2005 Chevrolet Silverado Problems

THE VEHICLES BRAKES ARE CORRODING AND FAILED ALMOST CAUSING AN ACCIDENT ON 2/09/2016 WHEN THE VEHICLE WAS IN MOTION (AT THE INTERSECTION OF IL ROUTE 34 AND WOLFS CROSSING)

PEDAL GOES ON DOWN WHEN PRESSED -- SEEMS LIKE ABS ISN'T WORKING PROPERLY

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHILE THE VEHICLE WAS PARKED WITH THE AIR CONDITIONER SET ON LEVEL FIVE, THE BLOWER INTERMITTENTLY CLICKED OFF AND ON. THE CONTACT ALSO STATED THAT A BURNING SMELL EMITTED THROUGH THE VENTS OF THE VEHICLE. THE FAILURE RECURRED ON SEVERAL OCCASIONS UNTIL LEVEL FIVE AND FOUR SETTINGS NO LONGER WORKED. THE CONTACT INSPECTED THE CONNECTOR SW/POWER ST ADJUSTER AND DISCOVERED THAT THE WIRES WERE MELTED. THE VEHICLE WAS TAKEN TO THE DEALER AND WAS NOT DIAGNOSED OR REPAIRED. THE DEALER INFORMED THE CONTACT THAT THE CONNECTOR AND RESISTOR FOR THE AIR CONDITIONER AND HEATER AND THE RESISTOR FOR THE HEATER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 97,000.

SPEEDOMETER DOES NOT READ ACCURATE. IT EITHER READS 15 MPH AT HIGHWAY SPEEDS, OR GOES WAY HIGH SUCH AS 120 MPH AT 55 TO 60 MPH. SOMETIMES AT THE HIGHER READING, IT WILL READ 60 MPH WHEN VEHICLE IS STOPPED, IN PARK, AND IGNITION OFF. I WAS TOLD THIS IS A STEPPING MOTOR BUT HARD TO CHANGE AND EXPENSIVE TO CHANGE. I HAVE READ THAT THERE WAS A CLASS ACTION LAWSUIT THAT WAS NEVER BROUGHT UP. *TR

The contact owns a 2005 Chevrolet Silverado 1500. The contact stated while driving approximately 50 mph, he lost control of the vehicle due to losing consciousness. The vehicle left the roadway and went airborne and crashed with a road sign landing in a field. None of the airbags deployed and only the seatbelt lap belt tensioned not the shoulder strap. The contact sustained injuries such as several lacerations across the face and inside the mouth, and broken L1 vertebrae. The contact mentioned he fractured the steering wheel with his face during the impact. A police report was filed and the vehicle was towed to a local lot then towed again to the contacts insurance lot where it was awaiting a diagnosis. The manufacturer was not informed of the failure. The failure mileage was approximately 281,000.

SRS WARNING CAME ON. HAD FAULT CODE. CALLED CHEVY DEALER AND THEY SAID I WOULD NEED A NEW AIRBAG. I RESEARCHED AND FOUND THAT GM DOES KNOW ABOUT THIS AND EVEN PUT OUT A TSB. IT IS A CONNECTOR TO THE AIRBAG ITSELF LOCATED IN THE LEFT KICK PANEL. THE FIX IS TO CLEAN THE CONNECTOR OR REPLACE IT. NO NEW AIRBAG IS NEEDED BUT IT DID REOCCUR ABOUT A YEAR LATER. RECLEANED AND OK AGAIN. THIS IS A SAFETY ITEM AND SHOULD BE A RECALL. SINCE GM KNEW IT I MUST ASSUME THAT NHTSA KNEW IT ALSO. I CAN SEE WHERE A LOT OF PEOPLE WOULD NOT FIX THIS AND JUST DRIVE LIKE THIS SINCE A LOT OF TECHNICIANS THINK YOU NEED A NEW AIRBAG WHEN IT IS IN FACT POOR WIRING BY GM. *TR

COMING HOME AFTER A NIGHT OF BOWLING WITH A TRUCK FULL OF KIDS. I COULD FEEL AND HEAR A GRINDING NOISE COMING FROM THE FRONT END. I THOUGHT IT WAS MY BRAKES UNTIL I GOT BACK INTO TOWN. WHEN I HIT THE BRAKES AND MOVED THE STEERING WHEEL BACK AND FORTH I COULD I KNEW IT WASN'T MY BRAKES. I TOOK THE FRONT TIRE OFF THE NEXT DAY AND I COULD WIGGLE THE WHEEL HUB BACK AND FORTH. VERY DANGEROUS. I FEEL LUCKY THAT NOBODY GOT HURT. THE ROAD I TRAVELED HOME WAS HWY 32 AND IT HAS ALOT OF CURVES. THIS SHOULD BE ADDRESSED. EVERY CHEVY THAT HAS THIS PROBLEM SHOULD BE NOTIFIED. IM A BACK YARD MECHANIC. I KNEW SOMETHING WAS WRONG. WHAT HAPPENS WITH THE SINGLE MOTHER WHO KNOWS NOTHING ABOUT THIS STUFF. SHE'S GOING TO BE LUCKY IF SHE DOESN'T GET IN AN ACCIDENT OR WORSE YET. KILLED! *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 25 MPH, THE CONTACT NOTICED A CLUNKING NOISE FROM THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC ADVISED THAT THE INTERMEDIATE STEERING SHAFT WOULD HAVE TO BE REPLACED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 05V018000 (STEERING:GEAR BOX:SHAFT SECTOR) THAT THE CONTACT BELIEVED WAS RELATED TO THE FAILURE. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 31,000.

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT NOTICED THERE WAS A ENGINE LEAK AND NOTICED THAT A FEW BOLTS THAT HOLD THE EXHAUST PIPE WERE MISSING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VIN WAS NOT AVAILABLE.

HAD TO ADD COOLANT OVER A TIME.....NO EVIDENCE OF A LEAK ON MY DRIVEWAY OR ANY OTHER PLACE. STARTED TRUCK ONE MORNING AND HEARD CLICKING NOISE COMING FROM ENGINE. I OBSERVED WATER COMING FROM THE MUFFLER. TOOK VEHICLE TO DEALER ON APRIL 22, 2014. ( MILEAGE 84241) DEALER FOUND BLOWN HEAD GASKET AND SEALS, ONE CRACKED HEAD AND WATER IN OIL. REPAIRS DONE: COMPLETE VALVE JOB (REPLACE HEAD GASKET, SEALS & OTHER ASSOCIATED PARTS), REPLACE BROKEN BOLTS, REPLACE COOLANT HOSES, RADIATOR & HEATER HOSES AND THERMOSTAT ETC.. WAS NOT ADVISED BY SERVICE CONSULTANT OF ANY RECALLS OR BULLETINS FOR 2005 SILVERADO. THIS IS LOW MILEAGE FOR THIS KIND OF ENGINE PROBLEM. REPAIR COST: $3683.92 MARTIN CHEVROLET *** TORRANCE, CALIF. *TR

TRUCK FRAME RUSTED SO BADLY VEHICLE CAN'T BE INSPECTED WITHOUT REPLACING FRAME. REAR SHOCK ABSORBERS MOUNTED ON CROSS-MEMBERS THAT ARE ENTIRELY RUSTED THROUGH. SAME FRAME DESIGN ON 2014 TRUCKS OF SAME MODEL. BODY IS STILL GOOD, BUT INSPECTION WILL EXPIRE AT END OF SEPT. 2014 AND THIS 9 YEAR OLD TRUCK WITH 76,000 ORIGINAL MILES WILL BE UNABLE TO BE PUT ON THE ROAD WITHOUT FRAME REPLACEMENT. PRETTY SAD WHEN '87 CHEVY'S ARE STILL ON THE ROAD AND THIS PIECE OF RUST IS ONLY GOOD FOR LOOKING AT. *TR

WHILE DRIVING, LOUD BANG. LOOKED UNDER TRUCK, DRIVER'S SIDE REAR LEAF SPRING SHACKLE HAD ROTTED OFF AND THE LEAF SPRING BUSTED THROUGH THE BED OF THE TRUCK. 2 WEEKS LATER, A BANGING ON THE UNDER SIDE OF BED. LOOK UNDERNEATH AND THE DRIVER'S SIDE REAR SHOCK MOUNT HAS RUSTED OFF THE FRAME. NOT EVEN SURE THERE IS ENOUGH METAL LEFT TO WELD OR PUT ON A NEW MOUNT! THE REAR CROSS MEMBER THAT HOLDS THE SPARE TIRE IS NON-EXISTENT. IT HAS RUSTED AWAY. THE BODY OF THE TRUCK IS IN GREAT SHAPE. IT IS JUST THE FRAME AREA AND MOUNTS THAT ATTACH TO IT. I HAVE OWNED THIS TRUCK SINCE IT WAS NEW, IT HAS NEVER BEEN OFF ROAD AND HAS BEEN KEPT IN EXCELLENT RUNNING CONDITION. THIS SEEMS TO BE AN ONGOING PROBLEM WITH GM. I HAVE SEEN MANY COMPLAINTS AND HOPES THAT THE NHTSA TAKES NOTICE AND ACTION. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT NOTICED THERE WAS A ENGINE LEAK AND NOTICED THAT A FEW BOLTS THAT HOLD THE EXHAUST PIPE WERE MISSING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VIN WAS NOT AVAILABLE.

I WAS ENTERING MY DRIVEWAY AND BEGAN TO BRAKE GOING DOWNHILL, THE BRAKE PEDAL SUDDEN "WENT TO THE FLOOR" (BRAKE LINE HAD RUPTURED DUE TO CORROSION). AFTER TAKING TRUCK TO MECHANIC, I LEARNED ALL MY BRAKE LINES WERE SERVERELY CORRODED AND HAD TO BE REPLACED - FUEL LINES AS WELL. REPAIRS TOTALED $2185. I OWNED SEVERAL OTHER MAKE PICKUPS, DRIVEN UNDER THE SAME CONDITIONS AND HAVE NEVER EXPERIENCED ANY PROBLEM WITH EITHER BRAKE OR FUEL LINES. *TR

DRIVING BACK TO WORK FROM LUNCH ON BUSY 4 LANE HIGHWAY, BRAKE PEDAL WENT TO FLOOR. NARROWLY AVOIDED A COLLISION AT A RED LIGHT. PUT FLASHERS ON, LOWERED THE GEAR SELECTOR, AND USED COMBO OF MINIMAL BRAKE PEDAL AND E BRAKE TO MAKE IT BACK TO THE PARKING LOT AT WORK. UPON INSPECTION, LARGE PUDDLE OF BRAKE FLUID ON DRIVER SIDE NEAR GAS TANK. LARGE LEAK IN HIGHLY CORRODED BRAKE LINE. ALL BRAKE LINES IN SIMILAR CONDITION AND ARE CURRENTLY BEING REPLACED IN THE SHOP. TRANSMISSION LINES AND FUEL LINE ARE IN SIMILAR HIGHLY CORRODED CONDITION. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH WHEN THE GEAR INDICATOR LIGHTS FAILED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR REPAIRS OR DIAGNOSIS. THE CONTACT STATED THERE WAS A RECALL (NHTSA CAMPAIGN ID NUMBER: 05V055000-POWER TRAIN:MANUAL TRANSMISSION:SHIFT PATTERN INDICATOR)BUT THE MANUFACTURER INFORMED THE CONTACT THAT HIS VEHICLE WAS NOT INCLUDED IN THE RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 72,000.

WAS ON HIGHWAY WHEN HEARD A NOISE AND PULLED OVER TO SEE A DOUGHNUT FOR A TIRE AND RUBBER PIECES TIED AROUND TAILPIPE,_E-BRAKE AND OTHER PARTS UNDERNEATH. DAMAGED REAR PANEL THE MILEAGE AT THE TIME WAS 30100MILES COULD'VE CAUSED A BAD ACCIDENT. ALSO BROKE A CLUSTER LOST ALL METERS ON DASH. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE VEHICLE WAS EQUIPPED WITH GENERAL TIRES, LINE SIZE P245/70R17. THE CONTACT STATED THAT THE FRONT DRIVER SIDE TIRE WENT FLAT. HE PURCHASED PENNZOIL FIX A FLAT S455, 16 OZ TO REPAIR THE TIRE. THE CONTACT WAS ATTEMPTING TO FIX THE FLAT WHEN THE HOSE DISCONNECTED FROM THE CAN. THE CONTACT STATED THAT THE PLASTIC RING WAS FRACTURED AND THE CHEMICALS FROM THE CAN RELEASED INTO HIS FACE. THE CONTACT SUSTAINED INJURIES TO HIS LUNGS, BOTH EYES AND BURNS TO THE FACE. THE CONTACT STATED THAT THE BOTTLE WAS NOT LABELED IN REGARDS TO WEARING GOGGLES OR PROTECTION WHEN USING THE PRODUCT. HE REFERENCED NHTSA CAMPAIGN ID NUMBER: 99E007000 (TIRES) BUT HAD NOT CONTACTED THE MANUFACTURER IN REGARDS TO THE RECALL. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 54,000.

FRAME IS ROTTED,WONT PASS INSPECTION,BRAKE LINES ARE ALSO ROTTED HAD TO REPLACE TWICE. *TR

I WENT TO SLOW TO MAKE TURN AND BRAKES WENT TO THE FLOOR SUDDENLY SO I USED EMERGENCY BRAKE TO STOP. I BELIEVE ALL LINES WILL NEED TO BE REPLACED AS OTHER LOOK AS RUSTY. RUST HAS BEEN AN ISSUE FOR LAST 2 YEARS WITH ROTORS NEEDING REPLACE THEN BEARINGS IN FRONT RUSTED AND ANTI-LOCK BRAKE LIGHT WOULD COME ON AND PEDAL WOULD SURGE. THIS IS THE WORSE CHEVY TRUCK I EVER BOUGHT AS EVEN SEEING RUST ALREADY IN LOWER PANELS AND ENTIRE FRAME. LOOKS BAD FOR ONLY 53,474 MILES. *TR

4 WHEEL DRIVE AUTOMATIC SHIFT TO TAKE THE 4 WHEEL DRIVE IN AND OUT MESSED UP HAD TO CHANGE THE SERVO OUT.THE OTHER ISSUE IS THE BEARING HUB FOR THE FRONT WHEEL HUBS 4 WHEEL DRIVE HAS A DEFECT I HAVE HAD THESE HUBS CHANGED OUT 3 TIMES AT A VERY COSTLY PRICE. *JS

I WAS DRIVING HOME FROM WORK WHICH IS 1.5 MILES, WHEN I HEARD A THUMPING SOUND, AND IT SEEMED AS IF MY REAR WHEELS WERE NOT TURNING. I HAD A FRIEND TOW IT TO THE DEALER COX CHEVROLET IN BRADENTON, FL, AND THEY TOLD ME, THAT THE REAR END (SPIDER GEARS, AND BEARINGS) WERE NEEDING REPLACING BUT ARE NOT PART OF THE POWER TRAIN SO IT WAS NOT COVERED UNDER WARRANTY, AND IT WOULD COST ME $2600. I HAD HIM TOW IT AGAIN TO A LOCAL TRANSMISSION SHOP AND THEY TOLD ME IT WAS COMMON IN THAT YEAR OF CHEVY TRUCKS. I ALSO NEEDED BOTH CLUTCHES REPLACED IN EACH REAR WHEEL, COST WAS WELL UNDER THE DEALERS CHARGE. THE OWNER OF THE TRANSMISSION SHOP INFORMED ME THAT HE HAS REPLACED A COUPLE 100 OF THESE AND THERE SHOULD BE A RECALL ON THEM. I COULD HAVE BEEN IN AN ACCIDENT WHEN THE WHEELS LOCKED. *TR

I OWN BOTH A CHEVY SILVERADO AND SUBURBAN 2005. BOTH VEHICLES WILL RANDOMLY START BLOWING HOT AIR OUT THE DRIVER'S SIDE. I KNOW AT LEAST 5 OTHER PEOPLE THAT HAVE 2005 CHEVYS AND THEIR VEHICLE DOES THE SAME THING. I TRIED WORKING WITH THE DEALER AND CHEVY AND BOTH ACT LIKE THEY NEVER HEARD OF THE PROBLEM. CHEVY REFUSES TO ACKNOWLEDGE THAT THIS IS A DEFECTED ISSUE ON THEIR PART AND WANT OVER $1000.00 TO FIX THE ISSUE. IS THERE ANYWAY YOU CAN GET GOVERNMENT MOTORS TO ISSUE A RECALL? *TR

COLD AIR BLOWING INSTEAD OF HOT AIR AND COULD NOT DEFROST WINDSHIELD. HAD TO PULL OFF ROAD AND SCRAPE INSIDE OF WINDSHIELD. THIS HAS OCCURRED SEVERAL TIMES OVER THE YEARS WHERE HOT AIR IS COMING FROM PASSENGER SIDE AND COLD AIR COMING FROM DRIVERS SIDE. VERY DANGEROUS IF YOU CANNOT SEE THROUGH THE WINDSHIELD AS WINDOWS FOG OR FREEZE UP. *TR

WAS ON HIGHWAY WHEN HEARD A NOISE AND PULLED OVER TO SEE A DOUGHNUT FOR A TIRE AND RUBBER PIECES TIED AROUND TAILPIPE,_E-BRAKE AND OTHER PARTS UNDERNEATH. DAMAGED REAR PANEL THE MILEAGE AT THE TIME WAS 30100MILES COULD'VE CAUSED A BAD ACCIDENT. ALSO BROKE A CLUSTER LOST ALL METERS ON DASH. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THE SPARE TIRE CABLE FRACTURED CAUSING THE SPARE TIRE TO DETACH FROM THE VEHICLE. THE STRANDS WHERE THE CABLE FRACTURED WERE UNEVEN AND CONTAINED RUST. THE CONTACT WAS UNAWARE UNSURE WHAT THE APPROXIMATE SPEED WAS WHEN THE FAILURE OCCURRED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 70,000. UPDATED 01/13/12*LJ

DASH LIGHTS GO OUT WHILE DRIVING DOWN THE ROAD HAVE TO PUSH ON DASHBOARD TO MAKE THEM COME BACK CONCERNED THAT THIS MAY BE A FIRE HAZARD

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHILE DRIVING AT APPROXIMATELY 65 MPH, THE SPEEDOMETER REMAINED AT 120 MPH AND FAILED TO PROVIDE AN ACCURATE READING. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 113,000.

The contact owns a 2005 Chevrolet Silverado 1500. The contact stated while driving approximately 50 mph, he lost control of the vehicle due to losing consciousness. The vehicle left the roadway and went airborne and crashed with a road sign landing in a field. None of the airbags deployed and only the seatbelt lap belt tensioned not the shoulder strap. The contact sustained injuries such as several lacerations across the face and inside the mouth, and broken L1 vertebrae. The contact mentioned he fractured the steering wheel with his face during the impact. A police report was filed and the vehicle was towed to a local lot then towed again to the contacts insurance lot where it was awaiting a diagnosis. The manufacturer was not informed of the failure. The failure mileage was approximately 281,000.

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE DOOR AJAR SAFETY ALARM AND THE SEAT BELT ALARM CHIME FAILED. THE CONTACT INDICATED THAT WHILE THE DOOR WAS OPENED WHILE THE VEHICLE WAS IN MOTION BUT THE CHIME DID NOT ACTIVATE . ADDITIONALLY, THE CHIME DID NOT SOUND WHEN THE SEAT BELTS WERE NOT SECURED WHILE THE VEHICLE WAS IN MOTION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 75,000.

CONSUMER REQUESTING THE AUTOMATIC DOOR LOCKS BE DEACTIVATED FOR THE SAFETY OF PASSENGERS IN CASE OF AN EMERGENCY. *TS ***NO ANSWER REQUIRED****JB

DT: THE CONTACT STATED THE DRIVER'S POWER ADJUSTED SEAT MALFUNCTIONED. WHEN EXITING THE VEHICLE THE SEAT WAS SLIDING FORWARD INSTEAD OF BACKWARD TO LET THE DRIVER OUT OF THE VEHICLE. THE VEHICLE HAS BEEN TAKEN TO THE DEALERSHIP FOR INSPECTION THREE TIMES. ON THE THIRD TIME THE DEALER UNPLUGGED THE SEAT. THE MANUFACTURER WAS CONTACTED ,AND THEY WERE IN TOUCH WITH THE DEALERSHIP. THE DEALER AND THE MANUFACTURER CONCLUDED THAT THE SEAT WAS PERFORMING CORRECTLY. HOWEVER, AT THIS TIME, THE DEALER LEFT THE SEAT UNPLUGGED SINCE THEY COULD NOT REPAIR IT. *AK

I BEGAN TO HAVE TROUBLE WITH MY LIGHT BULBS. WHEN I TRIED TO CHANGE BULB I FOUND EVIDENCE OF POOR CONNECTION WITH THE PLASTIC OF THE BULB AND OF THE SOCKET SOMEWHAT BURNED. THE FILAMENTS OF THE BULBS WERE OK. A FRIEND OF MINE ADVISED ME TO COAT THE CONNECTION WITH SILICONE GREASE. RECENTLY A VIRGINIA STATE TROOPER STOPPED ME FOR TWO BULBS NOT FUNCTIONING. SAME PROBLEM. LUCKILY HE WAITED WHILE I REMOVED THE ASSEMBLY AND, YES, THE BULBS WERE FINE BUT NOT MAKING GOOD CONTACT. HE EXPLAINED THAT HE ALSO HAS A CHEVROLET TRUCK AND HAS THE SAME PROBLEM. A FORMER EMPLOYEE OF GM IN AIKEN GA TOLD ME THAT GM WAS SUPPOSED TO APPLY THIS GREASE TO ELECTRICAL CONTACTS BUT FAILED TO DO SO. THIS IS A SAFETY PROBLEM OR THE TROOPER WOULD NOT HAVE STOPPED ME! *TR

2005 CHEVROLET SILVERADO HD 2500. DRIVING HEAD LIGHTS AUTOMATICALLY CAME ON BY THEMSELVES. VEHICLE WAS SHUT OFF AT 7:00 PM, RECEIVED A PHONE CALL AT 3:00 AM THAT THE HEAD LIGHTS WERE ON. VEHICLE HAD NOT BEEN MOVED OR STARTED SINCE IT HAD BEEN PARKED AT 7:00 PM. COULD NOT GET THE LIGHTS TO SHUT OFF. RESTARTED VEHICLE AND SHUT OFF VEHICLE AND LIGHTS STILL WOULDN'T SHUT OFF. THE HEAD LIGHTS WERE ON BUT NO TAIL LIGHTS. TURNED AUTOMATIC HEAD LIGHT SWITCH O OFF, NOTHING HAPPENED. IT TOOK ABOUT 5 TIMES OF DOING THIS BEFORE THEY FINALLY SHUT OFF. IT SEEMS LIKE IT MAYBE A FAULTY SWITCH. *NM

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 70 MPH WITH THE AIR CONDITIONER ON, THE DRIVERS SIDE VENT WAS RELEASING HOT AIR WHILE THE PASSENGER SIDE VENT CONTINUED TO RELEASE COLD AIR. THE CONTACT SHUT THE VEHICLE OFF AND AFTER RESTARTING IT THE AIR CONDITIONER BEGAN TO FUNCTION PROPERLY. THE VEHICLE WAS NOT TAKEN TO AN AUTHORIZED DEALER. THE FAILURE CONTINUED TO OCCUR INTERMITTENTLY. THE CONTACT STATED THAT OVER TIME THE FAILURE BECAME PROGRESSIVELY WORSE. THE FAILURE WAS NOT DIAGNOSED BY AN AUTHORIZED DEALER. THE CONTACT WAS INFORMED THAT THERE WAS A TECHNICAL SERVICE BULLETIN RELATED TO THE FAILURE. THE FAILURE MILEAGE WAS 55,000 AND THE CURRENT MILEAGE WAS 71,000. THE VIN WAS UNAVAILABLE.