2019 Volkswagen GTI

On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

The Office of Defects Investigation (ODI) has completed its review of a defect petition received on 14 August 2019 requesting an investigation of an alleged defect of the manual transmissions in Model Year (MY) 2019 Volkswagen (VW) GTI, Golf GTI and Jetta GLI vehicles. The stalling incidents cited occurred without warning as the vehicle slows to a stop or prepares to make a turn across traffic with the clutch pressed in and the vehicle in neutral.The hazard posed by a vehicle stalling event is manifested in the inability of the vehicle to move with the flow of surrounding traffic. Two factors have a major impact on the potential hazard to the vehicle, its occupants and surrounding vehicles: the surrounding traffic speed and the subject vehicle's restart ability. In the case of the vehicles that are the subject of this petition, restart is immediate and the stalls occur when the vehicle is slowing to stop for a traffic signal, making a turn, or is completely stopped. These circumstances substantially reduce the risk of harm to the vehicle, its occupants and surrounding vehicles.As of March 2, 2020, out of the population of 11,333 subject vehicles, NHTSA has identified 214 consumer complaints in its database, with unique Vehicle Identification Numbers (VIN), citing engine stalling as vehicles are being brought to a stop and/or preparing to make a cross traffic turn. When combined with the warranty, field report and customer complaint data received from VW in response to the Information Request letter sent, NHTSA identified 413 unique VINs alleging low speed engine stalling.Volkswagen determined that the low speed / idle engine stall was the result of unwanted gases remaining in the cylinder caused by the intake valve camshaft not being in the correct position at idle. The intake camshaft is in an advanced position. This advanced position results in too much overlap with the position of the exhaust valve camshaft, allowing both the intake and exhaust valves to be open at the same time. The erroneous advanced position of the intake camshaft is a result of low oil pressure at idle and high oil temperatures, greater than or equal to 110?C/230?F combined with engine control algorithms in the Engine Control Module (ECM) that position the intake camshaft. Based on examination of returned engines, only engines manufactured at the Silao Mexico plant were affected due to a tolerance stack-up issue with the oil system of the engines.In December of 2019, VW initiated a Service Action (24FD) to remedy the stalling issue in the affected vehicles. The warranty for the affected vehicles was extended to December 31, 2025. The software in the Engine Control Module (ECM) will be updated with a new calibration value for the adaptation nodes of the regulation valve. This is a directed action with letters being sent to vehicle owners asking them to bring their vehicles to their dealership to have the software update installed in their vehicle. The letters were sent in December 2019.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Volkswagen in response to an information request and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that the stalling condition as alleged by the petitioner indicates the likelihood of a safety related defect that would warrant a formal investigation, therefore the petition is denied. Further specifics can be found in the Federal Register Notice.ODI complaint ID Numbers are listed on the attached sheet.

I own a vehicle built from two salvage vehicles: a 2019 VW Golf Sportwagen (VIN [XXX] - the body) and a 2019 VW GTI (VIN [XXX] - the engine, suspension, fuel tank/system, etc). The vehicle is registered and titled under the Sportwagen VIN. Safety Recall 20UF requires replacement of the suction jet pump to prevent risk of fire. The recall was performed on the Sportwagen prior to its crash, but not on the GTI. Since the Sportwagen no longer has it's original engine/fuel tank, but that from the GTI, this means my vehicle has the defective, unsafe part. Because the dealer service department goes by the registered body VIN, they refused to perform the recall. I called VWoA Customer Care, who advised me that they could not do anything, and that the dealer service department must request an exception from VWoA and inspect the vehicle. I have attempted reaching out to my two nearest VW dealers, including my regular dealer, and they have either refused to perform the recall, or refused to get back to me. One dealer even said I should perform the repair myself, and when I pressed for VW to perform the recall, he said he'd have to call his regional manager and call me back at the end of the week. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11754905

Incident

Aug 5, 2026

While simply driving 75mph (speed limit during time of incident) on the highway, i heard a loud explosion sound and the sunroof had completely shattered and was blown upwards. Glass began and continued to fly off, creating a large hole, while trying to get to a stopping point. The was only very little shards of debris that had gotten inside the vehicle while driving, but had potential to put me and a passenger at risk of serious injury. No vehicles were close to mine that could have caused debris to hit the area and no other vehicles were affected. There was no cracks or chips in the glass prior to the incident. There is reason to believe that it is a manufacturing error or installation error prior to purchasing the vehicle in 2020. Supporting that, i have researched reports of other Volkswagen Golf GTI models dealing with the same or similar issues with the sunroof exploding upwards with zero cause or explanation. There has not been an inspection or investigation of the damage as is happened around 3:00pm on this date ( January 30th, 2026).

NHTSA ID

11714588

Incident

Jan 30, 2026

The front collision brake assist goes on when there is no obstacle. It has given me obstacle warnings before, but this time it slammed on the brakes and brought me to a stop. This "safety" feature is going to get me rear ended. I have not taken it to a dealer because internet search shows me it is a widespread problem for which there is no fix. I would like it permanently disabled.

NHTSA ID

11675819

Incident

Jul 9, 2025

The contact owns a 2019 Volkswagen GTI SE. The contact received notification of NHTSA Campaign Number: 24V110000 (FUEL SYSTEM, GASOLINE). The contact lives in Hawaii. However, there are no Volkswagen dealers on the island. The contact was told by the manufacturer that the recall repairs would need to be done by a dealer. It was suggested that the vehicle be shipped to O'ahu at the contact's expense. The contact stated that the manufacturer did not offer any assistance when asked if a local independent mechanic could repair the vehicle. The contact had not experienced a failure.

NHTSA ID

11655500

Incident

Apr 18, 2025

Rough idle on start. RPM is not maintaining to keep the engine running. After a few try, it starts ok and drive off the parking lot, but the engine dies after about 10 seconds over 30mph. It feels like gasoline is not igniting corretly. Scanned Error Code P0171: System Too Lean Bank 1 P0190: Fuel Rail Pressure Sensor A Circuit Dealership can't replicate the issue and find the issue. Could be related to Fuel System Recall.

NHTSA ID

11618799

Incident

Sep 17, 2024

There has been no incident. I am filing this complaint because I have been unable to get an expected date of repair from VW by calling VW.

NHTSA ID

11589689

Incident

May 17, 2024

VEHICLE STALLS AT LOW SPEEDS. I HAVE NOTICED MY CAR STALL WHEN LEAVING A PARKING SPOT WHERE I WILL GET HALFWAY OUT OF THE PARK, AND THEN THE RPM GOES TO 0 AND I HAVE TO PUT IT INTO PARK, TURN THE KEY, AND AFTER A LONGER THAN NORMAL STARTUP TIME, IT GOES.

NHTSA ID

11397180

Incident

Feb 14, 2021

Mileage

21,000 mi

WHILE DRIVING ON HIGHWAY AT APPROX. 75MPH, MY 2019 VOLKSWAGEN GTI SE PANORAMIC SUNROOF SPONTANEOUSLY EXPLODED. I HEARD A VERY LOUD BANG FOLLOWED BY SHATTERED GLASS FALLING INTO THE CAR. THE ENTIRE SUNROOF HAD SHATTERED AND A VERY LARGE HOLE (APPROX. 1' X 1.5' LARGE) NEAR THE FRONT OF SUNROOF WAS PRESENT. I DID NOT SEE ANYTHING HIT THE SUNROOF. GIVEN THE LOUD BANG AND THE EXTENT OF DAMAGE TO THE SUNROOF, I FIND IT DIFFICULT TO BELIEVE A ROCK OR SOME OTHER OBJECT HIT THE SUNROOF.

NHTSA ID

11374175

Incident

Nov 11, 2020

Mileage

13,400 mi

This is a notice for software changes with the ODIS diagnostic program to correct the communication during vehicle programming function: A software fix is needed to correct the issue: DA 0019 - Hotfix 12-V battery test(s) – No battery diagnosis - Inconclusive test result.

Oil Consumption Measurement and Electronic Oil Consumption Measurement

Lubricating engine components before reassembly.

Instruction, how to lubicate engine before initial start.

Inquiries

Volkswagen Engine Oil Standards