2001 Volkswagen Passat Owner Complaints

My fuses keep blowing, this is leading to replacing the Brake switch which I believe was recalled. If it was replaced,it's not working.

NHTSA ID

11745122

Incident

Jun 18, 2026

The driver's side airbag of my 2001 VW Passat spontaneously deployed while I drove on Hwy 494 in Woodbury MN. Sometime within 24 hours before the airbag deployed, the airbag fault light turned on in the car's dashboard display. Within 15 minutes before the incident, the car's automatic locking locks unlocked twice while I was driving the car. After the second time, I tried to lock the car doors by pressing the lock button on the driver's door console but the doors would not locked. At that time I noticed that the two interior lights in the back seat area were turned on. All the doors of the car were properly shut. When the airbags deployed I was driving on the smooth 1 year old concrete section of Hwy 494. I did not hit anything on the highway. After the deployment, I parked on the shoulder, shut off the engine and opened the passenger door to air out the car. After about 5 minutes, I got back in the car and drove home. The automatic locks worked again. The interior lights automatically turned off. The drive home was uneventful.

NHTSA ID

11422304

Incident

Jun 10, 2021

TOOK CAR TO VW DEALER TO HAVE TIMING BELT REPLACED AND WAS NOTIFIED THAT THERE WERE SEVERAL OPEN RECALLS AND THEY OFFERED TO TAKE CARE OF THEM FREE OF CHARGE. HOWEVER, THEY WERE UNABLE TO PERFORM RECALL #08V156. MANUFACTURER #26E5. THEY INSTALLED THE HEAT SHIELD BUT COULD NOT PERFORM SOFTWARE UPGRADE. I NEVER RECEIVED ANY RECALL NOTICES IN THE MAIL. NOW VW WANTS TO BUY THE CAR BACK BECAUSE THEY CAN'T FIX IT. IT'S A 2001 VW PASSAT WITH 25K MILES IN SHOWROOM SHAPE. WAS NEVER DRIVEN IN SNOW AND GARAGED IT'S ENTIRE LIFE. THEY OFFERED ME $1500 OUT OF WHICH I OWE $1300 FOR THE TIMING BELT. THEY SAID IT MAY NEED A ECU BUT THEY ARE NO LONGER AVAILABLE FROM VW BUT REFUSE TO INSTALL A USED ONE. THE CAR HAS BEEN AT THE VW DEALER SINCE 12/28/2020. I WAS UNDER THE IMPRESSION THAT RECALLS NEVER EXPIRE.

NHTSA ID

11389398

Incident

Dec 28, 2020

Mileage

25 mi

ABS LIGHT ON AND BREAK LIGHT FLASHING

NHTSA ID

11120015

Incident

Jul 18, 2018

Mileage

125,000 mi

STARTED SMELLING GAS AND MILEAGE STARTED DROPPI G BAD AROUND THE END OF NOVEMBER. WE SEE THAT THERE HAS BEEN RECALLS ON THE GAS TANK AND FUEL LINES FOR 01 VOLKSWAGEN PASSATS BUT UNFORTUNATELY NOT FOR THIS VIN # WHICH HAPPENS TO BE MY SONS CAR. NOW ITS AT THE SHOP BECAUSE ITS GAS MILEAGE WENT WAY DOWN AND AND SMELLS LIKE GAS AND HE WAS TOLD THAT HE WAS DRIVING A BOMB BASICALLY. IT COULD BE AROUND $1000 TO FIX IT. NONE OF US HAVE THAT KIND OF $ AND HES STILL HAS $800 LEFT OWEING ON IT. HELP

NHTSA ID

11054149

Incident

Nov 27, 2017

FAULTY CAM CHAIN TENSIONER FAILED AND CAUSED SEVERE ENGINE DAMAGE TO VALVES, PISTONS, CAMSHAFT, CAM TIMING CHAIN. I WAS STATIONARY WAITING AT A RED LIGHT WHEN I HEARD A SUDDEN LOUD GRINDING NOISE FROM INSIDE THE ENGINE COMPARTMENT, THE ENGINE BEGAN TO SHAKE AND SPUTTER. THE CAR LOST MOST OF ITS POWER AND I WAS BARELY ABLE TO MAKE IT THROUGH THE INTERSECTION WHEN THE LIGHT TURNED GREEN. UPON INSPECTION IT WAS CLEAR TO SEE THAT THE CAM CHAIN TENSIONER HAD SELF DESTRUCTED AND CAUSED THE ENGINE TO FAIL.

NHTSA ID

11046400

Incident

Nov 10, 2017

Mileage

160,000 mi

MY 2001 VOLKSWAGEN PASSAT HAS HAD AN R5 RECALL FOR FUEL LINES, FUEL TANK, AND A HEAT SHIELD. THE HARD (LOW PRESSURE FUEL RETURN?) LINE, THE MIDDLE ONE OF THE MOUNTING BRACKET ATOP THE FIREWALL, HAS FAILED CATASTROPHICALLY. IT NOW SPRAYS GASOLINE DIRECTLY DOWN ONTO THE CATALYTIC CONVERTER HEAT SHIELD. THIS IS THE SAME FAILURE IN THE SAME EXACT POINT THAT MANY OTHER OWNERS HAVE HAD. THIS PART IS DANGEROUS AND COULD HAVE KILLED ME AND DESTROYED MY CAR. VOLKSWAGEN REFUSED TO FIX IT. I'VE BEEN IN CONTACT WITH VW CUSTOMER CARE AND MY LOCAL DEALER, BOTH TOLD ME THAT ONCE THE RECALL IS CLOSED ON MY VEHICLE THAT THERE IS NOTHING THEY'LL DO. THEY WANTED ME TO TOW MY CAR TO THE DEALERSHIP AND PAY $135 FOR A DIAGNOSTIC UNTIL I SHOWED THEM A VIDEO OF THE FUEL LINE UNDER PRESSURE SPRAYING EVERYWHERE.

NHTSA ID

11012185

Incident

Aug 1, 2017

Mileage

240,000 mi

MY CAR IS A 2001 MODEL, AND I'D LIKE TO KNOW IF IT HAS TAKATA AIRBAGS IN IT, EVEN IF IT ISN'T COVERED BY THE RECALL. DEALER DOESN'T KNOW IF THE AIRBAGS ARE TAKATA OR NOT. CAN YOU GIVE ME THIS INFORMATION?? I HOPE SO, OTHERWISE I DON'T KNOW HOW TO FIND OUT. THANKS [XXX] *DL INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*JB

NHTSA ID

10955699

Incident

Feb 20, 2017

ABS CONTROL MODULE FAULT

NHTSA ID

10908805

Incident

Sep 22, 2016

Mileage

172,000 mi

AS MY SON GOT ON THE HIGHWAY THE TRANSMISSION FELT LIKE IT WAS SLIPPING AND JERKING TO THEN CATCH BACK UP TO THE ORIGINAL SPEED I WAS GOING. WHEN HE PUT HIS FOOT ON THE GAS PEDAL THE CAR WOULD STRUGGLE TO GO, 5 SECONDS LATER IT WOULD GET UP TO SPEED BUT THEN SLOW BACK DOWN. AT A STOPLIGHT THE CAR WOULD SHAKE ROUGHLY AND IDLE REALLY HIGH, THEN HE SAW THE FRONT OF THE HOOD START TO SMOKE AND I REALIZED THERE WAS A PROBLEM.

NHTSA ID

10865850

Incident

May 19, 2016

Mileage

132,273 mi

VWOFA HAVE NOT TAKEN STEPS NECESSARY TO FACILITATE THIS FIRE HAZARD RECALL!

NHTSA ID

10806596

Incident

Feb 16, 2015

Mileage

90,000 mi

TL* THE CONTACT OWNS A 2001 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHILE DRIVING AT UNKNOWN SPEEDS, THE TRANSMISSION WOULD SLIP AND THEN THE VEHICLE STALLED. THE ENGINE CONTINUED TO RUN, BUT THE VEHICLE WOULD NOT MOVE. THE VEHICLE WAS TAKEN TO A DEALER AND IT WAS DETERMINED THAT THE TEETH ON THE GEARS OF THE TRANSMISSION HAD FRACTURED AND THE ENTIRE TRANSMISSION NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 160,000. UPDATED 8/19/15*CN THE CONSUMER STATED THERE WAS A RECALL FOR THE SAME MAKE, MODEL, AND YEAR BUT, THE CONSUMER'S VIN WAS NOT INCLUDED. UPDATED 9/30/2015*JS

NHTSA ID

10717045

Incident

May 15, 2015

Mileage

160,000 mi

SO I GOT REAR ENDED AT THE OTHER PARTY'S FAULT AT HIGH SPEED WHILE I WAS AT A STOP SIGN AND THEY NEGLECTED TO STOP PUSHING ME INTO AN INTERSECTION FULL OF TRAFFIC...NO AIRBAGS DEPLOYED..AND SINCE MY HEATER DOESN'T WORK BUT PASSENGER SEAT HEAT BURNED MY 12 YEAR OLD DAUGHTERS BUTT...ANYONE HELP? I JUST WANT HEAT FOR MY BABIES..BELOW ZERO HERE :( THANK YOU!! [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10658597

Incident

Nov 10, 2014

Mileage

180,220 mi

I WAS DRIVING ON I-95 AT APPROX. 78 MPH WHEN THE CAR SUDDENLY SAYS STOP! BRAKE FAILURE! SEE VOLKSWAGEN SERVICE. IN MY RESEARCH ON THE ISSUE, I'VE FOUND THIS HAPPENS ON ALMOST ALL 1998-2001 VW PASSATS AND AUDI A-4S. THIS NEEDS TO BE ADDRESSED. *TR

NHTSA ID

10611366

Incident

Jun 20, 2014

Mileage

104,435 mi

I WAS DRIVING AND I PULLED INTO MY PARKING LOT AND MY ENGINE CAUGHT ON FIRE. I PUT IT OUT WITH SNOW THANK GOD OR IT WOULD HAVE BEEN A LOT WORSE. I ALWAYS HAVE COOLANT AND OIL AND I CHECKED IT A LOT CAUSE OF THE FREEZING WEATHER WE HAVE HAD RECENTLY HAD -30 FOR QUITE AWHILE. I CALLED VW CUSTOMER CARE AND THEY WERE VERY WORRIED ABOUT MY SAFETY AT 1ST THEN THEY HAD A PRODUCT SOMETHING GUY CALL ME AFTER SEE THE PICTURE I SENT THEM. I UNDERSTAND THEY HAVE PEOPLE ALWAYS LOOKING FOR A QUICK ESCAPE GOAT BUT THIS WAS A FIRE IT COULD HAVE BEEN SO MUCH WORSE IF THERE WAS NOT SNOW NEAR BY. I WANT MY CAR FIXED BUT I AM MORE WORRIED ABOUT THE NEXT PERSON THIS COULD HAPPEN TOO. I SHOULD TELL YOU AFTER ASK HIM IF HE JUST WANTED TO FIND THE REASON BEHIND IT HE SAID NO. PERSONALLY A CAR FIRE IS NOT A NORMAL THING. *TR

NHTSA ID

10564966

Incident

Feb 18, 2014

Mileage

101,000 mi

I NOTICE THAT FUEL IS LEAKING FROM MY VW PASSAT 2001'S FUEL TANK. I FILL OUT THIS COMPLAINT IN ORDER TO SEEK A HELP FROM AUTHORITIES ON THESE MATTERS AND ALSO KNOWING IF MY ISSUES CAN BE HANDLED BY VOLKSWAGEN AMERICA. *TR

NHTSA ID

10560737

Incident

Jan 21, 2014

Mileage

175,000 mi

ABS MODULE IS OUT, CAN'T GET EMISSIONS PASSED UNLESS I PAY OVER 600 DOLLARS. ALSO I DON'T HAVE ABS, CAN'T SEE IF MY CHECK ENGINE LIGHT MEANS ANYTHING BECAUSE I'M TOLD IT ALL GETS RE ROUTED THOROUGH THE ABS MODULE AND CAN'T GET PAST THAT PROBLEM. *TR

NHTSA ID

10548346

Incident

Oct 11, 2013

Mileage

152,000 mi

2001 VW PASSAT STICKING GAS PEDAL COMMENTS: THIS HAS HAPPENED TO ME RECENTLY 2 TIMES....GAS PEDAL STUCK TO FLOOR, REDLINE, ALMOST CRASHED. RESEARCHING I FOUND IT TO BE A COMMON PROBLEM. VW SHOULD BE HELD ACCOUNTABLE... THIS IS A DANGEROUS SITUATION! SHOULD I STOP DRIVING IT??? MORE ACCOUNTS AT: HTTP://WWW.PASSATWORLD.COM/FORUMS/42-VOLKSWAGEN-PASSAT-B5-DISCUSSION/236513-ANYONE-ELSE'S-GAS-PEDAL-GET-STUCK.HTML. *TR

NHTSA ID

10522521

Incident

Apr 1, 2013

Mileage

80,000 mi

2001 PASSAT 1.8T MANUAL TRANSMISSION DEVELOPED FUEL LEAK ON THE FIREWALL ATTACHMENT AREA, ON THE MIDDLE LINE DIRECTLY OVER CATALYTIC CONVERTER; CAR COMPARTMENT SMELLED HEAVILY OF GASOLINE. STOPPING CAR AND INSPECTING THE FUEL LINE SHOWED THE CRACK. THIS IS A VERY SERIOUS ISSUE AND WAS VERY LUCKY IN THIS CASE NOT TO HAVE CAR ON FIRE. PLEASE INVESTIGATE THIS AS THERE SEEMS TO BE RELATED RECALLS FROM VW ON THIS ISSUE. I'M SCARED TO HAVE KIDS ON BOARD THE PASSAT. *TR

NHTSA ID

10512737

Incident

May 18, 2013

Mileage

176,000 mi

I WAS STOPPED AT A STOP LIGHT THAT WAS OUT OF ORDER. THE DRIVER OF THE SUV IN FRONT OF ME TOOK HER FOOT OFF THE BRAKE AND I ASSUMED SHE WAS GOING TO SUBSEQUENTLY DEPRESS THE ACCELERATOR, SO I INSTINCTIVELY PUT MY FOOT ON THE ACCELERATOR TO EASE FORWARD. UNFORTUNATELY, I MISCALCULATED AS THE DRIVER IN FRONT OF ME DID NOT MOVE FORWARD. AS A RESULT OF MY ACTIONS, I REAR-ENDED THE DRIVER IN FRONT OF ME. I WAS GOING BETWEEN 5-10 MPH. MY CAR SUSTAINED ABOUT 90% OF THE DAMAGE. MY COMPLAINT IS REGARDING THE DEPLOYMENT OR LACK THEREOF OF THE AIRBAGS. THEY NEVER DEPLOYED. MAYBE I WAS WRONG TO ASSUME THAT THEY WOULD DEPLOY ON SUCH A LOW SPEED. PLEASE ADVISE AS THE IMPACT FROM THE ACCIDENT WAS RATHER STRONG. *TR

NHTSA ID

10509501

Incident

Apr 19, 2013

Mileage

134,400 mi

SENDING THIS E-MAIL TO COMPLAIN ABOUT THE ABS MODULE ON MY 2001 VOLKSWAGEN PASSAT THEY ARE NO REASON WHY IT SHOULD BE OUT , I BELIEVE ITS A DEFECTIVE PART, SHOULD LAST LONGER OTHER PEOPLE I TALK WITH SAY THEY HAVE BEEN THRU THE SAME PROBLEM. I BELIEVE VOLKSWAGEN NEED TO HAVE A RECALL ON THIS ABS MODULE. *TR

NHTSA ID

10504325

Incident

Mar 3, 2013

MY CAR HAS BEEN LEAKING COOLANT. I TOOK IT TO A SHOP AND WAS INFORMED THAT THE HEATER CORE WAS BAD. I HAVE HAD TO REPLACE THE INSIDE COMPUTER ALREADY AND PROBABLY ALL THE CARPET SINCE THE WATER HAS BEEN LEAKING INTO THE CAR. I SUFFER FROM ASTHMA AND CAN NO LONGER DRIVE THIS CAR SINCE IT SMELLS LIKE COOLANT/MOLD AND NOT TO MENTION WATER LEAKING ON MY FOOT AS I DRIVE (VERY UNSAFE SINCE THE PEDAL GETS SLIPPERY.) I HAVE READ ONLINE ON MANY SITES THAT THERE WAS A RECALL REGARDING THIS MATTER AND THE OWNERS WERE NEVER NOTIFIED. I NEED THIS FIXED BEFORE SOMETHING BAD HAPPENS; EITHER I GET INTO AN ACCIDENT OR I END UP IN THE HOSPITAL. THANK YOU VERY MUCH FOR GETTING BACK TO ME AND GETTING THIS MATTER FIXED PROMPTLY. *TR

NHTSA ID

10500670

Incident

Aug 10, 2012

Mileage

155,000 mi

CAR HAD BEEN SITTING ALL DAY DROVE IT ONCE CAUGHT FIRE AROUND 4AM IN THE MORNING CAR TOTAL ALOT BURN BAD IN THE FRONT. I HAD NOTICE THAT SOME FEATURES WERE NOT WORKING BUT I DID NOT ATTRIBUTE IT TO A ELECTRICAL PROBLEM ACCORDING TO THE FIRE DEPT WHO CAME TO PUT THE BLAZE OUT. *TR

NHTSA ID

10485005

Incident

Nov 16, 2012

Mileage

1,570,000 mi

ANTI-LOCK BRAKING SYSTEM (ABS) MODULE FAILURE WHICH CAUSES PERMANENT LOSS OF ANTI-LOCK BRAKING SYSTEM. *TR

NHTSA ID

10470614

Incident

Jul 10, 2012

Mileage

126,000 mi

TL* THE CONTACT OWNS A 2001 VOLKSWAGEN PASSAT. THE CONTACT NOTICED THAT THE FUEL GAUGE INDICATED THAT THE VEHICLE HAD MORE FUEL THAN WHAT WAS ACTUALLY IN THE TANK. THE VEHICLE WAS TAKEN TO A REPAIR SHOP WHERE THE MECHANIC FOUND THE FAILURE IN THE FUEL TANK LEVEL SENDING UNITS. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 01V157000 (FUEL SYSTEM, GASOLINE: STORAGE: TANK ASSEMBLY) BUT WAS ADVISED BY THE MANUFACTURER THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE CURRENT AND FAILURE MILEAGE WAS 78,370.

NHTSA ID

10463542

Incident

Jun 23, 2012

Mileage

78,370 mi