2020 Chevrolet Malibu Electrical Problems

My 2020 Chevrolet Malibu experienced a sudden and severe electrical failure after driving through normal roadway water. Immediately afterward, the vehicle displayed multiple safety‑critical warnings including loss of power steering assist, Electronic Stability Control (ESC) faults, brake control faults, and reduced propulsion. A GM dealership inspected the vehicle, scanned the modules, and found more than a dozen network and chassis‑related diagnostic trouble codes, including: B3979, U0164, B1325, B3122, U0121, C0196, C0460, B1011, B097B, B3205, C056E, C056D, U0420, U1510, C0545, U0422. These codes indicate failures in the steering system, brake control module, stability control system, body control module, and multiple CAN‑bus communication networks. The dealership confirmed: – No physical damage – No evidence of collision or impact – No evidence of flood damage – The suspected failed component is the electric power steering rack (GM part 85621696) – The part is not available, meaning the vehicle cannot be repaired – I would be responsible for diagnostic and repair costs This is a major safety concern. The vehicle can lose steering assist, stability control, and braking support without warning. The inability to obtain the required steering component makes the vehicle unrepairable and unsafe to operate. I am reporting this because this appears to be a systemic electrical/network failure affecting critical safety systems. I believe this defect poses a significant risk to drivers, passengers, and other motorists. The attached photo is a is a picture of the printout the Chevrolet dealership Service Manager provided to me.

NHTSA ID

11755071

Incident

Jul 27, 2026

So while I was driving my car going 60 on the highway it seemed to be having electrical issues all the lights on my dash popped on then popped off and only a few lights actually stayed on I can't remember exactly but the check engine and my abs stayed on and then on my screen it read to me warning power steering fault my headlights were dimming on and off like my car was going to die, so I had to pull over for my safety and other drivers safety, so after I pulled over safely I shut my car completely off and waited about 5 minutes and turned it back on when it turned back on the only light that popped on my dash was the check engine light, but the check engine light had actually been on the dash for a while after I replaced the 21 fuses that were missing that I didn't know were missing when I purchased the vehicle as is from a dealership the only thing that made me decide to check my fuses was because my check engine light was popping on and off and would stay off for a while then come back on a code reader said it was something to do with my turbo that code it was just very odd and the car was shifting weird 3 or 4 months after the purchase date XXX also after I put all the fuses back in a ton of codes popped up others safety and mine were at risk as I didn't really have control of my vehicle when it was doing that and it started breaking itself when I wasn't even hitting the break it was like jolting it's self and stopping slightly. I took my car to AAMCO Total car Care for a free diagnostic test, and then I had recently took my car to a Chevy dealership in Nampa Idaho off garrity boulevard because online it had told me there was recalls for my car and that recall was exactly what I was thinking had started off as the original problem originally leading into the other problems I got told to bring my car in then the fed me information saying pretty much it was a bust and that specific Malibu has no recall I think they just didn't want to work on it

NHTSA ID

11754086

Incident

May 4, 2026

May 7, 2026 National Highway Traffic Safety Administration 1200 New Jersey Avenue SE Washington, DC 20590 RE: Safety Defect Complaint – Brake System / Vehicle Control Concerns 2020 Chevrolet Malibu Dear NHTSA, I am submitting a safety complaint regarding persistent braking and vehicle control issues involving my 2020 Chevrolet Malibu. Prior to December 31, 2025, the vehicle exhibited jerking during braking, all dashboard gauges go to the left, warning lights, reduced power (20-25mph), and inconsistent braking behavior. This situation happens without warning, at any given time, even in the flow of traffic. An independent inspection indicated the brake system was in proper condition, suggesting a more complex underlying safety issue. The vehicle was taken to Reed-Lallier Chevrolet for diagnosis and remained there for approximately five months. During that time, I was not provided documentation confirming completion of a brake system diagnostic or a clear resolution path. Due to the extended delay without diagnosis, I no longer feel safe operating the vehicle. I am also concerned that prolonged inactivity without proper repair may have worsened the condition and increased risk of failure. Given the nature of the symptoms involving braking and vehicle control, I request review for potential safety-related investigation. Vehicle Information: 2020 Chevrolet Malibu VIN: Mileage:

NHTSA ID

11736449

Incident

Dec 31, 2025

The contact owns a 2020 Chevrolet Malibu. The contact stated that while driving approximately 35 MPH, an unknown warning light illuminated, and the vehicle started to lose motive power. The contact stopped at a traffic signal and after depressing the accelerator pedal when the light changed, the vehicle stalled. The vehicle was restarted after several attempts, but the vehicle failed to exceed 5 MPH while accelerating. The contact stopped and the vehicle was towed to an independent mechanic. The vehicle was diagnosed, the battery was replaced, and the system was reset; however, the failure reoccurred and the vehicle was towed to a dealer. The vehicle was diagnosed, and it was determined that the front wiring harness needed to be replaced. The vehicle was repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 23,000.

NHTSA ID

11730116

Incident

Apr 14, 2025

Mileage

23,000 mi

Several things have been going wrong with this car. I have only had it for about 7 months. Minimal driving. Got the car with 84,000 miles and it now has 88,000 miles. About 2 months ago the check engine light came on. Got it into a shop and they said an oil change may possibly help with this. Got the oil change, cleared the code, drove it around and check engine light came back on. Brought it back to the shop and now the entire valve cover needs replaced. It’s been about 2 weeks since then haven’t had it fixed due to low funds. A couple days ago I was driving with two [XXX] olds in the car and was at a stop light. After about a minute the cars engine turned completely off lost all power including the center screen that displays your settings and radio, all lights, and the screen behind the wheel all with my foot on the break at a stop light. Due to this situation I was unable to turn my hazards on to alert the cars coming up being me at a green light absolutely panicked that we were going to get into an accident. A little while after the car turned back on, but unfortunately when trying to push down on the gas pedal nothing was happening. No revving sound and no movement of the car. Car still in drive. A police officer pulled up behind me to check if we were okay. He stayed to keep us safe until people came to push the car off to the side. During the push the wheel was almost completely locked up as well as the breaks. This is not the first time the breaks have locked up on me. Next day we got the car to a safe area to be parked. A couple days later went to try and turn the car on and immediately the car is shaking violently and making horrible noises. The car is unsafe for me to drive and unsafe for people on the road. This car is completely unable to be driven now also due to the horrible shaking. No recalls were found under my VIN, but all of these signs seem to be a problem for other people. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11718928

Incident

Feb 13, 2026

Got this car Oct 16 2025 and check engine lights on the place in Greenbriar dreka passed emmission and the shop explicit auto sold me car for 7500 been having problems with car since owner told me to do what I need to do no refund nothing in writing saying as is this car needs axles ball joint lower arm control and more car not safe for me and my kids this car go get emission passed so when u take title to DMV you can get a tag for a car that not passing emissions also purchase a second car same day Oct 16 2025 and this car need oil pump oil sensor brake sensor brake caliber and more and explicit auto wont fix cars the man that sell these cars are on Instagram and dolufree and explicit auto is the name of both Names if you look you'll see light on in every car he post and sell to people for high price and no results when you bring car back every car sold from them need to be investigated. We need help I have two cases that I cannot drive and I was charged 13,500 for both cars and this is illegal for someone to use someone else access and get these cars and sell them under someone else license the address for business have a old national address but cars being sold at 2263 metropolitan pkwy and I don't know what to do at this point

NHTSA ID

11711718

Incident

Oct 16, 2025

This is a 2020 Malibu with only 18,000 miles on it now. We are having intermittent loss of power. Car will be moving fine when suddenly it looses power when pulling into traffic from a stop. It has also happened on the highway(right after leaving the dealer service department) when going to pass a vehicle…all of a sudden power drops and rpms go up and car slows up. When it suddenly happens, pulling into traffic is very slow. The only way to get power back is to turn off traction control via a button. It is back at the dealer now. They have had it the last two weeks. They fixed a shift to park issue but cannot duplicate the loss of power. So they are saying it is ready to pick up. Once, recently, a check engine light come on along with a message saying something like low power mode. We went straight to the dealer with the vehicle. They had the car for three five out of six weeks and were able to duplicate the loss of power once. We wanted them to contact Chevy to help resolve this, but we are unsure if they actually did. These problems first were serviced in April of 2024. This car is very scary to be in, the way this happens and when it is happening.

NHTSA ID

11706146

Incident

Apr 1, 2024

The shifter will not read when the vehicle has been placed in park.

NHTSA ID

11696906

Incident

Aug 14, 2025

Th e brakes are not working at all. We have to go slow then the brakes are hard to press. Th I s makes it keep driving anc brake pedal doesn't stop it.

NHTSA ID

11679673

Incident

Aug 10, 2025

A liAdjustmentght came on my dashboard. State power engine reduce period then it stalls when I press my foot down on the accelerator not giving it any power to go period then when I try to break it actually pushes my foot back off and it's hard to break period and when I press the start button to turn the engine on. It turns right back off after about.Maybe four or five seconds and no I just had to have a towed to my home. The special Coverage adjustment code in 182188250 is what my vehicle would apply to, but that code only covers the 2016 and 2018 models. What can I do now? Because it is under that code. But the dealerships won't cover it because they're saying my model is not but twenty twenty I need help please. I have 132k miles. Good condition. Why wouldn't letter models be covered under the same act?What would make it stop if it's doing the same thing?It did for those twenty sixteen and twenty eighteen models

NHTSA ID

11678201

Incident

Aug 2, 2025

Shift to park

NHTSA ID

11672776

Incident

Jul 11, 2025

Will not shift into park with out hitting the shifting lever

NHTSA ID

11671156

Incident

Jul 3, 2025

Shift to park

NHTSA ID

11665500

Incident

Jun 7, 2025

When putting my car in park and turning the car off I get a shift to park message.

NHTSA ID

11664982

Incident

Jun 4, 2025

After pressing the button to turn the vehicle off the message board displays a "shift to park" alert. The vehicle will not completely turn off until you clear the message. I do not know how to clear the message so the vehicle will completely turn off and to keep this from happening again. It requires me to turn the vehicle off, restart it, put it in drive, stop, put it in park, then turn it off. Simply turning the vehicle off and back on does not clear the message. It takes me at least 3 tries to get the vehicle to finally turn off normally without the "shift to park" message. This does not happen every single time when I turn the vehicle off and at no particular frequency. It is very annoying because it happens when you least expect it. When you are on a time schedule you do not have 5-10 minutes to re-start and turn off the vehicle again numerous times to get the message to disappear. It is also not good for the engine and transmission components to keep having to go through this process. This issue has been occuring for approximately 1 year. I thought it was fixed because the message stopped coming up for awhile but the issue is occurring again at no particular frequency. Please check into this and issue a recall. From what I can see, I am not the only one having this issue.

NHTSA ID

11663888

Incident

May 31, 2024

I was driving in the interstate at about 4pm on May 16th and the check engine light came on. Thus is nothing new because since I bought the car on Feb. 14th, 2024 the check engine light is on about 75% of the time. I went to use my brakes and the pedal was hard as a rock. I had to use both feet to depress the pedal to get the car to slow down. I brought the car to Autozone and they did a scan and it showed the Power Brake Booster Vacuum Sensor needed replacement. I ordered it and had a friend who is a mechanic replace it and the problem still persisted. My friend thought it was the Power Brake Booster Vacuum Pump. I ordered it and he replaced it and the brakes are back to normal. My research regarding this has found that his is a VERY common issue with this vehicle which has lead to costly repairs for many people and has resulted in a class action lawsuit. This is a SERIOUS safety issue! When a person can’t hardly press their brakes when driving that endangers the lives of the driver, the occupants of the car and every other person on the road. Why do we have to wait for people to be killed before this is fixed?

NHTSA ID

11663572

Incident

May 16, 2025

When the car was turned off a message appeared that said shift the park the gear indicator already stated the car was in park and the car gear shift was already in park. Looked into this issue and apparently there is an open recall for the year and make of my car but it for some reason does not include my vin number

NHTSA ID

11648208

Incident

Mar 13, 2025

"Shift to park" error message and "engine power is reduced" error message

NHTSA ID

11644621

Incident

Feb 4, 2025

My car is in Park. But the dash board is flashing Shift to park. I need to turn it off and on multiple times until it finally stops. I can not lock my car if this is happening and I can’t just let it go because it will drain my battery.

NHTSA ID

11638965

Incident

Nov 8, 2024

Malibu displays “shift to park” message because of a known issue with the electronic shifter. The shifter fails to detect when the vehicle is properly in park, requiring adjustments until the system recognizes the correct gear position. Informed by dealer to just move gear shift back and forth until message clears then can turn off vehicle. This can take up to 10-15 minutes. Also advised to keep emergency break on or vehicle could roll away!!! Apparently this is a known issue per the mechanic. Said the electronic shifter may or may not resolve this and if it doesn't resolve the problem can also affect the transmission.

NHTSA ID

11634445

Incident

Dec 17, 2024

“shift to park” message appears after car has already been shifted to park. Will not allow car to be turned off as the car thinks it’s still not in park. Known issue with earlier models of the malibu that warranted a recall of models 2019 and before. Seems like this is a continued issue in the 2020 model

NHTSA ID

11633722

Incident

Jan 2, 2025

Shift to park detected when I have gear in park

NHTSA ID

11628415

Incident

Apr 1, 2024

The problems listed in my vehicle are the following • U0073: Control Module Communication Bus A Off • U0100: Lost Communication With Engine Control Module • U0121: Lost Communication with Electronic Brake Control Module • U0140: Lost Communication With Body Control Module • P0700: Transmission Control Module Requested MIL Illumination I believe this is due to a bad design in the wiring. Also the electric brake vacuum broke which is a common problem.

NHTSA ID

11607742

Incident

Jul 25, 2024

Yes my car has just started to displaying a shift to park message on the message center when you shift the car into park. I know there are recalls on 2016-2019 Malibu and now it’s doing it on my 2020. Come on Chevy

NHTSA ID

11606221

Incident

Jul 12, 2024

So far it is only once in a while when I shift into park and turn off the engine the ‘Shift to Park’ message will be displayed in the dash. Sometimes I can jiggle the shift lever a little to make it go out, other times I have to start/stop engine , shift out and into park several times to make it go out. I don’t want to leave the vehicle without making sure it’s in park. I read in another complaint that the doors won’t lock, and that it goes into accessory mode and could drain the battery down if left that way, but I did not check if that happens on my vehicle. It just started doing this a few weeks ago. I have not contacted the dealership yet, but I understand that GM has put out a recall on the Malibu and other models concerning this issue. I am hoping it will cover my VIN. number soon. Thank you for taking time to read my complaint.

NHTSA ID

11601594

Incident

Jul 10, 2024