2009 Chevrolet Silverado 1500 Fuel system Problems

Solenoid was rubbed by the wiring harness which caused a leak.

NHTSA ID

11582806

Incident

Apr 13, 2024

Steel fuel line of fuel sending unit rusted out causing fuel to be sprayed through a pin hole sized area at high pressure.

NHTSA ID

11548926

Incident

Oct 6, 2023

Fuel system leak at fuel pump due to corrosion. Found raw gas leaking out from under vehicle while vehicle in operation. Upon further investigation, found metal supply and return lines severely corroded and leaking. Repaired with new pump. While being repaired, noted severe corrosion on frame and cross members to include upper shock mounts and spare tire mount. Holes in frame were noted.

NHTSA ID

11491344

Incident

Oct 28, 2022

For the last few months, my Silverado 1500 Hybrid has been experiencing "bump jerk" phenomenon related to the Hybrid mode auto stop mode and the auxiliary transmission pump intermittently not operating correctly. This issue is intermittent. Sometimes in autostop, the truck behaves normally in Hybrid mode. However, when the auxiliary transmission pump is not operating correctly in auto stop mode and below 25 mph, the truck is at risk of not moving forward in proportion to throttle response as well as rolling backward if my foot is let off the brake while in traffic. After some research, this issue is described in PIP4751G.

NHTSA ID

11441112

Incident

Nov 19, 2021

Gas leak on top of fuel tank. When fuel pump is powered gas leaks.

NHTSA ID

11427558

Incident

Jul 26, 2021

MY FUEL PUMP CONTROL MODULE PN20759945 SHORTED. RECALL BULLETIN 14515 COVERS MY MODEL YEAR AND PART NUMBER. HOWEVER, GM CLAIMS MY VIN IS NOT COVERED BY THIS. THIS IS THE SAME PART AND SAME FAILURE LISTED IN THE RECALL BULLETIN, AND IMO IT SHOULD BE COVERED BY GM. FCPM'S ARE POORLY DESIGNED AND POORLY PLACED AND FAIL ON MANY MANY GM MODELS OVER A NUMBER OF YEARS. THIS IS AN ITEM THAT SHOULD BE EXPANDED TO INCLUDE ALL VEHICLES WITH THAT PART NUMBER, ESPECIALLY IF THEY ARE MOUNTED EXTERNALLY AND EXPOSED TO THE ENVIRONMENT SUCH AS ON ALL CHEVY SLIVERADOS AND RELATED TRUCKS. THE FAULT IN MY CASE WAS A CHECK ENGINE LIGHT, AND NOT A CRANK NO START. I TOOK THE TRUCK TO GM FOR DIAGNOSIS. THEY SAID THE FCPM NEEDS REPLACED AS IT SHOWS AND INTERNAL FAULT. THIS IS AN EXPENSIVE PART AND SERVICE,WHICH SHOULD BE COVERED BY GM UNDER THE BULLETIN IMO.

NHTSA ID

11192870

Incident

Dec 26, 2018

Mileage

115,000 mi

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO 1500. WHILE DRIVING 40 MPH, THE VEHICLE STALLED AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FUEL FLOW CONTROL MODULE HAD MOISTURE IN IT, WHICH CAUSED THE VEHICLE TO STALL. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 68,242.

NHTSA ID

11175069

Incident

Feb 3, 2019

Mileage

68,242 mi

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO 1500. WHILE DRIVING APPROXIMATELY 50 MPH, THE CHECK ENGINE INDICATOR ILLUMINATED AND THE ENGINE SHUT DOWN A FEW MINUTES LATER. THE VEHICLE WAS TOWED TO DAVE WHITE CHEVROLET (419-885-4444, LOCATED AT 5880 MONROE ST, SYLVANIA, OH 43560) WHERE THE TECHNICIAN DIAGNOSED AND REPLACED THE FUEL PUMP CONTROL MODULE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 65,199. *DT CONSUMER STATED ALL INFO IS CORRECT. UPDATED 12/19/18*JB

NHTSA ID

11150320

Incident

Oct 31, 2018

Mileage

65,199 mi

THE LIFTERS IN THE 5.3 ENGINES ARE COMPLETELY TRASH. EVERYONE WHO HAS A SILVER WITH THE 5.3 HAS TO CHANGE LIFTERS OFTEN. MY LIFTERS HAS WENT OUT 2 TIMES IN THE LAST 5 MONTHS. THIS IS A BIG FLAW IN THE SILVERADO. I WAS DRIVING DOWN THE HIGHWAY AT ABOUT 70 AN ALL OF THE SUDDEN MY ENGINE LIGHT STARTS FLASHING AND MY TRUCK STARTS TICKING AND MISSING REALLY BAD.

NHTSA ID

11091003

Incident

Apr 29, 2018

Mileage

123,000 mi

THE VEHICLE WAS BEING DRIVEN BY MY SON WHEN SERVICE ENGINE LIGHT CAME ON AND I THEN USED MY ACTRON SCAN TOOL AND PULLED 3X CODES FROM THE COMPUTER (ECU) CODES RELATED TO THE FUEL PUMP CONTROL MODULE , AND TRAILER BRAKE WARNING LIGHT APPEARED ON THE INSTRUMENT CLUSTER CLEARED THESE CODES. 2 DAYS LATER CODES REAPPEARED ALL WERE FUEL PUMP CIRCUIT LOW, FUEL PUMP MODULE AND TRAILER BRAKE CODES. CLEARED CODES THEN INSPECTED THE FPSM VISUALLY REMOVED REAR COVER AND THE FPSM WAS FULL OF WATER I THEM DRIED IT OUT FOR 2X DAYS IN THE SUN TRUCK RAN AFTER REASSEMBLY. BUT 3X DAYS LATER THE TRUCK FAILED TO START THIS TIME WITH COMPUTER SCAN TOOL IN HAND I CHECKED THE FUEL PUMP PRESSURE, THE TRUCK HAD NO FUEL PUMP PRESSURE. I THEN WENT TO MY LOCAL CHEVROLET DEALER AND GAVE THEM THE V.I.N. # TO CHECK THE VEHICLE FOR RECALLS. ONLY RECALL WAS FOR SAFETY BELT RECALL WHICH WAS DONE IN 2009. I FOUND OUT THERE WAS A POTENTIAL RECALL FOR THE FPSM ON THIS WEBSITE. SO II INQUIRED TO THE PARTS DEPARTMENT FOR THIS PART,IT WAS IN STOCK AND 183.00. I THEN PURCHASED A NEW AC DELCO MODULE ON-LINE FOR 85.00 PUT IT ON AND THEN FOUND MY LOCAL SHOP IN TOWN TO HAVE A TECH COME OUT TO RE-FLASH THE FPSM SO THE (ECU) WOULD RECOGNIZE THE NEW PART. I AM SAVING MY COPIES OF THE BILLS SO THAT WHEN SOMEONE DIES FROM THIS PART FAILING WHEN IT STOPS THE VEHICLE HOPEFULLY I CAN BE REIMBURSED FOR ANOTHER PLANNED GM PART FAILURE... SINCERELY MR. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *JB *TR

NHTSA ID

10986074

Incident

Apr 23, 2017

Mileage

72,316 mi

ON THURSDSY, APRIL 27, 2017, I PARKED MY 2009 CHEVY SILVERADO AT HOME IN MY DRIVEWAY AFTER WORK AND SHUT IT OFF FOR THE NIGHT. IT WAS STATIONARY AT THAT POINT. I DID NOT RESTART IT OR MOVE IT FOR THE REMAINDER OF THE DAY/EVENING. THE NEXT MORNING, THE ENGINE WOULD NOT START. IT SOUNDED LIKE IT WAS GOING TO START, BUT TO NO AVAIL AFTER SEVERAL TRIES. I DETERMINED IT WAS NOT GETTING FUEL. I CALLED A LOCAL AUTO REPAIR TECH WHO DIAGNOSED IT ON SITE, TO BE A FAULTY CHASSIS ELECTRONIC CONTROL MODULE, WHICH SENDS FUEL TO THE FUEL PUMP. UPON RESEARCHING THE PROBLEM, I FOUND A RECALL BULLETIN / PRODUCT SAFETY RECALL #14515B ISSUED JANUARY 2015. IT CLEARLY STATES THAT THE 2007-2013 CHEVROLET SILVERADO (ALONG WITH MANY OTHER MAKES/MODELS/YEARS) MAY HAVE A CHASSIS ELECTRONIC MODULE COULD HAVE INTERNAL CONTAMINATION (WATER, BUILD-UP CAUSING WIRE AND BOLT CORROSION). I BELIEVE THIS TO BE THE CASE FOR MY VEHICLE. ACCORDING TO THE BULLETIN, THE UNSAFE FACTOR IS THAT THE "VEHICLE COULD STALL WHILE IN MOTION AND INCREASE THE RISK OF A VEHICLE CRASH." WWW-ODI.NHTSA.DOT.GOV/ACMS/CS/JAXRS/DOWNLOAD/DOC/UCM472842/RCRIT-14V614-0055.PDF I AM THE THIRD OWNER SO I DID NOT RECEIVE A RECALL NOTICE DIRECTLY. I PURCHASED THIS VEHICLE MAY 24, 2016.

NHTSA ID

10982982

Incident

Apr 27, 2017

Mileage

92,000 mi

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO 1500. WHEN THE CONTACT ATTEMPTED TO START THE VEHICLE, ALL THE WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT'S UNCLE CHECKED THE VEHICLE AND DETERMINED THAT THE ENGINE FAILED TO RECEIVE FUEL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 84,000.

NHTSA ID

10970988

Incident

Mar 21, 2017

Mileage

84,000 mi

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO 1500. WHILE DRIVING 40 MPH, THE VEHICLE EXPERIENCED HESITATION, A LOSS OF POWER, AND STALLING. ALSO, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP MODULE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.

NHTSA ID

10969038

Incident

Mar 27, 2017

Mileage

80,000 mi

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE RESTARTED AFTER NUMEROUS ATTEMPTS. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE FUEL SYSTEM CONTROL MODULE WAS REPLACED. THE VEHICLE WAS ALSO TAKEN TO THE DEALER, WHO REPROGRAMMED THE PCM SOFTWARE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 104,000.

NHTSA ID

10596439

Incident

May 2, 2014

Mileage

104,000 mi

WAS JUST LEAVING FUNERAL AND STARTED VEHICLE THEN SERVICE TRACTION CONTROL, SERVICE STABILITRAK, TRACTION CONTROL OFF, STABILITRAK OFF, LOSS OF CONTROL NOTICED DISPLAYED. TRIED TO DRIVE BUT EXPERIENCED BUCKING AND DRASTIC POWER LOSS. TOOK TO DEALER WHO SAID FAILURE WAS DUE TO FAULTY THROTTLE POSITION SENSOR - A PROBLEM HE INDICATED WAS RECURRING FOR THAT VEHICLE. LUCKILY HE SERVICED UNDER VEHICLE WARRANTY. BUT DISAPPOINTING TO SEE AT LESS THAN 40,000 MILES. *TR

NHTSA ID

10588548

Incident

Jan 7, 2014

Mileage

39,289 mi