2012 Volkswagen GTI

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.This Recall Query has been upgraded to an Engineering Analysis (EA18-003) to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 107626

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.

ABS Control Module short and failure occurred. Trouble codes generated include 01325 - Tire Pressure Monitoring Control Module No signal/communication and 01130 - ABS Operation Implausible signal static. Upon visiting an Authorized Volkswagen dealer service center was charged $200 for ABS diagnostic fee and told the ABS Control Module has failed and I will need to pay >$2900 to replace. ABS, ESP/ASR, airbag, and parking brake lights are now permanently active as a result and not certain these systems are functioning.

NHTSA ID

11605256

Incident

Apr 6, 2024

The contact owns a 2012 Volkswagen GTI. The contact stated that while driving at an undisclosed speed, the low coolant level warning light illuminated. The contact stopped and refilled the coolant reservoir bottle. The vehicle was taken to the dealer where it was diagnosed with a failed water pump. The contact was informed that the water pump needed to be replaced. The contact stated that the failure had been persistent, and the water pump had been replaced three times previously. The contact was informed that oil leaked onto the gasket and caused the housing of the water pump to crack, which caused the engine to overheat. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 50,000.

NHTSA ID

11562435

Incident

Dec 28, 2015

Mileage

50,000 mi

My Air bag light came on. Plus all the controls on my steering column do not work, including the horn. I called the VW dealer. They knew exactly what it was. The Clock Spring. This happened in early May. I was told the part has been on back order for 6 months. The dealer does not have any cars to give me until the part comes in. I was told 6 other cars have the same problem This to me is a major safety issue. I HAVE to drive my car, and I am not comfortable with that.

NHTSA ID

11482092

Incident

May 9, 2022

A MONTH AGO I NOTICED MY GTI WAS STALLING WHEN I TRIED TO ACCELERATE AFTER A STOP. WENT ON A DRIVE WITH A LOT OF HILL CLIMBING AND THE CAR STARTING TO STALL ON THE UPHILL PORTIONS. THE PROBLEM WAS NOTICEABLY WORSE AFTER THAT, SO I TOOK IT TO A LOCAL SHOP. THEY WEREN'T ENTIRELY SURE BUT PUT IN A NEW FUEL FILTER. THE PROBLEM DID NOT GET BETTER. TODAY, A MONTH LATER, I TOOK MY CAR TO A DIFFERENT SHOP FOR FURTHER DIAGNOSIS AND THEY DETERMINED IT WAS A HIGH PRESSURE FUEL PUMP/CAMSHAFT FAILURE. THE CAR IS NOT PERFORMING SAFELY DUE TO STALLING AND A LAG IN ACCELERATION.

NHTSA ID

11349341

Incident

Aug 14, 2020

Mileage

104,000 mi

THE CLOCK SPRING IN MY STEERING WHEEL HAS BROKEN/QUIT WORKING, VOLKSWAGEN REFUSES TO REPLACE IT UNDER THE RECALL BECAUSE MY VIN NUMBER WAS NOT FLAGGED DURING THE RECALL, THE AIRBAG LIGHT, ABS LIGHT, BRAKE LIGHT, AND TRACTION CONTROL LIGHT ARE ALL ON, MY MECHANIC DIAGNOSED IT TO BE THE CLOCK SPRING CAUSING THE ISSUE.

NHTSA ID

11287820

Incident

Feb 8, 2017

Mileage

60,000 mi

TL* THE CONTACT OWNS A 2012 VOLKSWAGEN GTI. THE CONTACT STATED THAT WHEN THE ENGINE WAS STARTED, IT RATTLED INSIDE. THE VEHICLE WAS TAKEN TO DEMONTROND VOLKSWAGEN (14101 NORTH FWY, HOUSTON, TX 77090, (281) 872-3855) WHERE IT WAS DIAGNOSED THAT THE TIMING CHAIN AND THE TIMING TENSIONER NEEDED TO BE REPLACED. THE VEHICLE WAS LATER TAKEN TO AN INDEPENDENT MECHANIC WHERE THE REPAIR WAS COMPLETED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED CASE NUMBER: 190-669-582. THE FAILURE MILEAGE WAS APPROXIMATELY 67,000.

NHTSA ID

11267382

Incident

Aug 14, 2019

Mileage

67,000 mi

WHEN THE SUN BEATS DOWN ON MY PASSENGER DOOR OR ON A VERY HOT DAY, AND THE DOOR IS THEN OPENED, IT WILL NOT LATCH.IT WILL SWING OPEN WHEN DRIVING. I HAVE TO HOLD SHUT WITH A ROPE. IF THE CAR IS PARKED WITH SUN ON THE OTHER SIDE OF THE CAR THIS DOESN'T HAPPEN. APPARENTLY THE CABLE STRETCHES WHEN IT GETS HOT PREVENTING THE LATCH FROM OPERATING. IT WILL RETURN TO NORMAL OPERATION WHEN PARTS COOL DOWN EITHER DURING THE RIDE OR ONCE AT HOME IN DARK GARAGE. AT THAT POINT THE LATCH WILL WORK AND DOOR WILL CLOSE. THIS HAS PREVIOUSLY HAPPENED ON MY DRIVER'S SIDE DOOR AND WAS FIXED UNDER WARRANTY. I AM NOW PAST MY MAXIMUM MILEAGE WARRANTY SO IT WILL NOT BE COVERED.

NHTSA ID

11174238

Incident

Sep 1, 2018

Mileage

110,000 mi

WHILE CAR WAS STOPPED BUT RUNNING THE VACUUM PUMP 'BROKE' WITH A LOUD GRINDING SOUND AND OIL STARTED LEAKING EVERYWHERE. PUTTING THE CAR IN MOTION WASN'T A PROBLEM DISPITE THE GRINDING SOUND BUT BRAKES WERE *VERY* HARD TO PRESS AND WAS *VERY* DIFFICULT TO STOP THE CAR. DECIDED THAT IT WAS UNSAFE TO DRIVE AND CALLED A TOW TRUCK TO TAKE TO THE DEALER. THEY REPLACED THE VACUUM PUMP AT MY EXPENSE.

NHTSA ID

11174233

Incident

Jan 26, 2019

Mileage

118,000 mi

This is a notice for software changes with the ODIS diagnostic program to correct the communication during vehicle programming function: A software fix is needed to correct the issue: DA 0019 - Hotfix 12-V battery test(s) – No battery diagnosis - Inconclusive test result.

Oil Consumption Measurement and Electronic Oil Consumption Measurement

Lubricating engine components before reassembly.

Instruction, how to lubicate engine before initial start.

Inquiries

Volkswagen Engine Oil Standards