2001 Volkswagen Passat Steering Problems

THE PASSAT HAS BEEN A WELL MAINTAINED FAMILY WAGON. THE CAR HAS ALWAYS BEEN GARAGED AND HAS MOSTLY EASY HIGHWAY MILES. MY WIFE WAS DRIVING WITH MY DAUGHTER ON A RAINY EVENING. AFTER MAKING A RIGHT HAND TURN, THE STEERING WHEEL WOULD NOT TURN BACK TO THE LEFT PAST CENTERED. SHE STOPPED THE DISABLED CAR ON THE RIGHT SHOULDER AND CALLED ME AND THE TOW TRUCK. WHEN I ARRIVED I CONFIRMED HER ANALYSIS. THE TOW DRIVER HAD NEVER SEEN ANYTHING LIKE IT. THE VW DEALER CALLED THE NEXT DAY AND INDICATED THAT THE STEERING RACK HAD FAILED. THEY ALSO REPLACED UPPER ARMS AND THE RIGHT AXLE. I SPENT $1950 FOR THE REPAIR AND ANOTHER $200 FOR THE RACK, IF NEEDED FOR ANALYSIS BY NHTSA OR OTHERS. IF THIS FAILURE HAD HAPPENED AT A DIFFERENT PLACE OR AT HIGHER SPEED IT COULD HAVE RESULTED IN A CATASTROPHE. *TR

NHTSA ID

10440898

Incident

Dec 7, 2011

Mileage

153,340 mi

TL* THE CONTACT OWNS A 2001 VOLKSWAGEN PASSAT. THE CONTACT WAS DRIVING AT A RELATIVELY LOW SPEED WHEN THE STEERING WHEEL LOCKED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY FOR DIAGNOSTIC TESTING. THE CONTACT WAS ADVISED BY THE MECHANIC THAT THE RACK AND PINION WAS DEFECTIVE. THE CONTACT STATED THE TIE RODS WERE PREVIOUSLY REPLACED DUE TO LOOSE STEERING. THE MANUFACTURER ADVISED THEY WOULD ASSIST WITH TEN PERCENT OF THE TOTAL COST OF REPAIRS. THE VEHICLE WAS REPAIRED BY THE DEALER. THE FAILURE MILEAGE WAS 109,000 AND THE CURRENT MILEAGE WAS 113,747.

NHTSA ID

10346045

Incident

Oct 21, 2009

Mileage

109,000 mi

I AND THOUSANDS OF OTHER VW PASSAT OWNERS WISH FOR VW OF NORTH AMERICA TO ISSUE A RECALL ON THE TIE RODS, CONTROL ARMS, BALL JOINTS, ETC. (THE WHOLE FRONT SUSPENSION OF PASSATS) DUE TO THE OBVIOUS FAILURE OF THESE SYSTEMS. I PERSONALLY KNOW OF A MECHANIC IN STOUGHTON, WI WHO HAS REPLACED THIS SYSTEM ON 3 PASSATS THIS MONTH ALONE AND MY CAR IS NEXT. WE'RE TALKING TO THE TUNE OF $1800.00-$2000.00 FOR PARTS ALONE. THIS IS VERY EXPENSIVE AND ONE IS COMPLETELY HANDCUFFED BECAUSE ONE'S CAR IS NOT SAFE TO DRIVE IF THIS ISSUE IS NEGLECTED. FURTHER, WHEN ONE CONTACTS A LOCAL VW DEALERSHIP (ZIMBRICK VW OF MADISON, WI) AND INQUIRES ABOUT THIS KIT TO REBUILD THE FRONT END, THE PARTS MANAGER ADMITS THAT THEY KEEP MANY OF THESE KITS IN STOCK BECAUSE THEY ARE VERY AWARE OF THIS ISSUE. SO, WHY IS VW OF NORTH AMERICAN IGNORING THE OBVIOUS? COULD IT BE THAT THEY WOULD BE OUT A HANDSOME AMOUNT OF MONEY? BETTER TO LET THE CONSUMER TAKE THE BRUNT OF THIS ISSUE AND HOPE IT EVENTUALLY GOES AWAY? PLEASE HELP!!! *TR

NHTSA ID

10209303

Incident

Nov 16, 2007

TOOK CAR FOR STATE INSPECTION. MECHANIC FOUND BOTH LEFT AN RIGHT UPPER BALL JOINTS AND BOTH TIE RODS DEFECTIVE AT 53,000 MILES. *AK

NHTSA ID

10186231

Incident

Mar 21, 2007

Mileage

53,000 mi

ENGINE SLUDGE IN ENGINE LEADING TO FAILURE OF THE OIL PUMP AND THE TURBO. IN ADDITION, ALSO HAD TO HAVE THE FRONT CONTROL ARMS ,AND TIE-RODS REPLACED , AND EVEN NOW THERE WERE STILL PROBLEMS WITH THE FRONT SUSPENSION. I HAVE RESEARCHED AND FOUND THESE WERE SIMILAR PROBLEMS WITH MANY PASSAT OWNERS. I STILL RECALL THE MAJOR ISSUE / RECALL OVER THE IGNITION COIL FAILURES AND HOW VW OF AMERICA DENIED THERE EVER WAS A PROBLEM. THE ENTIRE CAR SHOULD BE DECLARED A LEMON !!!! THE OIL PUMP FAILURE LEADING TO FAILURES OF THE TURBO, AND SEIZURE OF THE ENGINE SHOULD BE PROOF ENOUGH THAT THIS CAR HAS TOO MANY MAJOR PROBLEMS AND SHOULD BE RECALLED . *AK

NHTSA ID

10186084

Incident

Mar 22, 2007

Mileage

100,000 mi

TL*- THE CONTACT TOOK THE 2001 VOLKSWAGEN PASSAT TO A DEALER, AND THEY STATED THAT THE VEHICLE WAS UNSAFE TO DRIVE. ALL 8 TIE RODS AND THE ONE LINK ARM WERE SHOWING EXCESSIVE WEAR. THE DEALER AND THE MANUFACTURER STATED THAT THE VEHICLE WAS OUT OF WARRANTY SO THE REPAIR WOULD BE AT CONTACTS EXPENSE. THE CURRENT AND FAILURE MILEAGE WERE BOTH 79200.*AK THE RIGHT OUTER CV BOOT WAS TORN AND THE LEFT OUTER TIE ROD END WAS WORN. THE ABS CONTROL MODULE WAS REPLACED. UPDATED 03/30/07. *JB

NHTSA ID

10184566

Incident

Jan 29, 2007

Mileage

79,200 mi

I OWN 2001 VW PASSAT WITH 43200 MILES. THIS PAST YEAR I NOTICED FAILURES OF OUTER CV JOINT BOOT BOTH SIDES AND RUBBER DUST BOOTS ON ALL BALL JOINTS WHICH CAUSES A DIRT AND WATER TO DESTROY BALL JOINTS. I CHANGED OUTER CV JOIN BOOT BOTH SIDES AND ONE UPPER CONTROL ARM BALL JOINT AND OTHERS WILL FAIL SOON. *JB

NHTSA ID

10138154

Incident

Sep 21, 2005

Mileage

40,000 mi

DT: ON AUGUST 25 ONWER WAS UPSET BECAUSE HE HAD TO REPLACE TIE RODS, AND HAD THE VEHICLE ALIGNED. HE SAID THE TIE RODS HAD TO BE REPLACED BECUASE THEY WERE FROZEN. THE REPAIR SHOP REPLACED THE TIE RODS.*AK *NM

NHTSA ID

10134298

Incident

Aug 25, 2005

THE STEERING WHEEL WAS LOOSE. DEALER HAD TO TIGHTEN THE RACK AND PINION IN ORDER TO ALLEVIATE THE PROBLEM.*AK...MECHANIC REPORTED THAT PART WAS ALMOST OUT ON ONE SIDE, AND HAD IT COME OUT ABILITY TO STEER WOULD HAVE BEEN LOST. *AK

NHTSA ID

10109260

Incident

Jan 21, 2005

Mileage

32,000 mi

AT 13,000 MILES, STEERING COLUMN BEGAN TO "CLUNK" WHEN TURNING THE WHEEL. NEW STEERING COLUMN INSTALLED UNDER WARRANTY. AT 27,000 MILES, SAME PROBLEM RETURNED. INFORMED BY A MECHANIC THAT ISSUE MAY BE DUE TO DESIGN OF COLUMN UNIVERSAL JOINT WHEN PASSING THROUGH FIREWALL (SHARP ANGLE LEADS TO MORE STRESS AND LIKELY FAILURE OVER TIME.) WHEN WARRANTY EXPIRES, THIS WILL BECOME MY ISSUE.*AK

NHTSA ID

10098198

Incident

Oct 10, 2004

Mileage

13,000 mi

UPPER CONTROL ARMS ON BOTH SIDES ARE WORN OUT. TIE RODS ARE WORN OUT ON BOTH SIDES. CATALYTIC CONVERTERS NEEDED REPLACED. I PAID FOR THE TIE RODS, WARRANTY COVERED CONVERTERS, AND I HAVE NOT HAD THE UPPER CONTROL ARMS REPLACED. OIL LEAKS ON ENGINE. INTERIOR LIGHTS DO NOT ACTIVATE WHEN DRIVERS DOOR IS OPENED.

NHTSA ID

10058454

Incident

Oct 15, 2003

Mileage

59,100 mi

BOLTS HOLDING STEERING RACK TO FRAME KEEP COMING LOOSE. THIS HAS HAPPENED 3 TIMES WITH THE FIRST AT ABOUT 18K MILES.*JB

NHTSA ID

762203

Incident

May 20, 2002

CONSUMER IS EXPERIENCING PROBLEMS WITH THE LOWER WORM SHAFT IN THE STEERING. *JG

NHTSA ID

746847

Incident

Apr 17, 2001