2009 Chevrolet Silverado 1500 Steering Problems

Power steering assist motor shaft broke. This caused power steering failure and lost control of the vehicle.

NHTSA ID

11494979

Incident

Nov 25, 2022

The contact owns a 2009 Chevrolet Silverado 1500. The contact stated while driving at an undisclosed speed, the brakes seized without warning, causing the ABS to activate. The failure nearly caused a collision. The vehicle was taken to the dealer where it was diagnosed with a faulty steering angle sensor; however, the dealer informed the contact that the steering angle sensor part was no longer being manufactured. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 220,000.

NHTSA ID

11467149

Incident

Jan 1, 2022

Mileage

220,000 mi

I was driving on the road. The road naturally turned to the left, and when I turned the steering wheel, the truck did not turn. I hit three parked cars. The steering column steering shaft disconnected from the back of the steering wheel. There was no warning signs prior to the accident. I contacted GM. They sent out a adjuster. And denied my claim but did not give me a reason why. My safety was at risk because I lost my steering. The steering wheel turned but the steering shaft became disconnected from the back of the steering wheel and there was no steering. This is a huge safety concern. If this happens to other people. Some one will get killed. I have pictures of the defective part.

NHTSA ID

11436233

Incident

Jul 6, 2021

STEERING ANGLE SENSOR IS FAULTY. THIS IS AN INTEGRAL PART OF THE VEHICLE SAFETY SYSTEMS, INCLUDING ABS, AND TRACTION/ STABILITY CONTROL. HOW CAN THIS PART BE NO LONGER MANUFACTURED AFTER ONLY 9 YEARS? ALL SAFETY CONTROLS SHUT OFF WHILE VEHICLE IS IN MOTION.

NHTSA ID

11375358

Incident

Nov 3, 2020

Mileage

158,000 mi

AT 75MPH ON TOLL ROAD AT NIGHT, SUDDENLY THE LIGHTS (ALL EXTERNAL & INTERNAL) WENT DARK. HAZARD LIGHT WOULD NOT WORK, ENGINE QUIT, BELL WENT OFF (DOOR-KEY IN IGNITION BELL), RPM SURGED. WAS ABLE TO GET OFF ROAD AND WAITED 10 MINUTES AND TRUCK STARTED. DROVE OFF, GOT TO 60 AND SAME THING HAPPENED. WAITED 30 MINUTES AND TRUCK WAS OK EXCEPT WHEN BRAKES APPLIED -DOOR/KEY BELL WENT OFF. DEALER HAD TRUCK FOR THREE DAYS AND COULD NOT DUPLICATE. WENT TO UTUBE AND TYPED IN ELECTRICAL PROBLEMS-2009 SILVERADO AND SEVERAL PAGES OF THE EXACT SAME PROBLEM APPEARED.CALLED DEALER TOLD THEM TO REPLACE THE BATTERY GROUND CABLE AND TO CHECK THE MEGA FUSE. SO FAR THE TRUCK IS RUNNING OK (INCIDENT HAPPENED IN JULY 2017) SEEMS LIKE THE BACK YARD MECHANICS KNOW MORE ABOUT HOW TO FIX THIS PROBLEM. THIS IS SERIOUS, DRIVING AT NIGHT AT 75 AND LOSING ALL ELECTRICS IS AN ACCIDENT WAITING TO HAPPEN. THE MANUFACTURE NEEDS TO BE HELD ACCOUNTABLE FOR THE POOR QUALITY GROUND CABLES; THIS SHOULD BE A RECALL!!!

NHTSA ID

11039210

Incident

Jul 26, 2017

Mileage

49,750 mi

WHILE EXITING A PARKING LOT TO TURN NORTH, THE STEERING FAILED CAUSING MY VEHICLE TO GO ACROSS ONTO THE MEDIAN BEFORE I STOPPED THE VEHICLE. THE MOTOR SHAFT OF THE ELECTRICAL POWER STEERING SNAPPED.

NHTSA ID

10939577

Incident

Dec 15, 2016

Mileage

73,000 mi

TOOK TRUCK IN FOR VEHICLE INSPECTION. TRUCK FAILED INSPECTION DUE TO LEAKING STEERING GEAR. THE DEALER SAID I WOULD HAVE TO REPLACE THE STEERING GEAR $800 AND THEN THE TRUCK WOULD PASS INSPECTION . THIS TRUCK HAS 14000 MILES ON IT . A SEARCH ONLINE REPORTED A RECALL BECAUSE OF THE TIE ROD GOING INTO THE STEERING BOX WAS NOT TIGHT ENOUGH CAUSING DAMAGE TO GEAR BOX . DEALER WAS SUPPOSE TO FIX AT NO CHARGE THIS PROBLEM.

NHTSA ID

10762500

Incident

Sep 9, 2015

Mileage

14,000 mi

I BOUGHT THIS TRUCK USED FROM A CHEVY DEALER. IT STEERS BADLY. CONSTANT NEED TO OVER CORRECT. HIGH TURNING RESISTANCE AT ANY SPEED. THE DEALERS MECHANIC DROVE IT AND SAID NOTHING WRONG. NOT ABLE TO GREASE BALL JOINTS. SOMETHING DRAGGY OR LOW PUMP PRESSURE, ETC. THIS TRUCK IS TIRING TO DRIVE AND NOT SAFE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10617648

Incident

Jul 30, 2014

Mileage

68,000 mi

VEHICLE WAS STRUCK BY A MOTORCYCLE TRAVELING AROUND 50MPH IN THE DRIVERS SIDE FRONT TIRE. THIS IS A 4 WHEEL DRIVE VEHICLE. THE MOTORCYCLE WAS ONLY A 50CC MODEL SMALL MOTORCYCLE. THIS RESULTED IN THE SPINDLE BREAKING IN TWO AT THE POINT JUST BEHIND WHERE THE TIE ROD END CONNECTS RESULTING IN A LOSS OF STEERING ON THAT WHEEL. LUCKILY THE SILVERADO WAS ONLY TRAVELING APPROXIMATELY 25 MPH AT THE TIME OF THE ACCIDENT AND WAS SAFELY STOPPED IN A SHORT DISTANCE. THIS IS A HEAVY DUTY PART AND SHOULD NOT HAVE BROKEN. THE TIE ROD SHOULD HAVE BROKEN FIRST. *TR

NHTSA ID

10286158

Incident

Oct 2, 2009

Mileage

12,745 mi