Owner-reported complaints naming the powertrain system, filed with NHTSA
Data refreshed
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials. Every record below is an owner-reported complaint about the 2002 Chevrolet Silverado 1500 submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 11 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
my truck won't pick up speed when trying to accelerate. I don't know what it is. I know it's a problem and it's a hazard and accident waiting to happen!!!! Please, fix. I have had nothing but, issues with this Chevy Silverado.
I was driving today and my truck started making a strange noise(like something was loose). I stop the truck to see what was loose, I found nothing. I got back in the truck driving about 20 mph the truck started making the noise again and the truck started dragging( like it wouldn't go faster). I then stop and pulled in a church parking lot where the truck was not drivable. I was told by a concern passerby( mechanic, which happen to be) it's has something to do with the rest axle. The truck gave me no warning whatever. I was told I could have had a major accident and I had NO!!! warning. Please, fix. I have nothing but, issues with this truck.
WHEN WE BOUGHT TRUCK I CHECKED VIN AND ONLY THE TAILGATE RECALL CAME UP BUT LISTED MY TRUCK BEING A CHEVY 800 MODEL, WELL COUPLE WEEKS AGO OUR TRUCK WOULDN'T BRAKE WHILE PARKING MAKING A LEFT INTO A RESTAURANT AND THE TRUCK WOULDN'T STOP AND HIT THE RESTAURANT WINDOW!!! WHEN I CHECKED JUST OUR EXACT VEHICLE 15 PLUS RECALLS CAME UP WITH THIS PARTICULAR DEFECT LISTED, PLEASE HELP ADVISE. THANK THE PARKERD
I FIRST OF ALL ABOUT A YEAR AGO AND NOTICED 2ND GEAR HAS GONE OUT IN IT SINCE I VERY RARELY WENT IN THE REVERSE IT DIDN'T NOTICE THAT TELL HER I WAS IN A PREDICAMENT AND HAD TO PUSH IT OUT AND NOW IT'S STUCK IN FIRST GEAR
TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. WHILE DRIVING APPROXIMATELY 60 MPH, THE TRANSMISSION FAILED TO RESPOND PROPERLY IN THE OVERDRIVE POSITION. IN ADDITION, THE TRANSMISSION TEMPERATURE WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED WHENEVER THE VEHICLE WAS IN OPERATION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC ON THREE SEPARATE OCCASIONS WHERE A REPAIR WAS PERFORMED EACH TIME. THE CONTACT WAS UNCERTAIN OF THE SPECIFIC PARTS THAT WERE REPLACED. THE FAILURE RECURRED AND AN INDEPENDENT MECHANIC WAS DIAGNOSING THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE AND VIN WERE UNAVAILABLE.
CRESTED A SMALL HILL TO SEE A RED LIGHT WITH THREE CARS IN LINE. I DEPRESSED BRAKE PEDAL, WHICH WENT TO THE FLOOR. THE VEHICLE WAS STOPPED USING THE PARKING BRAKE AFTER SWERVING INTO EMPTY LANE OF ONCOMING TRAFFIC IN ORDER TO AVOID HITTING THE LINE OF CARS FROM BEHIND. UPON INSPECTION, THE FRONT BRAKE CIRCUIT WAS BLOWN IN THE PIPING JUST AFT OF THE FRONT DRIVER'S SIDE WHEEL. IT IS EXTREMELY DIFFICULT TO STOP A LARGE TRUCK WITH EMPTY BED USING ONLY THE REAR BRAKES AS THEY LOCK UP EASILY. THERE SEEMED TO BE NO BRAKE POWER USING THE BRAKE PEDAL, WHICH IS WHY THE PARKING PEDAL WAS USED. EVEN WITH A FUNCTIONAL PARKING BRAKE, THE "FAILSAFE" OF HAVING ONLY ONE CIRCUIT IS NEARLY USELESS GIVEN AN EMPTY TRUCK BED (LOW REAR-WHEEL TRACTION) AND A LOSS OF PRESSURE ON THE FRONT CIRCUIT. IN MY OPINION, LOSING THE FRONT BRAKES ON A TRUCK IS CATASTROPHIC. IN ANY EVENT, IN MY CASE, THE SUPPOSED FAIL-SAFE EITHER DID NOT WORK OR WAS INCONSEQUENTIAL. ALL OF THE HARD LINES (FUEL AND BRAKE) ON THIS VEHICLE ARE EXTREMELY CORRODED AND ARE BEING REPLACED WITH STAINLESS. THIS CAR SPENT THE FIRST FIVE YEARS OF ITS LIFE IN OKLAHOMA AND MISSOURI (WHERE LITTLE TO NO SALT IS USED) AND MOVED TO NH IN 2006. THE REAR DRIVER'S SIDE ROCKER PANEL IS ALSO RUSTED THROUGH AND THE FRAME HAS VERY SIGNIFICANT RUST, ESPECIALLY ON THE LEAF SPRING HANGERS. IN ADDITION, THE FRONT DRIVESHAFT IS RUSTED TO THE POINT THAT I WILL NOT OPERATE THE VEHICLE IN 4WD UNTIL I REPLACE IT. THIS VEHICLE SEEMS VERY SUSCEPTIBLE TO RUST, ESPECIALLY THE BRAKE LINES, SOME OF WHICH CRUMBLED IN MY HUSBANDS HANDS WHILE REMOVING. *TR
WHERE CLUTCH MASTER CYLINDER MOUNTS IN CLUTCH PEDAL ASSY BROKE. WAS UNABLE TO GET OUT OF GEAR CAUSING ME TO HIT A POLE. DAMAGING BUMPER HOOD FENDER HEADLIGHT TURN SIGNAL AND GRILL. CALLED THE DEALER THEY TOLD ME THAT CLUTCH BRAKING ISSUES WHILE DRIVING IS NOT A SAFETY ISSUE. I HAVE DONE SOME CHECKING AND THERE ARE A LOT OF PEOPLE WITH THIS ISSUE BUT BECAUSE GM SAYS NOT A SAFETY ISSUE THEY JUST WANT TO SELL US PARTS TO FIX THIS PROBLEM. *TR
I WENT TO STOP AT STREET LIGHT AND THE BRAKE WENT TO THE FLOOR NO BRAKES AT ALL. LATER FOUND BRAKES LINES RUSTED THREW. ALL TRANSMISSION LINES ALSO RUST THREW. PRICE TO HAVE FIXED OVER $2000.00 *TR
CHEVY EXTENDED CAB, 1500 SILVERADO: WHILE DRIVING 45 MPH, TRUCK LOST COMPLETE POWER, I.E. ENGINE QUIT, PWR STEERING LOSS, NO RADIO, GAUGES LOSS PWR. COMPLETE LOSS OF POWER IN TRAFFIC. TRUCK RESTARTED, SPUTTERED, POWER LOSS, ENGINE BACK ON LINE (INTERMITTENTLY FOR APPROXIMATELY 1/4 MILE). VEHICLE RESUMED NORMAL OPERATION FOR SEVERAL DAYS. GARAGE FOUND NOT DISCREPANCIES WITH VEHICLE. FIVE DAYS ELAPSED. VEHICLE LOSS (DIED) ON HIGHWAY AGAIN. SAME DESCRIBED SYMPTOMS. IS THERE A RECALL OR OTHER SIMILAR ISSUES OUT THERE? *TR
2002 CHEVY SILVERADO C1500 PLASTIC CLUTCH PEDAL AND PLASTIC SLATE CYLINDER HAS BROKEN APART TWICE. ONCE AROUND 80,000 MILES AND 128,000 ENDANGER MY LIFE ONCE ON THE FREEWAY AND ON HEAVY STREET TRAFFIC . I FEEL THAT THE PROBLEM I AM HAVING IS DANGER TO MY HEALTH. I KNOW THESE PART SHOULD NOT HAVE BEEN INSTALLED OR APPROVED. SINCE THIS IS THE MOST IMPORTANT PARTS WITH A MANUAL TRANSMISSION, I FEEL THESE PLASTIC DO NOT BELONG IN THE POWERTRAIN SYSTEM PLEASE HELP ME WITH THIS PROBLEMS I HAVE TWO PLASTIC CLUTCH OLD PARTS FOR PROOF. THANK YOU *TR
TL*THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. THE CONTACT EXPERIENCED SEVERAL ISSUES WITH HIS VEHICLE AND TOOK IT TO AN INDEPENDENT MECHANIC FOR REPAIR. WHEN HE TOOK THE RECEIPT FOR THE REPAIR TO THE DEALER, THEY REFUSED TO SPEAK WITH HIM. THE DEALER CLAIMED TO HAVE CALLED THE MANUFACTURER AND WAS INFORMED THAT THEY WERE NOT RESPONSIBLE FOR THE REPAIR CHARGES BECAUSE THE VEHICLE WAS SERVICED BY AN INDEPENDENT MECHANIC. THE REAR END SEAL, TRANSMISSION COLLAR, INTAKE GASKET, THEUPDATED 04-20-09 *BF HEAD GASKET ON THE ENGINE, AND THE CATALYTIC CONVERTER WERE ALL REPLACED. THE FAILURE MILEAGE WAS 98,000.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .