2017 Volkswagen GTI

On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Fuel pump and thermostat failure. Known issue on 2017 GTI models and VW corporate will not grant an exception for the class action settlement since vehicle is outside of coverage period. All scheduled maintenance on vehicle has been done at a dealership and i have had no issues. Spoke with VW Corporate and they will not grant an exception or allow me to speak to anyone else after requesting an escalation request to a supervisor. They also said filing a complaint will not do anything since the outcome will not change.

NHTSA ID

11753293

Incident

Jul 26, 2026

On June 24, 2026, Safety Recall 20UF (Suction Jet Pump) was completed by an authorized Volkswagen dealer. Upon leaving the dealership, the vehicle immediately experienced a severe engine stall and extended no-start condition. During the recall service, liquid fuel flooded the EVAP lines and charcoal canister, saturating the intake with raw fuel. This caused an immediate safety hazard, stalling the vehicle in active traffic in 110+ degree summer heat. The vehicle was brought back to the dealer, who confirmed the stall but incorrectly blamed a fuel injector, refusing to acknowledge the EVAP flooding caused by the recall work. Due to the no-start condition, the vehicle was flatbed towed. Raw fuel from this EVAP lines washed past the piston rings, requiring an emergency engine oil change to prevent catastrophic engine failure from severe oil dilution. VW Customer CARE (Case #07594393) refused reimbursement for the towing ($167.00) and oil flush ($101.74) resulting directly from the botched recall. VW failed to provide a safe, effective, cost-free recall remedy. Repair documents attached.

NHTSA ID

11752743

Incident

Jun 24, 2026

Had an immediate loss of propulsion event without warning (2-Feb-2026) after recall work completed on 16-Dec-20256 (24V110000). I lost propulsion on public roads and was lucky that this happened just after I exited the highway otherwise I would have ended up in a life threatening situation

NHTSA ID

11716457

Incident

Feb 5, 2026

The vehicle was involved in a low-speed frontal collision (under approximately 20 mph) resulting in relatively minor front-end damage. Despite the limited severity of the impact, the driver frontal airbag and both the front and rear driver-side curtain airbags deployed. The vehicle has no prior accident history, had no SRS or airbag warning lights prior to the incident, and has approximately 86,000 miles. Due to the nature of the collision and the deployment of multiple airbags, I have concerns that the airbag system may have deployed unnecessarily or abnormally. I am requesting that this concern be formally documented. It is available for inspection. It has not been fixed. I have opened a case with VW.

NHTSA ID

11710400

Incident

Jan 9, 2026

Description of the Problem: The fuel pump failed and began spraying gasoline during operation. The malfunction was documented on video by an authorized Volkswagen mechanic and confirmed by a Volkswagen dealership in Honolulu, Hawaii. The component is available for inspection if required. Safety Risk: The failure caused pressurized gasoline to spray within the engine compartment, presenting a serious fire and explosion hazard. This defect posed a danger to the driver, passengers, and others nearby due to potential ignition of leaked fuel. Reproduction and Inspection: The condition was reproduced and confirmed by both an independent authorized Volkswagen mechanic and a Volkswagen dealership in Honolulu. The issue has not yet been inspected by Volkswagen of America, insurance representatives, or police authorities. Warning Signs or Prior Symptoms: A strong smell of gasoline inside the passenger cabin was present prior to discovery of the leak. No dashboard warning lights or error messages appeared. Summary: Fuel pump failure caused gasoline to spray under pressure. The problem was verified by an authorized VW mechanic and dealership in Honolulu, HI. The defective component remains available for inspection. Immediate safety risk due to potential ignition of fuel vapors.

NHTSA ID

11694805

Incident

Oct 8, 2025

On October 13, 2025, while driving my 2017 Volkswagen GTI, I noticed a strong odor of gasoline inside and around the vehicle. After parking and inspecting the car, I observed a large pool of gasoline forming in front of the rear passenger-side wheel well. This poses a serious safety risk due to the potential for fire or explosion from fuel leakage. This is the second time my vehicle has experienced gasoline leaking from this same area. The issue appears to originate from a component in or near the fuel system (potentially the fuel line, rollover valve, or suction jet pump assembly), but the specific part has not yet been confirmed. The vehicle is currently at Honolulu Volkswagen for inspection, and the affected components are available for review upon request. At this time, no warning lights, dashboard messages, or prior symptoms appeared before the leak occurred. The odor of gasoline was the first sign of the issue. I believe this recurring fuel leak presents a significant fire hazard and warrants further investigation by Volkswagen and NHTSA.

NHTSA ID

11693205

Incident

Oct 13, 2025

Rear back-up camera fails repeatedly. The image portrayed on the dash is garbled and I am unable to determine vehicles, obstacles or persons behind me when backing. Problem is very reproducible although the dealer has not diagnosed the problem. The car is out of warranty. The only message displayed on the screen is something like "Park Pilot error".

NHTSA ID

11686354

Incident

Jun 1, 2025

I had fuel leaking from my carbon canister. I was driving the previous day and noticed a gasoline smell. I thought it was something I ran over. The next day, while performing errands, I noticed the smell even more. Then I exited the vehicle to see the fuel pouring out of the car. The dealership has it now.

NHTSA ID

11680099

Incident

Aug 9, 2025

This is a notice for software changes with the ODIS diagnostic program to correct the communication during vehicle programming function: A software fix is needed to correct the issue: DA 0019 - Hotfix 12-V battery test(s) – No battery diagnosis - Inconclusive test result.

Oil Consumption Measurement and Electronic Oil Consumption Measurement

Lubricating engine components before reassembly.

Instruction, how to lubicate engine before initial start.

Inquiries

Volkswagen Engine Oil Standards