2011 Volkswagen GTI

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.This Recall Query has been upgraded to an Engineering Analysis (EA18-003) to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 107626

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.

The contact owns a 2011 Volkswagen GTI. The contact stated that he lost the function of the steering wheel, horn, controls, and air bag. The air bag warning indicator light was illuminated. The contact called the local dealer and it was diagnosed that the clock spring needed to be replaced. The contact was informed that the parts required were on backorder. The vehicle was not repaired. The manufacturer was contacted but provided no additional assistance. The approximate failure mileage was 55,000.

NHTSA ID

11478572

Incident

Nov 11, 2021

Mileage

55,000 mi

My horn had stopped working and I brought it to the dealership to get it diagnosed. They identified it as a clockspring issue, and with the knowledge that VW has an active recall for the clockspring, I was hoping that I could get the clockspring replaced under the warranty. However, VW of America refuses to replace the clockspring under the warranty as my airbag light isn't on. I am frustrated because my horn issue is clearly due to the clockspring, and now I do not have a working horn and have to pay out of pocket to fix it. Also, there are no available parts for the clockspring, so even if I wanted to fix it I have to wait for months.

NHTSA ID

11474199

Incident

Jul 1, 2022

The contact owns a 2011 Volkswagen GTI. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. The vehicle was taken to an independent mechanic who diagnosed that the timing chain needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA. The failure mileage was approximately 108,000.

NHTSA ID

11465936

Incident

May 24, 2022

Mileage

108,000 mi

I bought the car and a couple days later the dash started lighting up with a bunch of codes about exterior lights so we checked them all fine I went to the auto part store and they said that the vehichle I have has a known issue with the fuses burning so we pull the fuse and sure enough it melted and we replaced fuse drove a week longer and the fuse box caught fire so I took and had a new fuse box installed and it again is burning fuses. Flashing all kinds of code error lights on dash and the sunroof opens and closes by its self . I looked at other VIN OF SAME CAR SAME YEARS and they are recalled for this problem but my VIN is not for some reason

NHTSA ID

11457483

Incident

Jan 20, 2021

There are many cases of clock spring failure in my model as well as many others. The problem here is that this failure has caused my to lose the use of all my steering wheel controls, horn and airbag and shifters. VW has obliged about the problem and is willing to repair it under warranty. The problem is, is that there are no parts available for the repair. I have no choice but to drive a car with many safety issues. Someone needs to look into allowing aftermarket parts to be used by dealer or expedite the manufacturer. This is putting many people in danger on the road, I am sure it's not only me. Thank You

NHTSA ID

11448621

Incident

Nov 1, 2021

The horn works on some trips and not on others. I've brought it to the dealership near me and been told that it needs to be broken for them to be able to diagnose it. I hear a clicking sound from the steering wheel when i've needed to press the horn and it doesn't work. However, even if your horn doesn't work on the last trip you had, it sounds fine when you click the key fob lock button. No lights come on anywhere to notify me that horn won't work today, only remembering to try it out in the driveway when I go out

NHTSA ID

11448568

Incident

Jan 23, 2022

PUT MY KEY INTO THE IGNITION AND RECIEVED, "ERROR: AIRBAG" NOW MY AIRBAG LIGHT IS ON AND I DIDNT DO ANYTHING TO MY ELECTRICAL OR AIRBAG SYSTEM.

NHTSA ID

11373144

Incident

Nov 2, 2020

Mileage

126,832 mi

WHEN THE KEY HAS BEEN INSERTED INTO THE IGNITION CYLINDER, THE KEY WILL NOT TURN ALL THE WAY TO TURN ON THE VEHICLE. IT WILL STOP IN THE ACCESSORY SETTING AND NOT GO FURTHER. THE KEY CAN BE TAKEN OUT AGAIN BUT SAME ISSUE CONTINUES IF YOU TRY AGAIN. THE AUTOMATIC TRANSMISSION ON MY VEHICLE IS FULLY ENGAGED IN PARK AND THE STEERING WHEEL IS NOT LOCKED. THE CAR WILL NOT TURN ON AND WILL FORCE ME TO HAVE IT TOWED TO A MECHANIC TO REPAIR OR REPLACE THE IGNITION LOCK CYLINDER THAT SEEMS TO BE DAMAGED. ALL ACCESSORIES POWER ON JUST FINE WHEN THE ACCESSORY SETTING IS ENGAGED SO THAT LEADS ME TO BELIEVE THE IGNITION SWITCH IS FINE BUT THE CYLINDER IS DAMAGED. REPLACEMENT OF THIS PART REQUIRES THE REMOVAL OF THE STEERING WHEEL, AIRBAG, STEERING COLUMN ARMS AND OTHER ELECTRONICS SO I AM TAKING IT TO A MECHANIC IN FEAR THAT THIS IS TOO ADVANCED A PROJECT FOR HOME REPAIR. THIS ISSUE WAS FIRST DOCUMENTED ON OCTOBER 5TH 2019 AND HAS NEVER GIVEN ANY ISSUES IN THE PAST.

NHTSA ID

11266594

Incident

Oct 5, 2019

Mileage

103,000 mi

This is a notice for software changes with the ODIS diagnostic program to correct the communication during vehicle programming function: A software fix is needed to correct the issue: DA 0019 - Hotfix 12-V battery test(s) – No battery diagnosis - Inconclusive test result.

Oil Consumption Measurement and Electronic Oil Consumption Measurement

Instruction, how to lubicate engine before initial start.

Lubricating engine components before reassembly.

Inquiries

Volkswagen Engine Oil Standards