS TOLD THAT I WOULD NOT BE ELIGIBLE FOR THE REPLACEMENT BECAUSE MY VIN DOES NOT MATCH THEIR LIST. DUH, PUT IT ON THE LIST BECAUSE IT HAPPENED. THE MORONIC "CUSTOMER ADVOCATE" AS THEY CALL THEMSELVES KEPT REPEATING THAT THE VIN IS NOT ON THE LIST SO HE CANNOT DO ANYTHING. CAN NHTSA DO SOMETHING ABOUT THIS PROBLEM? MR

NHTSA ID

768428

Incident

May 1, 2002

WHEN THE KEY IS INSERTED INTO THE IGNITION AND TURNED, THE ENGINE DOES NOT START, WHICH ALSO CAUSED OTHER COMPONETS TO BECOME INOPERATIVE, CONSUMER HAD THE IGNITION LOCK ASSEMBLY REPLACED. AFTER THE REPLACEMENT, CONSUMER WAS STILL EXPERIENCING DIFFICULTIES IN STARTING THE VEHICLE. THE MECHANIC STATED THAT THE IGNITION LOCK ASSEMBLY WAS FAULTY, ALSO THE BATTERY WAS EPLACED.*JG

NHTSA ID

565496

Incident

Sep 1, 2000