2006 BMW X3

BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.

IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).

1. The front passenger airbag light is continuously on. 2. Fasten seat belt audible alarm, and fasten seat belt dash light are continuously on when front passenger seat is NOT occupied.

NHTSA ID

11740974

Incident

May 28, 2026

Dealer states my occupancy detection mat was already reworked, however the original mat is still in the seat and no evidence exists to show what was done to prevent future fatigue of the mat. The date code on the mat is 2005 and the dealer stated it only needed replacing if it showed visible cracking during inspection. They stated it wasn't required to replace it but the date of warranty started from date of inspection.

NHTSA ID

11498224

Incident

Dec 20, 2022

The contact owns a 2006 BMW X3. The contact stated while driving 30 MPH, the front passenger's side air bag warning light illuminated. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The contact associated the failure with NHTSA Campaign Number: 17V605000 (Air Bags) however, the VIN was not included. The failure mileage was approximately 83,000.

NHTSA ID

11491031

Incident

Aug 26, 2022

Mileage

83,000 mi

I can smell a burning smell at times coming out from my blower and the heat and air condition is not functioning properly. Also my rear hatch lights on the interior are always on and when I hit bumps they flash off and on.

NHTSA ID

11455860

Incident

May 5, 2021

The contact owns a 2006 BMW X3. The contact stated that while driving at 30 MPH, the contact rear-ended another vehicle. All the air bags except for the passenger’s side air bag deployed upon impact. The contact suffered a migraine from the collision but did not receive medical attention but planned to go to urgent care afterward. A police report was filed. The vehicle was towed to the contact's residence. The vehicle was not totaled. The manufacturer was not made aware of the failure. Prior to the failure, the dealer serviced the recall under NHTSA Campaign Number: 17V605000 (Air Bags). The failure mileage was approximately 130,000.

NHTSA ID

11443820

Incident

Dec 14, 2021

Mileage

130,000 mi

I turned on my heated seat and within about a minute and a half I smelled a burning smell. Pulled over as I started to feel a burn on my leg because the seat heater has burnt through the leather in my car. This is a known problem at BMW and they have not issued a recall for this.

NHTSA ID

11443453

Incident

Dec 11, 2021

FAULTY CLOCK SPRING BMW AIRBAG LIGHT ON HORN DOESN'T WORK BMW STEERING WHEEL BUTTONS DON'T WORK, PADDLE SHIFTER NOT WORKING, FAULT CODE: DRIVER SQUIB CIRCUIT OPEN OR HIGH RESISTANCE, CODE B1049 AND B1054.

NHTSA ID

11399912

Incident

Mar 1, 2021

Mileage

172,000 mi

NHTSA WEBSITE CLAIMS THAT MY VEHICLE HAS HAD AN UNREPAIRED RECALL. THE RECALL IS FOR: FRONT PASSENGER SEAT OCCUPANT DETECTION MAT: THIS SAFETY RECALL INVOLVES THE FRONT PASSENGER SEAT OCCUPANT DETECTION MAT. DEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE MAT CAN FATIGUE DURING FIELD USAGE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT. SPECIFICALLY, OVER TIME MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT. IF A MICRO-CRACK LEADS TO A BREAK OF A CONDUCTIVE PATH, THE SYSTEM WILL RECOGNIZE A FAILURE. CONSEQUENTLY, THE FRONT PASSENGER AIR BAGS WITH THE EXCEPTION OF THE HEAD PROTECTION SYSTEM WILL BE DEACTIVATED.

NHTSA ID

11386209

Incident

Sep 28, 2018

While driving the vehicle on normal roads at10mph and above, a "cracking" sound from the top of the B-pillar(s) is heard.

The basic conditions for initializing the power windows are not met.

The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle “discharged battery” complaints.

A noise can be heard from underneath the seat while the seat is being moved either forwards or backwards. This can occur to the driver’s and/or the passenger’s front seat.

This situation can result in two customer complaints: 1. Wind noise 2. Excess water entry

The front sunroof glass seal has shrunk, creating a gap which can cause wind noise or excess water entry.