2005 Chevrolet Ssr

The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.

CAR STARTED SFIFTING ON ITS OWN WHILE IN MOTION. WAS TOLD TO REPLACE THE TCM. THE ONLY THING I COULD DO IS TO BUY A USED ONE. I WAS TOLD MINE WAS A 1 YEAR BUILD MODEL. VERY HARD TO FIND! WHY IF GM KNEW THEY WERE JUNK , ARE THEY NOT MAKING REPLACMENTS? THIS IS THERE FAULT. THERE ARE NO AFTERMARKET ONES. ALSO, I WAS TOLD I NEED A FUSE BLOCK. ALSO MADE BY GM WITH NO RECALL ! THEY ARE ALSO DEFECTIVE! $50,000.00 FOR A DEATH TRAP?

NHTSA ID

11399938

Incident

Mar 5, 2021

Mileage

30,000 mi

FUEL GAGE READS WAY PASS FULL

NHTSA ID

11093714

Incident

May 14, 2018

Mileage

66,000 mi

TL* THE CONTACT OWNS A 2005 CHEVROLET SSR. WHILE THE VEHICLE WAS PARKED, IT FAILED TO TURN OFF WITHOUT WARNING AFTER NUMEROUS ATTEMPTS. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 58,000. ..UPDATED 03/16/16 *BF THE CONSUMER STATED THE ENGINE AND RADIO WOULD NOT TURN OFF, AFTER THE KEY WAS REMOVED FROM THE IGNITION. THE ALARM BUZZER WOULD NOT STOP BUZZING AFTER THE KEY WAS REMOVED FROM THE IGNITION. IN ORDER TO TURN OFF THE ENGINE, THE CONSUMER HAD TO TOUCH THE BRAKE AND OPEN AND CLOSE THE DOOR, SOMETIMES SEVERAL TIMES. UPDATED 03/22/16.*JB

NHTSA ID

10838199

Incident

May 12, 2015

Mileage

58,000 mi

PO463 CODE INDICATING FUEL LEVEL SENSOR COMES ON THEN CHECK ENGINE LIGHT COMES ON. THE FUEL GAUGE WILL GO TO EMPTY AND BACK TO FULL OR EXISTING FUEL LEVEL. THIS OCCURS WHEN VEHICLE IS MOVING OR STATIONARY, WITH THE ENGINE RUNNING. PURCHASED FROM CHEVROLET DEALER ON 05/26/2015 (THIRD OWNER), AND MALFUNCTION HAPPENED THE SAME DAY, AND THE DEALER WOULD NOT MAKE REPAIRS, SAID SOLD AS IS. I HAVE BEEN TRYING TO GET FIXED SINCE THEN WITHOUT ANY RESULTS. I RECENTLY HEARD THAT CHEVROLET PROVIDED A RECALL TO CORRECT OR REPLACE PROBLEM (COVERING 10 YRS OR 120,000 MILES), BUT THIS VEHICLE WAS NOT FIXED, AND I COULD NOT FIND ANY TYPE OF NOTIFICATION UNDER CARFAX THAT I RECEIVED FROM THE DEALER.

NHTSA ID

10836498

Incident

May 26, 2015

Mileage

62,689 mi

THE ENGINE RATTLES AT ANY RPM. CHECK ENGINE LIGHT P0430 INDICATES FAILED CATALYTIC CONVERTER (GM DEALER VERIFIED). FIRST TIME IT HAPPENED WAS AT 15000 MILES IN 2011, HAPPENED AGAIN NOW IN 2014 AT 47000 MILES. WHEN REPLACED AT 15000 MILES, IT WAS COVERED UNDER FEDERAL WARRANTY 8YR/80000MILES. NOW CHEVROLET REFUSES TO COVER THE COST ($1600 FOR THE PART, EST. $300 IN LABOR). DEALERSHIP MANAGER OFFERED TO DO ALL THE WORK UNDER A $500 'CUSTOMER DEDUCTIBLE'. I ACCEPTED THE OFFER AND WAS TOLD THE PART IS ON BACK ORDER. IT'S BEEN OVER A MONTH NOW AND MY TRUCK CONTINUES TO RATTLE WITH THE CHECK ENGINE LIGHT ON. DEALERSHIP CLAIMS THE CURRENT CONDITION WILL NOT PASS STATE INSPECTION. MY COMPLAINT IS THE CATALYTIC CONVERTER HAS FAILED TWICE SINE THE VEHICLE WAS PUT INTO SERVICE AND THE REPLACEMENT PART HAS NO SIGNS OF BEING AVAILABLE ANYTIME SOON. *TR

NHTSA ID

10618724

Incident

Mar 15, 2011

Mileage

15,000 mi

TL* THE CONTACT OWNS A 2005 CHEVROLET SSR. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO BE RESTARTED AFTER SEVERAL ATTEMPTS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO REPLACED THE IGNITION SWITCH HOWEVER, THE FAILURE RECURRED TWENTY TIMES OVER A PERIOD OF FOUR MONTHS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 17,000.

NHTSA ID

10579701

Incident

Feb 10, 2014

Mileage

17,000 mi

TRANSMISSION GEARS HARD TO ENGAGE. ABS LIGHTS ON, FUEL SYSTEM MALFUNCTIONS WITH ON BOARD COMPUTER SYSTEM MALFUNCTIONS. ALSO DOOR PANEL LOCK WILL NOT OPEN DOORS. CATALYTIC CONVERTER MALFUNCTIONING. *TR

NHTSA ID

10556987

Incident

Jul 11, 2013

Mileage

74,000 mi

ENGINE OVER HEATS, ELECTRICAL SYSTEM MALFUNCTIONS, SPEEDOMETER CLUSTER MALFUNCTIONS, CENTER SWITCHES MALFUNCTION, CENTER SWITCH FAILURES. FUEL SYSTEM MALFUNCTIONS, FUEL SYSTEM DELIVERY SYSTEM MAKE VEHICLE STALL. REAR TRANSMISSION SEAL LEAKS, CLUTCH RELEASE SPRING SPRING OUT. ABS LIGHTS, OIL LIGHTS & ENGINE OVER HEATING LIGHTS COMES ON, TRANSMISSION SLAVE LEAKS. ENGINE FAN MALFUNCTIONS, IT NEVER COMES ON. TEMPERATURE GAGE LOCKS, HEAT & GAS GAGE LOCKS. THESE ISSUES HAS BEEN BROUGHT TO THE ATTENTION OF GM CORPORATION. THESE GUYS REFUSE TO PAY FOR THEIR MANUFACTURING PROBLEMS, THEY WANT TO SHARE COST. AS A CONSUMER I SHOULDN'T HAVE TO SHARE THE COST OF THESE MANUFACTURING PROBLEMS. *TR

NHTSA ID

10556986

Incident

Jun 11, 2013

Mileage

74,000 mi

This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the noise for assessment by engineering. Technician will need to call General Motors Technical Assistance Center for further assistance.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.