2022 BMW X2

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

While driving on the interstate, the drivetrain malfunction warning appeared causing the car to become "limp." This limp mode caused a sudden inability to accelerate in a lane requiring mobility to avoid collision with merging right lane traffic. If this car had not already been in the far right lane, it would have potentially cause a serious hazard in a high traffic area. Prior to this drivetrain warning, the vehicle had been serviced at BMW twice in the past 6 months. December of 2024 the battery was replaced. All 4 run flat tires were purchased new in April. By the end of April this drivetrain malfunction occurred requiring a tow back to BMW. Initially they diagnosed the battery as bad, though I informed them that shouldn't be happening since the battery was purchased just a few months prior. After more testing, I was informed that the battery is fine but the throttle body is draining it. This is a part that should last throughout the life of the engine. I asked if there was any way this could have been diagnosed during previous service, as this is a serious failure and had I not told them I already bought a new battery I would have had another incorrect diagnosis and further engine damage.

NHTSA ID

11659175

Incident

Apr 17, 2025

The EVAP systems purge (vent) valve limited warranty for defects in materials and / or workmanship has been extended to 15 years / 150,000 miles as determined from the original first in-service / delivery date.

The EVAP systems purge (vent) valve limited warranty for defects in materials or workmanship has been extended to 15 years / 150,000 miles as determined from the original in-service date.

During inspection and/or diagnosis there is noticeable dirt/grease buildup on the axles near the inner and/orouter CV boots.

Gasket Set Return

The engines turbocharger wastegate valve controller limited warranty for defects in materials and / or workmanship has been extended to 15 years / 150,000 miles as determined from the original in-service date.

Check control message (790) “Emergency gearbox release activated” is displayed immediately after starting the engine. This applies only to U11 equipped with the 7-speed M-DCT transmission.