2019 BMW X3

Oil pump failure after 48,000 miles

NHTSA ID

11765982

Incident

Sep 20, 2026

On Sept 16th, 2026 my wife was operating the vehicle under normal, routine driving conditions. While she was completely stopped at a stop sign the vehicle spontaneously caught fire. Description of the Issue and Damage: 1. There was no collision, impact, or external trauma prior to the fire. 2. There were no check engine lights, overheating warnings, or malfunction indicators on the dashboard leading up to this event. 3. The vehicle has been properly maintained and unmodified. 4. The fire originated spontaneously within the engine compartment. As documented in the attached photographs, the thermal event was heavily concentrated on the passenger side of the engine bay. 5. The fire escalated rapidly, resulting in the total destruction of the engine bay, the melting of the passenger-side front fascia and alloy wheel, the destruction of the structural fender, and severe thermal damage to the hood and lower windshield area. 6. My wife was thankfully able to immediately evacuate the vehicle before the cabin was engulfed, escaping physical injury, but she was placed in extreme danger due to this sudden defect. 7. The local Fire Department responded to the scene and extinguished the fire.

NHTSA ID

11765067

Incident

Sep 16, 2026

UNKNOWN cause. while driving approximately 45–55 mph, the vehicle experienced a sudden and unexpected braking event and engine shut down. •The vehicle automatically came to an abrupt, complete stop. •The engine shut off and then immediately restarted automatically. •A “Service Rear Pads” warning appeared after the vehicle auto-restarted. The vehicle did not gradually slow down; it suddenly and forcefully braked to a complete stop and shut down completely. This was a serious and potentially dangerous safety event as an unexpected stop/shut down event at 45–55 mph could have created a significant risk of collision. We contacted the BMW service center and scheduled a diagnostic appointment for June 22. During the June service visit, the dealership performed: diagnostics, rear brakes and rotors replacement, A/C recharge, tire rotation and balance, and oil change/service. Following the June service, we began experiencing new and intermittent symptoms that had not been present before, including: Ticking, metal clanking, new road/tire noise, Changes in vehicle dynamics and overall driving feel, other intermittent noises. On July 21, we contacted BMW to report the new intermittent noises and changes following the June service and requested an appointment to have these concerns evaluated. An appointment was scheduled for July 24. The July MPI identified several concerns that differed substantially from the June MPI, including: Rear differential leak, worn motor mounts, low battery concerns, & uneven tire wear and cracking. We also observed a permanent brake-pad imprint on a new rotor. These discrepancies raised additional questions and we were told by the SM that the technician had “missed” them in June, even though he documented as good. We refused to accept the X3 back for now d/t safety concerns, and we notified BMW of North America for investigation. The cause for the critical shut down event remains unknown. How can Flow BMW assure it's safe to drive?

NHTSA ID

11764232

Incident

Jun 18, 2026

The contact owns a 2019 BMW X3. While the vehicle was at an independent mechanic for maintenance, the technician discovered an active coolant leak coming from the coolant expansion tank. The mechanic stated that the leak was caused by excessive system pressure stressing the factory plastic tank. The mechanic informed the contact that if the issue was not resolved, the failure might become a major coolant leak into the engine, and the engine would need to be replaced. The vehicle was not repaired because the leak was coming from several areas. The contact stated that all the plastic parts need to be replaced with metallic parts. The vehicle was towed to the dealer but was not yet diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 69,000.

NHTSA ID

11759410

Incident

Mar 1, 2026

Mileage

69,000 mi

I was driving in my bmw x3 going about 35 miles an hour and hit a small pothole next thing I know is I got a flat tire when I pulled over the perch plate on the strut had slipped down and hit the tire causing it to blow out and now I'm stuck having to replace the entire strut assembly

NHTSA ID

11755647

Incident

Aug 6, 2026

**Description of Incident** On **July 25, 2026**, I parked my 2019 BMW X3 xDrive30i in a parking lot and turned the engine off. The vehicle was shifted into Park, locked, and I walked into a nearby store. At approximately 6:41 p.m., I received the update on my phone confirming that my vehicle had been locked. I remained inside the store for approximately six minutes. My purchase transaction was completed at approximately 6:47 p.m., at which time I immediately exited the store. When I returned to the parking lot, I found my vehicle fully engulfed in flames, not merely smoking. The fire had developed rapidly during the brief period the vehicle was parked and unattended. Prior to parking the vehicle, it had been operating normally. There were no warning lights illuminated on the instrument panel, including no check engine light, no engine overheating warning, no temperature warnings, and no other indications of a mechanical or electrical problem. The vehicle was not overdue for scheduled maintenance, and I had no reason to believe there was any issue that would place the vehicle at risk of catching fire. The vehicle was completely destroyed by the fire, which also spread to nearby parked vehicles. Based on the absence of any warning signs and the fact that the fire occurred while the vehicle was parked with the engine turned off for only a few minutes, I am requesting that this incident be investigated to determine whether it may have resulted from a vehicle defect.

NHTSA ID

11752961

Incident

Jul 25, 2026

I bought my 2019 BMW X3 late 2025 before Christmas. The Carfax was fine and there were no open recalls on the vehicle. The vehicle had been serviced regularly at BMW facilities. Our family mechanic looked at the vehicle before I bought it and performed some basic diagnostics. The vehicle appeared fine. There were no error codes and all of the fluids were topped off. I don't know if the issues with the coolant were there before I purchased the vehicle or if they happened afterwards. There were no warning lights and everything looked good. This car is garage kept and is used a couple of times a week. I did my research on the internet and took my car in for an oil change at a highly-rated independent auto repair facility that specializes in European vehicles and are famous for providing dealership-level expertise, ASE-certified with factory trained technicians from Germany. On March 5th, 2026, when I went to pick up my car, they told me the bad news that is a well known manufacturer defect within the industry regarding these vehicles. They used plastic components in the engine compartment and in the cooling system, which makes the vehicles malfunction. From their report, with pictures, they state the following repairs need to be made, "During the vehicle inspection noticed active coolant leaks are present from multiple locations. The radiator plastic tank actively leaking coolant. The water pump change over valve leaking coolant. The turbocharger coolant line has a coolant crud build up . Oil filter housing and coolant flange on the cylinder block are discolored. For proper cooling system repair recommend complete update of the cooling system. Both balance shaft end caps leaking oil. Recommend replacement during cooling system update." They quoted me $8,914.86 for this repair. That's over HALF the value of the vehicle. They said the entire system needs to be replaced because ALL of the plastic parts in Florida's hot sun will fail. Sudden coolant failures in FL = DEATH.

NHTSA ID

11748660

Incident

Mar 5, 2026

I am submitting this complaint regarding a serious mechanical and safety issue involving my 2019 BMW X3. On or around January 21, 2024, while driving from my home, a warning signal suddenly appeared on my dashboard related to the vehicle’s cooling system/engine. Due to safety concerns, I pulled into a nearby Wawa parking lot, which was the safest available place to stop at the time. I turned the vehicle off and waited approximately 15 minutes before carefully driving the vehicle back home. After inspection and diagnosis, I was informed that the vehicle required extensive repairs, including an engine replacement and cooling system repairs. At the time the coolant warning appeared, the replacement engine reportedly had approximately 59 miles on it. I believe a sudden engine or cooling system malfunction while operating a vehicle presents a serious safety concern for drivers, passengers, and others on the roadway. In addition, I experienced issues involving the shark fin antenna on the vehicle, which I understand may be connected to broader complaints involving BMW vehicles. I am requesting that NHTSA review this matter to determine whether these issues may indicate a broader defect or safety-related concern affecting other consumers. I am willing to provide supporting documentation including repair invoices, dealership records, photographs, and any additional information requested. Thank you for your attention to this matter and for your commitment to vehicle safety.

NHTSA ID

11740824

Incident

Jan 21, 2024

BMW Notice of the Court’s Final Approval for Shark-Fin Antenna Settlement (X3, X4, X5, X6, X7)

Rear Roof Antenna Shark Fin Cover Sealing Issue

The NVLD limited emissionrelated warranty for defects in materials or workmanship has been extended to 15 years/150,000 miles as determined from the original in-service date.

SHARK FIN ROOF ANTENNA SEALING SETTLEMENT Extended Warranty

The EVAP systems purge (vent) valve limited warranty for defects in materials or workmanship has been extended to 15 years / 150,000 miles as determined from the original in-service date.

The Supplemental Restraint Systems (SRS) Front Passenger’s Seat Occupancy Capacitive Interior Sensor (CIS) Mat for defects in materials and/or workmanship that causes a false seat occupancy alert to occur has been extended to 10 years / 120,000 miles as determined from the vehicle's original in-service / first delivery date.