2001 Volkswagen Passat Powertrain (other) Problems

AS MY SON GOT ON THE HIGHWAY THE TRANSMISSION FELT LIKE IT WAS SLIPPING AND JERKING TO THEN CATCH BACK UP TO THE ORIGINAL SPEED I WAS GOING. WHEN HE PUT HIS FOOT ON THE GAS PEDAL THE CAR WOULD STRUGGLE TO GO, 5 SECONDS LATER IT WOULD GET UP TO SPEED BUT THEN SLOW BACK DOWN. AT A STOPLIGHT THE CAR WOULD SHAKE ROUGHLY AND IDLE REALLY HIGH, THEN HE SAW THE FRONT OF THE HOOD START TO SMOKE AND I REALIZED THERE WAS A PROBLEM.

NHTSA ID

10865850

Incident

May 19, 2016

Mileage

132,273 mi

TL* THE CONTACT OWNS A 2001 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHILE DRIVING AT UNKNOWN SPEEDS, THE TRANSMISSION WOULD SLIP AND THEN THE VEHICLE STALLED. THE ENGINE CONTINUED TO RUN, BUT THE VEHICLE WOULD NOT MOVE. THE VEHICLE WAS TAKEN TO A DEALER AND IT WAS DETERMINED THAT THE TEETH ON THE GEARS OF THE TRANSMISSION HAD FRACTURED AND THE ENTIRE TRANSMISSION NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 160,000. UPDATED 8/19/15*CN THE CONSUMER STATED THERE WAS A RECALL FOR THE SAME MAKE, MODEL, AND YEAR BUT, THE CONSUMER'S VIN WAS NOT INCLUDED. UPDATED 9/30/2015*JS

NHTSA ID

10717045

Incident

May 15, 2015

Mileage

160,000 mi

2001 VW PASSAT STICKING GAS PEDAL COMMENTS: THIS HAS HAPPENED TO ME RECENTLY 2 TIMES....GAS PEDAL STUCK TO FLOOR, REDLINE, ALMOST CRASHED. RESEARCHING I FOUND IT TO BE A COMMON PROBLEM. VW SHOULD BE HELD ACCOUNTABLE... THIS IS A DANGEROUS SITUATION! SHOULD I STOP DRIVING IT??? MORE ACCOUNTS AT: HTTP://WWW.PASSATWORLD.COM/FORUMS/42-VOLKSWAGEN-PASSAT-B5-DISCUSSION/236513-ANYONE-ELSE'S-GAS-PEDAL-GET-STUCK.HTML. *TR

NHTSA ID

10522521

Incident

Apr 1, 2013

Mileage

80,000 mi

TL*THE CONTACT OWNS A 2001 VOLKSWAGEN PASSAT. THE VEHICLE WAS SERVICED FOR A ROUTINE TUNE-UP AND A HONDA DEALER WROTE ON THE INVOICE THAT THE CONTROL VALVE JOINTS AND BOOTS WERE TORN, IN ADDITION TO THE SHAFT. THE CONTACT STATED THAT THE FAILURES WERE RELATED TO SEVERAL COMPLAINTS ON THE NHTSA WEBSITE. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 56,511. UPDATED 05/08/09. *LJ THE CONSUMER STATED THE CV JOINTS WERE REPLACED. UPDATED 05/08/09.*JB

NHTSA ID

10263713

Incident

Mar 30, 2009

1. FRONT AND REAR BRAKES INADEQUATE FOR VEHICLE--HAD TO HAVE BRAKE WORK AT ~20,000 MILES AND AGAIN AT JUST UNDER 42,000 MILES (THIS HAS NEVER BEEN A PROBLEM WITH ANY OTHER CAR). BRAKES REPAIRED/PARTS REPLACED TWICE. CAR SHOULD BE RECALLED BY MANUFACTURER FOR BRAKES 2. SUNROOF +/- WINDSHIELD DRAIN(S) BECAME BLOCKED AND LEAKED AND FLOODED PASSENGER FOOTWELLS, WITH RISK OF DAMAGE TO TRANSMISSION. THIS IS A MANUFACTURING DEFECT WITH THIS MAKE AND MODEL AND HAS BEEN WIDELY REPORTED ON THE WEB. VW NEEDS TO RECALL CARS FOR THE PROBLEM WITH BLOCKED DRAINS/LEAKAGE AND DAMAGE TO VEHICLES. COST TO VACUUM WATER OUT OF FOOTWELLS BELOW THE CARPET > $600 WITH NO GUARANTEE THAT PROBLEM WILL NOT RECUR 3. VW PASSAT HAS A KNOWN PROBLEM WITH SLUDGE BUILD UP IN ENGINE AND CONSEQUENT ENGINE FAILURE--I HAVE NOT (?YET) HAD THE PROBLEM BUT FEEL THAT VW GUARANTEE TO REPAIR PROBLEM ONLY IF OWNER CAN PROVE OIL CHANGES EVERY 3000 MILES IN AN UNREASONABLE ABNEGATION OF DUTY. THIS IS A DESIGN FLAW AND THE COMPANY SHOULD HAVE TO RECALL ALL CARS WITH THE PROBLEM AND REPAIR AT NO CHARGE WITHOUT BEING ABLE TO SHIFT BLAME TO CONSUMER. NOW HAVING TO USE EXPENSIVE SYNTHETIC OIL FOR OIL CHANGES ON A VERY FREQUENT BASIS. *TR

NHTSA ID

10224606

Incident

Apr 3, 2008

TL*- THE CONTACT TOOK THE 2001 VOLKSWAGEN PASSAT TO A DEALER, AND THEY STATED THAT THE VEHICLE WAS UNSAFE TO DRIVE. ALL 8 TIE RODS AND THE ONE LINK ARM WERE SHOWING EXCESSIVE WEAR. THE DEALER AND THE MANUFACTURER STATED THAT THE VEHICLE WAS OUT OF WARRANTY SO THE REPAIR WOULD BE AT CONTACTS EXPENSE. THE CURRENT AND FAILURE MILEAGE WERE BOTH 79200.*AK THE RIGHT OUTER CV BOOT WAS TORN AND THE LEFT OUTER TIE ROD END WAS WORN. THE ABS CONTROL MODULE WAS REPLACED. UPDATED 03/30/07. *JB

NHTSA ID

10184566

Incident

Jan 29, 2007

Mileage

79,200 mi

I OWN 2001 VW PASSAT WITH 43200 MILES. THIS PAST YEAR I NOTICED FAILURES OF OUTER CV JOINT BOOT BOTH SIDES AND RUBBER DUST BOOTS ON ALL BALL JOINTS WHICH CAUSES A DIRT AND WATER TO DESTROY BALL JOINTS. I CHANGED OUTER CV JOIN BOOT BOTH SIDES AND ONE UPPER CONTROL ARM BALL JOINT AND OTHERS WILL FAIL SOON. *JB

NHTSA ID

10138154

Incident

Sep 21, 2005

Mileage

40,000 mi

CAR DIED WHILE DRIVING ON 55 MPH ROAD. STARTER WORKED AND ENGINE WOULD TURN, BUT WOULD NOT RUN. DEALER FOUND NO CODES IN COMPUTER. ENGINE AND HORN FUSES BLOWN AND DEALER REPLACED HORN RELAY. I ASKED THE DEALER WHY THERE WERE NO CODES IN THE COMPUTER AND THEY DIDN'T KNOW THE ANSWER. THEY WOULD NOT REPLACE THE COMPUTER. CAR WAS IN THE SHOP FOR 7 DAYS. INCIDENT HAPPENED OVER 100 MILES FROM HOME AND DEALER FINALLY AUTHORIZED LOANER AFTER 2 DAYS. DEALER WAS VERY RUDE DURING THE WHOLE INCIDENT AND CONSTRUCTION MADE IT DIFFICULT TO COMMUNICATE. PHONE LINES WERE DISCONNECTED PART OF THE TIME.

NHTSA ID

10079100

Incident

Jul 9, 2002

Mileage

14,362 mi

SAFETY: OPERATION OF THE "DRIVE BY WIRE THROTTLE" ON MY V6/TIPTRONIC 2001.5 VW PASSAT. THE THROTTLE DOES NOT OPERATE IN A "LINEAR MANNER". IT MAY STRUGGLE TO MOVE OUT FROM A STOP (SOUNDS AS IF THE ENGINE IS WORKING VERY HARD TO MOVE THE CAR) ONE MOMENT AND THEN IT MAY "LEAP" AHEAD UNDER LIGHT THROTTLE APPLICATION FROM THE NEXT STOP. (THIS CAN LEAVE YOU STRUGGLING TO CROSS A BUSY INTERESCTION) THE DEALER SAYS VW SAYS THIS IS "NORMAL OPERATION".

NHTSA ID

10004968

Incident

Sep 13, 2002

Mileage

22,000 mi

THIS ISSUE CAUSED MY CAR TO MISFIRE SO BAD I WAS UNABLE TO GET MY CAR TO ACCELERATE AND NEARLY CAUSED AN ACCIDENT. THIS ISSUE COULD LEAVE MANY STRANDED AND HAS ALREADY CAUSED MAJOR PROBLEMS FOR HUNDREDS OF OWNERS. *PH *JB **DIMSII IVOQ ENTRY POSTED AFTER 12/12/02 CUT OVER TO ARTEMIS**770852

NHTSA ID

10006825

Mileage

26,000 mi

AFTER THE CAR HAS BEEN PICKED UP FOR 6 DAYS, THE FRONT LEFT CV BOOT WORE OUT DUE TO LOOSE INSTALLATION. THIS PROBLEM WAS NOT FOUND BY DEALER BEFORE DELIVERY. THE CV BOOT IS NOW REPLACED BY DEALER.*AK

NHTSA ID

751778

Incident

Aug 31, 2001