2019 BMW 330I

The contact owned a 2019 BMW 330I. The contact stated that while the vehicle was parked at the residence in the driveway, there was an abnormal cracking sound coming from outside the residence. The contact checked and became aware that the vehicle was on fire. The vehicle was unoccupied at the time. The contact stated that the residential camera showed that the fire had started by the front driver's side tire. The Fire Department arrived at the residence and extinguished the fire. The residence and the vehicle were consumed by the fire. The vehicle was towed to a local tow yard. No injuries were sustained. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 110,000.

NHTSA ID

11752479

Incident

Mar 26, 2026

Mileage

110,000 mi

KAFAS Mid Camera has software malfunction, internal fault, system does not operate as designed. Takes down all driver assistance features. Module unable to accept new coding/programming. BMW service information - B66 20 19

NHTSA ID

11749521

Incident

Jul 10, 2026

Please update recall repair status to repaired for this VIN (dealer repair invoice attached)

NHTSA ID

11737293

Incident

May 11, 2026

The contact owns a 2019 BMW 330I. The contact received notification of NHTSA Campaign Number: 25V636000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted, but the vehicle had not been diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that while driving up to a red light, the vehicle became inoperable. The "Call Roadside Assistance", "Starter System Failure" and "Engine Could Not Start" messages were displayed. The vehicle was able to restart; however, upon arriving to the residence, the vehicle became inoperable. The failure mileage was 81,652.

NHTSA ID

11726631

Incident

Mar 22, 2026

Mileage

81,652 mi

Description of the Problem: •Component/system that failed: The engine starter, which is subject to an open recall issued September 23, 2025. The starter was not replaced during a service visit. The vehicle no longer exists due to the fire, but the VIN and service records are available for inspection. •Safety risk: The starter malfunction caused the vehicle to catch fire while parked, creating a serious safety risk to myself, my child, and others nearby. •Problem reproduction/confirmation: The fire and defect were confirmed by BMW’s inspection as originating from the starter irregularity tied to the recall. •Inspections: The vehicle was inspected by BMW North America’s engineering team after the fire, and insurance representatives confirmed the total loss. •Warning signs prior to failure: There were no warning lamps, messages, or symptoms indicating the starter defect before the fire. Additional context: The vehicle was serviced at an authorized BMW dealership on December 3, 2025. I was not informed of the recall, and the starter was not replaced. The vehicle caught fire on December 19, 2025, resulting in a total loss. While my insurance resolved the ACV, this incident was caused by BMW’s recall-related defect and procedural failure. I have escalated this matter to BMW North America and am requesting a resolution that restores me to a comparable position (replacement vehicle or financial support). Official confirmation: BMW North America confirmed in a confidential letter that the fire originated from the starter defect tied to the open recall. This letter is available for review upon request.

NHTSA ID

11720473

Incident

Dec 19, 2025

Vehicle shudders under acceleration no warning lights or errors . Changed transfer case oil and same problem continues. No recall from manufacturer for issu

NHTSA ID

11720158

Incident

Feb 24, 2026

See attached document for complaint.

NHTSA ID

11718904

Incident

Nov 10, 2025

I am reporting a premature failure of two critical engine components: the Heat Management Module (Coolant Pump/Thermostat assembly) and the Oil Filter Housing. Despite the vehicle's low mileage (40,000 miles), the Heat Management Module began leaking coolant, posing a significant risk of engine overheating and sudden loss of power while driving. Simultaneously, the Oil Filter Housing has developed a leak, allowing oil to seep onto the engine block and potentially onto the serpentine belt. Both failures represent a safety hazard: Coolant Leak: Risk of thermal engine damage and being stranded in traffic due to overheating. Oil Leak: Risk of oil contacting hot exhaust components (fire hazard) or causing the serpentine belt to slip/fail, resulting in a sudden loss of power steering and charging systems. These components appear to have failed due to manufacturing or material defects rather than standard wear and tear for a vehicle of this age and mileage

NHTSA ID

11718383

Incident

Feb 13, 2026

The EVAP systems purge (vent) valve limited warranty for defects in materials and / or workmanship has been extended to 15 years / 150,000 miles as determined from the original first in-service / delivery date.

The EVAP systems purge (vent) valve limited warranty for defects in materials or workmanship has been extended to 15 years / 150,000 miles as determined from the original in-service date.

The Radiator Grilles Lower Active Air Flap Assembly limited warranty for defects in materials and/or workmanship has been extended to 15 years / 150,000 miles as determined from the original first in-service / delivery date.

It was found that the rubber mounts of the wishbone or the tension strut were not correctly pressed in due to a manufacturing fault at the supplier's end. This can lead to an acoustic abnormality in the vehicle.

The Supplemental Restraint Systems (SRS) Front Passenger’s Seat Occupancy Capacitive Interior Sensor (CIS) Mat for defects in materials and/or workmanship that causes a false seat occupancy alert to occur has been extended to 10 years / 120,000 miles as determined from the vehicle's original in-service / first delivery date.

A vehicle listed above may arrive with a Check Control Message (CCM), and/or malfunction indicator lamp(MIL) illuminated. After carrying out the vehicle test, one or more of the stored faults indicate that the operation of the front bottomactive air flap is obstructed or blocked. Thoroughly inspect the front bottom air flap, when applicable, remove any contamination that is found caught inand between the bottom air flaps (aka “blinds”) and/or the housing.