2022 Chevrolet Tahoe Engine Problems

Vehicle sold with undisclosed recall/defect causing 5-month service hold and MY APARTMENT breach of peace void repo. 2022 Tahoe VIN [XXX] purchased from Lone Star Chevrolet. VIN 10th digit [XXX] = 2022 model year. Dealer sold with open recall / known APP defect requiring warranty repair approved by WAYSEAL LLC CAGE [XXX]. Vehicle held at Lone Star 5 months for same defect, no loaner provided. Despite TD Auto Finance hardship extension granted 09-30-2024, vehicle repossessed from MY APARTMENT gated apartment complex Dallas TX at night — breach of peace per UCC 9.609, therefore VOID repo. TD reported $346.73 phantom interest after payoff, $24,525.98 void deficiency now with Associated Credit Services Inc. Related Federal Complaints: CFPB [XXX], [XXX], [XXX], FTC [XXX]. Cause assessment: GM sold vehicle with known defective APP/electrical module requiring extended warranty hold. Dealer failed to disclose recall at sale. Resulted in loss of 159 days MY APARTMENT federal apartment income, $10,300 ALLY products with $0 rebate, and void collection. Injuries: UNKNOWN — financial loss only, no crash. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11775317

Incident

Dec 31, 1969

The dealership diagnosed the truck after investigating a ticking noise and engine misfire. During the inspection, they removed the valve cover and found that one of the pushrods on cylinder #5 was bent. Further disassembly revealed that both lifters on cylinder #5 had failed, causing excessive wear on the camshaft lobe. As a result, the dealership determined that the necessary repair was to replace the camshaft and all 16 lifters. The engine was then cleaned, reassembled, and tested to ensure proper operation. The root cause of the issue appears to have been a failing lifter, which led to damage of the associated valvetrain components.

NHTSA ID

11772644

Incident

Jun 30, 2026

The contact owns a 2022 Chevrolet Tahoe. The contact stated that while driving at an undisclosed speed, the forward collision, check engine, and traction control warning lights illuminated, and the messages "Forward Collision Unavailable," "Service Traction Control," and "Service ESC" displayed on the instrument panel. An abnormal muffler sound was heard, the engine compartment vibrated, and the vehicle failed to accelerate above 35 MPH. The vehicle was taken to the dealer, where the engine was disassembled and it was determined that the lifters failed and the engine required replacement. Prior to the failure, the vehicle was taken to the dealer for an illuminated check engine warning light and an engine knocking sound; however, the dealer only cleared the diagnostic trouble codes while the vehicle was under warranty. The manufacturer was notified of the failure by phone. The failure mileage was unknown.

NHTSA ID

11771349

Incident

Aug 6, 2026

Thursday XXX - Left [XXX] on our way to [XXX] for a beach vacation on our 2022 Chevy Tahoe z71. Made it to [XXX] and spent the night there Friday XXX - Left our hotel in [XXX] and headed to [XXX]. Expected arrival time 8 pm About 40 miles east of [XXX] our Tahoe shuts down and I pull to the side of the road in the middle of nowhere. It’s 99 degrees. I called several dealerships around and decided on Ryan Chevrolet in [XXX]. I called a tow truck and wait for 3 hours. My wife and two kids walk 1 mile to a gas station. I call the XXXstate patrol to get them to park behind me as semis at 80 miles per hour are flying by me. Having semis pass by at 80 miles per hour is obviously very scary and extremely dangerous. Tow truck takes me and the Tahoe to Ryan Chevrolet and am able to drop the car there 30 minutes before they close for the weekend. Tow truck driver takes me to the XXX airport where I have managed to rent an SUV that will allow me to complete my vacation. Drive through the night and make it to my hotel in [XXX] at 2:30 am. Thursday XXX - Drive back to [XXX] Friday XXX Go to Enterprise Rental cars in [XXX], explain that I will need a car till my Tahoe gets its engine replaced. I get a Chevy Blazer. Friday XXX - I drive 5 hours to [XXX] to pick up my Chevy Tahoe, return the Enterprise rental at the [XXX] airport and then drive another 5 hours back to [XXX]. I bought this car new at the dealership and has only been serviced by that same dealership. About a year ago the oil type was changed as part of the recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11770085

Incident

Jun 26, 2026

The contact owns a 2022 Chevrolet Tahoe. The contact stated that while driving approximately 70 MPH, the vehicle stalled with the message "Press to Start" displayed. The vehicle was parked on the shoulder of the road and failed to restart. The vehicle was later towed to the local dealer, and the contact was informed that the engine needed to be replaced. The contact stated that the engine was the replacement engine after the failure of the original engine. The replacement was performed under NHTSA Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING). The manufacturer was notified of the failure. The failure mileage was 10,000.

NHTSA ID

11767469

Incident

Sep 25, 2026

Mileage

10,000 mi

My 2022 Chevrolet Tahoe equipped with the 5.3L V8 experienced a severe engine failure at approximately 92,144 miles. The vehicle developed multiple misfires and was towed to the Chevrolet dealership for diagnosis. The dealership documented a failed lifter, significant camshaft damage, metal in the engine oil, and metal contamination throughout the engine. The engine had to be replaced with a complete long block at a total cost of approximately $14,395. I am concerned because this was a major internal engine failure at relatively low mileage, involving a lifter and resulting in extensive engine damage. GM has issued technical service information regarding lifter-related conditions and misfires affecting the 5.3L L84 engine family, which is the engine in my vehicle. GM provided $1,859.29 in partial repair assistance but has declined any additional assistance. I am reporting this failure because I believe the nature and severity of the engine failure warrant investigation for a potential recurring safety or reliability issue involving the 5.3L L84 engine.

NHTSA ID

11766915

Incident

Mar 24, 2024

Vehicle began making loud knocking sound XXX Towed to dealer 9/8 after holiday. They found metal in the oil and believe it needs an engine replacement. A week later I have no answers, there's no loaners available, so I am just without a car. We bought car from Zimbrick Chevy in [XXX]. It was never disclosed to us that the vehicle had an engine replacement right before we purchased. New engine lasted about 16,000 miles. Only once we saw the history of the car in the current dealership's service app did we learn about the engine replacement. This is beyond unacceptable! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11764193

Incident

Sep 8, 2026

The contact owns a 2022 Chevrolet Tahoe. The contact stated that while driving at an undisclosed speed, the engine seized. There was no warning light illuminated. The contact attempted to restart the vehicle; however, the engine cranked for 2 minutes and indicated that there was no oil pressure. The engine cranked over after several minutes. The vehicle was taken to the dealer, where it was diagnosed with rod-bearing failure and that the engine needed to be replaced. The contact received notification of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). The engine was replaced under the recall. The manufacturer was notified of the failure. The dealer repaired the vehicle. The vehicle engine seized but was able to be driven at a reduced speed. The failure mileage was 45,059.

NHTSA ID

11764093

Incident

Sep 14, 2026

Mileage

45,059 mi

Had a engine failure at 93,000 miles and upon doing a vin report found out it also had a engine put it at 7,800 miles so it now has its third engine in it and also had the high pressure pump fail and the gauge cluster fail and had to be replaced

NHTSA ID

11761160

Incident

Nov 3, 2025

This vehicle is subject to Safety Recall N252494000 / NHTSA Campaign 25V274 for a known L87 6.2L V8 engine defect. Prior to the June 2025 recall notice, I incurred repair costs for the same defect at Schumacher Chevrolet, [XXX], on XXX ($405.63) and XXX ($2,755.76), neither of which resolved the issue. On XXX and again on 02/14/2025, the vehicle suffered total loss of propulsion on [XXX], once causing a missed professional licensing exam and requiring emergency roadside repair. The vehicle's engine replacement repair order remained open for 181 consecutive days (XXX) before GM authorized a full engine replacement under warranty. I submitted a written reimbursement demand to GM on XXX for $10,717.31 in documented losses under 49 CFR § 577.7. GM has not responded in writing and instead offered an unverifiable verbal credit of $3,000, which the servicing dealer has no record of. I am filing this complaint due to GM's failure to remedy this known, pre-notification defect within a reasonable time as required by 49 U.S.C. § 30120. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11759102

Incident

Feb 20, 2025

2022 Chevy Tahoe went into limp mode at 62,500 miles out of the blue and check engine light came on. At the certified Chevy dealership I was told it was the transmission control valve, Code P2732, which is a known widespread factory issue in these models. Upon further inspection, was told my transmission fluid was completely black and burned and it ruined the transmission and therefore it needs to be replaced. "Consequential Damage Policy: When a control valve body fails and stays "stuck on," it forces maximum line pressure through the system. Continuing to drive under these conditions quickly destroys the internal clutch packs, burns the fluid, and melts down the transmission." This is exactly what happened and my vehicle was never put on a recall list but clearly was a ticking time bomb.

NHTSA ID

11755417

Incident

Aug 4, 2026

Driving the vehicle down the highway at approximately 65 miles per hour, the check engine light came on and the engine went into limp mode, slowing immediately. Upon getting the vehicle to the left shoulder on a busy highway, the vehicle displayed "engine overheating", "battery low", and 0% oil life. A full oil and filter change had been done less than 1000 miles ago and upon checking the oil, it was at the correct level. The engine completely failed and is not being replaced at a Chevrolet dealership. I completed the recall N252494003 on March 5th, 2026 which comprised of an engine inspection, higher viscosity oil, a new oil cap, filter replacement, and owner's manual insert. The engine still failed and required replacement despite having this done.

NHTSA ID

11751156

Incident

Jun 30, 2026

2022 Tahoe engine failure occurred on the highway due to 6.2L engine defect "L87 Engine Loss of Propulsion". Wife was stranded on the highway with no shoulder in 80 mph traffic. L87 Engine Loss of Propulsion defect was confirmed by Chevrolet, and car has been sitting at the service center for 6 weeks awaiting an engine. Just got notification that it is being shipped.

NHTSA ID

11747885

Incident

May 15, 2026

Vehicle lost all power while driving on interstate, there were no warning messages displayed. The initial recall was performed on vehicle.

NHTSA ID

11735055

Incident

Apr 23, 2026

My 2022 Chevrolet Tahoe diesel unexpectedly lost power while driving. I was stopped, made a right turn, and accelerated to approximately 34–40 mph on a two-way street when the vehicle suddenly shook, shifted into neutral, and the engine shut off without warning. There were no warning lights, dashboard messages, or prior symptoms before the failure. I was driving with two young children secured in car seats at the time. This created a serious safety risk because the vehicle became disabled in the roadway, and I had limited control while traffic was present. The vehicle has not yet been diagnosed, and the exact failed component/system is unknown. The vehicle is available for inspection upon request. The incident has been reported to a dealer or service center, but the problem has not yet been confirmed or reproduced at this time.

NHTSA ID

11734060

Incident

Apr 25, 2026

The contact owns a 2022 Chevrolet Tahoe. The contact stated that while driving at various speeds, the check engine warning light was flashing, and the vehicle was shuddering. The vehicle was taken to the dealer several times, and it was diagnosed with a misfire in cylinder #5. The dealer informed the contact that the engine was taken apart during the diagnostic process, and the vehicle was repaired; however, the contact expressed doubts that the engine was taken apart or repaired because the dealer had only sent pictures of the exterior of the vehicle to the warranty company. Additionally, the failure recurred while driving. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 85,000.

NHTSA ID

11732995

Incident

Dec 22, 2025

Mileage

85,000 mi

The contact owns a 2022 Chevrolet Tahoe. The contact stated that at approximately 55,000 miles, the vehicle experienced a torque converter failure, and the torque converter was replaced under the factory warranty. The contact stated that four months later, the failure reoccurred, and the dealer declined to cover the repair. Subsequently, the camshaft failed, leading to a recommendation for a complete engine replacement. The contact stated that old parts from the original engine were installed on the new engine without authorization. Two months after the engine replacement, the transmission valve body failed while the vehicle was 237th on a back-order list. Three months after a second transmission repair, the vehicle suffered another transmission failure. The contact was informed that the transmission was new but discovered but was being charged for the installation of old, faulty parts from the original engine onto the new powertrain. The vehicle was currently at the dealer, and the contact was without transportation. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 130,000.

NHTSA ID

11731482

Incident

Dec 1, 2024

Mileage

130,000 mi

I had the recall for the Momentary Rear Wheel Lock-up completed on 2025-05-04. While I was driving March 2026 my Tahoe went into limp mode and I had to have it towed because it wouldn’t reverse it was towed a day after this happened to Lynch Chevrolet. It has sat there ever since with no fix in site. I had to get a rental vehicle that GM is paying for but they have stipulations to what they pay for and the vehicle they gave is not comparable or better than MY car. Not only is this an inconvenience but they are doing the bare minimum to help with their mistakes.

NHTSA ID

11730486

Incident

Mar 17, 2026

My 2022 Chevrolet Tahoe has a recurring pattern of excessive oil consumption, smoke from the exhaust, repeated check engine light events, P0420 catalyst-efficiency faults, and repeated catalytic-converter-related repairs. At approximately 75,000 miles, the vehicle shut down on the freeway. At approximately 121,000 miles, the first catalytic converter failed. Chevrolet of Wesley Chapel documented P0420 and catalyst failure in November 2025, and GM service history reflects catalytic-converter replacements at 131,468 miles and approximately 141,082 miles. The vehicle also underwent major injector-related repair in early 2026. At 141,620 miles, Chevrolet of Wesley Chapel started an oil consumption test and stated in writing that oil consumption can lead to repeat failed converters and false oxygen sensor readings. Despite substantial repairs, the problem pattern continued. I am reporting this as a possible safety-related defect affecting engine operation, emissions-system failure, and drivability, and I am asking NHTSA to review whether this indicates a broader safety-related defect.

NHTSA ID

11725697

Incident

Mar 29, 2024

The contact's wife owns a 2022 Chevrolet Tahoe. The contact stated that while driving approximately 50-60 MPH, several unknown warning lights illuminated. The driver pulled over to the side of the road. The vehicle failed to restart and was towed to the dealer, where it was diagnosed and determined that unknown engine valves had collapsed, and there was possible camshaft damage. The contact was advised that further diagnostic tests were required. The dealer informed the contact that a recall should be issued for the failure. The vehicle was not repaired. The manufacturer was notified of the failure, and the contact was referred to the dealer for assistance. The failure mileage was approximately 68,000.

NHTSA ID

11725181

Incident

Mar 6, 2026

Mileage

68,000 mi

Driving down I495 in Mass when engine stopped with no warning or prior symptoms. My wife and 4 children (including 2 friends of our kids) were in the car. Luckily we were able to safely pull to the shoulder after coasting through a construction zone. If we hadn’t made it to a safe piece of shoulder chances are high that another vehicle would have hit our vehicle and hurt and killed us. These 6.2 engines are a serious safety hazard and I only hope my new engine proves to be reliable. Car was towed to dealer who diagnosed it as a seized motor. Car is a 2022 Chevy Tahoe with the problematic 6.2 engine. Engine had passed Chevrolet’s Pico test as per the 6.2 recall about 7,000 miles before it seized. Vehicle and engine dealer maintained with all required changes/maintenance. Engine seized/failed with no warning.

NHTSA ID

11724933

Incident

Feb 17, 2026

The vehicle shifted itself into neutral and shut off while driving. It happened twice in three days. The first time I was pulling into the driveway so I was able to put it in park and restart the car safely. The second time I was in the middle of traffic in Tampa and it shifted into neutral and shut off in the middle of the road. Luckily no cars hit me but again I had to apply the break , restart the car and put it back in drive. This was very scary and I had my kids with me. Earlier in the day I had been driving on 75 and if it had happened then it could have been a bad wreck. It shows there are no current recalls on my vehicle. No warning lights or messages appeared. Vehicle was purchased less than 30 days ago. I will contact the dealership to verify there are no open recalls just in case but again when I checked I found none.

NHTSA ID

11724226

Incident

Mar 13, 2026

I took the vehicle in for the engine recall. They put in the higher viscosity oil. Shortly thereafter the engine failed. They are trying to claim it's not related to the recall issue.

NHTSA ID

11717382

Incident

Feb 8, 2026

My Tahoe died on a busy bridge in Moore OK during rush hour traffic. Got a ticket for impending traffic. Had to get car towed. Tahoe is still in shop. I have a rental….GM trax. My car is in the shop indefinitely. I’m requesting a rental car of equal value to what my Tahoe was. Please make contact with the appropriate Hertz company as we will have bad weather in 2 days.

NHTSA ID

11712509

Incident

Jan 7, 2026

Unknown.

NHTSA ID

11710764

Incident

Dec 18, 2025