2002 Chevrolet S10 Owner Complaints

The contact owns a 2002 Chevrolet S10. The contact stated that while driving at an undisclosed speed, the vehicle started shuddering and lost motive power, prompting the contact to pull to the shoulder of the roadway to turn off the vehicle. After restarting the vehicle, the vehicle briefly returned to normal functionality, but the failure reoccurred. Several unknown warning lights were illuminated. The vehicle was taken to an independent mechanic, who determined that the engine had seized, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 171,000.

NHTSA ID

11586813

Incident

Nov 23, 2023

Mileage

171,000 mi

The contact owns a 2002 Chevy S10 equipped with Tornel Classic All Season Tires. Tire Size: 205/75 R15, and DOT Number: N/A. The contact stated that while the vehicle was parked, the contact's friend noticed that the passenger's front tire had a large bubble.  The contact stated that the bubble was the size of a football.  The tire was recently purchased online from Walmart.  The dealer was not made aware of the failure.  The manufacturer was made aware of the failure. The failure mileage was approximately 1,000. VIN Unavailable.

NHTSA ID

11579483

Incident

Dec 4, 2023

Driving down highway 56mph went ro pass and the accelerate stayed wide open causing to go off road to shut off truck to be able to slow down and hopefully stop. Hit the gravel on shoulder to avoid collision with other cars spun out of control going in ditch

NHTSA ID

11578616

Incident

Mar 1, 2024

TURNED ON WINDSHIELD WIPERS AND NOTHING HAPPENED. MADE IT TO THE SIDE OF THE ROAD DURING DOWNPOUR. CHECKED FUSES AND STILL NOTHING. FAULTY SOLDERS ON WIPER CONTROL BOARD. DANGEROUS SITUATION AS VISIBILITY WAS GREATLY IMPAIRED. COULD HAVE CAUSED A LIFE THREATENING CRASH.

NHTSA ID

11377215

Incident

Nov 17, 2020

Mileage

1,065,000 mi

CHUCK HUTTON CHEVROLET SERVICE -CHARGED 05CVZ BRAKES/ 88911428 STEER/SUP PARTS $219.24 LABOR $366.66/F JOINT KIT/STEERING IDLER ARM 88911297 PART: $97.99 LABOR: $366.66/ 19297307 F-(S)ARM PARTS: $42.89 LABOR: $331.30 ON SEPT 15, 2020, SERVICE CONSULTANT ADVISED CUSTOMER THAT IT WOULD TAKE 7 DAYS FOR HER PARTS TO ARRIVE AT CHUCK HUTTON PARTS DEPARTMENT. CUSTOMER CALLED ON SEPT 24, 2020. SERVICE CONSULTANT ADVISED, SHE WAS STILL WAITING ON THE DELIVERY OF THE PARTS. CUSTOMER SPOKE WITH SERVICE CONSULTANT ON OCTOBER 1, 2020. CUSTOMER WAS ADVISED AGAIN BY SERVICE CONSULTANT THAT SHE IS STILL WAITING ON THE PARTS. HUNG UP PHONE AND CALLED CUSTOMER BACK WITHIN 5 MINUTES, AND SAID HER PARTS WAS HERE, HER VEHICLE WILL BE READY BY 4:30PM THE 1ST. I KNEW THAT WAS IMPOSSIBLE. SO, I WENT IN ON OCTOBER 2, 2020 BETWEEN 4:30PM-5:00PM. I PAID MY TICKET PRICE OF $1,912.81 WITH A CREDIT CARD. TWENTY MINUTES LATER, I WAS TOLD MY VEHICLE WOULDN'T START. MY VEHICLE IS STILL THERE. MY CREDIT CARD WAS BILLED THE TICKET PRICE. THIS IS A VERY BAD CUSTOMER EXPERIENCE WITH CHUCK HUTTON SERVICE CONSULTANT (GREEDY COMMISSION) UPON INSPECTION FOUND BALL JOINTS WORN AND COMING APART/THE STEERING IDLER ARM WAS WORN AT THE JOINTS. THE STEERING PITMAN ARM WAS WORN AT THE JOINT. INSPECTED THE STEERING SYSTEM AND ADVISED. REPLACED THE STEERING PITMAN ARM AND LUBE CHASSIS. PRICE GOUGING ON LABOR $1190.40/ INVOICE #2551188 VEHICLE ENTERED SERVICE AREA ON SEPT 15, 2020. SERVICE CONSULTANT ADVISED THE CUSTOMER, HER CAR WAS READY FOR PICK UP ON SEPT 2. WHEN CUSTOMER ARRIVED, SHE PAID FOR REPAIRS, CUSTOMER WAS ADVISED 30 MINUTES LATER, HER VEHICLE WOULD NOT START. CUSTOMER TOOK HER VEHICLE IN FOR A ROUTINE EXCHANGE COOLANT 36 PART FLUSH ,$169.95/ REPLACED RESERVOIR $100.52 LABOR: $65.48 MAINTENANCE CHECK $65.48(?)

NHTSA ID

11362727

Incident

Oct 2, 2020

WHEN MY TRUCK RAN OUT OF GAS ON THE FREEWAY, MY STEERING LOCKED UP AND BRAK S FAILED.

NHTSA ID

11163669

Incident

Nov 26, 2018

Mileage

190,000 mi

TRUCK OR VEHICLE SHUT DOWN WHILE DRIVING.

NHTSA ID

11132351

Incident

Sep 12, 2017

AIR BAG LIGHT ON AND CAN'T GET PARTS

NHTSA ID

11045292

Incident

Sep 1, 2017

TL* THE CONTACT OWNS A 2002 CHEVROLET S10 EQUIPPED WITH UNIROYAL TIGER PAW AWP II TIRES, SIZE: P205/75/R15 (NA). WHILE DRIVING 40 MPH, THE VEHICLE BEGAN TO VIBRATE AND THE FRONT DRIVER SIDE TIRE BLEW OUT. THE CONTACT INDEPENDENTLY REPLACED THE TIRE WITH THE SPARE. THE TIRE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE TIRE FAILURE MILEAGE WAS 10,000 AND THE VEHICLE FAILURE MILEAGE WAS 66,000.

NHTSA ID

10907708

Incident

Sep 18, 2016

Mileage

66,000 mi

2002 CHEV. S-10 EXT. CAB, V6 AUTO. 88,XXX MI. 9/10/16 SUNNY, DRY AM MID 70'S.SOUTHBOUND I 41 70MPH ENGINE SUDDENLY STOPPED RUNNING. NO PRIOR INDICATION OF TROUBLE, NOT OVERHEATED, NO LEAKS. OTHER GAUGES WERE INDICATING NORMAL. I HAD ONLY DRIVEN 5MI. ON STATE HWY. PRIOR TO DRIVING 15MI. ON INTERSTATE WHEN ENGINE STOPPED, V6 VORTEC 4.3L. PREVIOUS SERVICE TO ENGINE INCLUDED WATER PUMP REPLACEMENT 1 WK. EARLIER BY DEALER. NOW ON SIDE OF ROAD VEHICLE WILL NOT START, TURNS OVER, DASH INDICATORS, BATT. STRONG. THIS VEHICLE HAS 88,000 ORIGINAL MILES, I AM SECOND OWNER, 2002 EXT. CAB S-10. TOWED TO LOCAL CHEV. DEALER AND THEY REPLACED MAF (MASS AIR FLOW) SENSOR, $477 PARTS AND LABOR,+ TAX, AND SUGGESTED REPLACING FUEL INJECTOR SYSTEM. I DECLINED INJECTOR REPLACEMENT. DROVE VEHICLE 5MI. ON STATE HWY. TOWARD HOME WHEN SUDDENLY THE ENGINE STOPPED, AS BEFORE. TOWED VEHICLE TO GMC DEALER WHO RECOMMENDS REPLACING THE ICM (IGNITION CONTROL MODULE) $375 PART, IT SHOULD ARRIVE IN A COUPLE OF DAYS, AND SAYS IT'S DEFINITELY NOT THE INJECTORS. JUST DOING MY FAIR SHARE TO BOOST THE ECONOMY. IT'S ALL JUST A MONEY GRAB ANYWAY. I FIGURE ANOTHER $500-$1000 AND IT MAY RUN AGAIN. SOLUTION : UNKOWN AS YET. INSTEAD OF CARFAX, WE NEED A PERMANENT LEMON LABEL ON DEALERSHIP DOORS/SHOW ROOM FLOOR INDICATING ANY CAR OR TRUCK HISTORY WITH 2 OR MORE RECALLS AND CONSTANT REPAIRS, MAYBE GM SHOULD HAVE FAILED (BANKRUPT). TOYOTA REALLY ISN'T TO GOOD EITHER. WHAT A CON GAME.

NHTSA ID

10907324

Incident

Sep 10, 2016

Mileage

88,000 mi

2002 CHEVROLET S-10. CONSUMER WRITES IN REGARDS TO OIL LEAKING ONTO THE MANIFOLD. *LD

NHTSA ID

10838400

Incident

Feb 1, 2016

TL* THE CONTACT OWNS A 2002 CHEVROLET S-10. THE CONTACT STATED THAT WHILE DRIVING, THE AIR BAG ON LIGHT WAS ILLUMINATED. THE CONTACT MERGED TO THE SHOULDER OF THE ROAD AND POWERED OFF THE AIR BAG WITH THE SWITCH. THE CONTACT STATED THAT SUDDENLY THE VEHICLE FAILED TO RESTART AND WAS PUSHED BACK TO THE RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

10836521

Incident

Aug 10, 2015

I BOUGHT A SET OF GOODYEAR VIVA 2 TIRES AT WALMART. I HAVE LESS THAN 30K MILES ON THEM. I NOTICE THEY SEEM TO ALWAYS BE OUT OF BALANCE, EVEN WHEN I CARRY MY VEHICLE IN TO HAVE THE TIRES ROTATED AND BALANCED. THE OTHER DAY, I HAD TAKEN MY VEHICLE IN AND THE TECH LOOKED AT ONE OF MY TIRES AND NOTICED A BULDGE ON THE SIDE OF ONE OF MY TIRES AND MADE A COMMENT ABOUT THE BELTS SEPERATING AND BEING READY FOR A BLOW-OUT. I ASK IF WALMART WAS REPLACING THEM AND HE SAID NO. AFTER GETTING HOME I NOTICED TWO MORE TIRES WITH THAT SAME BULDGE ON THE SIDE.

NHTSA ID

10750205

Incident

Aug 17, 2015

FIRST INCIDENT APPROXIMATELY 2/15/2015, BRAKES PEDAL WENT CLOSE TO FLOOR WHEN TRYING TO STOP VEHICLE, DOWNSHIFTED TRANSMISSION TO HELP STOP VEHICLE. IT WAS DETERMINED RUST HAD CAUSED A HOLE TO DEVELOP IN BRAKE LINE COOLER BEHIND RADIATOR OF VEHICLE. SIGNIFICANT LOSS OF BRAKE FLUID. SECOND INCIDENT APPROXIMATELY 5/15/2015, BRAKES BECAME MUSHY LOSS OF BRAKE FLUID. RUST CAUSED PIN HOLE LEAK IN BRAKE LINE AT REAR WHEEL BRAKE CYLINDER. THIRD INCIDENT APPROXIMATELY 7/26/2015 SIGNIFICANT LOSS OF BRAKE FLUID. CAUSE YET UNDETERMINED

NHTSA ID

10744087

Incident

Feb 15, 2015

Mileage

65,327 mi

THE O-RINGS IN THE FUEL SYSTEM ARE FAILING AT THE FUEL TANK, CAUSING FUEL LOSS AND LEAKAGE, WHILE DRIVING.

NHTSA ID

10743573

Incident

Jul 27, 2015

Mileage

100,000 mi

TL* THE CONTACT OWNS A 2002 CHEVROLET S-10. WHILE DRIVING APPROXIMATELY 30 MPH WITH THE BRAKE PEDAL ENGAGED, THE ABS WARNING INDICATOR ILLUMINATED AND THE VEHICLE BEGAN TO SHAKE. THE FAILURE RECURRED ON SEVERAL OCCASIONS AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE FRONT WHEEL HUBS WERE FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 45,500. UPDATED 8/19/15*CN

NHTSA ID

10724366

Incident

Jul 1, 2014

Mileage

45,500 mi

TL* THE CONTACT OWNS A 2002 CHEVROLET S-10. WHILE REFUELING THE VEHICLE, THE CONTACT NOTICED THAT FUEL WAS LEAKING. THE DEALER STATED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 86,000. UPDATED 11/26/14*CN THE CONSUMER STATED THE VEHICLE HAD TWO GAS LEAKS. UPDATED 10/5/2015 *JS

NHTSA ID

10643390

Incident

Aug 1, 2014

Mileage

86,000 mi

BRAKES LOST POWER AT ABOUT 50 MPH ON US-24 IN MICHIGAN. MAIN BRAKE LINE SPRUNG LEAK TO REAR AXLE WAS ABLE TO USE EMERGENCY BRAKE TO SAFELY STOP. I HAVE NOT REMOVED LINE YET IF YOU WANT DIGITAL PICTURES MADE MICHIGAN MECHANIC CERTIFICATE # [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10609425

Incident

Jul 9, 2014

Mileage

98,618 mi

TL* THE CONTACT OWNS A 2002 CHEVROLET S10. THE CONTACT STATED THAT THE BRAKE LINE FAILED DUE TO CORROSION ISSUES. THE DEALER WAS NOT NOTIFIED ABOUT THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,911.

NHTSA ID

10607533

Incident

Jun 28, 2014

Mileage

100,911 mi

1999 CHEVROLET S10 DRIVEWORKS STEERING INNER TIE ROD END PART NO. DW-ES3380T. RIGHT AGAINST THE FRONT CROSS MEMBER ON MY 1999 S10.THIS COULD CAUSE BINDING IN THE STEERING. COULD CAUSE TRUCK TO CRASH. ECONOMY INNER TIE RODS ARE WRONG BUT PROFESSIONAL GRADE INNER TIE RODS ARE CORRECT. THIS IS A PROBLEM AT MANY PARTS STORES AND ONLINE PART STORES (ADVANCE AUTO, AUTO ZONE, ROCKAUTO, ETC.) I BELIEVE THIS COULD CAUSE SERIOUS INJURY OR DEATH. *TR

NHTSA ID

10514665

Incident

Jun 1, 2013

TL* THE CONTACT OWNS A 2002 CHEVROLET S10. THE CONTACT STATED THAT WHILE OPENING THE REAR TAILGATE DOOR, THE DOOR FRACTURED BECAUSE THE HINGES AND THE CABLES WERE SEVERELY RUSTED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 89,000. THE VIN WAS UNAVAILABLE. *TR

NHTSA ID

10502812

Incident

Mar 13, 2013

Mileage

89,000 mi

HAD A CHECK ENGINE LIGHT AT A STARTUP. CODE WAS P0305. SEEN MANY OWNERS ARE HAVING THIS PROBLEM AND MANY CAN NOT FIND THE PROBLEM WITH CAR. CALIFORNIA RECALLED THIS MATTER AND THE REST OF THE STATES DID NOT. THANKS *TR

NHTSA ID

10480754

Incident

Oct 12, 2012

Mileage

161,126 mi

TL* THE CONTACT OWNS A 2002 CHEVROLET S10. WHILE DRIVING APPROXIMATELY 35 MPH, THE SPARE TIRE LOCATED UNDER THE VEHICLE DETACHED. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE CABLE THAT HELD THE TIRE IN PLACE WAS FRACTURED. ALSO, THE CONTACT STATED THAT THE INTERIOR DOOR HANDLE ON THE FRONT DRIVER'S SIDE DOOR WAS FRACTURED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE DOOR HANDLE WAS REPLACED HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS OR REPAIRS FOR THE SPARE TIRE CABLE. THE APPROXIMATE FAILURE MILEAGE WAS 89,000.

NHTSA ID

10471235

Incident

Aug 13, 2012

Mileage

89,000 mi

SUNSHELL BLEW OUT ON TRANSMISSION. *TR

NHTSA ID

10469538

Incident

Jun 4, 2012

Mileage

95,000 mi

AFTER I'D OWNED THE VEHICLE FOR A LITTLE OVER 3 YEARS AND HAD ONLY ABOUT 13,000 MILES ON IT, IT BEGAN TO PULL HARD ON BRAKING. ONE OF THE FRONT BRAKE CALIPERS SEIZED AND RUINED THE FRONT ROTOR IN THE PROCESS. ALTHOUGH THE TRUCK WAS JUST OUT OF WARRANTY, BECAUSE OF THE LOW MILEAGE AND AGE OF THE VEHICLE, I TOOK IT TO THE DEALER. CHEVROLET REFUSED TO HONOR THE REPAIRS UNDER WARRANTY OR ACKNOWLEDGE ANY PROBLEMS. THEY SAID IT WAS BECAUSE THE TRUCK SAT OUTSIDE. IT IS PARKED ON A PAVED STREET IN FRONT OF MY HOUSE. IT IS A TRUCK AND MOST TRUCKS IN MY EXPERIENCE "SIT OUTSIDE," SO I FOUND THIS EXPLANATION TOTALLY UNSATISFACTORY. WHATEVER HAPPENED TO "LIKE A ROCK!" I REPLACED BOTH FRONT ROTORS, BOTH FRONT CALIPERS (UPGRADED FROM OEM) AND OF COURSE THE BRAKE FLUID AT MY EXPENSE. AGAIN THIS YEAR, IN MAY 2012, I EXPERIENCED THE SAME PROBLEM WITH A FRONT CALIPER SEIZING. I TOOK IT TO THE DEALER AGAIN AND THE DEALER VERIFIED THE PROBLEM AND SAID I NEEDED TO REPLACE THE CALIPERS, PADS AND, IN ADDITION, THE BRAKE LINES. THEY OFFERED TO DO THIS FOR A MERE $975 PLUS TAX AND $80 FOR NEW PADS. I WILL ONCE AGAIN REPLACE THE CALIPERS, PADS, FLUIDS AND THIS TIME THE BRAKE LINES WHICH I SUSPECT WERE THE ORIGINAL PROBLEM. WHEN I FLUSHED THE LINES TO REPLACE THE FLUID BACK IN 2006 AND AGAIN IN 2012 THERE WAS OBVIOUS CONTAMINATION IN THE LINES WHICH WHEN IT BUILDS UP IN THE CALIPER, IN MY OPINION, CAUSES IT TO SEIZE. I'VE OWNED A NUMBER OF VEHICLES MOST OF WHICH SAT OUTSIDE FOR YEARS AND NEVER EXPERIENCED ANY TYPE OF PROBLEM WITH THE BRAKES. MY COMPLAINT IS THAT I BELIEVE CHEVROLET USED SUBSTANDARD LINES IN THEIR VEHICLES OR ALLOWED CONTAMINATION OF THESE PARTS OR DESIGNED A DEFECTIVE SYSTEM THAT ALLOWS CONDENSATION TO INFILTRATE THE SYSTEM AND DESTROY THE LINES. *TR

NHTSA ID

10468400

Incident

Sep 1, 2006

Mileage

13,000 mi