2006 Chevrolet Aveo Problems

The interior dash caught on fire and burned only in the middle of the dashboard. This happened hours after it started smoking inside the car and the headlights would not turn off even though they were already off.

Lights malfunction. Headlights dim intermittently, turn signal causes headlights to turn off, dashboard lights do not work, running lights work intermittently. The splice pack in the fuse box is burnt and so are the wires connected to it.

A DEER WAS HIT IN THE FRONT HOOD AND BUMPER OF THIS CAR WHILE DRIVING ON A STRAIGHT SECTION OF COUNTY ROAD AND NONE OF THE AIRBAGS DEPLOYED.

SO I WAS AT HOME AND MY CAR WAS PARKED OUTSIDE AND IT CAUGHT ON FIRE IN THE INSIDE. THE FIRE DEPARTMENT CAME AND PUT OUT THE FIRE. IT DAMAGED THE DASHBOARD AND THE WINDOW. I HAVE READ THAT IT IS A RECALL ON MY VEHICLE WHICH CAUSES IT TO CATCH ON FIRE. MANUFACTURER RECALL NUMBERA140093 NHTSA RECALL NUMBER14V261 RECALL STATUSRECALL INCOMPLETE

The splicer connected to the fuse box in the engine burns up after a while of use causing the Dash lights, right brake light and front marker light to not work at night. It is a major safety issue and hundreds/thousands of complaints online (via google) have been made about it burning up.

MY ELECTRICAL PANEL WAS DEFECTIVE, SENT IN 4 TIMES AND THEY CLAIMED TO REPLACE THE ELECTRICAL PANEL. IT WAS RIGGED BY CROSSING WIRES AND LIGHTS IN DASH DONT WORK AND RADIO TAPPED INTO WIPERS. THEN CALIPERS,SWAY ARMS,SHOCKS, CATALYTIC CONVERTER WAS DEFECTIVE AND ALSO NEVER REPLACED RIGHT. PAID SOMEONE TO PUT EMISSIONS STICKER TO PASS.

This is happening to my car. Would like them to fix it . Manufacture defect and it is a huge safety issue. Effect pedal function. Some customers may comment on an intermittent malfunction indicator lamp (MIL) being Illuminated with a message or an indicator that displays Reduced Engine Power. The technician may observe on a scan tool DTC P2138 - Accelerator Pedal Position (APP) Sensor 1-2 Correlation set as Current or in History. This condition may be caused by water intrusion into the instrument panel (IP) to body harness connector, which carries the APP sensor signals to the ECM/PCM. This water intrusion results in a voltage difference between APP Sensor 1 and APP Sensor 2 that exceeds a predetermined value for more than a calibrated period of time, setting P2138. This technical bulletin provides repair information for repairing the ip to body harness connector to correct a customer concern for intermittent malfunction indicator lamp (mil) illuminated with reduced engine power displayed and dtc p2138 set. Known issue. Has not been recalled yet. https://www.tsbsearch.com/Chevrolet/07-06-04-019E

TL* THE CONTACT OWNS A 2006 CHEVROLET AVEO. THE CONTACT STATED THAT RADIATOR FLUID MIXED WITH THE TRANSMISSION FLUID. AS A RESULT, THE TRANSMISSION HESITATED WHEN THE CONTACT ATTEMPTED TO SWITCH GEARS AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS DRIVEN TO COMMUNITY CHEVROLET (200 W OLIVE AVE, BURBANK, CA 91502, (866) 610-2450) WHERE IT WAS DIAGNOSED THAT THE CLOCK SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE CHECK ENGINE AND AIR BAG WARNING INDICATORS WERE ILLUMINATED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 87,794.

This is happening to my car. Would like them to fix it . Manufacture defect and it is a huge safety issue. Effect pedal function. Some customers may comment on an intermittent malfunction indicator lamp (MIL) being Illuminated with a message or an indicator that displays Reduced Engine Power. The technician may observe on a scan tool DTC P2138 - Accelerator Pedal Position (APP) Sensor 1-2 Correlation set as Current or in History. This condition may be caused by water intrusion into the instrument panel (IP) to body harness connector, which carries the APP sensor signals to the ECM/PCM. This water intrusion results in a voltage difference between APP Sensor 1 and APP Sensor 2 that exceeds a predetermined value for more than a calibrated period of time, setting P2138. This technical bulletin provides repair information for repairing the ip to body harness connector to correct a customer concern for intermittent malfunction indicator lamp (mil) illuminated with reduced engine power displayed and dtc p2138 set. Known issue. Has not been recalled yet. https://www.tsbsearch.com/Chevrolet/07-06-04-019E

MY CAR JUST NOT RUNNING RIGHT I JUST BOUGHT IT AND SEEN A RECALL

TL* THE CONTACT OWNS A 2006 CHEVROLET AVEO. THE CONTACT STATED THAT RADIATOR FLUID MIXED WITH THE TRANSMISSION FLUID. AS A RESULT, THE TRANSMISSION HESITATED WHEN THE CONTACT ATTEMPTED TO SWITCH GEARS AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS DRIVEN TO COMMUNITY CHEVROLET (200 W OLIVE AVE, BURBANK, CA 91502, (866) 610-2450) WHERE IT WAS DIAGNOSED THAT THE CLOCK SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE CHECK ENGINE AND AIR BAG WARNING INDICATORS WERE ILLUMINATED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 87,794.

MY KEY WAS STUCK IN THE IGNITION BETWEEN THE "ACCESSORY" SETTING AND HAVING THE CAR RUNNING. I GOOGLED THE PROBLEM; RECOMMENDED FIX WAS TO REMOVE FUSE FOR RADIO, SO I DID. I WAS ABLE TO REMOVE KEYS FROM IGNITION BUT WHEN I WAS READY TO LEAVE AGAIN I COULD NOT SHIFT OUT OF 'PARK.' I PUT THE RADIO FUSE BACK IN, AND MY GEARSHIFT & TRANSMISSION WORK PERFECTLY. EVERY TIME I GET OUT OF MY CAR I HAVE TO PULL THE RADIO FUSE OUT, REMOVE MY KEYS, THEN INSTALL THE RADIO FUSE AGAIN SO THAT I CAN GET OUT OF 'PARK' WHEN I NEED TO DRIVE LATER. *TR

I FELL ASLEEP AT THE WHEEL WENT THROUGH THE MEDIAN WHILE DRIVING DOWN THE INTERSTATE WHERE THE SPEED LIMIT IS 80 OUTSIDE DOUGLAS WYOMING. AS I WOKE WHEN THE CAR WAS IN THE MIDDLE OF THE MEDIAN MY CAR IMPACTED A CONCRETE CULVERT AND WENT THROUGH THE GUARD RAIL ONTO THE OTHER SIDE OF THE INTERSTATE WHERE IT FINALLY CAN TO A STOP ACROSS THE OTHER TWO LANES OF ON COMING TRAFFIC ALL WITH NO AIR BAG DEPLOYMENT. *TR

REPLACED EVERY EMISSIONS AT LEAST FOUR/TWO SETS OF TIRES/SHOCKS/STRUTSENGINE SEALS/SIGNAL LIGHTS/HEADLIGHT /TAIL LIGHT PRETTY MUCH EVERY LIGHT INCLUDING INSIDE CAR THAT I CAN THINK OF/ REPLACED TWO BATTERIES/ HAD CORROSION TAKEN OUT OF DIFFERENT PARTS UNDER HOOD AS WELL REPLACE MANY WIRES UNDER HOOD. I HAVE PUTTING MONEY IN THIS CAR SINCE 2009. I AM DONE IT HAS A TOTAL OF 43,000 MILES .DO NOT BUY ONE. *TR

Front subframe. Pulls one way during acceleration and pulling the opposite way during braking

MY ELECTRICAL PANEL WAS DEFECTIVE, SENT IN 4 TIMES AND THEY CLAIMED TO REPLACE THE ELECTRICAL PANEL. IT WAS RIGGED BY CROSSING WIRES AND LIGHTS IN DASH DONT WORK AND RADIO TAPPED INTO WIPERS. THEN CALIPERS,SWAY ARMS,SHOCKS, CATALYTIC CONVERTER WAS DEFECTIVE AND ALSO NEVER REPLACED RIGHT. PAID SOMEONE TO PUT EMISSIONS STICKER TO PASS.

POWER STEERING FLUID IS LEAKING OUT, RELEASE VALVE GETS STUCK.

I TRY TO PUT A SEAT BELT ON A CHILD IN THE BACK SEAT AND IT DOSE NOT WORK AT ALL. THE STEERING ON MY AVEO IS ALSO NOT SAFE IT FEELS AS IF MY AXEL ON MY CAR IS GOING TO BRAKE? ALSO THIS CAR HAS CAUGHT ON FIRE AS I WAS ON THE FREEWAY COMING FROM WORK. I HAVE REPLACE THE CADILLAC CONVERTER ON THIS CAR AS WELL AS 2,000 OTHER REPAIRS INTO MY CAR. IT IS VERY DANGEROUS KNOWING THAT ONE DAY WHEN I GET IN MY CAR IT MAY CAUGHT ON FIRE IF IT GET TO HOT. IT VERY SAD ALL I WOULD LIKE TO DO IS GO TO SCHOOL AND WORK GET HOME SAFE GUARANTEED EVERY DAY.

Front subframe. Pulls one way during acceleration and pulling the opposite way during braking

BURNT PLASTIC SMELL INSIDE THE VEHICLE. FRONT OF DASHBOARD AND STEERING COLUMN PRODUCING EXCESSIVE HEAT. HOT TO TOUCH AND THE IGNITION KEY IS HOT. *TR

PARKED THE CAR IN A PARKING SPOT AT A STORE, WENT INSIDE FOR A LITTLE WHILE, CAME BACK OUT TO HAVE THE SHIFTER NOT SHIFT FROM PARK AFTER BRAKE PEDAL WAS DEPRESSED. I'VE ALREADY TRIED REPLACING THE BRAKE SWITCH NEAR THE BRAKE PEDAL AND REPLACED THE BRAKE TRANSAXLE SOLENOID. NEITHER OPTION HAS WORKED. TOOK TO THE DEALERSHIP TO HAVE THEM LOOK AT IT. $80 LATER, THEY WANT OVER 400 TO FIX THE SHIFTER BY REPLACING THE ENTIRE SHIFT ASSEMBLY. FROM WHAT I HAVE RESEARCHED ONLINE, THIS IS NOT THE ISSUE. THIS SHOULD BE AUTOMATICALLY TAKEN CARE OF BY THE DEALERSHIP AT NO COST TO US. IT STILL IS NOT FIXED BECAUSE WE CANNOT AFFORD TO SPEND ANOTHER 400 DOLLARS TO FIX SOMETHING THAT FAILED RIGHT AFTER THE 36,000 MARK. *TR

MY WIFE HAS A 2006 CHEVY AVEO THAT THE SHIFTER WENT BAD, FOR AN AUTOMATIC TRANSMISSION. IT IS GOING TO COST $400.00 TO REPAIR. THE CAR HAS 76,000 MILES ON IT. SHIFTERS SHOULD NEVER GO BAD. *TR

THIS CAR HAS A DEFECTIVE THROTTLE BODY AND IAC(IDLE CONTROL ASSEMBLY) .I HAVE TO TRY TO CRANK IT 7-8 TIME BEFORE IT WILL STAY RUNNING.I AM PHYSICALLY DISABLED AND ON A FIXED INCOME ,THEY TOLD ME THAT IT WILL COST $1000 TO $1500 TO FIX THIS CAR WHICH THERE IS NO WAY I CAN PAY THIS LARGE AMOUNT. I BELIEVE THAT CHEVORLET SHOULD DO THE RIGHT THING AND PUT THERE DEFECT ON THE RECALL LIST.

MY CHEVROLET AVEO 2006 AUTOMOBILE HAS SEVERAL ISSUES THAT NEED TO BE ADDRESSED IMMEDIATELY. MY CAR HAS ISSUES WITH SHIFTING AND IT SUDDENLY SPEEDS UP FOR UNKNOWN REASONS. MY CHECK ENGINE LIGHT COMES ON ALL OF THE TIME. I TIGHTEN THE GAS CAP AS THE MANUAL STATES AND IT REMAINS ON. ALSO, THERE COULD BE POSSIBLE PROBLEMS WITH THE GAS LINE AS THE CAR IS MAKING A LOUD SOUNDS WHEN I ACCELERATE AND SMELLS LIKE GAS. I RECEIVED A SAFETY RECALL NOTICE LAST YEAR AND WAS TOLD THAT I WOULD BE CONTACTED BY MAIL WHEN PARTS WERE READY. AFTER 6 MONTHS, I CONTACTED CHEVROLET WHO REPLIED THAT THE PARTS WERE STILL NOT READY AFTER NO RESPONSE FROM CHEVROLET. I HAD TO DO THE LEG WORK MYSELF. THEIR ABSOLUTE DISREGARD FOR IMMEDIATE ACTION IS UTTERLY REPREHENSIBLE. PEOPLE ARE BEING KILLED OR INJURED BECAUSE OF THEIR LACK OF OR INABILITY TO ADDRESS THE SITUATION. *JS

WENT TO LOCK DRIVER SIDE DOOR AND INSIDE LOCK WOULD NOT PUSH DOWN AND FOUND OUTSIDE LOCK HAD FALLEN INSIDE THE DOOR PANEL. ONLINE RESEARCH INDICATES THIS IS A VERY COMMON PROBLEM ON AVEOS DUE TO DEFECTIVE PLASTIC PARTS AND DEALERSHIPS SEEM TO BE CHARGING VERY HIGH AMOUNT TO REPAIR. SEEMS THERE SHOULD BE A RECALL PROVIDED BY GMC TO FIX THIS PROBLEM AS PREVENTS BEING ABLE TO SECURE THE VEHICLE AND BELONGINGS AND OCCUPANTS OF THE VEHICLE. *TR

2006 CHEVY AVEO WITH APP. 82,000 MILES. LOCK ON DRIVER'S SIDE FELL IN, CANNOT LOCK THE DOOR. *KB

I TRY TO PUT A SEAT BELT ON A CHILD IN THE BACK SEAT AND IT DOSE NOT WORK AT ALL. THE STEERING ON MY AVEO IS ALSO NOT SAFE IT FEELS AS IF MY AXEL ON MY CAR IS GOING TO BRAKE? ALSO THIS CAR HAS CAUGHT ON FIRE AS I WAS ON THE FREEWAY COMING FROM WORK. I HAVE REPLACE THE CADILLAC CONVERTER ON THIS CAR AS WELL AS 2,000 OTHER REPAIRS INTO MY CAR. IT IS VERY DANGEROUS KNOWING THAT ONE DAY WHEN I GET IN MY CAR IT MAY CAUGHT ON FIRE IF IT GET TO HOT. IT VERY SAD ALL I WOULD LIKE TO DO IS GO TO SCHOOL AND WORK GET HOME SAFE GUARANTEED EVERY DAY.

THE SAME TIME THE RECALL FOR DAYTIME RUNNING LIGHTS MODULE CAME MY DAYTIME RUNNING LIGHTS INDICATOR STARTED FLASHING AND MY AIRBAG LIGHT CAME ON. I TOOK IT TO DEALER TO FIX DAYTIME RUNNING LIGHTS MODULE, I ALSO HAD AIRBAG LIGHT CHECK AND THEY SAID THE WIRING HARNESS MELTED AND IT COST ME OVER $300.00 TO FIX. IS THIS CONNECTED TO DAYTIME RUNNING LIGHT MODULE PROBLEM? IF SO I WOULD LIKE MY MONEY BACK! LET ME KNOW PLEASE.

CHECK ENGINE LIGHT CONSTANTLY COMING ON. JUNE, 2011 LIGHT KEPT COMING ON EVEN AFTER REPLACEMENT FOR O2 SENSORS. JULY, 2011 THERMOSTAT HOUSING GOES OUT WITHOUT CHECK ENGINE LIGHT COMING ON. HOUSING REPLACED AND LIGHT KEEPS COMING BACK ON AGAIN. ALTERNATOR WENT OUT RIGHT AFTER WARRANTY EXPIRED. WINDSHIELD CRACKED WHEN TEMPERATURE DROPPED QUICKLY OUTSIDE. OTHER PARTS REPLACED AS WELL. *KB

THE AIRBAG LIGHT WOULD NOT TURN OFF, STILL AT THE DEALER WAITING FOR A PART TO COME IN, IT WAS A FAULTY FUSE IN THE STEERING WHEEL IF IN A ACCIDENT AIRBAGS WOULD NOT DEPLOY. 2.THE HEAT STARTED WORKING LESS AND LESS, WHEN I WOULD COME TO A STOP THE AIR WOULD COME OUT COLD, IT FELT LIKE I HAD THE AIR CONDITIONING ON. IF IT SAT FOR TOO LONG THE TEMPERATURE WOULD START TO RISE AND IT WOULD START TO OVERHEAT. *TR

REPLACED EVERY EMISSIONS AT LEAST FOUR/TWO SETS OF TIRES/SHOCKS/STRUTSENGINE SEALS/SIGNAL LIGHTS/HEADLIGHT /TAIL LIGHT PRETTY MUCH EVERY LIGHT INCLUDING INSIDE CAR THAT I CAN THINK OF/ REPLACED TWO BATTERIES/ HAD CORROSION TAKEN OUT OF DIFFERENT PARTS UNDER HOOD AS WELL REPLACE MANY WIRES UNDER HOOD. I HAVE PUTTING MONEY IN THIS CAR SINCE 2009. I AM DONE IT HAS A TOTAL OF 43,000 MILES .DO NOT BUY ONE. *TR

THE BRAND NEW HANKOOK TIRES ON MY 2006 CHEVY AVEO ARE DEFECTIVE. I HIT A POT HOLE AND THE FIRST ONE WAS RUINED JUST 26 DAYS AFTER I DROVE THE CAR OFF THE DEALER LOT. THE REPLACEMENT TIRE I JUST BOUGHT FOR $265.55 POPPED TONIGHT 3 DAYS AFTER I DROVE OFF THE REPAIR SHOP LOT. *JB

I HAVE CONTACTED YOU BEFORE. FIRST, SOME MONTHS AFTER I PURCHASED CAR WHEN I TURNED OFF CAR IGNITION WOULD NOT TURN COMPLETELY OFF. WENT ON FOR TWO + YEARS USED WD FORTY FINALLY GOT IT TO WORK MOST OF THE TIME. HAD TO GO BACK TO CAR HOURS AFTER DRIVING UNTIL IT WOULD RELEASE KEY AND TURN ALL THE WAY OFF. THE DASH LIGHT STAYED ON AND DRAINED THE BATTERY. I NOTICED, (NOT ALL THE TIME) THAT THE GAS PEDAL UNDER MY FOOT FELT REALLY HOT; THOUGHT IT WAS BECAUSE IT WAS A WARM DAY ETC, BUT IT HAPPENED IN COOL WEATHER ALSO. REPLACED HEAD GASKET SEAL TWICE STILL HAVE OIL LEAK. ABOUT THREE YEARS AGO + OR -, HAD TO HAVE BALL SOMETHING IN FRONT WHEEL REPLACED. IT BROKE AGAIN HAD IT DONE AGAIN. WHEN I ACCELERATE LEFT FRONT WHEEL RATTLES. I DRIVE SLOW IN IT AND ONLY GO TO SCHOOL TO GET GRAND KIDS AND TO STORE PRIMARILY. WENT TO A BIG CITY AND CAR( DRAGGED, WOULD NOT ACCELERATE )ON UP RAMPS, WENT TO ORLANDO ONCE TO VISIT FAMILY, SAME THING. TWO WEEKS AFTER PURCHASE CAR ACTED DEAD, WOULD NOT START,TOOK OFF BATTERY CABLES, REPLACED THEM AND CAR STARTED. I CALLED THE PH # IN OWNERS MANUAL AT ONSET OF PROBLEMS, THEY SAID I WOULD HAVE TO PAY FOR DIAGNOSTICS. I HAD REPAIRS DONE BY MECHANICS NOT ASSC'D W/ DEALERSHIP, BECAUSE OF COST. I SPENT A LOT ON REPAIRS FROM EARLY ON AFTER PURCHASE. I BOUGHT A CAR FOR RELIABILITY, TO TRANSPORT MY GKIDS AND GET TO GO VISIT MY FAMILY MEMBERS I FL AND TENN, BUT I ONLY WENT TO VISIT ORLANDO ONCE BECAUSE I WAS AFRAID OF DRIVING IN THE MOUNTAINS. *TR UPDATED 4/1/15*CN

TIRES NEVER LAST VERY LONG, MAY GET 10,000 MILES OUT OF A SET SINCE WE BOUGHT THE CAR. CAR HAS BEEN MAKING ALOT OF NOISE GOING OVER ANY LITTLE BUMP AND WE CHANGED THE SHOCKS AND ONE WAS BAD, STARTED AROUND 90,000. IT IS STILL MAKING SOME NOISE AND THE DEALER SAID THAT THE REAR AXLE BUSHING IS BAD AND WOULD HAVE TO GET A NEW REAR AXLE $$$-$$$$. ALSO THE PAINT ALONG THE BOTTOM OF BOTH DOORS ON THE OUTSIDE ON BOTH SIDES HAD BEEN STARTING TO COME OFF. *TR