2013 Volkswagen GTI

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.This Recall Query has been upgraded to an Engineering Analysis (EA18-003) to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 107626

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.

DSG automatic transmission started going into neutral at various speeds and driving conditions. It feels as though the clutch disengages momentarily, causing the vehicle to slow down and engine to rev. This is definitely not safe when trying to merge or drive on the highway. This is a know issue with VW DSG transmissions and warranted a safety recall on earlier vehicles. My vehicle is newer than the recall so VW has no obligation to help me. They inspected the car and told me it needed a transmission replacement, but that the transmission is no longer produced or available. I would need to source a used transmission and try my luck. It is unacceptable that VW has no liability in this issue that is known, common and a real safety issue.

NHTSA ID

11656161

Incident

Apr 21, 2025

I'M ON MY WAY TO WORK ON THE HIGHWAY GOING UPHILL AND THE TEMPERATURE RED LIGHT STARTS FLASHING. I DECIDED TO SLOW DOWN BECAUSE THE FLASHING LIGHT HAD ME CONCERNED. THE TEMPERATURE GAUGE STAYED AT NORMAL POSITION SO I WAS ABLE TO BRING IT HOME. I WAITED AWHILE AND THEN CHECKED UNDER THE HOOD FOR COOLANT LEVEL AND IT WAS DOWN TO THE BOTTOM BARELY ANY LEFT. SO I BOUGHT THE RECOMMENDED COOLANT BY VW AND FILLED IT UP TO LEVEL. I DROVE THE NEXT DAY AND PARKED IN MY DRIVE WAY AND LATER THAT DAY I SAW COOLANT PUDDLE ON CONCRETE DRIPPED FROM ENGINE. I SUSPECT IT'S THE WATER PUMP AGAIN. I HAD THIS PROBLEM WITH THIS CAR BEFORE WITH COOLING SYSTEM TWICE. THE FIRST TIME THE DEALERSHIP DEALT WITH IT BY REPLACING WATER PUMP WHILE IT WAS UNDER WARRANTY. THE SECOND TIME I TOOK IT TO MECHANIC AND THEY WERE ABLE TO REPLACE WATER PUMP AND FIX THE PROBLEM. I WAS ABLE FIND THE LEAK AND TAKE PICTURES. IT SEEMS TO BE LEAKING NEAR THE WATER PUMP. SO RIGHT NOW I'M FILLING COOLANT ALMOST EVERYDAY UNTIL I CAN GET TO THE DEALERSHIP.

NHTSA ID

11398578

Incident

Feb 18, 2021

Mileage

106,000 mi

I WAS DRIVING AT NORMAL HIGHWAY SPEEDS AND WHEN I WENT TO SLOW DOWN FOR A RED LIGHT MY BRAKES WERE NOT ENGAGING UNTIL MY PEDAL WAS PUSHED WELL OVER HALF WAY DOWN. THIS WAS A VERY SERIOUS ISSUE. I STARTED NOTICING THAT IF I PUMPED MY BRAKE PEDAL, THE BRAKES WOULD BECOME MORE EFFECTIVE, BUT THE VEHICLE REALLY WAS NOT SAFE. I TOOK THE CAR TO MY LOCAL TIRES PLUS REPAIR SHOP WHO BELIEVED THE BRAKE MASTER CYLINDER WAS BAD AND IT WAS REPLACED UNDER WARRANTY. ONCE THE REPAIR WAS COMPLETED I PICKED UP MY VEHICLE AND THE BRAKES STILL WERE NOT EFFECTIVELY ENGAGING. AT THAT POINT THE REAR BRAKE CALIPERS HAD GOTTEN REPLACED AND EVEN AFTER THAT, NOTHING HAD IMPROVED. TIRES PLUS DECIDED THE CAR NEEDED TO GO TO VOLKSWAGEN BECAUSE THEY COULD NOT FIGURE OUT THE ISSUE. I TOOK THE CAR TO MY LOCAL REPAIR SHOP WHO DIAGNOSED THE CAR AND INSISTED THERE WERE NO ISSUES WITH MY BRAKES AND THAT THE WAY MY BRAKE PEDAL FELT WAS NORMAL. I KNOW FOR A FACT THIS ISN'T TRUE AND THE SERVICE CENTER REFUSED TO ACKNOWLEDGE MY CONCERNS. IN RESPONSE I WAS TOLD THAT I JUST DON'T KNOW HOW BRAKES ARE SUPPOSED TO WORK AND THAT MUCH DEAD PEDAL TRAVEL IS NORMAL. I PICKED MY CAR UP AND AFTER A WEEK MY BRAKES HAD GOTTEN WORSE AND THEY CONTINUE TO GET WORSE. THE BRAKE PEDAL IS STILL NOT ENGAGING MY BRAKES UNTIL OVER HALFWAY THROUGH THE PEDAL TRAVEL AND ONCE THE BRAKES DO ENGAGE THE PEDAL IS VERY STIFF. I AGAIN EXPRESSED MY CONCERNS TO THE DEALERSHIP AND THE SERVICE ADVISOR SIMPLY YELLED AT ME AND TOLD ME THAT THERE WAS ABSOLUTELY NOTHING WRONG WITH MY CAR AND THAT I NEEDED TO JUST LISTEN TO THE EXPERTS. AND YET THEY HAVE NOT DRIVEN MY CAR BECAUSE THEY DENIED TO DO SO. I HAVE TAKEN MY CAR TO TWO OTHER REPAIR SHOPS WHO INSIST THERE IS AN ISSUE BUT COULD NOT PROPERLY DIAGNOSE THE ISSUE AND INSIST VOLKSWAGEN NEEDS TO DEEPLY LOOK INTO MY CARS BRAKING SYSTEM BUT VOLKSWAGEN WON'T DO FURTHER INVESTIGATING INTO THE BRAKES.

NHTSA ID

11377947

Incident

Nov 18, 2020

SUNROOF SPONTANEOUSLY EXPLODED ON THE HIGHWAY.

NHTSA ID

11353352

Incident

Sep 4, 2020

Mileage

57,000 mi

INTAKE MANIFOLD WAS REPLACED UNDER WARRANTY IN 2015. IN LATE 2019 THE VEHICLE DISPLAYED A SERVICE ENGINE WARNING WHICH TURNED OUT TO BE THE INTAKE MANIFOLD AGAIN. OUT OF WARRANTY THE SERVICE COST ME IN EXCESS OF $1000. I SEE THE WARRANTY WAS EXTENDED ON OLDER YEARS FOR THE SAME EXACT REASON BUT NOT THE 2013. THIS NEEDS TO BE REMEDIED AS SOON AS POSSIBLE.

NHTSA ID

11311130

Incident

Nov 1, 2019

Mileage

120,000 mi

WITHOUT WARNING THE VEHICLE PUTS ITSELF INTO NEUTRAL WAS TOLD NOTHING CAN BE DONE UNLESS IT'S ABLE TO BE DIAGNOSED OR REPLICATED THIS IS A KNOWN ISSUE ON EARLIER MODELS THAT RESULTED IN AN EXTENDED WARRANTY DUE TO THE SAFETY CONCERNS. DID CONTACT DEALER AND VOA

NHTSA ID

11197284

Incident

Apr 13, 2019

Mileage

57,000 mi

TL* THE CONTACT OWNS A 2013 VOLKSWAGEN GTI. WHILE DRIVING AT ANY SPEED, THE GEAR SHIFTED INTO NEUTRAL AND COMMUNICATION WAS LOST WITH THE GEAR BOX. ALSO, THE RPMS INCREASED. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS PLACED IN PARK, SHUT OFF, AND RESTARTED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO VALLEY AUTO WORLD VOLKSWAGEN (910-867-7000, LOCATED AT 3810 SYCAMORE DAIRY RD, FAYETTEVILLE, NC 28303) WHERE IT WAS DIAGNOSED THAT THE COMPUTER SYSTEM NEEDED TO BE REPLACED. THE COMPUTER SYSTEM WAS NOT REPLACED. THE CONTACT CALLED THE MANUFACTURER, BUT WAS UNABLE TO REACH ANYONE. THE FAILURE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 15,000.

NHTSA ID

11153943

Incident

Jun 28, 2016

Mileage

15,000 mi

CAR WAS DRIVEN IN A NEIGHBORHOOD. FIRST NOTICED SOME SMOKE COMING OUT OF THE HOOD, STOPPED THE CAR, MORE AND MORE SMOKE CAME OUT AND COULDN'T EVEN SEE ANYTHING IF ANYONE WERE TO BE IN THE CAR. NOTICE SOME FIRE START TO APPEAR AT THE BOTTOM OF THE CAR, CALLED 911. THE ENTIRE HOOD WAS ON FIRE BY THE TIME FIREFIGHTERS ARRIVED. IT SEEMED THERE WAS GOING TO BE AN EXPLOSION IF FIREFIGHTERS WERE TO ARRIVE A MINUTE LATER.

NHTSA ID

11151280

Incident

Nov 10, 2018

Mileage

35,000 mi

This is a notice for software changes with the ODIS diagnostic program to correct the communication during vehicle programming function: A software fix is needed to correct the issue: DA 0019 - Hotfix 12-V battery test(s) – No battery diagnosis - Inconclusive test result.

Oil Consumption Measurement and Electronic Oil Consumption Measurement

Lubricating engine components before reassembly.

Instruction, how to lubicate engine before initial start.

Inquiries

Volkswagen Engine Oil Standards