2001 Volkswagen Passat Engine Problems

TOOK CAR TO VW DEALER TO HAVE TIMING BELT REPLACED AND WAS NOTIFIED THAT THERE WERE SEVERAL OPEN RECALLS AND THEY OFFERED TO TAKE CARE OF THEM FREE OF CHARGE. HOWEVER, THEY WERE UNABLE TO PERFORM RECALL #08V156. MANUFACTURER #26E5. THEY INSTALLED THE HEAT SHIELD BUT COULD NOT PERFORM SOFTWARE UPGRADE. I NEVER RECEIVED ANY RECALL NOTICES IN THE MAIL. NOW VW WANTS TO BUY THE CAR BACK BECAUSE THEY CAN'T FIX IT. IT'S A 2001 VW PASSAT WITH 25K MILES IN SHOWROOM SHAPE. WAS NEVER DRIVEN IN SNOW AND GARAGED IT'S ENTIRE LIFE. THEY OFFERED ME $1500 OUT OF WHICH I OWE $1300 FOR THE TIMING BELT. THEY SAID IT MAY NEED A ECU BUT THEY ARE NO LONGER AVAILABLE FROM VW BUT REFUSE TO INSTALL A USED ONE. THE CAR HAS BEEN AT THE VW DEALER SINCE 12/28/2020. I WAS UNDER THE IMPRESSION THAT RECALLS NEVER EXPIRE.

NHTSA ID

11389398

Incident

Dec 28, 2020

Mileage

25 mi

FAULTY CAM CHAIN TENSIONER FAILED AND CAUSED SEVERE ENGINE DAMAGE TO VALVES, PISTONS, CAMSHAFT, CAM TIMING CHAIN. I WAS STATIONARY WAITING AT A RED LIGHT WHEN I HEARD A SUDDEN LOUD GRINDING NOISE FROM INSIDE THE ENGINE COMPARTMENT, THE ENGINE BEGAN TO SHAKE AND SPUTTER. THE CAR LOST MOST OF ITS POWER AND I WAS BARELY ABLE TO MAKE IT THROUGH THE INTERSECTION WHEN THE LIGHT TURNED GREEN. UPON INSPECTION IT WAS CLEAR TO SEE THAT THE CAM CHAIN TENSIONER HAD SELF DESTRUCTED AND CAUSED THE ENGINE TO FAIL.

NHTSA ID

11046400

Incident

Nov 10, 2017

Mileage

160,000 mi

SO I GOT REAR ENDED AT THE OTHER PARTY'S FAULT AT HIGH SPEED WHILE I WAS AT A STOP SIGN AND THEY NEGLECTED TO STOP PUSHING ME INTO AN INTERSECTION FULL OF TRAFFIC...NO AIRBAGS DEPLOYED..AND SINCE MY HEATER DOESN'T WORK BUT PASSENGER SEAT HEAT BURNED MY 12 YEAR OLD DAUGHTERS BUTT...ANYONE HELP? I JUST WANT HEAT FOR MY BABIES..BELOW ZERO HERE :( THANK YOU!! [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10658597

Incident

Nov 10, 2014

Mileage

180,220 mi

I WAS DRIVING AND I PULLED INTO MY PARKING LOT AND MY ENGINE CAUGHT ON FIRE. I PUT IT OUT WITH SNOW THANK GOD OR IT WOULD HAVE BEEN A LOT WORSE. I ALWAYS HAVE COOLANT AND OIL AND I CHECKED IT A LOT CAUSE OF THE FREEZING WEATHER WE HAVE HAD RECENTLY HAD -30 FOR QUITE AWHILE. I CALLED VW CUSTOMER CARE AND THEY WERE VERY WORRIED ABOUT MY SAFETY AT 1ST THEN THEY HAD A PRODUCT SOMETHING GUY CALL ME AFTER SEE THE PICTURE I SENT THEM. I UNDERSTAND THEY HAVE PEOPLE ALWAYS LOOKING FOR A QUICK ESCAPE GOAT BUT THIS WAS A FIRE IT COULD HAVE BEEN SO MUCH WORSE IF THERE WAS NOT SNOW NEAR BY. I WANT MY CAR FIXED BUT I AM MORE WORRIED ABOUT THE NEXT PERSON THIS COULD HAPPEN TOO. I SHOULD TELL YOU AFTER ASK HIM IF HE JUST WANTED TO FIND THE REASON BEHIND IT HE SAID NO. PERSONALLY A CAR FIRE IS NOT A NORMAL THING. *TR

NHTSA ID

10564966

Incident

Feb 18, 2014

Mileage

101,000 mi

MY CAR HAS BEEN LEAKING COOLANT. I TOOK IT TO A SHOP AND WAS INFORMED THAT THE HEATER CORE WAS BAD. I HAVE HAD TO REPLACE THE INSIDE COMPUTER ALREADY AND PROBABLY ALL THE CARPET SINCE THE WATER HAS BEEN LEAKING INTO THE CAR. I SUFFER FROM ASTHMA AND CAN NO LONGER DRIVE THIS CAR SINCE IT SMELLS LIKE COOLANT/MOLD AND NOT TO MENTION WATER LEAKING ON MY FOOT AS I DRIVE (VERY UNSAFE SINCE THE PEDAL GETS SLIPPERY.) I HAVE READ ONLINE ON MANY SITES THAT THERE WAS A RECALL REGARDING THIS MATTER AND THE OWNERS WERE NEVER NOTIFIED. I NEED THIS FIXED BEFORE SOMETHING BAD HAPPENS; EITHER I GET INTO AN ACCIDENT OR I END UP IN THE HOSPITAL. THANK YOU VERY MUCH FOR GETTING BACK TO ME AND GETTING THIS MATTER FIXED PROMPTLY. *TR

NHTSA ID

10500670

Incident

Aug 10, 2012

Mileage

155,000 mi

CAR HAD BEEN SITTING ALL DAY DROVE IT ONCE CAUGHT FIRE AROUND 4AM IN THE MORNING CAR TOTAL ALOT BURN BAD IN THE FRONT. I HAD NOTICE THAT SOME FEATURES WERE NOT WORKING BUT I DID NOT ATTRIBUTE IT TO A ELECTRICAL PROBLEM ACCORDING TO THE FIRE DEPT WHO CAME TO PUT THE BLAZE OUT. *TR

NHTSA ID

10485005

Incident

Nov 16, 2012

Mileage

1,570,000 mi

TL* THE CONTACT OWNS A 2001 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING COOLANT, CAUSING SMOKE TO BE RELEASED. THE DEALER DIAGNOSED THAT ANTIFREEZE LEAKED ONTO THE ELECTRICAL WIRES. THE DEALER DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT DENIED ANY ASSISTANCE WITH REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 127,980 AND THE CURRENT MILEAGE WAS 128,000.

NHTSA ID

10444616

Incident

Jan 4, 2012

Mileage

127,980 mi

TL* THE CONTACT OWNS A 2001 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE VEHICLE WAS SITTING AT A TRAFFIC STOP WHEN HE NOTICED SMOKE AND FIRE COMING FROM UNDER THE HOOD OF THE VEHICLE. THE FIRE DEPARTMENT WAS CALLED TO EXTINGUISH THE FIRE. A POLICE AND FIRE REPORT WAS FILED AND AVAILABLE. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 70,000. THE VIN WAS UNAVAILABLE.

NHTSA ID

10440596

Incident

Dec 19, 2011

Mileage

70,000 mi

"OIL PRESSURE. STOP ENGINE" LIGHT CAME ON. AFTER SEVERAL MILES DRIVING AND LOT OF NOISE FROM BACK OFF THE ENGINE. NEED NEW OIL PUMP PASSABLE REBUILT ENGINE. IT IS SITTING PARKED IN MY DRIVEWAY. *TR

NHTSA ID

10373775

Incident

Dec 20, 2010

Mileage

118,200 mi

CLASS ACTION LAW SUIT SETTLED WITH VW FOR OIL SLUDGE. THIS MAKES NO SENSE BY THE TIME THE SETTLEMENT WAS REACHED MY 2001 VW PASSAT, 1.8 TURBO WAS NOT COVERED. 7 OR 8 WEEKS AGO I TOOK MY VEHICLE INTO THE VW DEALER (HALMARK VW OF MADISON) THEY TOLD ME I HAD A SLUDGE PROBLEM AND DID NOT EVEN MENTION THAT IT WAS A KNOWN PROBLEM OR THAT THE LAW SUIT WAS UNDERWAY- VERY SNEAKY. THEY TOLD ME TO REPLACE MY ENGINE OR TO CHANGE THE OIL EVERY 1000 MILES FOR AWHILE. MY ABS AND COMPUTER MODULE FAILED AT THE SAME TIME WITH NO ONE TAKING RESPONSIBILITY FOR IT. NOW I HAVE THE PROBLEM BUT HAVE NO WAY TO GET IT RESOLVED. *TR

NHTSA ID

10372686

Incident

Nov 7, 2010

Mileage

165,000 mi

TL-THE CONTACT OWNS A 2001 VOLKSWAGEN PASSAT GLX. WHILE DRIVING APPROXIMATELY 40 MPH THE VEHICLE ENGINE LIGHT CAME ON. THE CONTACT STATED HE DROVE THE VEHICLE TO HIS DESTINATION. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP AND HE WAS TOLD THE CATALYTIC CONVERTER NEEDED REPLACING. THE FAILURE WAS CONSTANT SINCE JULY 1, 2008. THE VEHICLE HAS NOT BEEN REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 51,000 AND THE CURRENT MILEAGE WAS 62,000. VWB

NHTSA ID

10339849

Incident

Jul 1, 2008

Mileage

51,000 mi

VW ENGINE OIL SLUDGE PROBLEM.

NHTSA ID

10321628

Incident

Mar 20, 2010

Mileage

62,000 mi

HEATER CORE FAILURE,PLUGGING UP. VEHICLE HAS NO HEAT UNABLE TO CLEAR WINDSHIELD TO SEE. HEATER CORE PORSES TOO SMALL AND CLOGGED FROM REACTION FROM ANTI FREEZE CALCIFIED REACTION WITH METAL USED IN CORE. *TR

NHTSA ID

10289209

Incident

Sep 10, 2009

Mileage

102,000 mi

I BROUGHT MY VEHICLE INTO FIRESTONE FOR A ROUNTINE TUNE-UP AND TO REPLACE MY AXLE. BECAUSE OF FIRESTONES MIS-DIAGNOSIS OF THE TUNE-UP, THEY DETERMINED IT WAS THE ENGINE COIL. MY VEHICLE HAD TO BE TOWED TO AUDI OF BROOKLINE FOR A COMPLETE DIAGNOSTIC AND THEY FOUND THIS.....A PRE-EXISTING CONDITION - E.C.M..THE ENGINE COIL WAS ONLY A SYMPTOM OF THE BIGGER PROBLEM IN THE FAULTY E.C.M. MISFIRING. PRIOR TO BRINGING MY VEHICLE INTO FIRESTONE, IT WAS OPERABLE. BECAUSE OF THEIR TAMPERING WITH THE IGNITION COILS; MY VEHICLE WAS SUBSEQUENTLY DESTROYED. REGARDING THE DIAGNOSTIC REPORT, THE CURRENT AND PASSED CONDITION OF MY VEHICLE, WHICH IS NORMALLY A HEALTHY, SAFE, VEHICLE, IS AS FOLLOWS: "FUEL DELIVERY INSPECTION AT PRESENT TIME, IGNITION SYSTEM CHECK, AND POWER PROVIDED TO COILS TECH FOUND NO COMMUNICATION BETWEEN ENGINE CONTROL MODULE (E.C.M.) AND A.B.S. CONTROL MODULE BECAUSE A.B.S. CONTROL MODULE WAS DISCONNECTED. RECONNECT AND ACCESS A.B.S. SYSTEM AND FAULT DETECTED CUSTOMER AWARE OF THE A.B.S. PROBLEM AND WARNING HAS BEEN ON FOR A WHILE. THAT IS TRUE, AND NOT THE REASON FOR THIS LETTER. CONTINUED: FOUND E.C.M. FAULT FOR #3 IGNITION COIL OPEN CIRCUIT. PIN CHECK WIRES ON #3 IGNITION COIL PLUG #3 POST FROM CONNECTOR TO E.C.M. FOUND HEIGHT RESISTANCE IN WIRE, REPLACED #3 CONNECTOR AND RE-TESTED OK. ALSO CLEAN AND REPLACE TERMINAL ON TOP OF VALVE COVER FOR PROPER GROUND. START ENGINE AND ROAD TEST VEHICLE, FOUND ENGINE MISFIRE ON #1, #2, #3, #4 IGNITION COILS". I HAVE TO REPLACE ALL 4 IGNITION COILS, CATAYLTIC CONVERTER, AND E.C.M. THIS IS THE SECOND IGNITION COIL REPLACED IN THE 1 YEAR I'VE OWNED THE VEHICLE. THIS CAR HAS MORE MECHANICAL ERRORS THAN IMAGINABLE. THE ESTIMATED COST OF REPAIRS IS IN THE THOUSANDS. I CAN'T AFFORD TO MAINTENANCE THIS TEMPERMENATL VEHICLE. I WILL HAVE TO JUNK THE CAR. I REFUSE TO FIX THIS VEHICLE. PUSHING FOR A RECALL!! *TR

NHTSA ID

10285456

Incident

Sep 3, 2009

Mileage

106,000 mi

1. DURING MY WIFE'S MORNING COMMUTE THE OIL LIGHT STOP ENGINE LIGHT ILLUMINATED IN OUR 2001.5 VW PASSAT. FORTUNATELY SHE WAS IN A RURAL AREA AND WAS ABLE TO GET THE CAR SHUT OFF IMMEDIATELY AND COASTED OFF THE ROAD WITHOUT INCIDENT. 2. THE FAILURE WAS THE RESULT OF SEVERE OIL COKING WITH THE 1.8T ENGINE. VW ISSUED A NOTIFICATION LETTER DATED AUGUST 2004 ADVISING OF THE ?OIL SLUDGE? PROBLEM. THE LETTER STATES ?ENGINE OIL SLUDGE OCCURS WHEN OLD, DIRTY ENGINE OIL THICKENS AND CANNOT CONTINUE TO PROVIDE ADEQUATE ENGINE LUBRICATION.? THE LETTER IMPLIES THE ISSUE IS DUE TO POOR MAINTENANCE. IN REALITY THE FAILURE IS DUE TO A LATENT DESIGN DEFECT OF IMPROPER HEAT REJECTION ATTRIBUTE OF THE ENGINE SUMP. BASICALLY NOT ENOUGH OIL QUANTITY AND OIL COOLING CAPACITY. THE OIL THEN COKES OVER TIME IN A SIMILAR MANNER AS IS ENCOUNTERED ON GAS TURBINE ENGINES UNDER EXTREME TEMPERATURES. EVENTUALLY THE COKED PARTICLES ACCUMULATE AND PLUGS THE SUMP SCREEN. THE OIL PUMP THEN RESULTING IN THE LOSS OF OIL PRESSURE AND ENGINE FAILURE. THE LOSS OF ENGINE POWER AT A CRITICAL TIME IS A SAFETY CONCERN. 3. FORTUNATELY AS OUR CAR WAS NOT RUN WITHOUT OIL PRESSURE I WAS ABLE TO SAVE THE ENGINE. VW WOULD NOT HONOR THE WARRANTY DESPITE PROVIDING A LOG BOOK FROM ALL THE MAINTENANCE PERFORMED FROM NEW. THEY REQUIRED ALL RECEIPTS OF OIL CHANGES. I PERFORM ALL MY OWN MAINTENANCE. VW CLEARLY HAS GAMED THE WARRANTY AND MISREPRESENTED THE PROBLEM AS POOR MAINTENANCE AND SLUDGE. I HAVE ALWAYS CHANGED THE OIL EVERY 5K MILES. THIS COST ME NEARLY $2K IN PARTS NOT INCLUDING MY LABOR. THIS IS A MAJOR REPAIR. THE OIL PUMP, SUMP SCREEN, ALL CRANK CASE VENTILATION LINES, TURBO LINES, ETC. HAD TO BE REPLACED. THERE WAS COFFEE GROUNDS (COKED OIL) THROUGHOUT THE ENGINE. WHAT A MESS. I HOLD A BS IN AERO ENGR TECH AND FAA A&P LICENSE. I RUN THE AFTERMARKET FOR A LARGE GAS TURBINE ENGINE MFG. I KNOW ENGINE DESIGN AND WARRANTY GAMING WHEN I SEE IT. *TR

NHTSA ID

10284689

Incident

Feb 2, 2008

Mileage

155,000 mi

I HAVE A 2001.5- 2.8 DOHC VW PASSAT WITH JUST OVER 106K MILES.AT AROUND 98K MILES I STARTED TO EXPERIENCE A LOSS OF POWER IN THE ENGINE AND GOT MULTIPLE MISFIRES ON THE SCAN OF THE ENGINE. THIS HAPPENS INTERMITTENTLY, ALTHOUGH MOSTLY WHEN I START THE CAR AT THE BEGINNING OF THE DAY, REGARDLESS OF TEMPERATURE. FAST FORWARD 6 MONTHS, AFTER ALREADY REPLACING THE COIL PACK TWICE, I STILL HAVE THE SAME PROBLEM. THE DEALERSHIP WANTS TO CHARGE ME OVER $600 DOLLARS TO TRY AND FIGURE OUT WHAT "MIGHT" BE THE PROBLEM. THEY'RE STILL NOT SURE. IF ANYONE IS HAVING THIS PROBLEM, PLEASE LET ME KNOW IF YOU'VE FIGURED OUT WHAT IT IS. *TR

NHTSA ID

10280415

Incident

Aug 13, 2009

2001 1/2 VOLKSWAGEN PASSAT STATION WAGON, MANUAL, 1.8T PERSISTENT ISSUES WITH IGNITION COILS, AND CHECK ENGINE LIGHT OVER 8 YEARS. *TR

NHTSA ID

10266083

Incident

Mar 27, 2009

Mileage

142,000 mi

TL*THE CONTACT OWNS A 2001 VOLKSWAGEN PASSAT. THE VEHICLE WAS SERVICED FOR A ROUTINE TUNE-UP AND A HONDA DEALER WROTE ON THE INVOICE THAT THE CONTROL VALVE JOINTS AND BOOTS WERE TORN, IN ADDITION TO THE SHAFT. THE CONTACT STATED THAT THE FAILURES WERE RELATED TO SEVERAL COMPLAINTS ON THE NHTSA WEBSITE. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 56,511. UPDATED 05/08/09. *LJ THE CONSUMER STATED THE CV JOINTS WERE REPLACED. UPDATED 05/08/09.*JB

NHTSA ID

10263713

Incident

Mar 30, 2009

TL*THE CONTACT OWNS A 2001 VOLKSWAGEN PASSAT. THE VEHICLE FAILED A ROUTINE INSPECTION BECAUSE THE ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT CONTROL PANEL. THE INSPECTOR ADVISED THE CONTACT OF A RECALL ON HER VEHICLE PERTAINING TO THE FAILURE. THE DEALER STATED THAT THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 08V156000 (FUEL SYSTEM, GASOLINE:DELIVERY). THE VEHICLE HAS NOT YET BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 62,004. THE CONSUMER STATED THERE WAS A STRONG SMELL OF GAS EVERY TIME SHE TURNED THE VEHICLE OFF. UPDATED 02/24/09. *JB

NHTSA ID

10248291

Incident

Nov 3, 2008

Mileage

62,004 mi

MY 2001 VW PASSAT ABS MODULE BECAME DEFECTIVE AFTER 1 YEAR OF OWNING CAR FROM THE ORIGINAL OWNER. NOT SURE IF ORIGINAL OWNER HAD DONE REPAIRS/REPLACEMENTS OF THE UNIT. NOW THERE IS NO COMMUNICATION BETWEEN THE CAR COMPUTER AND THE MODULE, THEREFORE NO ABS BRAKE IS ACTIVE. ABS LIGHT STAYS ON AND BRAKE LIGHT FLASHES INTERMITTENTLY. THERE ARE ALSO 3 BEEPS WHEN CAR HAS BEEN STARTED. I AM A VERY UNHAPPY CONSUMER OF VW DUE TO THEIR FAULTY VEHICLE EQUIPMENT AND HAS DETER ME FROM PURCHASING ANY VW IN THE FUTURE. I HAVE RECENTLY JUST HAD A REPAIR TO REPLACE MY MAF SENSOR, 2 IGNITION COILS, 4 SPARK PLUGS AGAIN AFTER PURCHASING BRAND NEW ONES JUST A MONTH PRIOR. IT WAS VERY COSTLY!! *TR

NHTSA ID

10245585

Incident

May 15, 2008

Mileage

115,000 mi

TL*THE CONTACT OWNS A 2001 VOLKSWAGEN PASSAT. WHILE DRIVING APPROXIMATELY 55 MPH, THE "STOP VEHICLE DO NOT DRIVE", AND OIL PRESSURE WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE INDICATORS REMAINED ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER AND THEY REPAIRED THE ENGINE. THE PREVIOUS REPAIR REQUIRED THE VEHICLE TO REMAIN AT THE DEALER FOR ONE MONTH. ON THREE SEPARATE OCCASIONS, THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR IDENTICAL FAILURES, BUT THERE WERE NO RESOLUTIONS. IN ADDITION, DURING RAINY WEATHER CONDITIONS, FIVE INCHES OF WATER LEAKED ONTO THE FRONT PASSENGER SIDE FLOOR PANEL. THERE WAS ELECTRICAL FAILURE DUE TO THE WATER LEAKAGE THAT CAUSED GEAR COMPONENT DAMAGE. RECENTLY, THE CONTACT RECEIVED A RECALL NOTICE THAT CONSISTS OF INSTALLATION OF A DRAINAGE FILTER AND FUEL SYSTEM COMPONENT REPAIR. THE VEHICLE HAS NOT BEEN REPAIRED FOR THESE MALFUNCTIONS. THE NHTSA CAMPAIGN ID NUMBER WAS UNKNOWN. THE FAILURE MILEAGE WAS 36,000 AND CURRENT MILEAGE WAS 85,000.

NHTSA ID

10243564

Incident

Sep 10, 2005

Mileage

36,000 mi

I WAS DRIVING TO MY NEW EMPLOYMENT WHEN MY 2001.5 PASSAT LOST POWER. THE ENGINE RAN VERY ROUGH AND THE IDLE WAS STABLE. THE ENGINE CONTINUED TO STALL AND RENDERED THE VEHICLE UNUSABLE. MY PASSAT WAS TAKEN TO A GARAGE NEAR MY PLACE OF EMPLOYMENT AND I WAS TOLD THE CYLINDER #4 HAS FAILED. I HAD THE VEHICLE TOWED HOME (90 MILES) TO MY LOCAL GARAGE TO BE TOLD THE SAME. CYLINDER #4 HAS NO COMPRESSION AND THE TURBO HAS ALSO FAILED AS A RESULT OF THE FAILING CYLINDER. I WAS TOLD BY VW THAT I NEED TO REPLACE THE COIL PACKS AND SPARK PLUGS AND THE ERROR SHOULD CLEAR UP. I HAD THE MECHANIC REPLACE THE SPARK PLUGS AND ALL FOUR COIL PACKS ON THE VEHICLE. AFTER THE REPAIR THE MECHANIC STATED TO ME THAT THE VEHICLE PERFORMANCE AND ISSUE WAS NOT FIXED WITH THE REPAIR AND THE CYLINDER #4 WAS STILL DOWN. I HAVE BEEN LEFT WITHOUT A VEHICLE NOW FOR ALMOST TWO MONTHS WHILE STILL HAVING TO MAKE PAYMENTS ON A VEHICLE THAT I CAN NOT USE. *TR

NHTSA ID

10238979

Incident

Jul 1, 2008

Mileage

74,000 mi

I HAVE A '01 VW PASSAT. I HAD TO GO TO THE VW DEALER TODAY SINCE I WAS HEARING A PINGING NOISE WHEN I DRIVE. THEY CHECKED AND ADVISED THAT THE LOWER CONTROL ARM AND TIE ENDS WOULD NEED TO BE REPLACED SINCE THEY WERE WORN OUT. THE CAR HAS 77K MILES AND ON RESEARCHING HAVE FOUND THAT OTHER VW PASSAT OWNERS FROM THE SAME TIME FRAME ARE HAVING THE SAME ISSUE. IT HAS BEEN ATTRIBUTED TO DESIGN FLAWS. I AM WORRIED THAT THIS IS GOING TO DETERIORATE AND LEAD TO AN ACCIDENT. ADDITIONALLY THEY IDENTIFIED A VALVE COVER CAMSHAFT SEAL LEAKAGE. THIS IS ANOTHER ISSUE THAT HAS BEEN IDENTIFIED BY OTHER OWNERS. *TR

NHTSA ID

10235852

Incident

Jul 26, 2008

Mileage

77,105 mi

OWNER DRIVING THE CAR WHEN SMOKE BEGAN APPEARING FROM THE RIGHT SIDE OF THE DASHBOARD. FIRE DENSITY INCREASED RAPIDLY AND OWNER DROVE INTO A SAFEWAY PARKING LOT WAS ABLE TO GET OUT OF THE VEHICLE WHEN IT IMMEDIATELY FILLED WITH SMOKE. FIRE DEPT. WAS CALLED AND BROKE ALL WINDOWS CAUSING A TREMENDOUS AMOUNT OF SMOKE TO BE RELEASED. THE SMOKE WAS WHITE AND BLACK. *TR

NHTSA ID

10229012

Incident

May 9, 2008

I HAVE HAD MY 2001 VW PASSAT FOR 7 YEARS NOW AND HAVE HAD IT IN THE SHOP MULTIPLE ISSUES INCLUDING WARPED ROTORS (FRONT AND BACK), CRACKED CHASSE, ELECTRICAL ISSUES AND VARIOUS OTHER PROBLEMS. BEFORE HAVING THIS CAR, I HAD A TOYOTA FOR 8 YEARS AND IN THE 8 YEARS I HAD THE TOYOTA, I ONLY HAD IT IN THE SHOP FOR ROUTINE MAINTENANCE. THIS CAR IS DISAPPOINTING AND EVERYONE I TALK TO WHO HAS A SIMILAR MODEL/YEAR SAYS THE SAME THING. I THINK THE 2001 VW PASSAT IS A LEMON. *TR

NHTSA ID

10223581

Incident

Apr 7, 2008

Mileage

6,000 mi