2009 Chevrolet Silverado 1500 Brakes Problems

While driving my 2009 Chevy Silverado hybrid with 32000 miles my brakes stopped working my DIC showed brake problems, stable track and traction control, had it towed to Chevy dealership was informed it will cost $4000 to fix, the one bad parts is a Modulator Valve part #25922981, I have found a Chevy service bulletin from May -2016 #PIT4383P about this problem looks like if this part goes bad they will replace it can you confirm this, if I was on a highway this would have been a very bad accident thanks for your help

NHTSA ID

11473064

Incident

Jun 8, 2022

The contact owns a 2009 Chevrolet Silverado 1500. The contact stated that upon starting the vehicle, the brake and ABS warning lights were illuminated. The vehicle was taken to the dealer who diagnosed that the electronic control module and the ABS module needed to be replaced. The manufacturer was made aware of the failure and advised the contact that they would follow up with the dealer. The vehicle was not repaired. The approximate failure mileage was 70,800.

NHTSA ID

11428110

Incident

Jul 16, 2021

Mileage

70,800 mi

INCREDIBLE AMOUNT OF FRAME RUST. VEHICLE ONLY HAS 22500 MILES BUT HAS EXTENSIVE FRAME RUST AND FRONT SWAY BAR FRAME SEPARATION. ALSO HEAVILY RUSTED BRAKE LINES. I HAVE ALREADY REPLACED TRANSMISSION SHIFTER PAWL AND TRANSMISSION COOLING LINES. I SEE WIDELY POSTED OCCURRENCE ON YOUTUBE & SOCIAL MEDIA. I DO NOT UNDERSTAND WHY GM IS GETTING A PASS ON THESE HORRIBLE PRODUCT ISSUES. NO LISTED RECALLS ON SITE.

NHTSA ID

11376105

Incident

Nov 1, 2020

STEERING ANGLE SENSOR IS FAULTY. THIS IS AN INTEGRAL PART OF THE VEHICLE SAFETY SYSTEMS, INCLUDING ABS, AND TRACTION/ STABILITY CONTROL. HOW CAN THIS PART BE NO LONGER MANUFACTURED AFTER ONLY 9 YEARS? ALL SAFETY CONTROLS SHUT OFF WHILE VEHICLE IS IN MOTION.

NHTSA ID

11375358

Incident

Nov 3, 2020

Mileage

158,000 mi

THE ENTIRE UNDERBODY, INCLUDING ROCKERS, INNER DOOR PANEL FRAME, TAILGATE AREA, ENGINE BAY AREA, AND BRAKES, CONTROL ARMS, STRUTS IS RUSTED OVER.

NHTSA ID

11101668

Incident

Jan 10, 2013

Mileage

70,000 mi

I OWN A '09 CHEVROLET SILVERADO 2500 PICKUP WITH AN INTEGRATED TRAILER BRAKE CONTROLLER. MY DRIVER INFORMATION CENTER GAVE ME A WARNING "SERVICE TRAILER BRAKE SYSTEM". I TOOK THE TRUCK TO THE DEALER AND WAS TOLD THAT THE ABS/STABILITY CONTROL MODULE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THEY SAID IT WAS ON BACKORDER FROM GM. IT TURNS OUT THAT GM HAS NO ABS CONTROL MODULES (PART#25802684) IN THE ENTIRE COUNTRY! WITH THIS MODULE BEING BAD IT CUTS POWER TO THE TRAILER BRAKES. YOU END UP WITH NO BRAKES ON ANY TRAILER YOU TOW THAT HAS ELECTRIC BRAKES. THIS IS AN EXTREMELY DANGEROUS SITUATION. I WAS LUCKY THAT MY TRAILER WAS NOT CONNECTED AT THE TIME OF THE FAULT. IF I HAD BEEN TOWING MY CAMPER AND LOST BRAKING POWER TO IT, THE RESULT COULD HAVE BEEN CATASTROPHIC. GM HAS NO FIX FOR THIS. I AND EVERY OTHER OWNER (A LOT) ARE STUCK WITH NO PARTS TO FIX THIS PROBLEM. PLEASE INVESTIGATE WHY GM LET THEIR STOCK IN THE ENTIRE COUNTRY GO TO ZERO ON SUCH A CRITICAL SAFETY RELATED PART. THANK YOU *TR

NHTSA ID

10893354

Incident

Jul 25, 2016

STOPPED AT A STOP SIGN, AND TRUCK WOULD NOT MOVE SO I BACKUP THEN IT WENT AHEAD. THE FIRST CORNER I WENT AROUND HEARD A SCRAPPING SOUND. WENT TO DEALER TRUCK HAD 16615 MI. ON IT , HAD 16615 MILES ON WHEN I GOT IT BACK, THEY SAID NOTHING WRONG. HAD SAME TROUBLE 2 DAYS LATER WENT BACK TO DEALER THEN THEY TOLD ME BOTH REAR SEALS WERE LEAKING THAT ALSO RUINED BOTH REAR BRAKE CYLINDERS. ALL WAS REPLACED THEY SAID WAS NOT COVERED ON MY WARRANTY COST 191.20 REAR WHEEL SEALS, 98.08 FOR REAR WHEEL BRAKE CYLINDERS. GM WAS NO HELP.

NHTSA ID

10863182

Incident

Sep 23, 2013

Mileage

16,615 mi

I HAVE A 2009 CHEVROLET SILVERADO 1500. THE BRAKE SYSTEM WENT OUT AND THE DEALERS REFUSE TO DO ANYTHING BECAUSE IT IS OUT OF WARRANTY. I DID SOME RESEARCH AND FOUND THAT THE 2009 CHEVROLET SILVERADO ON MANY TRUCKS HAVE HAD PROBLEMS. I HAVE ANOTHER 2009 CHEVROLET SILVERADO WITH 26,000 MILES WITH THE SAME PROBLEM...UPDATED 05-26-15 *BF UPDATED 7/6/2015*JS UPDATED 11/4/2015*JS

NHTSA ID

10705719

Incident

Feb 20, 2015

Mileage

43,000 mi

WHILE DRIVING THE STABILITRAK LIGHT CAME ON AND THEN THE ABS LIGHT. IT STAYED ON, SO I TOOK IT TO A MECHANIC WHO DETERMINED IT WAS THE BRAKE SWITCH AND HE REPLACED IT. IT HAS BEEN FINE UNTIL RECENTLY, WHEN IT CAME ON AGAIN AND MY BRAKE LIGHTS WERE STICKING ON, SO I REPLACED THE BRAKE SWITCH AGAIN. SO, FAR IT'S STAYED OFF. MY CONCERN IS THAT MY TRUCK MY START HAVING THE SAME ISSUES AS OUR OTHER GM VEHICLE, WHICH ALSO INVOLVES THE STABILITRAK/TRACTION CONTROL/REDUCED POWER LIGHTS COMING ON. REDUCED POWER IS DANGEROUS WHILE DRIVING, ESPECIALLY ON THE INTERSTATE IN HEAVY TRAFFIC. I HAVE READ GM FORUMS AND HAVE FOUND THAT THIS PROBLEM HAS BEEN HAPPENING AS FAR BACK AS 6 YEARS, AND GM STILL HAS NOT FIGURED OUT HOW TO FIX IT.

NHTSA ID

10706737

Incident

Mar 17, 2014

Mileage

88,986 mi

THE BRAKES ON THIS SILVERADO DO NOT RELEASE. YOU HAVE TO PRESS THE GAS ABOUT HALF WAY DOWN THEN THEY WILL "POP" AND BECOME FREE ALL AT ONCE LUNGING THE VEHICLE FORWARD. YOU THEN HAVE TO PRESS THE BRAKE AGAIN DUE TO THE AMOUNT OF THROTTLE APPLIED. ONCE APPLIED AGAIN THE BRAKES WILL LOCK UP AND THE PROCESS REPEATS ITSELF. THIS IS WHAT HAPPENS WHEN IN TRAFFIC. IF THE VEHICLE IS TRAVELING 20 MPH OR UNDER WHEN FOOT IS NOT ON THE ACCELERATOR THE TRUCK WILL APPLY THE BRAKES ON ITS OWN PULSING AND SURGING. THIS IS A VERY DANGEROUS SITUATION WHEN IN TRAFFIC AND TRYING TO NAVIGATE THROUGH PARKING LOTS AND ROADS WITH PEDESTRIANS. *TR

NHTSA ID

10683541

Incident

Nov 1, 2014

Mileage

70,000 mi

DASH CRACKED AT CORNER OF PASSENGER AIRBAG NOTICED AROUND 55,000 MILES. ENGINE CONSUMING OIL, NOTICED AROUND 40,000 MILES. FRONT BREAKS VIBRATING, NOTICED AROUND 18,000 MILES. DEALER AND GM HAS REFUSED TO FIX. *JS

NHTSA ID

10661947

Incident

Aug 8, 2014

Mileage

55,000 mi

I HAVE HAD THIS PROBLEM OCCASIONALLY SINCE I BOUGHT THE TRUCK NEW, BUT RECENTLY IT STARTED TO DO THE SAME THING ON A REGULAR BASIS. START THE TRUCK AND IT'S FINE, BUT GO TO SHIFT INTO GEAR AND THE SERVICE ENGINE, SERVICE TRACTION CONTROL, AND SERVICE ABS LIGHTS AND MESSAGES COME ON THE DASH. TODAY, I PRESSED THE BRAKES WHILE DRIVING IT AND HEARD A CLICK WHEN I DID SO, SO I PULLED OVER AND CHECKED AND FOUND THAT IF I PUSH MY BRAKE PEDAL VERY FAR, MY BRAKE LIGHTS WENT OUT. I JUST HAD MY VEHICLE SERVICED AND INSPECTED AT THE GM DEALERSHIP ABOUT 9 MONTHS/5,000 MILES AGO. HOPEFULLY THIS TRUCK DOESN'T GET ME OR MY WIFE INTO A FATAL ACCIDENT... *TR

NHTSA ID

10653670

Incident

Nov 1, 2014

Mileage

65,000 mi

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE BRAKE LIGHTS DID NOT ALWAYS ILLUMINATE WHEN THE BRAKE PEDAL WAS DEPRESSED. THE FAILURE RECURRED WHENEVER THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHERE THE BRAKE BOOSTER AND THE BRAKE SWITCH WERE REPLACED. THE FAILURE CONTINUED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 5. THE CONSUMER STATED HE PUSHED THE BRAKE PEDAL ALL THE WAY TO THE FLOOR TO ACTIVATE THE BRAKE LIGHTS. HE OBSERVED THE BRAKE LIGHTS USING THE GLASS WINDOWS. HE QUICKLY LET OFF THE PEDAL ABOUT 1/2 TO ONE INCH AND HE NOTICED THE LIGHTS WENT OUT BEFORE THE PEDAL WAS FULLY RELEASED. THE CONSUMER BELIEVED THE BRAKE SWITCH WAS DEFECTIVE.

NHTSA ID

10459580

Incident

Oct 1, 2009

Mileage

5 mi

WARPED FRONT ROTORS BOTH WHEELS. WHILE DRIVING GOING DOWN A HILL, THE STEERING WHEEL WOULD START SHAKING. I AM A RETIRED MASTER MECHANIC WITH OVER 30 YEARS EXPERIENCE SPECIALIZING IN BRAKES. I TOOK MY VEHICLE TO THE DEALER 4 TIMES WITH THIS COMPLAINT. THE DEALER COULD NOT DUPLICATE THE COMPLAINT BECAUSE OF NOT TEST DRIVING DOWN A HILL. TEST DRIVE WAS ON A FLAT SURFACE. PROBLEM ONLY OCCURS WHILE DRIVING DOWN A HILL. I WAS WORRIED ABOUT SAFETY AFTER SO MANY SERVICE VISITS, I FINALLY CALLED GENERAL MOTORS IN DETROIT TO FILE A COMPLAINT. GENERAL MOTORS REPLACED THE ROTORS AS A GOODWILL GESTURE. THE PROBLEM HAS NOT RE-OCCURRED AFTER ROTOR REPLACEMENT. *TR

NHTSA ID

10456351

Incident

Dec 7, 2010

Mileage

10,422 mi

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHENEVER THE BRAKES WERE DEPRESSED, THE HEADLIGHTS WOULD INTERMITTENTLY FLASH ON AND OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER APPROXIMATELY TWENTY TIMES BUT THE DEALER WAS UNSURE AS TO HOW TO REPAIR THE PROBLEM AND ADVISED THE FAILURE WAS NORMAL BECAUSE OF A NEW CHARGING SYSTEM. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 19,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 38,000.

NHTSA ID

10350243

Incident

Sep 20, 2009

Mileage

19,000 mi

WARPED FRONT ROTORS BOTH WHEELS. *TR

NHTSA ID

10331850

Incident

Feb 1, 2010

Mileage

2,000 mi

THE BRAKE PEDAL BACK PRESSURE IS WEAK, SPONGY OR SOFT WHEN APPLIED. THE BRAKE PEDAL GOES TO FLOOR BOARD FURTHER THAN NORMAL/ TRADITIONAL OF ALL MANUFACTURER VEHICLE MODELS THROUGH OUT PAST DECADES OF PRODUCTION. HAVE TO PUMP THIS VEHICLES BRAKE PEDAL MORE THAN TWICE IN ORDER TO OBTAIN SUFFICIENT BRAKE PEDAL PRESSURE NECESSARY TO ACHIEVE CONTROL OF VEHICLE'S BRAKES. FOR UNEXPECTED BRAKING, THE CURRENT BRAKING SYSTEM ON 1500 SILVERADO CHEVROLETS IS INADEQUATE FOR THE AVERAGE DRIVER WHICH POSSIBLY WILL RESULT WITH HARM TO OTHERS AND VEHICLE. *TR

NHTSA ID

10320339

Incident

Oct 2, 2009

NOT MUCH FOR BRAKES ON THE INITIAL PUSH OF THE PEDAL BUT IF YOU PUMP THEM UP THEY ARE GOOD. REALLY BAD IN A EMERGENCY STOP OR WHEN YOU HAVE A LIGHT TRAILER ON THAT DOESN'T REQUIRE SEPARATE BRAKES ON TRAILER. I HAD IT BOTH ON 1500 4X4 08GMC AND ON THE SAME 09 CHEVY I HAVE NOW. *TR

NHTSA ID

10316365

Incident

Oct 21, 2009

Mileage

3,600 mi