2011 BMW 328I Electrical Problems

The power cable to my battery needed to be replaced from the front to the rear. This seems like the recall NHTSA CAMPAIGN ID: 13V044000 but my car was not listed for it.

NHTSA ID

11713877

Incident

Jan 3, 2020

Footwell module (FRM) module went out after negative battery disconnect to change fuse. Module being inoperable is causing windows to not operate,interior lighting not working, headlights stay dim (not good for nightime driving), blinkers inoperable (not good for driving with windows not working- no arm signals), dash light also inoperable.

NHTSA ID

11699451

Incident

Nov 3, 2025

The contact owns a 2011 BMW 328I. The contact stated that while attempting to start the vehicle, the electrical system failed to function as intended. The contact stated there was no warning light illuminated. The vehicle eventually started; however, the failure occurred. The vehicle was not diagnosed or repaired. The contact stated that the failure persisted. The manufacturer had been informed of the failure and transferred the contact to the NHTSA Hotline. The contact researched online and related the failure to NHTSA Campaign Number: 13V044000 (Electrical System); however, the VIN was not included. The failure mileage was approximately 116,000.

NHTSA ID

11662192

Incident

Mar 20, 2025

Mileage

116,000 mi

Previously reported on February 20, 2024. NHTSA #1157301 RDC failure caused complete loss of all dashboard functions except the radio - loss of lights/turn signals/ speedometer/ tachometer/ HVAC etc. Received a call from BMW customer service today February 26,2024 at 4:38 EST duration 17 minutes. BMW informed me the conversation was recorded. I request that NHTSA obtain the transcript for that telephone call. This note will be sent to BMW with request to send a transcript of the call to NHTSA. BMW Custom Relations representative was polite. Her purpose for the call - "to inform me that BMW is cooperating with NHTSA".The person assigned had no useful information nor could she obtain any information to answer questions. Though BMW documents all reported parts failures and complications, she had no ability to provide information relevant to the RDC module problems.The call was useless from an owners viewpoint. It did not improve Customer Relations. The VANOS recall was also discussed.NHTSA: #23V-707 Recall notification October 2023 BMW has not provided a date when the repair will be available. Vanos Bolt problems were identified for my vehicle in 2014!!! A 10 year warranty without mileage limitation was created but BMW owners were not notified - unless engine failure occurred and the car presented to a BMW dealership. I am more than frustrated that repairs have not been initiated. The local BMW dealership would like to repair the car but cannot proceed without corporate approval. Parts are indeed available locally. BMW has been aware of the problems for a DECADE. Furthermore, the valve cover gasket has been replaced twice since 2014. The VANOS bolts were never inspected. The valve cover was replaced last at 149,000 miles. A mechanic advised replacing the VANOS bolts but did not inspect them. Cost of repair $1500. I declined. Abysmal customer service!

NHTSA ID

11574109

Incident

Feb 20, 2024

Tire pressure yellow warning light on. RDC module ordered but repair not completed. After starting the car at a gas station, multiple warning lights appeared in red including "car on a raised lift in red" which signifies car is to be taken directly for service. Drove to local mechanic one mile away. While observing the car with engine running at idle, ALL dashboard lights and functions stopped: No speedometer, No tachometer, No warning lights, No turn signals, No headlights, RDC module subsequently replaced with resolution of the problem. Opening the old RDC module demonstrated significant green corrosion - likely occurred over a long period of time. IF the loss of all dashboard function had occurred while driving, it would have presented very dangerous safety issues. Situation reviewed with local BMW dealership and BMW corporate customer relations. No recalls or warnings have been issued. Expressed my concerns in detail. This is a potentially dangerous problem for the BMW E90 models. The RDC module is located in the passenger rear wheel well and repeatedly exposed to wet/ snow/ slush conditions. This is a dangerous location outside the vehicle for the RDC module. The Tire pressure monitor system is a non-critical function. Repair of the RDC module is considered optional - yellow warning light. This event demonstrates that there is a serious risk when the RDC module is not functioning properly. BMW should make owners aware and offer replacement before dangerous events occur.

NHTSA ID

11573011

Incident

Feb 16, 2024

Received letter of recal Dec 2023 For recall Campaign No 23V-707 Is been almost two months and BMW not communicating with me to find solution letter said remedi unavailable Engine bolts may over time loosen and eventually break how they want public to drive like that this should be a priority is dangerous

NHTSA ID

11571133

Incident

Dec 1, 2023

The electrical keeps shutting off and own after hitting speed bumps. It shuts off all power on hvac windows seats and the odometer. I have heard this same issue with many owners

NHTSA ID

11563996

Incident

Jan 1, 2024

While driving at city speed limit the headlights started flicking on-off very difficult to see in the dark. I pulled over to the side of the road for safety but now realized the turn signals not working and also the hazard lights are not working either. I was in a very dangerous situation sitting on the side of the road without any warning light on. Not only for mine safety but also dangerous for other drivers passing by without seen my car in the dark. Its due to well known BMW FOOTWELL MODULE that has high failure incidents rate but BMW refused not to do a recall. Since this a safety issue NHTSA should request BMW to do a recall instead of just extended the warranty to 10/150K miles which my car is not qualify for. I've contacted BMW customer care but they refused to offer any assistance. I feel that BMW has deserted their customer and leaving a high cost burden on their customers although failure/flaw was directly from BMW.

NHTSA ID

11557086

Incident

Nov 23, 2023

The Battery died and had to jump start to take it for a replacement. Once the car started, there was warning related to the lighting system malfunction. I couldnt open the windows and the lights were not functional. Even after the battery was replaced, the functions were not restored. Dealer is recommending replacement of FRM module costing $1250. I understand there was a recall/repair offered for 10 years which i just missed by a year. Looks like it is a well known issue and caused by a simple battery issue causing huge safety issues. I had to drive the car to the dealer without any lights/indicator with tremendous risks. It is an irony that they will fix this issue for only 10 years when there is a clear manufacturing defect and safety issue. Would like to get any help on this issue.

NHTSA ID

11538031

Incident

Aug 11, 2023

The contact owns a 2011 BMW 328I. The contact stated that upon taking the vehicle into the dealer for service, she was informed that the footwell control module had failed and needed to be replaced. The battery warning light was illuminated. The vehicle was not repaired. After investigating the failure, the contact related the failure to TSB: SI-B01-20-16, but the vehicle was not included. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 215,000.

NHTSA ID

11534902

Incident

Jul 26, 2023

Mileage

215,000 mi

The engine made noise and then turned off. Would not restart. BMW dealer diagnosed the problem as a failed exhaust camshaft Vanos unit. BMW refuses to repair it even though it the engine, model and year fit the Vanos recall. This is the second BMW vehicle I have owned that failed for this reason, but was outside the covered claimed VIN numbers. I am requesting that you investigate this as wider range of vehicles, fitting the recall description exactly, but not covered, are failing...this vehicle is a 2011 with only 62,000 miles. I would also like a list of the VIN numbers currently affected.

NHTSA ID

11517685

Incident

Apr 7, 2023

The contact owns a 2011 BMW 328I. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The contact also stated that the vehicle stalled while starting during colder weather. The contact received notification of NHTSA Campaign Number: 17V676000 (Electrical System) and 22V119000 (Engine and Engine Cooling). The contact made a local dealer aware of the failure and the recall notification; however, the contact was directed to contact the manufacturer for further assistance with towing the vehicle or driving out of state to be serviced. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the issue but was unable to provide further assistance. The approximate failure mileage was 80,000.

NHTSA ID

11510609

Incident

Feb 3, 2023

Mileage

80,000 mi

I received the safety recall from BMW April 2022. I still have not heard from the local BMW dealer about a remedy. It's almost a year. My son lives in California and also has a 2011 BMW . His vehicle is also covered under the safety recall, and he has not heard anything about a remedy from a BMW dealer in Los Angeles. In fact he tells me his heater blower was not working and he took it into the dealer in early January 2023. They did "some repairs," never mentioned the recall, and when he went to drive away the heater DID catch fire and he was told not to use it by the dealer! Please advise how you are going to get BMW to comply with this remedy. Thank you,

NHTSA ID

11503062

Incident

Jan 13, 2022

Passenger door handle with comfort access shorted out and nearly caught fire. I was trying to get my comfort access working again after it suddenly stopped and I discovered that the fuse (#61) was blown. A couple minutes after replacing the fuse, the door handle let up a large plume of smoke and made a popping sound. I immediately powered down the car and removed the fuse and the smoking stopped. The door handle was hot to the touch and the rubber gaskets on the door handle appear to have melted (see attached photo). Upon further research, this appears to be a common problem with these cars.

NHTSA ID

11501966

Incident

Jan 16, 2023

This car has a heater problem with the PCV that causes the car to not run in cold weather. The PCV fails intermittently and the car will not idle or run in cold weather. BMW issued this recall in March but it is not November and they have offered no fix for this. It is a safety issue and it's also affecting how the car runs. How could we be 8 months into this without a fix?

NHTSA ID

11494775

Incident

Nov 23, 2022

The contact owns a 2011 BMW 328I. The contact stated while attempting to start the vehicle, the battery had failed. The contact stated no warning light was illuminated. The contact had the vehicle towed to a local dealer, where it was diagnosed and determined that the battery, battery cable, and fuse box needed to be replaced. The vehicle had not been repaired. The manufacturer had been informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 19V472000 (Electrical System) however, the VIN was not included. The failure mileage was approximately 125,000.

NHTSA ID

11485195

Incident

Sep 10, 2022

Mileage

125,000 mi

The contact's son owns a 2011 BMW 328I. The contact stated that the vehicle was taken to an unknown dealer for battery replacement; however, 2-3 weeks later while her son was driving at an undisclosed speed, several unknown warning lights illuminated. Additionally, the turn signals failed to operate as needed. The vehicle was taken to a second dealer and the vehicle failed to restart. The dealer diagnosed that the footwell module had failed. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was approximately 104,000.

NHTSA ID

11484662

Incident

Aug 24, 2022

Mileage

104,000 mi

There is a safety recall on my car. This recall involves an engine component known as the Positive Crankcase Ventilation (PCV) valve heater. The PCV valve heater may not have been produced to specifications which could lead to a short circuit. BMW DOES NOT HAVE AN AVAILABLE REMEDY FOR THIS RECALL AND DOES NOT HAVE ANY TIMELINE FOR FIXING IT.

NHTSA ID

11482507

Incident

Sep 1, 2022

Unable to unlock/lock doors on car (obviously very worrisome), unable to use turn signals, no interior lighting controls or functionality. Unable to control headlights, they still do turn on but I cannot control them. Cannot adjust any mirrors electronically. Some speedometer lighting affect or but the dials do still work, cannot see all buttons inside interior due to electrical issue. Problem: Footwell Control Module (FRM) needs replacement costing around $1300 to do minimum from dealer. This module controls all of the functions above and has gone bad. This FRM module is hidden and not easily gotten to tells me something like a fuse needs to be installed just in case a power surge from the car happens so the car does not break this very expensive equipment. Looked into it online and apparently this happens very often and one guy had to have his replaced twice. This is an obvious issue that will require a remedy.

NHTSA ID

11478189

Incident

Aug 1, 2022

Prior to this incident with my car i was having alot of power issues,the car was giving me alot of issues starting up or after being parked it sometimes wouldnt want to turn on i took my battery to get checked and battery had no issues and i continued to start to have electrical issues with my turning signals my lightning and windows stopped working until January 7 as i was driving my car just began to slowly slow down and completely stopped working that not even a jump start would help it turn on and it lost complete power and function and 2 months after i was contacted about its most recent recall and prior to that i also remember that my coolant wasnt lasting me as usual After being affected by the pandemic and loosing my job while being pregnant and finding out about my cars recall i was afraid of my safety and my kids safety that i havent felt safe to take to a mechanic out of fear that our lifes can be danger if the vehicle catches on fire the way the recall stated that it could happen and its brought major stress and trouble since nothing has been done because i havent had a vechile since

NHTSA ID

11477610

Incident

Jan 7, 2022

Unknown my car has been smoking g very bad lately idk if it is cause but this but this recall has never been fixed on my car would like to get looked at

NHTSA ID

11476767

Incident

Jul 1, 2022

Vehicle started smelling like smoke and making loud screeching noise in February. Took car to BMW certified shop to be fixed, put out thousands of dollars to have valve replaced, check engine light will still not turn off. In April I received a letter from BMW about the a recall on the PVC Valve. It is now July and they just diagnosed a remedy. Called around to every local dealership, they cannot fix it due to lack of parts. It has been over 5 months without having a car. BMW North America is giving me the run around and dealerships keep referring me to call BMW North America. Also have told me that they might not refund me for this since the problem wasn’t fixed even though BMW is at fault.

NHTSA ID

11472615

Incident

Feb 21, 2022

The contact owns a 2011 BMW 328i. The contact stated that the vehicle was parked and upon returning to the vehicle, he noticed that all four windows had rolled down independently. The contact stated that the failure reoccurred. There were no warning lights illuminated. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to NHTSA. The failure mileage was approximately 90,000.

NHTSA ID

11463911

Incident

May 9, 2021

Mileage

90,000 mi

My car was brought in to the BMW dealership for knocking noises, a fire smell, and shaking. I was told my car could not be repaired due to engine failure.l was informed that replacing the engine would cost me more than the vehicle is worth. He recommended l sell it for parts. Currently there are no lights/ indicators present on my dash board indicating that something is even wrong . l did not receive any warnings before the shaking and /or during the knocking . On the other hand; I have made multiple complaints to my mechanic about smelling fire or burnt rubber for the past six months and he thought it was coming from the radiator and he replaced it.. The smell did not improve .. he was still in the process of guessing what it could be . I guess we know now. The safety of my family has been at risk for months, knowing that burnt rubber smell could have evolved into something major at anytime . My life was in danger when the car began shaking while driving on the highway on my way to work . The car has been parked for a week now due to me not knowing what to do with a dead 10 years young vehicle. I have not called the police and my insurance company states they don’t cover mechanical issues. My car has only been viewed by a dealership and my mechanic shop. To make my situation worse , I am currently working overseas in Germany on orders and l don’t know what to do with this car. I don’t live a lifestyle where I can afford to purchase a vehicle with the intentions of it lasting 10 years or less . My car is definitely available for inspection upon request.. if someone could advise me on whom to contact , that would be great . The set back this has caused me is unrealistic. If there is anything I can do as a costumer please let me know .l am a healthcare worker .l am very reliant upon my vehicle . I need my car.

NHTSA ID

11461650

Incident

Apr 14, 2022

What component or system failed or malfunctioned, and is it available for inspection upon request? Footwell module. Computer system that controls turn signals, headlights, highbeams, windows, door locks etc. Yes it is available for inspection. How was your safety or the safety of others put at risk? I can't use my turn signals, highbeams, headlights, Windows. I can't signal my cars lane changes or see clearly at night. I can't roll the windows down or up which creates a unsafe hazard. My child is able to climb out of the window in the back seat while I'm driving. I have zero control over the windows. I can't determine if my child's door is open or closed when the car is in motion. My car doors no longer lock at all. My child can open up the door at any moment that the car is in motion. I'm unable to see at night without my highbeams. I'm now forced to drive with reduced visibility. Has the problem been reproduced or confirmed by a dealer or independent service center? Both by a dealership and independent shop. There have been reconcurring warrantee coverages offered but no recalls despite the clear determinant to safety. Common usage of the vehicle at this point in time is a safety concern of all surrounding users and transportation vehicles. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The manufacturer has inspected this module concern. I'm very sure that there have been accidents associated with this module malfunction. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? There are zero signs of this issue prior to it's failure. The failure had no warning.

NHTSA ID

11459157

Incident

Mar 28, 2022