2020 Chevrolet Malibu Owner Complaints

My 2020 Chevrolet Malibu experienced a sudden and severe electrical failure after driving through normal roadway water. Immediately afterward, the vehicle displayed multiple safety‑critical warnings including loss of power steering assist, Electronic Stability Control (ESC) faults, brake control faults, and reduced propulsion. A GM dealership inspected the vehicle, scanned the modules, and found more than a dozen network and chassis‑related diagnostic trouble codes, including: B3979, U0164, B1325, B3122, U0121, C0196, C0460, B1011, B097B, B3205, C056E, C056D, U0420, U1510, C0545, U0422. These codes indicate failures in the steering system, brake control module, stability control system, body control module, and multiple CAN‑bus communication networks. The dealership confirmed: – No physical damage – No evidence of collision or impact – No evidence of flood damage – The suspected failed component is the electric power steering rack (GM part 85621696) – The part is not available, meaning the vehicle cannot be repaired – I would be responsible for diagnostic and repair costs This is a major safety concern. The vehicle can lose steering assist, stability control, and braking support without warning. The inability to obtain the required steering component makes the vehicle unrepairable and unsafe to operate. I am reporting this because this appears to be a systemic electrical/network failure affecting critical safety systems. I believe this defect poses a significant risk to drivers, passengers, and other motorists. The attached photo is a is a picture of the printout the Chevrolet dealership Service Manager provided to me.

NHTSA ID

11755071

Incident

Jul 27, 2026

So while I was driving my car going 60 on the highway it seemed to be having electrical issues all the lights on my dash popped on then popped off and only a few lights actually stayed on I can't remember exactly but the check engine and my abs stayed on and then on my screen it read to me warning power steering fault my headlights were dimming on and off like my car was going to die, so I had to pull over for my safety and other drivers safety, so after I pulled over safely I shut my car completely off and waited about 5 minutes and turned it back on when it turned back on the only light that popped on my dash was the check engine light, but the check engine light had actually been on the dash for a while after I replaced the 21 fuses that were missing that I didn't know were missing when I purchased the vehicle as is from a dealership the only thing that made me decide to check my fuses was because my check engine light was popping on and off and would stay off for a while then come back on a code reader said it was something to do with my turbo that code it was just very odd and the car was shifting weird 3 or 4 months after the purchase date XXX also after I put all the fuses back in a ton of codes popped up others safety and mine were at risk as I didn't really have control of my vehicle when it was doing that and it started breaking itself when I wasn't even hitting the break it was like jolting it's self and stopping slightly. I took my car to AAMCO Total car Care for a free diagnostic test, and then I had recently took my car to a Chevy dealership in Nampa Idaho off garrity boulevard because online it had told me there was recalls for my car and that recall was exactly what I was thinking had started off as the original problem originally leading into the other problems I got told to bring my car in then the fed me information saying pretty much it was a bust and that specific Malibu has no recall I think they just didn't want to work on it

NHTSA ID

11754086

Incident

May 4, 2026

The contact owns a 2020 Chevrolet Malibu. The contact stated that while attempting to shift the vehicle into park, the transmission failed to shift into park after several attempts. The contact referenced TSB: 19-NA-206; as a possible cause for the failure; however, the VIN was not included in the TSB. The vehicle was taken to a dealer where it was diagnosed with gear shifter failure. The gear shifter was replaced, and the vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 50,198.

NHTSA ID

11752681

Incident

Feb 1, 2026

Mileage

50,198 mi

While attempting to enter a high-speed expressway, the transmission malfunctioned, preventing normal acceleration. The vehicle could only accelerate very slowly but managed to maintain a limited speed, creating a hazardous situation while trying to merge into fast-moving traffic. I was able to navigate the vehicle off the expressway, at which point the transmission completely failed and the vehicle died. The vehicle was towed to an authorized dealership service center, where technicians diagnosed a total internal failure of the CVT transmission requiring complete replacement. Mind you, the vehicle is under 6 years old and has fewer than 90,000 total miles, and this is the second time the transmission on this vehicle has suffered a total failure and required a complete replacement. Prior to this mechanical breakdown, there were no warning lights, abnormal symptoms, or performance issues indicating an impending transmission failure. The vehicle is currently available for inspection.

NHTSA ID

11749433

Incident

Jun 25, 2026

While driving, the brakes became hard and the vehicle was difficult to stop. The brake pedal required excessive force, brake assist was reduced, and the stopping distance increased, creating a serious safety hazard. The check engine light had been illuminated for approximately two years before the brake failure occurred. In January 2024, I reported brake-related concerns to a Chevrolet dealership while the vehicle was under warranty, but the root cause was not diagnosed. In November 2025, after the brake pedal became hard, an independent repair facility inspected the vehicle and determined the brake problem was caused by a failing engine vacuum pump. They advised that the vehicle be repaired by a Chevrolet dealership. By January 2026, the brake condition had worsened to the point that the vehicle was no longer safe to drive and had to be towed. A Chevrolet dealership later confirmed that the engine vacuum pump had seized and damaged the camshaft, requiring replacement of both components. The vehicle remains inoperable. The failed vacuum pump caused loss of brake assist, resulting in a hard brake pedal, reduced braking ability, and an increased risk of a crash. I believe this represents a serious safety defect because failure of the vacuum pump significantly impairs the driver’s ability to stop the vehicle safely. I understand GM has issued service information regarding vacuum pump failures on this engine, and I am submitting this complaint because I believe other drivers may experience the same dangerous brake failure.

NHTSA ID

11748641

Incident

Oct 31, 2025

Ejesitais to shift. Most of the times. Also shif to park when is o ready park.

NHTSA ID

11745075

Incident

Dec 31, 1969

Shift to park displaying when car is in park so it won't turn off and stalling out randomly with no warning or anything and being hesitant to go

NHTSA ID

11736695

Incident

May 5, 2026

May 7, 2026 National Highway Traffic Safety Administration 1200 New Jersey Avenue SE Washington, DC 20590 RE: Safety Defect Complaint – Brake System / Vehicle Control Concerns 2020 Chevrolet Malibu Dear NHTSA, I am submitting a safety complaint regarding persistent braking and vehicle control issues involving my 2020 Chevrolet Malibu. Prior to December 31, 2025, the vehicle exhibited jerking during braking, all dashboard gauges go to the left, warning lights, reduced power (20-25mph), and inconsistent braking behavior. This situation happens without warning, at any given time, even in the flow of traffic. An independent inspection indicated the brake system was in proper condition, suggesting a more complex underlying safety issue. The vehicle was taken to Reed-Lallier Chevrolet for diagnosis and remained there for approximately five months. During that time, I was not provided documentation confirming completion of a brake system diagnostic or a clear resolution path. Due to the extended delay without diagnosis, I no longer feel safe operating the vehicle. I am also concerned that prolonged inactivity without proper repair may have worsened the condition and increased risk of failure. Given the nature of the symptoms involving braking and vehicle control, I request review for potential safety-related investigation. Vehicle Information: 2020 Chevrolet Malibu VIN: Mileage:

NHTSA ID

11736449

Incident

Dec 31, 2025

To Whom It May Concern, ​I am writing to formally report a critical safety defect regarding my 2020 Chevrolet Malibu. This defect resulted in a life-threatening incident while I was driving on the highway, during which my vehicle failed to stop as required. ​While operating at highway speeds, the brake pedal became extremely hard to depress, making it nearly impossible to decelerate or bring the vehicle to a complete stop. This sudden loss of power assist forced me to manage an incredibly dangerous situation in high-speed traffic. Based on the symptoms, I am concerned that the brake booster vacuum pump has suffered an internal failure, a documented issue for this model year where oil sludge or debris causes the pump to seize. ​In addition to the physical resistance of the pedal, I am concerned about the reliability of the Electronic Brake Control Module (EBCM). The failure experienced on the highway demonstrates that this vehicle is unsafe for public roads, as the force required to engage the brakes in an emergency is far beyond safe operating standards. ​I request that the NHTSA investigate this brake failure and determine if a mandatory recall is necessary to prevent similar incidents from resulting in catastrophic collisions. ​Please contact me if you require further information Thank you [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11735781

Incident

Mar 21, 2026

Vehicle stalled/lost power while driving due to auto start/stop system.

NHTSA ID

11734207

Incident

Apr 25, 2026

I am writing to report a serious and dangerous issue that occurred with my 2020 Chevrolet Malibu LT on April 27th 2026. While driving on the interstate after work, my vehicle suddenly experienced a failure that made it extremely unsafe to operate. The brake pedal became extremely hard to press, and the vehicle did not want to slow down or stop properly. This created a very dangerous situation while I was driving at highway speeds. Additionally, I noticed that nearly all of the engine oil was gone, which is extremely concerning and may be related to the failure. Based on these symptoms, it appears the vacuum pump may have failed while the vehicle was in motion. This issue placed me at significant risk of an accident and could have resulted in serious injury. I am requesting an immediate investigation into this matter and assistance with repairs. I would also like to know if there are any recalls, known defects, or extended warranties related to this issue. Please advise on the next steps as soon as possible, as the vehicle is currently unsafe to drive.

NHTSA ID

11734196

Incident

Apr 27, 2026

When braking, the vehicle experiences a system failure. There is a loud impact, the dashboard shuts down, warning lights activate all gauges go to the left, and the vehicle loses power and enters a reduced speed mode before recovering. This has been ongoing and creates a dangerous driving condition. The dealership has had the vehicle over four months and has not diagnosed or repaired the issue. Please Note: I have attached the invoice sent to me on April 17, 2026, via email. The information in section 3 had been changed while I was sitting there. It originally state, engine repair needed. It said absolutely nothing about the reason I was there, which was what I am now describing. The description in section 3, has been worded incorrectly. It states I said, when coming to a stop, but it is not only when coming to a stop, but even if I am in flowing traffic and have to touch my brakes to slow down at any given time, there is a loud thump sound and a jolt, all of the dash lights come on, all the gauges go to the left, the warning lights are on and it has to sit there, not for a few seconds, but until those lights go back off and then it will move very slowly, until it decides to gain power. You have no warnings as to when it will happen or when the car will regain speed when it does happen. I gave pictures of the dash on April 17, 2026, as well and these pictures have the date December 31, 2025, on them. As I was having the issue while driving it to the dealership for repair. The invoice mentions [XXX] . I do not know her and have never met her. I only spoke with a man. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11733060

Incident

Dec 31, 2025

The contact owns a 2020 Chevrolet Malibu. The contact stated that while driving approximately 35 MPH, an unknown warning light illuminated, and the vehicle started to lose motive power. The contact stopped at a traffic signal and after depressing the accelerator pedal when the light changed, the vehicle stalled. The vehicle was restarted after several attempts, but the vehicle failed to exceed 5 MPH while accelerating. The contact stopped and the vehicle was towed to an independent mechanic. The vehicle was diagnosed, the battery was replaced, and the system was reset; however, the failure reoccurred and the vehicle was towed to a dealer. The vehicle was diagnosed, and it was determined that the front wiring harness needed to be replaced. The vehicle was repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 23,000.

NHTSA ID

11730116

Incident

Apr 14, 2025

Mileage

23,000 mi

Reduced Engine Power Light: The car limits acceleration, often accompanied by a check engine light. Stalling or Hesitation: Engine stalls or acts sluggish when accelerating, particularly in traffic. Limp Mode: The vehicle restricts speed, making it difficult to accelerate. The car stop working in the middle of the freeway and I was in the car with my child when it stop acceleration all gages in the car were going crazy, car was shaking bad finally car turn off. I was able to make it to the emergency lane of the freeway. There's similar complaints for 2020 Chevy Malibu but no recall has been done. Per my research it looks like a lot of this type of vehicles have problems with throttle body causing Engine stalls. Do the right thing and open up a vehicle recall, thank you!

NHTSA ID

11728914

Incident

Mar 31, 2026

While driving the brake pedal became hard to push out of no where. Once the car got to the shop it stopped cranking. The shop is stating that the brake vacuum pump is the cause of the brake pedal messing up, and that it also caused other engine damages estimating $3000.00

NHTSA ID

11726626

Incident

Feb 3, 2026

The contact owns a 2020 Chevrolet Malibu. The contact stated that while driving approximately 60 MPH on the freeway and depressing the brake pedal to slow down, the brake pedal was difficult to depress, and the vehicle failed to immediately stop. During the failure, the check engine and traction control warning lights were illuminated. The vehicle was slowly driven to the residence and parked. The cause of the failure was not yet determined. The local dealer was notified of the failure. The manufacturer was not yet contacted. The failure mileage was 85,547.

NHTSA ID

11722906

Incident

Mar 8, 2026

Mileage

85,547 mi

Several things have been going wrong with this car. I have only had it for about 7 months. Minimal driving. Got the car with 84,000 miles and it now has 88,000 miles. About 2 months ago the check engine light came on. Got it into a shop and they said an oil change may possibly help with this. Got the oil change, cleared the code, drove it around and check engine light came back on. Brought it back to the shop and now the entire valve cover needs replaced. It’s been about 2 weeks since then haven’t had it fixed due to low funds. A couple days ago I was driving with two [XXX] olds in the car and was at a stop light. After about a minute the cars engine turned completely off lost all power including the center screen that displays your settings and radio, all lights, and the screen behind the wheel all with my foot on the break at a stop light. Due to this situation I was unable to turn my hazards on to alert the cars coming up being me at a green light absolutely panicked that we were going to get into an accident. A little while after the car turned back on, but unfortunately when trying to push down on the gas pedal nothing was happening. No revving sound and no movement of the car. Car still in drive. A police officer pulled up behind me to check if we were okay. He stayed to keep us safe until people came to push the car off to the side. During the push the wheel was almost completely locked up as well as the breaks. This is not the first time the breaks have locked up on me. Next day we got the car to a safe area to be parked. A couple days later went to try and turn the car on and immediately the car is shaking violently and making horrible noises. The car is unsafe for me to drive and unsafe for people on the road. This car is completely unable to be driven now also due to the horrible shaking. No recalls were found under my VIN, but all of these signs seem to be a problem for other people. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11718928

Incident

Feb 13, 2026

The contact owned a 2020 Chevrolet Malibu. The contact stated that while driving approximately 65 MPH, the brake pedal became inoperable. There was a warning light illuminated. The contact stated that the brake pedal failed to function properly while attempting to stop the vehicle. Additionally, while the vehicle was parked and turned off, the contact became aware that brake fluid was leaking onto the engine. A mobile independent mechanic inspected the vehicle and determined that the brake vacuum pump had failed and needed to be replaced. The vehicle was not repaired. The dealer was not contacted. The manufacturer was not made aware of the failure. The failure mileage was approximately 118,000.

NHTSA ID

11717509

Incident

Feb 12, 2026

Mileage

118,000 mi

The contact owns a 2020 Chevrolet Malibu. The contact stated that while driving at various speeds, the vehicle hesitated and failed to properly accelerate while depressing the accelerator pedal. The check engine warning light was illuminated. The vehicle was taken to a local independent mechanic, who associated the failure with TSB: N222372590. An appointment was scheduled with the dealer to inspect the vehicle. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was approximately 114,000.

NHTSA ID

11716956

Incident

Feb 9, 2026

Mileage

114,000 mi

I was unaware that when I purchased this vehicle that when the oil is low, the breaks go out and the break power booster shatters. The beaks have gone out on me 2x already and thankfully I’ve only had to replace the break power booster only once. Now once the oil is changed the breaks go back to normal, there is no grinding of any sort heard, so now going forward I pay real close attention to my engine, I listen and pay attention to the feeling and sound of the breaks, once the oil begins to become low knowing it’s time for an oil change around 40% is when I start to feel a bit of the difference in the breaks and I can feel a little bit of grinding, no oil light has come on at this time nor has the oil light or any type of signal has ever come on at anytime to let me know that it was time for an oil change. I’ve checked for recalls, I’ve checked message boards, mechanics have no clue about this problem, but at least my mechanic does now!

NHTSA ID

11716063

Incident

Dec 23, 2025

The contact owns a 2020 Chevrolet Malibu. The contact stated that while driving approximately 35 MPH, the vehicle started losing motive power. The contact stated that the vehicle stalled, with the check engine warning light illuminated. The vehicle was towed to an independent mechanic, who diagnosed the vehicle and determined that the fuel injectors had failed and needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The contact stated that the vehicle was hesitating and losing power with the odor of gasoline inside the cabin of the vehicle. The contact stated there was no warning light illuminated. The contact was able to drive the vehicle to the residence, but had not taken the vehicle to a dealer or mechanic. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 112,000.

NHTSA ID

11715939

Incident

Aug 5, 2025

Mileage

112,000 mi

The contact owns a 2020 Chevrolet Malibu. The contact stated that the RPM was unexpectedly elevated while driving, and the vehicle was hesitating. The vehicle was taken to an independent mechanic, and the contact was informed that the throttle body needed to be cleaned. While driving approximately 35-40 MPH and depressing the accelerator pedal, the vehicle shuddered with white smoke coming from the tailpipe. The contact stated that the engine warning light was flashing with the reduced power message displayed. Upon research, the contact associated the failure with Technical Service Bulletin: PIP5812. The vehicle was taken to an independent mechanic who associated the failure with the turbocharger. The local dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 80,000.

NHTSA ID

11715468

Incident

Feb 4, 2025

Mileage

80,000 mi

The contact owns a 2020 Chevrolet Malibu. The contact stated that while driving at 35 MPH, the check engine warning light illuminated. While the vehicle was stopped at a traffic light or a stop sign, the failure was more noticeable. The contact stated that the vehicle jerked abnormally and failed to accelerate as intended while depressing the accelerator pedal. The RPM fluctuated before the transmission slammed into gear. The vehicle then returned to normal functionality. The vehicle was taken to the dealer, where it was diagnosed and determined that the turbocharger had failed and needed to be replaced. The vehicle remained at the dealer unrepaired. Prior to the most recent failure, the contact stated that while her daughter was driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal, and the vehicle failed to function as intended. The vehicle was towed to the dealer; however, no cause for the failure was found. The manufacturer was not notified of the failure. The failure mileage was approximately 77,000.

NHTSA ID

11715330

Incident

Jan 30, 2026

Mileage

77,000 mi

Got this car Oct 16 2025 and check engine lights on the place in Greenbriar dreka passed emmission and the shop explicit auto sold me car for 7500 been having problems with car since owner told me to do what I need to do no refund nothing in writing saying as is this car needs axles ball joint lower arm control and more car not safe for me and my kids this car go get emission passed so when u take title to DMV you can get a tag for a car that not passing emissions also purchase a second car same day Oct 16 2025 and this car need oil pump oil sensor brake sensor brake caliber and more and explicit auto wont fix cars the man that sell these cars are on Instagram and dolufree and explicit auto is the name of both Names if you look you'll see light on in every car he post and sell to people for high price and no results when you bring car back every car sold from them need to be investigated. We need help I have two cases that I cannot drive and I was charged 13,500 for both cars and this is illegal for someone to use someone else access and get these cars and sell them under someone else license the address for business have a old national address but cars being sold at 2263 metropolitan pkwy and I don't know what to do at this point

NHTSA ID

11711718

Incident

Oct 16, 2025

December 12, 2025 I had to drive 20-30 miles an hour the car would not break I had to use parking break. When I would try to Stop it would continue to roll. The pedal was Hard! This is very dangerous and other cars have crashed There are also class action lawsuits regarding just this! Vehicle vacuum pump The Bill was $5200 I am asking for reimbursement! Vehicle vacuum pump engine light on tire sensor light on Saw there have been more cases

NHTSA ID

11710815

Incident

Dec 12, 2025