2002 Chevrolet Silverado 1500 Problems

The emergency brake does not work properly. It automatically comes on while I am driving almost causing me to have a accident. Please, fix!!!!

ABS kicks in constantly at low speeds in dry conditions. This causes longer stopping distances. The ABS grinds or vibrates interfering with normal braking situations. Many near miss collisions at low speeds. The manufacturer should be responsible and replace all the ABS sensors. I purchased this truck brand new in 2002.

The contact owns a 2002 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, the contact heard a loud cracking sound coming from the vehicle. The contact noticed the loud cracking sound while driving over a pothole in the road. The vehicle was driven to the residence. The contact completed a thorough inspection of the vehicle and noticed a fracture behind the cab of the vehicle. In addition, the contact noticed corrosion of the undercarriage of the vehicle. The contact stated that the corrosion extended from the front passenger’s side to the rear of the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 250,000.

rocker panels rusted out

THE IGNITION IS NOT WORKING RIGHT

AT LOW SPEEDS MY 2002 CHEVY 4WD WILL NOT TURN TO THE RIGHT. LEFT DOES NOT SEEM TO BE AFFECTED. I HAVE REPLACED THE BELT, AND THE BELT TENSIONER, AND THE IDLER PULLY WITH NO CHANGE TO THE STEERING. I ALSO HAVE REPLACED THE POWER STEERING FLUID ON A REGULAR BASIS (50,000 MILES BETWEEN). I WAS ABOUT TO REPLACE THE POWER STEERING PUMP WHEN I FOUND THAT OTHERS HAVE HAD PROBLEMS WITH THE RACK AND PINION. I AM HOPING THIS REPORT WILL CONVINCE GM TO ISSUE A RECALL. TRUCK HAS APPROXIMATELY 107,000 MILES.

I HAVE AN EXHAUST LEAK, DUE TO A BROKEN EXHAUST MANIFOLD BOLT. GM USED THE WRONG BOLTS ON MY 5.3LITER ENGINE. MY CHEVY DEALER SAYS IT'S GOING TO COST ME $1200 TO $1400 TO REPAIR MY ENGINE. MY TRUCK ONLY HAS 87000 MILES ON IT.

4 BROKEN EXHAUST MANIFOLD BOLTS

ABS kicks in constantly at low speeds in dry conditions. This causes longer stopping distances. The ABS grinds or vibrates interfering with normal braking situations. Many near miss collisions at low speeds. The manufacturer should be responsible and replace all the ABS sensors. I purchased this truck brand new in 2002.

USING THE KEY THE IGNITION TURNS ON AND TRUCK STARTS AS IT SHOULD, ANYTIME THE KEY THEN COULD BE TAKEN OUT OF THE IGNITION AT ANYTIME. IGNITION CAN BE CLICKED BACK TO ACCESSORY AND THE KEY CAN FALL OUT WHEN DRIVING. NOTE CHANGING FROM RUN TO ACCESSORY IT EASILY DONE.

THE THROTTLE CABLE MAKES CONTACT AND RUB THROUGH THE FLEXIBLE PRESSURIZED FUEL LINE CREATING A PINHOLE LEAK OF NATURAL GAS. I SMELL GAS INSiDE CAB. CAUSES CHECK ENGINE LIGHT TO COME ON

TAKATA RECALL - HAVE BEEN STRANDED NUMEROUS TIMES AS IT HAS APPEARED TO BE THE FUEL PUMP NOT GETTING GAS TO START THE CAR. SOMETIME CAN HEAR PUMP RUNNING AS I HAVE REPLACE 3-4 PUMPS SINCE 2012 OR 13. SOME TIME BEATING UNDER TANK HELPS. THERE SEEM TO BE NUMEROUS COMPLAINTS ABOUT THIS PROBLEM. SECURITY LIGHT FLASHING AND START SOMETIME WHEN IT IS RESET. SOUNDS WONDERFUL WHEN IT RUNS. CAN IT BE THE COMPUTER? TOWED TO A SAFE LOCATION AFTER NOT STARTING AND DIAGNOSTIC TECHNICIAN SHOW 10% FUEL PRESSURE. I PARKED WENT IN TO MAKE A PAYMENT AT A BUSINESS AND WOULD NOT START FOR 4 DAYS

TL*THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. THE CONTACT EXPERIENCED SEVERAL ISSUES WITH HIS VEHICLE AND TOOK IT TO AN INDEPENDENT MECHANIC FOR REPAIR. WHEN HE TOOK THE RECEIPT FOR THE REPAIR TO THE DEALER, THEY REFUSED TO SPEAK WITH HIM. THE DEALER CLAIMED TO HAVE CALLED THE MANUFACTURER AND WAS INFORMED THAT THEY WERE NOT RESPONSIBLE FOR THE REPAIR CHARGES BECAUSE THE VEHICLE WAS SERVICED BY AN INDEPENDENT MECHANIC. THE REAR END SEAL, TRANSMISSION COLLAR, INTAKE GASKET, THEUPDATED 04-20-09 *BF HEAD GASKET ON THE ENGINE, AND THE CATALYTIC CONVERTER WERE ALL REPLACED. THE FAILURE MILEAGE WAS 98,000.

TRANSMISSION FAILED WHILE DRIVING. LOST REVERSE 2ND AND 4TH. COMMON PROBLEM WITH POOR QUALITY TRANSMISSION COMPONENTS USED BY GM. SCUM. ANYWAYS, ECONOMY IS IN A RECESSION AND I HAVE LOTS OF BILLS TO PAY AND NOW THIS ONE AS WELL. THANKS. I LAUGH EVERYTIME GM'S STOCK GETS LOWER. THEY TRULY DESERVE IT. *TR

Had a front end collision going 65 miles per hour. Air bag never deployed

The contact owns a 2002 Chevrolet Silverado 1500. The contact stated while driving 5-10 MPH, the airbag warning light illuminated. The independent mechanic was made aware of the failure and referred the contact to the dealer for diagnosis. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed nor repaired. The approximate failure mileage was 143,725.

I WAS DRIVING ON HWY 495 WHICH IS A CITY ROAD TOWARDS HWY 19 DRIVING APPROX 53 MPH IN CRYSTAL RIVER, FL. THE VECHILE AHEAD OF MY MINE WAS 3 CAR LENGTHS AHEAD WHEN I SAW THERE BRAKE LIGHTS ON, I APPLIED THE USUAL APPROPRIATE BRAKE PRESSURE WHICH IS NO HARDER OR SOFTER THEN ANY OTHER TIME. ONCE I SLOWED DOWN TO 40 MPH IN THE BACK PASSENGER SIDE REAR TIRE FELT LIKE IT EXPLODED AND HEARD A HUGE EXPLOSIVE TYPE SOUND AND ACTUALLY FELT THE ENTIRE BACK END OF MY SILVERADO LIFT UP AND SHIFT LEFTWARDS INTO THE OPPOSITE LANE CAUSING MY TRUCK TO ALSO GET STRUCK BY ANOTHER TRUCK CAUSING WHAT WAS A EXTREMELY WELL MAINTAINED TRUCK WITHOUT A SINGLE DING OR MECHANICAL ISSUES UNTIL THIS OCCURRED. I AM A ENGINEER AND HAVE NEVER WITNESSED A TIRE THAT LOOKED THE WAY THIS DID , BY SIMPLY DRIVING . I HAVE ALL RECORDS FOR MAINTAINCE,ROTATIONS ETC.. OVERALL I HAVE MADE MULTIPLE COMPLAINTS AND HAVE SPENT 3500 ON TIRES AND REPAIRS AND STILL THE TRUCK NEEDS 4500 MORE . I ALSO HAVE HAD TO REPLACE THE RIM THAT THE TIRE WERE ON AND THESE WERE THE RECOMMENDED TIRES FOR MY TRUCK.

MY BRAKE LINES FAILED, NEARLY RESULTING IN KILLING A CHILD THAT RODE HIS BIKE ONTO THE ROAD FROM A DRIVEWAY AND FORCING A VEHICLE HEADON INTO MY LANE OF TRAVEL. LUCKLY EVERYONE WAS ABLE TO SQUEEZE INTO APPROPRIATE PLACES AND WAS PAYING ATTENTION AS I WAS UNABLE TO SLOWDOWN. DUST COVERS ON THE REAR HAVE BEEN RUSTED AND GONE FOR THE LAST TWO YEARS, AND I HAVE REPLACED THE REGULATORS IN BOTH PASSENGER/DRIVERSIDE DOORS THREE TIME EACH DUE TO THE CABLES RUSTING AND SNAPPING. WHEN I TOOK MY VEHICLE INTO CHEVROLET DEALER SHIP FOR MAINTENANCE, IT HAD LESS THAN 36K AT THE TIME, THEY REMOVED ONE PLASTIC PANEL (FALLING DOWN FROM BEHIND THE DOOR INTERIOR TRIM PANELS) FROM EACH DOOR THAT WAS HANGING DOWN AND SCRATCHING MY ROCKER PANEL, AND SAID "WE DONT KNOW WHAT THESE ARE FOR, SO WE JUST REMOVED THEM", HMMM, MAYBE IT WAS TO HELP WITH MOITURE RELATED ISSUES WITHIN THE DOOR PANEL. NOT SURE JUST GUESSING, BUT CANT BELLIVE THAT THEY COULDN'T FIGURE IT OUT. OVER ALL NOT IMPRESSED WITH CHEVROLET EVEN THOUGH IT IS PRETTY MUCH ALL I HAVE OWNED, IF THEY KEEP PRODUCING THIS CRAP THEY SHOULD LOWER THE PRICE.

CRESTED A SMALL HILL TO SEE A RED LIGHT WITH THREE CARS IN LINE. I DEPRESSED BRAKE PEDAL, WHICH WENT TO THE FLOOR. THE VEHICLE WAS STOPPED USING THE PARKING BRAKE AFTER SWERVING INTO EMPTY LANE OF ONCOMING TRAFFIC IN ORDER TO AVOID HITTING THE LINE OF CARS FROM BEHIND. UPON INSPECTION, THE FRONT BRAKE CIRCUIT WAS BLOWN IN THE PIPING JUST AFT OF THE FRONT DRIVER'S SIDE WHEEL. IT IS EXTREMELY DIFFICULT TO STOP A LARGE TRUCK WITH EMPTY BED USING ONLY THE REAR BRAKES AS THEY LOCK UP EASILY. THERE SEEMED TO BE NO BRAKE POWER USING THE BRAKE PEDAL, WHICH IS WHY THE PARKING PEDAL WAS USED. EVEN WITH A FUNCTIONAL PARKING BRAKE, THE "FAILSAFE" OF HAVING ONLY ONE CIRCUIT IS NEARLY USELESS GIVEN AN EMPTY TRUCK BED (LOW REAR-WHEEL TRACTION) AND A LOSS OF PRESSURE ON THE FRONT CIRCUIT. IN MY OPINION, LOSING THE FRONT BRAKES ON A TRUCK IS CATASTROPHIC. IN ANY EVENT, IN MY CASE, THE SUPPOSED FAIL-SAFE EITHER DID NOT WORK OR WAS INCONSEQUENTIAL. ALL OF THE HARD LINES (FUEL AND BRAKE) ON THIS VEHICLE ARE EXTREMELY CORRODED AND ARE BEING REPLACED WITH STAINLESS. THIS CAR SPENT THE FIRST FIVE YEARS OF ITS LIFE IN OKLAHOMA AND MISSOURI (WHERE LITTLE TO NO SALT IS USED) AND MOVED TO NH IN 2006. THE REAR DRIVER'S SIDE ROCKER PANEL IS ALSO RUSTED THROUGH AND THE FRAME HAS VERY SIGNIFICANT RUST, ESPECIALLY ON THE LEAF SPRING HANGERS. IN ADDITION, THE FRONT DRIVESHAFT IS RUSTED TO THE POINT THAT I WILL NOT OPERATE THE VEHICLE IN 4WD UNTIL I REPLACE IT. THIS VEHICLE SEEMS VERY SUSCEPTIBLE TO RUST, ESPECIALLY THE BRAKE LINES, SOME OF WHICH CRUMBLED IN MY HUSBANDS HANDS WHILE REMOVING. *TR

STATE INSPECTION MY TRUCK FAILED DUE TO GASOLINE RUSTED AND LEAKING GAS,REAR SHACKLES RUSTED THRU, PARKING BREAK WON'T HOLD CORROSION. I HAVE NEVER HAD SO MANY RUSTED OUT PARTS ON MY TRUCK BEFORE, THE GAS LINE SHOULD NOT RUST THRU THIS IS A SAFETY ISSUE. SHACKLES RUSTED THRU WHAT GIVES MY OLD 88 NEVER HAD ANY OF THESE PROBLEM PLEASE DO A RECALL. *TR

WIPERS ONLY WORK ON HIGH. *TR

I WAS DRIVING DOWN LOCAL ROAD, WHEN THERE WAS A THREE CAR ACCIDENT WAY AHEAD. I SOWED RIGHT DOWN, MAY 25-30 MPH AS WE CAME UP ON IT, REALIZING AS I WENT TO SLOW DOWN MORE, MY BRAKE PEDAL WENT TO FLOOR. I MADE IT HOME AND PARKED. MY BOYFRIEND LOOKED AT IT NEXT MORNING, I HAD NO BRAKE FLUID LEFT, ONE OF THE LINES WAS SO CORRODED THE FLUID LEAKED ALL OVER THE DRIVEWAY. I HAD RECENTLY HAD MY BRAKES DONE AND INSPECTION WITHIN THE PAST MONTH. I BOUGHT THE TRUCK BRAND NEW, AND HAVE HAD A LOT OF ISSUES WITH IT. INCLUDING ABS THAT WAS PREVIOUSLY RECALLED, AND NEVER WORKED AFTER IT WAS REPLACED, WHICH I DID COMPLAIN ABOUT, HE INTERIOR SET MATERIAL NEEDED REPLACING, THE TAIL GATE CABLES AND HINGES ARE BROKE, THE DEALER SAYS THERE IS NO RECALL ON THEM. A SENSOR WENT IN GAS TANK, THE DRIVERS SIDE MIRROR FELL OFF, THE WINDOW CABLE ON DRIVERS SIDE HAS BEEN REPLACED TWICE, PASSENGER SIDE ONCE, THE LIST GOES ON AND ON. LIKE I SAID, I BOUGHT IT BRAND NEW OFF THE LOT, TRADED IN OLDER CHEVY SILVERADO, PAID CASH WITH GM DISCOUNT. I LOVE MY TRUCK, BUT THINK IT HAS HAD WAY TOO MANY PROBLEMS. I HAVE DEFINITELY READ A LOT OF COMPLAINTS ON THE CORRODED GAS LINES AMONG OTHER ISSUES AND WOULD HOPE CHEVY WOULD STAND BEHIND THEIR PRODUCTS. *TR

my truck won't pick up speed when trying to accelerate. I don't know what it is. I know it's a problem and it's a hazard and accident waiting to happen!!!! Please, fix. I have had nothing but, issues with this Chevy Silverado.

I was driving today and my truck started making a strange noise(like something was loose). I stop the truck to see what was loose, I found nothing. I got back in the truck driving about 20 mph the truck started making the noise again and the truck started dragging( like it wouldn't go faster). I then stop and pulled in a church parking lot where the truck was not drivable. I was told by a concern passerby( mechanic, which happen to be) it's has something to do with the rest axle. The truck gave me no warning whatever. I was told I could have had a major accident and I had NO!!! warning. Please, fix. I have nothing but, issues with this truck.

HERCULES TIRES 26575R 116 OWL HERCULES TERRA TRAC A/T 11 WORE OUT WITH ONLY 3800 MILES NOT ONLY ONCE BUT TWICE DEALER SAID I IT WAS BAD DRIVING NEVE IN MY 56 YRS DID I HAVE A TIRE WEAR THIS FAST THEY ARE DEATH TRAPS KOST TIRE CHARGE ROAD HAZARD WHEN IT ALL READY CAME WITH THE TIRE AND DID NOTHING TO RECTIFY THE PROBLEM CAN YOU HELP ME ON THIS PLEASE. *TR

TWICE I HAVE HAD THE SPARE TIRE WINCH CABLE BREAK ON ME,IF THIS WAS TO HAPPEN IN HEAVY TRAFFIC OR HIGH SPEEDS IT COULD CAUSE SERIOUS INJURY OR DEATH,AND I WAS NEVER AWARE IT WAS GONE UNTIL I NEEDED THE SPARE. *TR

ABS kicks in constantly at low speeds in dry conditions. This causes longer stopping distances. The ABS grinds or vibrates interfering with normal braking situations. Many near miss collisions at low speeds. The manufacturer should be responsible and replace all the ABS sensors. I purchased this truck brand new in 2002.

I WAS DRIVING AT LOW SPEED ON A STREET THAT IS 25MH AS I BREAK TO STOP AT THE STOP SIGN MY ABS ACTIVATED. ALMOST CAUSED ME A SERIOUS ACCIDENT BECAUSE I COULDN'T STOP SO I HAD TO BREAK SO HARD MY BUT WAS ACTUALLY OFF OF THE SEAT. AND THIS CONTINUES TO HAPPEN SO NOW I HAVE TO TAKE THE ABS FUSE OUT TO DEACTIVATE MY ABS.

TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT ANOTHER VEHICLE IN FRONT WAS MAKING A LEFT, THE DRIVER SLAMMED ON THE BRAKE PEDAL BUT THE LATCH FAILED CAUSING THE PASSENGER TO GO THROUGH THE WINDSHIELD DURING THE IMPACT. THE DRIVER PROCEEDED TO HIT A THIRD VEHICLE THAT WAS AT A STOP SIGN. THE OTHER DRIVER WAS FOUND AT FAULT BY THE POLICE. THE FRONT PASSENGER SEAT BELT LATCH FAILED TO RESTRAIN AND CAUSED THE FRONT PASSENGER INJURIES AT THE FACE, ARM, AND LEFT WRIST. THE FRONT PASSENGER AIR BAG FAILED TO FULLY DEPLOY AND CAUSED THE PASSENGERS HEAD HIT THE WINDSHIELD. THE DRIVER SUFFERED INJURIES TO THE STOMACH. MEDICAL ATTENTION WAS PROVIDED TO BOTH INJURED. THE POLICE DEPARTMENT WAS PRESENT AND A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT ALSO WANTED TO ADD THAT TSB SEAT 10-08-50-003B DESCRIBES THE SEAT BELT FAILURE. THE VEHICLE WAS TOWED TO THE DRIVER'S RESIDENCE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

SEATBELTS DOES NOT CATCH AND WILL NOT RECOIL. STARTED OUT AS LOOSE NOW IT WILL NOT RETRACT. STARTED WHEN I APPLIED THE BRAKES WHEN A DOG RAN IN FRONT OF ME AND SEATBELTS DID NOT CATCH AND MY CHEST HIT THE STEERING WHEEL. THE SEATBELTS DID NOT RETRACT AFTER IT PULL OUT. I WAS TRAVELING 55 MPH WHEN THE DOG CROSSED THE HIGHWAY.

TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. WHILE DRIVING VARIOUS SPEEDS, THE FRONT DRIVER SIDE SEAT METAL FRAME DETACHED. THE CONTACT COASTED TO THE SIDE OF THE ROAD AND THEN CONTINUED DRIVING. THE VEHICLE WAS TAKEN TO A POST REPAIR SHOP AND THE SEAT FRAME WAS WELDED. THE SEAT WAS REPAIRED. IN ADDITION, THE CONTACT WAS CONCERNED FOR HIS SAFETY BECAUSE THE SEAT BELT WAS ATTACHED TO THE FRAME. THE CONTACT CALLED PINE BELT CHEVROLET DEALER AND THE MANUFACTURER WHO STATED THAT THERE WAS NO REPLACEMENT PART. THE APPROXIMATE FAILURE MILEAGE WAS 218,000.

I PULLED INTO DRIVEWAY AND PUT CAR IN PARK, LEFT ENGINE RUNNING. WENT TO DOOR OF RESIDENCE TO GET MY KIDS. KIDS WENT OUT TO THE CAR AND WERE YELLING FIRE! I SEEN THE INSIDE UP IN SMOKE. I REACHED INSIDE TO TURN ENGINE OFF. WE THEN STARTED POURING BUCKETS OF WATER INTO SEAT AND ON FLOOR AROUND THE SEAT TO TRY TO PREVENT SPREAD OF THE FIRE. I LUCKILY PUT THE FIRE OUT. FIRE DEPT UNHOOKED BATTERY AND REMOVED MELTED PLASTIC AROUND SEAT. IT SEEMS A WIRE SOMEHOW SHORTED OUT BENEATH SEAT AND CAUGHT THE SEAT AND FLOOR ON FIRE.

WHILE DRIVING ON TWO LANE COUNTRY HIGHWAY AT 55MPH LOW BEAM HEAD LIGHTS WENT OFF. AFTER A FEW SCARY SECONDS I WAS ABLE TO FIND A SAFE PLACE TO STOP. I TRIED SEVERAL THINGS AND DISCOVERED THAT THE HIGH BEAMS STILL WORKED. I PROCEEDED TO MY DESTINATION DEFECTIVE MULTI FUNCTION SWITCH. INTERNET TELLS ME I AM ONE OF MANY.