2005 Chevrolet Silverado Airbags Problems

The contact owns a 2005 Chevrolet Silverado 1500. The contact stated while driving approximately 50 mph, he lost control of the vehicle due to losing consciousness. The vehicle left the roadway and went airborne and crashed with a road sign landing in a field. None of the airbags deployed and only the seatbelt lap belt tensioned not the shoulder strap. The contact sustained injuries such as several lacerations across the face and inside the mouth, and broken L1 vertebrae. The contact mentioned he fractured the steering wheel with his face during the impact. A police report was filed and the vehicle was towed to a local lot then towed again to the contacts insurance lot where it was awaiting a diagnosis. The manufacturer was not informed of the failure. The failure mileage was approximately 281,000.

NHTSA ID

11425653

Incident

Jul 16, 2021

Mileage

281,000 mi

SRS WARNING CAME ON. HAD FAULT CODE. CALLED CHEVY DEALER AND THEY SAID I WOULD NEED A NEW AIRBAG. I RESEARCHED AND FOUND THAT GM DOES KNOW ABOUT THIS AND EVEN PUT OUT A TSB. IT IS A CONNECTOR TO THE AIRBAG ITSELF LOCATED IN THE LEFT KICK PANEL. THE FIX IS TO CLEAN THE CONNECTOR OR REPLACE IT. NO NEW AIRBAG IS NEEDED BUT IT DID REOCCUR ABOUT A YEAR LATER. RECLEANED AND OK AGAIN. THIS IS A SAFETY ITEM AND SHOULD BE A RECALL. SINCE GM KNEW IT I MUST ASSUME THAT NHTSA KNEW IT ALSO. I CAN SEE WHERE A LOT OF PEOPLE WOULD NOT FIX THIS AND JUST DRIVE LIKE THIS SINCE A LOT OF TECHNICIANS THINK YOU NEED A NEW AIRBAG WHEN IT IS IN FACT POOR WIRING BY GM. *TR

NHTSA ID

10669755

Incident

Jan 6, 2014

Mileage

50,250 mi

WHEN I GOT IN THE TRUCK TO GO TO WORK, AIRBAG WARNING LIGHT ALONG WITH THE DIC NOTIFICATION WHERE ON. WITH A OSB II READER, GOT A CODE OR "B0104 FRONT RIGHT SENOR REPLACE". REPLACED THE SENOR AT OWNERS EXPENSE. WITH NEW PART INSTALLED THE WARNING LIGHT AND DIC MESSAGE CLEARED. *TR

NHTSA ID

10654005

Incident

Oct 24, 2014

Mileage

161,378 mi

CHECK AIRBAG LIGHT STAYS ON.. DO I NEED TO DISENGAGE? PLEASE ADVISE. *TR

NHTSA ID

10651480

Incident

Oct 8, 2014

FOR NO APPARENT REASON, THE AIR BAG WARNING LIGHTS ON VEHICLE CAME ON WHEN STARTING THE VEHICLE. VEHICLE HAS NOT BEEN INVOLVED IN ANY ACCIDENT. VEHICLE WAS TAKEN IN FOR REPAIR AND REPAIR SHOP SAID THE FRONT SENSORS FOR NO APPARENT REASON HAD GONE DEFECTIVE DISABLING THE AIR BAGS ON VEHICLE. SENSORS HAD TO BE REPLACED AND I WAS TOLD PARTS WERE ONLY AVAILABLE FROM A CHEVROLET DEALERSHIP. AFTER REPAIR I CHECKED ONLINE AND FOUND NUMEROUS OTHER OWNERS OF CHEVROLET VEHICLES HAVE EXPERIENCED THE SAME PROBLEM. I AM CONCERNED WITH THE SAFETY ISSUE OF DISABLED AIR BAGS WHEN THIS PART GOES DEFECTIVE FOR NO REASON. *TR

NHTSA ID

10644270

Incident

Oct 1, 2014

Mileage

77,000 mi

SERVICE AIR BAG WARNING LIGHT HAS BEEN ON SINCE 2007, WHEN VEHICLE WAS STILL UNDER WARRANTY. HAS BEEN TO BOB GRIMM CHEVROLET IN MORTON, IL FOR THIS SAME PROBLEM APPROX 9 TIMES. I NO LONGER LIVE IN THE VICINITY OF THIS DEALER, AND WOULDN'T WANT THEM WORKING ON IT AGAIN SINCE THEY HAVE BEEN UNABLE TO REPAIR MULTIPLE TIMES. WRITTEN COMMUNICATION TO GM ALL THE WAY UP TO CEO HAS NOT RESOLVED THIS ISSUE. JACK SCHMITT CHEVROLET IN O'FALLON, IL DID A DIAGNOSTIC AND REPORTED THE AIR BAG IN MY VEHICLE IS USED. NOBODY HAS EVER WORKED ON THE TRUCK REGARDING THE AIR BAG EXCEPT BOB GRIMM CHEVROLET. MY UNDERSTANDING IS WHEN THIS LIGHT IS ON, THE AIR BAG WILL NOT DEPLOY, ENDANGERING MY LIFE. *TR

NHTSA ID

10638496

Incident

Aug 3, 2007

Mileage

22,775 mi

WHILE DRIVING DOWN THE ROAD MY SERVICE AIR BAG LIGHT WHEN ON, WAS TOLD AIR BAGS AND SAFETY PRODUCTS WOULD NOT WORK UNLESS FIXED,$500.00 LATER DONE 2YRS LATER 08/22/14 LIGHT IS ON AGAIN?? 30,000 MORE MILES? I NEVER OFF ROAD AND KEEP MY STUFF VERY NICE. *TR

NHTSA ID

10632924

Incident

Jul 3, 2012

Mileage

72,568 mi

AS I WAS DRIVING THE "SERVICE AIR BAG" WARNING APPEARED IN THE INFORMATION CENTER OF THE DASH AND THE AIR BAG LIGHT STARTED TO BLINK. THERE WAS NO REASON FOR THE WARNING LIGHT. I RE-SET THE INFORMATION CENTER AND THE WARNING REAPPEARED. VERY DISAPPOINTING AS THERE ARE ONLY 64,537 MILES ON THE VEHICLE. I CHECKED ON THE INTERNET TO SEE IF THERE WAS A RECALL FOR THIS PROBLEM FOR MY VEHICLE, AS THE MILES ARE VERY LOW ON MY VEHICLE. OF COURSE THERE WAS NONE FOR MY VEHICLE. IT APPEARS THIS IS A COMMON PROBLEM WITH GM VEHICLES AND AN EXTRA EXPENSE TO THE OWNERS. I'M VERY DISAPPOINTED AT THIS POINT. I COULD NOT LOCATE ANY RECALLS FOR MY VEHICLE VIN, BUT THERE WERE OTHER RECALLS INVOLVING THE AIR BAGS WITH OTHER GM VEHICLES. I'M LOST FOR WORDS. *TR

NHTSA ID

10631391

Incident

Aug 31, 2014

Mileage

64,535 mi

AIR BAG LIGHT STAYS ON. *TR

NHTSA ID

10626838

Incident

Aug 1, 2014

Mileage

120,000 mi

TURNED KEY ON AND LIGHT SAYING SERVICE AIRBAG CAME ON. LOCAL MECHANIC SAID HE READ THAT THERE WAS GOING TO BE A RECALL ON IT. *TR

NHTSA ID

10626194

Incident

Aug 18, 2014

Mileage

35,300 mi

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE AIR BAG SENSOR LIGHT WAS ILLUMINATED. THE VEHICLE WAS DIAGNOSED BY AN INDEPENDENT MECHANIC THAT DETERMINED A SENSOR INSIDE THE FRONT BUMPER WAS THE CAUSE OF THE DEFECT. THE CONTACT ALSO REPORTED THAT THE DRIVER'S SIDE REAR BRAKE LINE WAS RUSTED AND RUPTURED, WHICH CAUSED THE REAR BRAKES TO BECOME INOPERABLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED FOR THE PROBLEM. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 72,000.

NHTSA ID

10558784

Incident

Jun 11, 2013

Mileage

72,000 mi

SERVICE AIRBAG LIGHT ON. *TR

NHTSA ID

10523366

Incident

Jun 21, 2013

Mileage

81,900 mi

MY AIR BAG SENSOR MALFUNCTIONED. THIS IS A PART THAT SHOULD BE GUARANTEED BY GENERAL MOTORS. INSTEAD I PAID OVER $500 DOLLARS TO HAVE IT REPAIRED AT A DEALERSHIP. 64K MILES / 8 YEARS AND THE AIR BAG SENSOR NEEDS TO BE REPLACED? I SEARCHED ONLINE AND NOTICED MANY OTHERS ARE HAVING THIS PROBLEM. GM GOT A GOVERNMENT BAILOUT AND SHOULD BE REQUIRED TO PAY FOR THIS REPAIR. *TR

NHTSA ID

10523353

Incident

Jul 1, 2013

Mileage

64,000 mi

UPON STARTING THE TRUCK FOR THE FIRST TIME ON 6-11-2013 THE "SERVICE AIR BAG" LIGHT CAME ON AND HAS STAYED ON. THERE IS NO REASON FOR THE FAILURE OTHER THAN POOR CRAFTSMANSHIP. *TR

NHTSA ID

10516240

Incident

Jun 11, 2013

Mileage

53,005 mi

UPON STARTING TRUCK IN MORNING, "SERVICE AIR BAG" MESSAGE CAME ON. TOOK TO DEALER WHO SAID THE L FRONT IMPACT SENSOR FAILED AND NEEDS TO BE REPLACED $400+. COST SEEMS EXCESSIVE AND THE SAFETY SYSTEM FAILURE, IF THAT IS WHAT IT REALLY IS, SHOULD NOT BE MY RESPONSIBILITY. *TR

NHTSA ID

10503079

Incident

Mar 14, 2013

Mileage

159,250 mi

I WAS DRIVING THE VEHICLE AT NORMAL SPEEDS AND I HAVE HAD THIS VEHICLE FOR ABOUT 6 MONTHS AND NEVER HAVE HAD A PROBLEM WITH IT. ALL THE SUDDEN I GET A MESSAGE THAT SAYS "SERVICE AIR BAG". I TOOK THE TRUCK TO THE DEALER AND THEY DIAGNOSED IT AND THEY SAID THAT THE TRUCK NEEDS A NEW FRONT DRIVERS SIDE IMPACT SENSOR THAT WENT BAD. THIS TRUCK HAS NEVER BEEN IN AN ACCIDENT AND THE AIRBAGS HAVE NEVER BEEN DEPLOYED. THEY TOLD ME THAT IF THIS REPAIR DOES NOT GET DONE, IF I HAVE AN ACCIDENT THE AIRBAGS WOULDN'T DEPLOY. *TR

NHTSA ID

10486627

Incident

Nov 15, 2012

Mileage

167,520 mi

SERVICE AIR BAG LIGHT WAS ACTIVATED WITHOUT ANY REASON. *TR

NHTSA ID

10476881

Incident

Sep 6, 2012

Mileage

85,000 mi

I WAS DRIVING 75 MPH WITH MY CRUISE CONTROL ON, AND THE SPEEDOMETER DROPPED TO 35 MPH. SHORTLY AFTER, ABOUT 10 MILES, THE AIR BAG LIGHT CAME ON. THE SPEEDOMETER RESET AFTER TURNING OFF THE IGNITION SWITCH AND WORKED PROPERLY. THIS HAPPENED AGAIN TWO MORE TIMES, AND THE SPEEDOMETER FAILED COMPLETELY. THE AIR BAG LIGHT REMAINED ON AND IS STILL ON AT 123,000 MILES. DIAGNOSTIC CHECK SHOWED NUMBER 1 AIR BAG SENSOR FAULT. REPLACED SENSOR. AIR BAG LIGHT STILL ON. I SENT THE SPEEDOMETER HEAD TO A PRIVATE MECHANIC IN MINNESOTA, AND IT NOW WORKS FINE. *JB

NHTSA ID

10461754

Incident

Jul 4, 2011

Mileage

115,000 mi

2005 CHEVY SILVERADO CK1500. CONSUMER WRITES IN REGARDS TO DISABLING THE SWITCH FOR THE DRIVERS' AIRBAG OR IF SHE CAN OBTAIN A WAIVER SO THAT THE DEALERSHIP CAN DISABLE THE DRIVER'S AIRBAG *TGW THE CONSUMER STATED SHE HAS TO HAVE THE SEAT UP ALL THE WAY, IN ORDER TO REACH THE PEDALS; PARTICULARLY THE CLUTCH. THE CONSUMER STATED THERE IS NO WAY SHE CAN BACK FURTHER THAN THE RECOMMENDED 10 INCHES FROM THE STEERING WHEEL, DUE TO HER HEIGHT. *JB

NHTSA ID

10450953

Incident

Mar 1, 2012

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE AIR BAG LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE WIRING FOR THE AIR BAG SENSOR UNDER THE PASSENGER SEAT WAS FAILING. THE VIN WAS AVAILABLE. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 50,000.

NHTSA ID

10412384

Incident

Jun 13, 2011

AIRBAG FAILURE IN HEAD-ON COLLISION, TOTALING 2 TRUCKS. *JB

NHTSA ID

10201747

Incident

Aug 27, 2007

Mileage

21,500 mi

DT*: THE CONTACT STATED THE VEHICLE WAS INVOLVED IN AN ACCIDENT ON DRY ROADS. TWO VEHICLES COLLIDED IN FRONT OF THE CONTACT, CAUSING AN EMERGENCY BRAKING SITUATION. THE CONTACT COLLIDED WITH THE REAR OF THE SECOND VEHICLE, AND THE AIR BAGS DID NOT DEPLOY. THE CONTACT WAS INJURED IN THE ACCIDENT. AN INDEPENDENT REPAIR SHOP WAS CONSULTED AND THEY WERE UNABLE TO DUPLICATE THE PROBLEM.

NHTSA ID

10153906

Incident

Mar 27, 2006

Mileage

30,100 mi

IN JULY, MY SERVICE AIR BAGS LIGHT CAME ON INTERMITTENTLY IN MY TRUCK. EVERYTIME I TOOK IT TO THE DEALER THEY COULDN'T REPRODUCE THE LIGHT. NOT LONG AFTER THAT STARTED TO HAPPEN, THE TRUCK STARTED TO "CHIME"(WARNING SIGNAL) AND BEEP, ALSO AT INTERMITTENT INTERVALS. AFTER 5 TRIPS TO THE DEALER AND 19 DAYS LATER(IN THE SHOP) THEY MIGHT HAVE FIXED THE PROBLEM. *JB

NHTSA ID

10146087

Incident

Jul 14, 2005

Mileage

10,000 mi

AT 38,000 MILES ON 2004 CHEVY SILVERADO Z71 THE AIR BAG LIGHT CAME ON AND WOULD NOT GO OFF. THE REAR VIEW MIRROR WHICH TELLS IF SOMEONE IS RIDING ON THE PASSENGER FRONT IS OFF. THERE IS NO WAY TO TELL IF THEY WILL WORK WHEN NEEDED OR NOT. *NM

NHTSA ID

10141451

Incident

Oct 16, 2005

Mileage

38,000 mi

DT: THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHILE DRIVING ON A STEEP CURVE HE HAD TO PANIC BRAKE TO AVOID GOING OVER AN EMBANKMENT. THE BRAKES LOCKED AND WOULD NOT ALLOW THE VEHICLE TO SLOW DOWN OR STOP. THE VEHICLE HIT THE GROUND AND PROCEEDED TO FLIP OVER. THE VEHICLE IS EQUIPPED WITH DRIVER AND PASSENGER SIDE AIR BAGS. UPON IMPACT THE FRONT AIR BAGS DID NOT DEPLOY. THE VEHICLE HAS NOT BEEN INSPECTED TO DETERMINE WHY THE BRAKES LOCKED UP OR WHY THE AIR BAGS DID NOT DEPLOY. HE HAS NOT CONTACTED THE MANUFACTURER OR THE SERVICE DEALER. *AK

NHTSA ID

10140240

Incident

Oct 12, 2005

Mileage

25,000 mi