2019 Honda Clarity Plug-In Hybrid

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

I was rear ended on the freeway that l caused my car to hit a guard rail, head on. I remember getting rear ended and then blacked out on hitting the guard rail. I then had chest pain. My driver's side airbags deployed with the driver's side front foot area airbags deploying. The airbags on the steering wheel did not deploy. There's a dash cam footage of this below that shows my car hitting head on with the guard rail at 31mph. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11752625

Incident

Jul 14, 2026

My 2019 Honda Clarity has had a hybrid battery failure that triggers “Check Engine” and “Power System” warnings, making the vehicle unsafe and unreliable to drive. I brought the car to Norm Reeves Honda Cerritos on 12/29/2025, and the battery—still under warranty—has been on backorder for over 6 months with no repair completed. The dealer repeatedly requested new diagnostic readings but has not fixed the issue. I have asked for a loaner due to safety concerns, but none has been provided. The ongoing delay leaves me with a vehicle that cannot operate safely, and Honda has not offered a timely resolution. Despite ongoing communication with American Honda Automobile Customer Service and Norm Reeves Honda Superstore Cerritos, the issue has remained unresolved.

NHTSA ID

11746360

Incident

Dec 29, 2025

I am writing to report an unresolved high-voltage safety defect involving the Motor Power Inverter Module on my 2019 Honda Clarity Plug-In Hybrid. The vehicle's high-voltage hybrid propulsion inverter is emitting a severe, high-pitched mechanical squealing noise during acceleration and regenerative braking.The high-voltage inverter serves as the foundational link regulating current between the lithium-ion battery and the electric drive motor. A failing inverter module presents an immediate, unreasonable safety hazard. Internal failure, thermal runaway, or component degradation within the inverter stack creates an imminent risk of sudden high-voltage isolation fault. This will result in an immediate vehicle stall and a total loss of propulsion while driving at highway speeds, leaving the vehicle stranded in traffic with no power to accelerate out of harm's way, creating a severe crash hazard.Furthermore, an authorized Honda dealership—Visalia Honda (Groppetti Automotive) in California—has failed to properly diagnose, isolate, or resolve this high-voltage drivetrain defect despite the vehicle being brought in specifically for this issue. Despite the component being legally covered under California’s mandated 15-year/150,000-mile extended emissions and hybrid warranty, the dealership has taken no constructive corrective action, allowing a known, physically degraded high-voltage component to remain active on public roadways.Federal intervention and a formal technical investigation into Honda's clarity hybrid propulsion inverter systems are required to address this vehicle stalling hazard before an electrical failure results in a highway collision.

NHTSA ID

11740510

Incident

May 16, 2026

Currently the high voltage inverter is squealing, it is currently at the dealership. They have verified it is the inverter that is malfunctioning but they will not warrenty the repair because they are saying it needs to completely fail and throw a code. This is the right time to fix it prior to catastrophic failure, can you please help.

NHTSA ID

11740506

Incident

May 16, 2026

The contact owns a 2019 Honda Clarity Plug-In Hybrid. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed; however, the vehicle failed to stop as intended. The contact stated that the BRAKE Hold system, hill start assist, collision mitigation system, VSA, and the electric parking brake warning lights were illuminated. The vehicle was driven to a safe location and turned off. The vehicle was restarted. Additionally, the warning lights were no longer illuminated. The contact stated that the failure had occurred while it was cold, and the temperature was below zero degrees. The vehicle was taken to the dealer, where it was diagnosed with an electric servo brake control unit/pedal seal simulator failure. The contact was informed that the electric servo brake control unit/pedal seal simulator needed to be replaced. The vehicle was not repaired. The contact was informed that parts were not in-stock and that the parts needed to be ordered. The contact researched the failure using an online chat group and was advised to take the vehicle back to the dealer. The vehicle was taken to the dealer, and the contact informed the dealer that the failure could be because of a failing battery. The dealer replaced the battery. A month later, the failure reoccurred. The contact stated that while sitting in the vehicle with the engine idling and the foot on the brake pedal, the vehicle rolled backwards. The vehicle almost crashed into the vehicle that was parked behind it. The contact immediately turned off the vehicle. The vehicle was restarted. The vehicle was driven to the residence without the failure recurring. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 44,000.

NHTSA ID

11723571

Incident

Feb 1, 2026

Mileage

44,000 mi

Took my car in due to the AC not working. We were told that AC Condenser and AC evaporator was broken. The AC condenser was replaced due to a recall and was placed under warranty a few years ago. Honda, indicated that AC Condenser was still under Warrenty, but the AC Evaporator is not. When it was explained to us at Honda Dealership in Dublin, CA. That the two parts go hand in hand, and that they would not be able to replace the AC Condenser until the AC Evaporator was replaced. As Honda requires a “pass” reading. The repair man at Honda also indicated that with AC Evaporator being broken imposes health risks such as breathing issues, dizziness, exposure to mildew and bacteria, as we were breathing in the gas from refrigerant that was leaking and burning then going in to the cabin of our vehicle when the AC was running. We have contacted Honda of USA and filed a case they indicated that due to our cars mileage, age and out of warranty that they have decided to decline assistance. This will be an ongoing issue as the two parts should be under warranty to get both of them fixed accordingly and to reduce health exposures.

NHTSA ID

11688006

Incident

Aug 28, 2025

The contact owns a 2019 Honda Clarity Plug-In Hybrid. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and confirmed that parts for the recall repair were not yet available. The contact called several other dealers, including Lake Elsinore Honda (18450 Collier Ave, Lake Elsinore, CA 92530), Diamond Valley Honda (300 Carriage Cir, Hemet, CA 92545), and DCH Honda of Temecula (26755 Ynez Rd, Temecula, CA 92591); and all confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA ID

11683661

Incident

Dec 18, 2023

I was entering the highway on ramp with a car in front of me going slow, when saw it was clear switched lanes and attempted to speed up to highway speed and the car's automatic braking system activated, flashed "BRAKE" on the dash with nothing in front of me, lane was clear, and then it applied the brakes hard. Came to an almost complete stop with my foot on the gas, had to remove foot to be able to accelerate again, luckily there was no near car behind me or it would have rear ended my car.

NHTSA ID

11674482

Incident

Jul 10, 2025

Owner Notification Letter - On some 2018-21 Clarity Plug-In Hybrid models, the A/C condenser may leak refrigerant. American Honda is extending the warranty on the A/C condenser to 10 years from the original date of purchase with unlimited miles. This warranty extension provides coverage for the original owner and any subsequent owners. No action is required on your part unless you experience a problem.

Service Bulletin - American Honda is extending the warranty on the A/C condenser to 10 years from the original date of purchase with unlimited miles. This warranty extension only covers vehicles that have a defective A/C condenser from the factory. The A/C condenser was not manufactured to specification. As a result, corrosion may develop in the form of tiny holes in the condenser tube walls that allow the refrigerant to leak out. This does not apply to any vehicle that has a leaking condenser due to foreign object damage. It also does not apply to any vehicle that has ever been declared a total loss or sold for salvage by a financial institution or insurer, or has a branded or similar title under any state's law.

Dealer Message - Today, May 28, 2021, American Honda is announcing a warranty extension for certain 2018-2020 Accord and Accord Hybrid, 2018-2020 Civic, 2017-2021 Civic Hatch, 2017-2021 Civic Type R, 2018-2021 Clarity PHEV, and 2019-2021 Insight vehicles. This warranty extension covers the A/C condenser to address concerns of leaking refrigerant. American Honda is extending the warranty on the A/C condenser to 10 years from the original date of purchase.

Service Bulletin - The Hybrid System Failure message comes on the MID, and DTC P1D8D (Generator Motor Inverter Short) is stored.