1996 Volkswagen GTI

ODI HAS RECEIVED THREE REPORTS, INCLUDING THE PETITIONERS, REGARDING ALLEGED HOOD LATCH FAILURES.ALL OF THE ODI REPORTS INDICATE THE HOOD FLEW UP WHILE DRIVING.FOLLOWING A TELEPHONE INQUIRY, VOLKSWAGEN PROVIDED ODI WITH SOME LIMITED INFORMATION REGARDING SIX ADDITIONAL REPORTS OF HOOD FLY-UP FOR MODEL YEARS 1995 AND 1996.THIS INVESTIGATION WAS OPENED TO FURTHER STUDY THIS ISSUE.DEFECT DESCRIPTION:IT IS POSSIBLE THAT ON SOME OF THE AFFECTED VEHICLES THE BOLTS SECURING THE FRONT HOOD LATCH MAY LOSE THEIR SPECIFIED FASTENING TORQUE OVER TIME.SHOULD THIS HAPPEN, THE LATCH COULD MOVE OUT OF ITS DESIGN POSITION AND CAUSE DISENGAGEMENT OF THE HOOD STRIKER FROM THE LATCH.IN SOME VEHICLES THE LATCH MAY NOT HAVE BEEN PROPERLY ALIGNED DURING PRODUCTION.REPEATED OPENING AND CLOSING OF THE HOOD WITH AN IMPROPERLY ALIGNED LATCH COULD RESULT IN DAMAGE TO THE LATCH.EITHER CONDITION COULD RESULT IN UNEXPECTED OPENING OF THE HOOD AND COULD OBSTRUCT A PORTION OF THE DRIVER'S VIEW OF THE ROAD WHILE DRIVING, AND RESULT IN AN ACCIDENT.REMEDY: VOLKSWAGEN OF AMERICA, INC. WILL INITIATE A VOLUNTARY SAFETY RECALL INSTRUCTING ITS AUTHORIZED DEALERS TO CHECK THE HOOD LATCH AND SECURING BOLTS AND REPLACE THEM IF NECESSARY.

TL* THE CONTACT OWNS A 1996 VOLSWAGEN GTI. HE STATED WHILE DRIVING 60 MPH THE VEHICLE WAS SIGNIFICANTLY LOSING SPEED TO 30 MPH AND THEN RE-GAIN NORMAL SPEED AFTER 10 SECONDS. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE CAMSHAFT WAS INOPERABLE AND NEEDED TO BE REPLACED. THE VEHICLE WAS BEING REPAIRED AT THE OWNER'S EXPENSE. THE VIN WAS UNAVAILABLE. THE MANUFACTURER WAS CONTACTED WHO ADVISED THAT THE VEHICLE WAS OUT OF WARRANTY. THE FAILURE AND CURRENT MILEAGES WERE 118,000. THE VIN WAS UNAVAILABLE.

NHTSA ID

10340783

Incident

Aug 10, 2009

Mileage

118,000 mi

ABS MODULE FAILURE. *TR

NHTSA ID

10240230

Incident

Mar 10, 2008

CAR ALARM WOULD GO OFF WHEN EXITING THE VEHICLE AND THE HORN WOULD GO OFF. THE FAILURE OCCURED WHILE DRIVING ON A MAIN ROAD, THE ALARM HORN ENGAGED AND WOULD NOT SHUT OFF. AFTER APPROXIMATELY 10 MINUTES OF CONTINUOUS HONKING THE WIRES TO THE ALARM HORN STARTED TO MELT. I ATTEMPTED TO DISCONNECT THE POWER TO THE HORN AND WAS BURNED BY THE WIRES. EVENTUALLY THE HORN DIED BUT SMOKE CONTINUED TO POUR OUT FROM UNDERNEATH THE COWLING.

NHTSA ID

10126236

Incident

Jun 10, 2003

Mileage

100,000 mi

THE REVERSE GEAR IS VERY WEAK IN STANDARD TRANSMISSIONS.THE GEAR CHIPS THEN BREAKS OFF AND FALLS INTO THE DIFFERENTIAL CAUSING AN EXPLOSION OF THE HOUSING AND THE LOSS OF ALL THE GEAR FLUID. REPLACEMENT OF COMPLETE UNIT IS THEN NECESSARY. THIS WILL BE MY THIRD TRANSMISSION IN 56000 MILES. LOCAL DEALERS JUST POINT FINGERS TO THE DRIVER OF THE CAR. I ALSO KNOW OF THREE OTHER PEOPLE THAT HAVE HAD THE SAME PROBLEM. THIS HAS TO BE MORE THAN A MERE COINCIDENCE. FURTHERMORE, ALL THESE INCIDENCES OCCUR ON VOLKSWAGEN GTI'S, JETTAS AND GULFS BETWEEN THE YEARS OF 1993-1998. IT IS NOT THE FAULT OF THE DRIVER. SOMETHING NEEDS TO BE DONE. THESE TRANSMISSIONS ARE NOT SAFE NOR RELIABLE.

NHTSA ID

10121095

Incident

Apr 20, 2002

Mileage

40,000 mi

THE VEHICLES DOOR HANDLE CAME OFF IN THE CONSUMERS HAND. *NLM

NHTSA ID

10017928

Incident

Apr 12, 2003

Mileage

140,000 mi

ELECTICALCOMPONENTS KEEP GOING, NOW SUN ROOF WON'T CLOSE

NHTSA ID

755195

THE CONSUMER HAS BEEN EXPERIENCING PROBLEMS WITH COMPUTER SYSTEM. THE COMPUTER MODULE HAS FAILED TO OPERATE 8 TIMES. VEHICLE HAS STALLED ON SEVERAL OCCASIONS BECAUSE OF THE PROBLEM. VEHICLE IS THEN TOWED BECAUSE IT WILL NOT RESTART. THE MANUFACTURER HAS BEEN CONTACTED. *AK

NHTSA ID

831249

Incident

Aug 21, 1998

LUGS:NUTS:BOLTS, ONE ON EACH TIRE, CANNOT BE REMOVED. DEALER WANTED TO CHARGE EXTRA FOR A SPECIAL DRILL TO REMOVE LUGS NUTS AND BOLTS. DEALER INFORMED CONSUMER THIS PROBLEM WAS PERTAINING TO LUGS: NUTS:BOLTS MANUFACTURER. (1-800/669-8788). *AK

NHTSA ID

828438

Incident

Sep 23, 1998

Updated to include additional models and model year applicability.

The part number listed in the document is to be returned if it meets the criteria provided.

Condensation and or water droplets visible on inside of exterior light lenses. TB updated to include model year 2019 applicability.

This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part numbers going forward.

VAS 6154 Replacement Part Setup Guide

This communication is to update our ProFi dealers of the current status of the latest inbound and outbound ProFi requests.