2008 Volkswagen GTI

THE SUBJECT VEHICLES ARE EQUIPPED WITH DIRECT SHIFT GEARBOX (DSG) TRANSMISSIONS, WHICH FEATURE A 6-SPEED AUTOMATIC GEARBOX WITH TWO WET RUNNING CLUTCHES (DUAL CLUTCH) IN WHICH THE CLUTCH MECHANISM AND GEAR CHANGES ARE ELECTROHYDRAULICALLY OPERATED BY A MECHATRONIC CONTROL UNIT.THE DSG MECHATRONIC CONTROLLER INCLUDES EXTENSIVE SELF DIAGNOSTIC FUNCTIONS AND STRATEGIES TO ENSURE SAFE OPERATION AND PREVENT SYSTEM/COMPONENT DAMAGE IN THE EVENT OF COMPONENT FAILURES OR HARSH OPERATING CONDITIONS.THE BASIC HIERARCHY OF FAULT MODES INCLUDES SOME THAT ONLY RESULT IN THE STORAGE OF A DIAGNOSTIC TROUBLE CODE (DTC) AND CAUSE NO LOSS OF FUNCTION, SOME THAT STORE A DTC AND REDUCE VEHICLE OPERATION TO A LIMP HOME MODE, AND SOME THAT STORE A DTC AND CAUSE AN INTERRUPTION OF MOTIVE POWER (I.E., OPEN CLUTCH).THE DRIVER IS ALERTED TO THE LATTER TWO MODES BY THE DASH GEAR POSITION INDICATOR (PRNDS) FLASHING. ONE OF THE CONDITIONS THAT RESULTS IN INTERRUPTION OF MOTIVE POWER IS EXCESS GEARBOX TEMPERATURE.THE SYSTEM INITIALLY RESPONDS TO INCREASED GEARBOX TEMPERATURE BY RAMPING DOWN ENGINE TORQUE.IF THE TEMPERATURE KEEPS RISING THE MECHATRONIC UNIT RESPONDS BY OPENING THE CLUTCH.IN A DEFECT INFORMATION REPORT SUBMITTED TO NHTSA ON AUGUST 20, 2009, VOLKSWAGEN DESCRIBED A POTENTIAL DEFECT IN THE WIRING HARNESSES OF THE DSG GEARBOX TEMPERATURE SENSORS USED IN APPROXIMATELY 16,000 MODEL YEAR (MY) 2009 AND 2010 VOLKSWAGEN (EOS, JETTA AND GTI) AND AUDI (A3 AND TT/TT ROADSTER) VEHICLES EQUIPPED WITH DSG TRANSMISSIONS AND BUILT FROM SEPTEMBER 2008 THROUGH AUGUST 2009 (NHTSA RECALL NO. 09V-333, VOLKSWAGEN RECALL NO. 37E3/S7 AND AUDI RECALL NO 37E4/J7). VOLKSWAGEN PROVIDED THIS DESCRIPTION OF THE DEFECT, THE WIRING HARNESS OF A TEMPERATURE SENSOR IN THE DSG MAY HAVE CONNECTOR WIRES THAT WERE INSUFFICIENTLY CRIMPED BY THE CONNECTOR SUPPLIER DURING A LIMITED PRODUCTION PERIOD.WITH INSUFFICIENTLY CRIMPED CONNECTOR WIRES, A TEMPERATURE SENSOR HAS THE POTENTIAL TO FALSELY DETECT A HIGH GEARBOX OIL TEMPERATURE, CAUSING THE TRANSMISSION TO ABRUPTLY SHIFT TO NEUTRAL.IF THIS HAPPENS, THE SELECTOR LEVER POSITION INDICATOR WITHIN THE INSTRUMENT PANEL WILL FLASH.IN ADDITION, THE DEPRESS BRAKE PEDAL INDICATOR LIGHT WILL BE ILLUMINATED, ALERTING THE DRIVER TO APPLY THE BRAKES.IN HEAVY TRAFFIC, THE ABRUPT SHIFT TO NEUTRAL COULD LEAD TO A CRASH WITHOUT WARNING.VOLKSWAGEN ESTIMATED THAT LESS THAN ONE PERCENT OF THE RECALLED VEHICLES MAY CONTAIN THE DEFECT CONDITION. ODI IDENTIFIED 40 COMPLAINTS THAT APPEAR TO BE RELATED TO THE TEMPERATURE SENSOR DEFECT CONDITION DESCRIBED BY VOLKSWAGEN.VOLKSWAGEN RECEIVED 139 COMPLAINTS RELATED TO THE CONDITION, WITH 7 INVOLVING VEHICLES REPORTED TO ODI, RESULTING A 172 TOTAL COMPLAINTS TO ODI AND VOLKSWAGEN.ALL OF THESE COMPLAINTS INVOLVE THE MY 2009 AN 2010 VEHICLES SUBJECT TO RECALL 09V-333. ODI ALSO IDENTIFIED COMPLAINTS OF HARSH/JERKY SHIFTING IN SOME VOLKSWAGEN VEHICLES WITH DSG.VOLKSWAGEN ATTRIBUTED THIS CONDITION, WHICH TYPICALLY OCCURS AT VERY LOW SPEEDS, TO EXCESSIVE WEAR IN THE BUSHINGS OF THE TWO SOLENOID VALVES IN THE MECHATRONIC UNIT THAT CONTROL CLUTCH OPERATION.VOLKSWAGEN DOES NOT BELIEVE THAT THE THIS CONDITION IS A SAFETY DEFECT BECAUSE THE CHANGES IN SHIFT QUALITY DEVELOP GRADUALLY OVER TIME, DO NOT CAUSE A LOSS OF MOTIVE POWER AND HAVE NOT RESULTED IN ANY FATALITIES, INJURIES OR SERIOUS CRASHES (THERE WERE THREE REPORTED PROPERTY DAMAGE INCIDENTS RESULTING IN MINOR BODY DAMAGE IN VERY LOW SPEED, PARKING MANEUVERS).VOLKSWAGEN ADDRESSED THIS PROBLEM IN THE FIELD WITH A CUSTOMER SERVICE PROGRAM THAT INCLUDES THE REPLACEMENT OF POTENTIALLY AFFECTED MECHATRONIC UNITS AS WELL

THE RPMS ONLY GO TO 4000 THE HEADLIGHTS ARE CONSTANTLY BLOWN, ONE OF THE FANS DOES NOT WORK ....THERE ARE A LOT OF ELECTRICAL PROBLEMS, THE MASS AIR INTAKE FLOW ISSUES WITH THAT THERE'S JUST A LOT OF ISSUES. IT'S AFFECTED THE ELECTRICAL, SPEED CONTROL, AIRBAGS, VISIBILITY AND WIPER,LIGHTING, FUEL SYSTEM MASS AIR INTAKE SENSOR

NHTSA ID

11340270

Incident

Jan 1, 2020

Mileage

10 mi

EA888 HAS A KNOWN TIMING CHAIN AND CHAIN TENSIONER ISSUE THAT CAUSES ENGINE FAILURE.

NHTSA ID

11228885

Incident

Mar 12, 2018

Mileage

77,878 mi

THE CAR JERKS OUT WHEN U ACCELERATE. THE CAR FEELS LIKE IT'S IN MANUAL WHEN TAKING OFF.

NHTSA ID

11110978

Incident

Jul 9, 2018

Mileage

164,956 mi

2.0 T USE OF EXCESSIVE OIL BETWEEN OIL CHANGES

NHTSA ID

11072991

Incident

Aug 1, 2017

Mileage

128,500 mi

CAR LOSS POWER HAD TO BE TOWED TO VOLTSWAGON LATER THE HIGH PRESSURE FUEL PUMP WAS FOUND TO HAVE FAILED CAUSING A LOST OF POWER WHILE ON THE ON RAMP TO THE HIGHWAY. THERE WAS ALSO DAMAGE DONE TO THE MOTOR FROM THE INTERNAL METAL FRAGMENTS FROM WHERE THE PUMP WORKS WITH THE CAM SHAFT AND THE METAL FELL INTO THE MOTOR. HAD TO HAVE A NEW ENGINE REPLACE MENT MILEAGE 135000.

NHTSA ID

11035352

Incident

Jun 12, 2017

Mileage

135,000 mi

RECENTLY I PREFORMED A ROUTINE MAINTENANCE CHECK ON MY VEHICLE AND AS SUGGESTED BY ALL MARK 5 GTI OWNERS I CHECKED THE CAM FOLLOWER. I FOUND THE CAM FOLLOWER COMPLETELY WORN THROUGH. I CONTACTED VW TO MAKE SURE I WAS UNDER THE EXTENDED WARRANTY HANDED OUT TO ALL 2006-2007 AND SOME 2008 OWNERS TO FIND OUT I WAS NOT UNDER THE WARRANTY EXTENSION. RIGHT NOW I HAVE A THE PIECE OFF MY OLD CAM FOLLOWER SOMEWHERE IN MY ENGINE AND VW REFUSES TO SERVICE MY VEHICLE DUE TO THEIR NEW IMPROVED MODEL APPARENTLY THAT MANY OTHER OWNERS ARE EXPERIENCING. VW KNOWS THAT THE CAM FOLLOWER IS FAULTY BUT REFUSES TO SERVICE MANY OTHER 2008 OWNERS SUCH AS MYSELF. RIGHT NOW IT FEELS LIKE MY CAR IS A TICKING TIME BOMB WITH THE CAM FOLLOWER PIECE SOMEWHERE IN THE ENGINE.

NHTSA ID

10926335

Incident

Nov 15, 2016

Mileage

84,440 mi

THE CAM FOLLOWER HAS PREMATURELY WARN OUT CAUSING THE INTAKE CAMSHAFT TO WEAR PREMATURELY AS WELL, WHICH HAS IN TURN CAUSED THE HIGH PRESSURE FUEL PUMP TO FAIL. THIS IS A LONG-TERM, DEGENERATIVE ISSUE. VOLKSWAGEN HAS EXTENDED THE WARRANTY ON THESE PARTS FOR SOME 2006-2008 GTI'S BUT NOT MY VIN. THEIR WARRANTY EXTENSION WAS NOT BROAD ENOUGH AS THESE SAME PARTS HAVE FAILED IN MY CAR.

NHTSA ID

10899349

Incident

Aug 15, 2016

Mileage

128,000 mi

I'VE RECENTLY HAD FREQUENT HEADLIGHT BULB FAILURES AND OTHER HEADLIGHT RELATED ISSUES DURING MY OWNERSHIP OF THE CAR. PRIOR TO INSTALLING ANOTHER EXPENSIVE NEW BULB I DID SOME INVESTIGATION INTO THE WIRING INSIDE THE HEADLIGHT HOUSING AND I WAS COMPLETELY STUNNED AND CONCERNED AT WHAT I FOUND. THE WIRING INSULATION/COVERING IS MISSING ON THE MAJORITY OF THE WIRES. ESPECIALLY AT THE MAIN CONNECTOR WHERE THE COVERING ON ALL WIRES IS MISSING. THE MAJORITY, APPROXIMATELY 80% OF THE WIRES ARE BARE. ANY WIRE INSULATION REMAINING IS CRACKED AND FRAIL. I AM CONCERNED ABOUT THE SAFETY OF THIS VEHICLES WIRING AND THE POTENTIAL FOR FIRE DUE TO ELECTRICAL SHORTS AS WELL AS THE POTENTIAL FOR THIS ISSUE TO CAUSE OTHER PROBLEMS WITH THE ELECTRICAL CIRCUIT OF THE CAR. THERE IS NO ROUTINE MAINTENANCE AS AN OWNER THAT COULD HAVE PREVENTED THIS FROM HAPPENING. I CONTACTED VOLKSWAGEN OF AMERICA AND I WAS TOLD THAT DUE TO THE AGE AND MILEAGE (103,257) OF THE VEHICLE THEY COULDN'T DO ANYTHING. I BELIEVE THIS TO BE AN ENGINEERING FAILURE TO PROVIDE ADEQUATE INSULATION TO THE WIRING IN AN ENVIRONMENT PRONE TO HEAT AND SHOULD BE SUBJECT TO A FORMAL INQUIRY OF OTHER VEHICLES OF THE SAME MAKE AND MODEL. THE HEADLIGHT FAILURE INDICATOR ON THE DASH CAME AS I STARTED THE CAR AND I VERIFIED THE LIGHT WAS OUT. THE WIRING ISSUE WAS FOUND WHILE THE CAR WAS STATIONARY DURING THE REPLACEMENT OF THE BULB.

NHTSA ID

10852395

Incident

Mar 29, 2016

Mileage

103,257 mi

VW Engine oil quality standards

VW Engine oil quality standards

Battery Testing and Charging Using Midtronics VAS6161 and or GRX3000VAS Charger. Update Tool terminology

Safety Related Inquiry and Reporting

Update to Volkswagen engine oil standards

Diagnostic assistance for excessive static current draw